The movement of a dual console configuration for a Juno DRF system was jerky. This was caused by either an address conflict where both consoles were sending on the same address, or data loss. The remedies were to power off the system, disconnect and reconnect the CAN cables to the correct ports on the splitter board to resolve address conflicts, or to connect a terminator plug to identify and isolate a console with a missing firmware version causing data loss.
The movement of a dual console configuration for a Juno DRF system was jerky. This was caused by either an address conflict where both consoles were sending on the same address, or data loss. The remedies were to power off the system, disconnect and reconnect the CAN cables to the correct ports on the splitter board to resolve address conflicts, or to connect a terminator plug to identify and isolate a console with a missing firmware version causing data loss.
The movement of a dual console configuration for a Juno DRF system was jerky. This was caused by either an address conflict where both consoles were sending on the same address, or data loss. The remedies were to power off the system, disconnect and reconnect the CAN cables to the correct ports on the splitter board to resolve address conflicts, or to connect a terminator plug to identify and isolate a console with a missing firmware version causing data loss.
The movement of a dual console configuration for a Juno DRF system was jerky. This was caused by either an address conflict where both consoles were sending on the same address, or data loss. The remedies were to power off the system, disconnect and reconnect the CAN cables to the correct ports on the splitter board to resolve address conflicts, or to connect a terminator plug to identify and isolate a console with a missing firmware version causing data loss.
Symptom : With dual console configuration the movement
is jerky
Cause : 1. address conflict, both consoles sending on
the same address OR 2. Data loss
Remedy : 1. - power off the Juno DRF cabinet
- disconnect both consoles CAN cables X8 from the CAN splitter board A21 - power on the Juno DRF cabinet, red window with CAN error 1500 pops up - select "work offline" on the console, enter the code 2573 - press console 1 for the control room and console 2 in the examination room - power off the Juno DRF cabinet - reconnect the CAN cables X8 to the correct port - check function
2. - press setup button and check which
console has Joy Version 0, (normal is Joy 1.02) - power off the Juno DRF cabinet - disconnect the related console CAN cable X8 from the CAN splitter board A21 - connect the provided CAN terminator plug (120R Pin1-2) to the end of that CAN Cable - power on the Juno DRF cabinet, red window with CAN error 1500 pops up - select "work offline" on the console, enter the code 2573 - press console 1 for the control room or console 2 for the examination room - power off the Juno DRF cabinet - remove terminator, reconnect the CAN cables X8 to the correct port - check function