Professional Documents
Culture Documents
Equipment
Equipment
Equipment
EQUIPMENT
CONTENTS
WASHER TANK . . . . . . . . . . . . . . . . . . . . . . . . . 2
7-2 EQUIPMENT – Front Turn Signal Lamps / Washer Tank
WASHER TANK
The washer tank for the windshield and rear window washers has been relocated from the engine compartment
to the luggage compartment.
Section A–A
A
Washer tank
Washer tank
A
Quarter panel inner
EQUIPMENT – Immobilizer System 7-3
IMMOBILIZER SYSTEM
The immobilizer system is optionally available.
The immobilizer system consists of the ignition key, permission signal to the engine-ECU. If they
the antenna, the immobilizer-ECU, and the engine- are not the same or if the ID code input cannot
ECU. The ignition key has a built-in transponder be received, the immobilizer-ECU sends a start-
as the oscillator. The antenna is installed on the ing prohibition signal to the engine-ECU.
steering lock key cylinder. The system prevents the As mentioned above, only the ID code which
engine from being started deviously to protect the is specific to each ignition key permits the engine
vehicle from theft. The operation is as follows. to start. Therefore, the engine can never be
1. When the ignition switch is turned on, immobiliz- started by means of a forged key or by connect-
er-ECU supplies power to the transponder in- ing the ignition wiring directly. The system is
side the ignition key via the antenna. significantly safe and reliable against theft. In
2. The energized transponder outputs an ID code addition, the driver has only to turn the ignition
to the immobilizer-ECU via the antenna. switch to the ON position to activate the immobi-
3. The immobilizer-ECU compares the input ID lizer system. If the ignition key is lost or another
code with the registered ID code. If they are ignition key is added, the ID code can be regis-
the same, the immobilizer-ECU sends a starting tered or erased by using the MUT-II.
Antenna
Immobilizer-ECU
ID code
Antenna ID code
*1
Electromagnetic CPU Transmission
wave receiver circuit Engine-ECU
ID code and transmitter *2
Transponder Starting
Power permission
code MUT-II
Ignition key Steering lock
key cylinder
NOTE
(1) *1: Starting permission code
(2) *2: Permission confirmation code
NOTES