Professional Documents
Culture Documents
As3 9
As3 9
As3 9
5.61
A rigid tank is divided into two rooms by a membrane, both containing water, shown
in Fig. P5.61. Room A is at 200 kPa, v = 0.5 m3/kg, VA = 1 m3, and room B contains
3.5 kg at 0.5 MPa, 400°C. The membrane now ruptures and heat transfer takes place
so the water comes to a uniform state at 100°C. Find the heat transfer during the
process.
Solution:
State 1B: Table B.1.3, vB1 = 0.6173, uB1 = 2963.2, VB = mB1vB1 = 2.16 m3
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for testing or
instructional purposes only to students enrolled in courses for which this textbook has been adopted. Any other
reproduction or translation of this work beyond that permitted by Sections 107 or 108 of the 1976 United States
Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
5.134
An air pistol contains compressed air in a small cylinder, shown in Fig. P5.134.
Assume that the volume is 1 cm3, pressure is 1 MPa, and the temperature is 27°C
when armed. A bullet, m = 15 g, acts as a piston initially held by a pin (trigger); when
released, the air expands in an isothermal process (T = constant). If the air pressure is
0.1 MPa in the cylinder as the bullet leaves the gun, find
a. The final volume and the mass of air.
b. The work done by the air and work done on the atmosphere.
c. The work to the bullet and the bullet exit velocity.
Solution:
C.V. Air.
Air ideal gas: mair = P1V1/RT1 = 1000 × 10-6/(0.287 × 300) = 1.17×10-5 kg
⌠P1V1
1W2 = ⌠
⌡PdV = dV = P1V1 ln (V2/V1) = 2.303 J
⌡ V
-6
1W2,ATM = P0(V2 - V1) = 101 × (10 − 1) × 10 kJ = 0.909 J
1
Wbullet = 1W2 - 1W2,ATM = 1.394 J = 2 mbullet(Vexit)2
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for testing or
instructional purposes only to students enrolled in courses for which this textbook has been adopted. Any other
reproduction or translation of this work beyond that permitted by Sections 107 or 108 of the 1976 United States
Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
6.138
A steam engine based on a turbine is shown in Fig. P6.138. The boiler tank has a
volume of 100 L and initially contains saturated liquid with a very small amount
of vapor at 100 kPa. Heat is now added by the burner, and the pressure regulator
does not open before the boiler pressure reaches 700 kPa, which it keeps constant.
The saturated vapor enters the turbine at 700 kPa and is discharged to the
atmosphere as saturated vapor at 100 kPa. The burner is turned off when no more
liquid is present in the boiler. Find the total turbine work and the total heat
transfer to the boiler for this process.
Solution:
C.V. Boiler tank. Heat transfer, no work and flow out.
Continuity Eq.6.15: m2 - m1 = − me
Energy Eq.6.16: m2u2 - m1u1 = QCV - mehe
State 1: Table B.1.1, 100 kPa => v1 = 0.001 043, u1 = 417.36 kJ/kg
=> m1 = V/v1 = 0.1/0.001 043 = 95.877 kg
State 2: Table B.1.1, 700 kPa => v2 = vg = 0.2729, u2 = 2572.5 kJ/kg
=> m2 = V/vg = 0.1/0.2729 = 0.366 kg,
Exit state: Table B.1.1, 700 kPa => he = 2763.5 kJ/kg
From continuity eq.: me = m1 - m2 = 95.511 kg
QCV = m2u2 - m1u1 + mehe
= 0.366 × 2572.5 - 95.877 × 417.36 + 95.511 × 2763.5
= 224 871 kJ = 224.9 MJ
C.V. Turbine, steady state, inlet state is boiler tank exit state.
Turbine exit state: Table B.1.1, 100 kPa => he = 2675.5 kJ/kg
Wturb = me (hin- hex) = 95.511 × (2763.5 - 2675.5) = 8405 kJ
cb
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for
testing or instructional purposes only to students enrolled in courses for which this textbook has been
adopted. Any other reproduction or translation of this work beyond that permitted by Sections 107 or 108
of the 1976 United States Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
8.171
Water in a piston/cylinder is at 1 MPa, 500°C. There are two stops, a lower one at
which Vmin = 1 m3 and an upper one at Vmax = 3 m3. The piston is loaded with a
mass and outside atmosphere such that it floats when the pressure is 500 kPa. This
setup is now cooled to 100°C by rejecting heat to the surroundings at 20°C. Find
the total entropy generated in the process.
C.V. Water.
Initial state: Table B.1.3: v1 = 0.35411 m3/kg, u1 = 3124.3, s1 = 7.7621
m =V/v1 = 3/0.35411 = 8.472 kg
P T
v=C
1000 1 1
500 2
2
v s
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for
testing or instructional purposes only to students enrolled in courses for which this textbook has been
adopted. Any other reproduction or translation of this work beyond that permitted by Sections 107 or 108
of the 1976 United States Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
8.178
A cylinder fitted with a piston contains 0.5 kg of R-134a at 60°C, with a quality
of 50 percent. The R-134a now expands in an internally reversible polytropic
process to ambient temperature, 20°C at which point the quality is 100 percent.
Any heat transfer is with a constant-temperature source, which is at 60°C. Find
the polytropic exponent n and show that this process satisfies the second law of
thermodynamics.
Solution:
C.V.: R-134a, Internally Reversible, Polytropic Expansion: PVn = Const.
Cont.Eq.: m2 = m1 = m ; Energy Eq.: m(u2 − u1) = 1Q2 − 1W2
Entropy Eq.: m(s2 − s1) = ∫ dQ/T + 1S2 gen
State 1: T1 = 60oC, x1 = 0.5, Table B.5.1: P1 = Pg = 1681.8 kPa,
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for
testing or instructional purposes only to students enrolled in courses for which this textbook has been
adopted. Any other reproduction or translation of this work beyond that permitted by Sections 107 or 108
of the 1976 United States Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
9.159
Air at 100 kPa, 17°C is compressed to 400 kPa after which it is expanded through
a nozzle back to the atmosphere. The compressor and the nozzle are both
reversible and adiabatic and kinetic energy in and out of the compressor can be
neglected. Find the compressor work and its exit temperature and find the nozzle
exit velocity.
Solution:
The ideal nozzle then expands back down to P1 (constant s) so state 3 equals
state 1. The energy equation has no work but kinetic energy and gives:
1 2
2V = h2 - h1 = -wC = 141 460 J/kg (remember conversion to J)
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for
testing or instructional purposes only to students enrolled in courses for which this textbook has been
adopted. Any other reproduction or translation of this work beyond that permitted by Sections 107 or 108
of the 1976 United States Copyright Act without the permission of the copyright owner is unlawful.
Borgnakke and Sonntag
9.160
Assume both the compressor and the nozzle in Problem 9.37 have an isentropic
efficiency of 90% the rest being unchanged. Find the actual compressor work and
its exit temperature and find the actual nozzle exit velocity.
1
T C.V. Ideal compressor, inlet: 1 exit: 2
3
2 P2 = P3
3 Adiabatic : q = 0.
-W
Reversible: sgen = 0
P1
1 4 5 s
5
Process gives constant s (isentropic) which with constant CPo gives Eq.8.32
k-1
=> T2 = T1( P2/P1) k = 290 (400/100) 0.2857 = 430.9 K
⇒ −wCs = CPo(T2 – T1) = 1.004 (430.9 – 290) = 141.46 kJ/kg
The ideal nozzle then expands back down to state 1 (constant s). The actual
compressor discharges at state 3 however, so we have:
wC = wCs/ηC = -157.18 ⇒ T3 = T1 - wC/Cp = 446.6 K
Nozzle receives air at 3 and exhausts at 5. We must do the ideal (exit at 4)
first.
k-1
s4 = s3 ⇒ Eq.8.32: T4 = T3 (P4/P3 )k = 300.5 K
1 2 1
2 Vs = Cp(T3 - T4) = 146.68 ⇒ 2 V2ac = 132 kJ/kg ⇒ Vac = 513.8 m/s
If we need it, the actual nozzle exit (5) can be found:
T5 = T3 - V2ac/2Cp = 315 K
Excerpts from this work may be reproduced by instructors for distribution on a not-for-profit basis for
testing or instructional purposes only to students enrolled in courses for which this textbook has been
adopted. Any other reproduction or translation of this work beyond that permitted by Sections 107 or 108
of the 1976 United States Copyright Act without the permission of the copyright owner is unlawful.