Professional Documents
Culture Documents
Cme340 Cadcam ST 1
Cme340 Cadcam ST 1
Marks
No Part–A: Answer ALL Questions. 10x 2 = 20 Marks
CO
BL
1 Define the term “Projection”. 2 BL1 CO1
2 What do you understand from scales? 2 BL2 CO1
3 Draw any four symbols with name used in GD & T. 2 BL2 CO1
4 What is the use of Drawing grid. 2 BL2 CO1
5 Give the example for Broken section view. 2 BL2 CO2
6 Draw the layout of title block. 2 BL1 CO2
7 What is the use of BOM creation? 2 BL2 CO2
8 Discuss the importance ballooning of 2D drawing for inspection reporting. 2 BL2 CO2
9 Differentiate: 2D to 3D and 3D to 2D. 2 BL2 CO3
10 Write the advantages of tree features in 3D modeling. 2 BL1 CO3
Part–B: Answer ALL Questions. 5 x 13 = 65 Marks
Discuss in detail about GD & T and its 14 symbols with their characteristics. 13 BL2 CO1
A
11 (OR)
Explain the scope of customer specific requirements in design. 13 BL2 CO1
B
Discuss in details about understanding of projections. 13 BL2 CO1
A
12 (OR)
Briefly discuss about title block reading & Revision / ECN status of drawing. 13 BL2 CO1
B
Give explanation with example for Projections views: BL2 CO2
(i) Orthographic views 7
A (ii) Axillary views 6
13
(OR)
Discuss in detail about Ballooning of 2D drawing and its features for Inspection reporting. 13 BL2 CO2
B
What is the need of Half Section views, Broken Section view & Offset Section view in drafting. Explain 13 BL2 CO2
A with example.
14 (OR)
Give the step-by-step procedure to create BOM Creation & Notes creation in drafting. 13 BL2 CO2
B
(OR)
Write down the importance of tree features used in 3D modeling with suitable example. 15 BL3 CO3
B
Page 2 of 2