7. TIGHTEN NUTS: Verify that the locating collar is sil positioned properly in the out
hole. Using an impact tool or a standard socket wrench with a deep-well socket, tighte
nuts evenly by alternating sides, maintaining nearly uniform bolt pad gaps, until the
upper (outlet) housing contacts the pine completely. Verity that the oval neck of each
bolt seats properly in the bolt holes. To complete the assembly, apply torque to each
nut with a torque wrench. Refer to the “Helpful information and Assembly Torque
Requirements” table below and the “Torque Wrench Selection” section in this hanabook
If you suspect that any hardware has been over-tightened (as indicated by a bend in
the bolt, bulging of the nut at the bolt pad interface, or damage to the bolt pad, etc.)
the entire outlet assembly shall be replaced immediately
NOTICE
‘For grooved outlets, refer to the applicable coupling installation instructions,
‘+ For threaded outlets, complete the assembly using standard threading
BRANCH CONNECTIONS
If branch connection is made to the upper (outlet) housing,
before the Mechanical-T is installed on the pipe, verify that the
branch connection is 90° to the pipe run before completing the
tightening sequence of the Mechanical-T assembly.
‘+ When the Mechanical-T is used as part of a connection
between two parallel runs, it shall be assembled onto the
runs before the branch connection is made.
Helpful Information and Assembly Torque Requirements
‘Actual Pipe Nut Deep-Well
Nominal | Outside Size Socket Size | Required
Pipe Size | Diameter | inches! inches! | Assembly
inches/DN_|_inchesimm | Metric mm Torques
[3-4 | 3500-4500 v4 % 50 ft-lbs
DN8O-DNi00| 889-1143 Miz 2 68 Nm
6 6625 % Me 75 ftlbs
DN150 168.3 Mie 27 102 Nem
8 8.625 % We 100 ft-lbs
DN200 219.1 M20 32 136Nm
\Aetauiic
HOLE-CUT PRODUCTS
INSTALLATION INSTRUCTIONS REV_H -100_253