Howo A7 Cam Nang Sua Chua Dien00030

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

Howo A7.

Electrical equipment
If the indicated message appears on the LCD display when the
Trailer left side
left turn indicator light switch or the hazard warning light
direction signal
switch is turned on, this indicates a short circuit in the
lamp short circuit to
circuit. Check the wiring harness and lamp.
the ground
If, when the left turn indicator switch or hazard warning light switch is
turned on, the specified lamp turns on, but the indicated error
IN_DIG_16(C10); message appears on the LCD display, this means that an
IN_DIG_37(D22); Trailer left side excessive power lamp is installed in the direction indicator lamp
Trailer left direction OUT_32(F15) direction signal (recommended power range 15 - 180W).
indicator lamp lamp overload Make sure that the wattage of the installed lamps corresponds
to the recommended value of the instruction.

If, when the left turn indicator light switch or the hazard
warning light switch is turned on, the specified light
turns on, but the indicated error message appears on
Trailer left side
the LCD display, this means that a lamp of too low
direction signal
power is installed in the turn signal light (recommended
lamp open circuit
power range 15 - 180W). Check the lamp, its wattage
and the condition of the wiring, and that the wiring
harness is connected correctly.
Primary vehicle If the indicated message appears on the LCD display when the
right front/right right turn indicator light switch or the hazard warning light
rear direction signal switch is turned on, this indicates a short circuit in the
lamp short circuit to circuit. Check the wiring harness and lamp.
the ground
If, when you turn on the right turn indicator switch or the hazard
warning light switch, these lights turn on, but the
IN_DIG_15(C09); Primary vehicle indicated error message appears on the LCD display,
Front rear main lights IN_DIG_37(D22); right front/ right this means that the direction indicator lights are equipped
of the indicator of the OUT_23(F02) rear direction signal with excessive power bulbs (recommended power range
right in-gate of the car lamp overload 30 - 54W). Make sure that the wattage of the installed
lamps corresponds to the recommended value of the
instruction.
If, when you turn on the right turn indicator light switch or the
hazard warning light switch, the specified lights turn on,
but the indicated error message appears on the LCD
Primary vehicle
display, this means that lamps of too low power are
right front/ right
installed in the turn signal lights (recommended power
rear direction signal
range 30 - 54W) ... Make sure that the wattage of the
lamp open circuit
installed lamps matches the recommended value and
that the wiring harness is in good condition.

If the indicated message appears on the LCD display when the


Primary vehicle right
right turn indicator light switch or the hazard warning light
middle direction
switch is turned on, this indicates a short circuit in the
signal lamp short
circuit. Check the wiring harness and lamp.
circuit to the ground

If, when you turn on the right turn indicator switch or the hazard
warning light switch, the specified lights turn on, but the
Primary vehicle indicated error message appears on the LCD display,
Right middle this means that excessive power lamps are installed in
The main middle light of IN_DIG_15(C09); direction indicator the direction indicator lights (recommended power range
the indicator of the right IN_DIG_37(D22); lamp overload 15 - 27W). Make sure that the wattage of the installed
turn of the car OUT_16(E04) lamps corresponds to the recommended value of the
instruction.
If, when you turn on the right turn indicator light switch or the
hazard warning light switch, the specified lights turn on,
Primary vehicle but the indicated error message appears on the LCD
Right middle display, this means that lamps of too low power are
direction indicator installed in the turn signal lights (recommended power
lamp open circuit range 15 - 27W) ... Check the lamp, its wattage and the
condition of the wiring, and that the wiring harness is
connected correctly.

30

You might also like