Professional Documents
Culture Documents
VT 1
VT 1
VT 1
B. Steel ruler
C. Steel tape
D. Mechanical gauge (micrometer)
6.The visible portion of the electromagnetic spectrum extend from.?
A. 210-370 nm
B. 570-891 nm
C. 100- 400 nm
D. 380-770 nm
7.in welding weld protrusion beyond the fusion line at the weld toe is called.?
A. Reinforcement
B. Overlap
C . Incomplete fusion
D. Undercut
8.An instrument that can be equipped with the forward,oblique, right angle or
retrospective visual system is called?
A. Stereoscope
B. An angulated borascope
C. A panoramic borascope
D. A microscope
9. A high intensity source of light may cause a inspection problem because?
A. The lamp head cannot be adjusted
B. Produced considerable heat
C.it has short blub life
D. It produce excessive glare
10.a device that provides the means of comparing a test surfaces to a standard
surface finish is called.?
A. Surfaces calibration
B. Surfaces magnifier
C . Surfaces comparator
D. Measuring magnifier
11.A method used for copying the topography of surfaces that cannot be moved
or one that would be damaged in transferal is called?
A. Surfaces matellography
B. NDT
C.in- situ ndt
D. Replication
12.The initiation of a fatigue crack could occur.?
A. Section change
B. Weld toe
C. All of options
D. Notches
13.visual inspection is the most extensively used inspection method on
weldments because.?
A. If gives important information about conformity to specification
B.All of the options
C. It simply and relatively inexpensive
D. It doesn't normally require special equipment
14. cracking under the combined action of corrosion and tensile stress referred to
as.?
A. Stress corrosion crack
[Type text] Page 3
VISUAL TESTING
B. Fatigue crack
C. Tensile stress cracking
D. Creep cracking
15.Hot tears ,inclusion, porosity, and cold shuts are?
A. Processing discontinuities
B. Welding discontinuities
C. Forging discontinuities
D. Casting discontinuities
16.in general visual inspection is performed?
A. All of the options
B. Before welding
C. During welding
D. After welding
17. Photometer used to measure reflectance of material or surface in specialized
ways are called?
A. Reflectometer
B.Glossmeter
C. Spectrometer
D. Radiometer
18. The testing of certain numbers less than the total in a production run lot is
called?
A. Random spacifide sampling
B.Random sampling
C.specifide sampling
D. Partial sampling
Answer
1.A
2.B
3.D
4.D
5.D
6.D
7.B
8.B
9.D
10.B
11.D
12.C
13.B
14.A
15.D
16.A
17.A
18.D
19.A
20.A
21.A
22.D
23.A
24.D
25.B