Professional Documents
Culture Documents
Technowrap HT Hardener Part B 130320
Technowrap HT Hardener Part B 130320
Technowrap HT Hardener Part B 130320
1.1 Relevant identified uses of the substance or mixture and uses advised against
(SU3) Industrial uses: Uses of substances as such or in preparations at industrial sites; (PC7) Base metals and alloys. [PROC19] Hand-mixing
with intimate contact and only PPE available; [ERC8d] Wide dispersive outdoor use of processing aids in open systems.
Precautionary Statements
Prevention: P260 Do not breathe mists.
P264 Wash exposed area with plenty of water and soap thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
Response: P301+P3330+P331+312 IF SWALLOWED: Immediately seek medical advice. DO NOT INDUCE VOMITING.
P303+P361+P364+P353+P352 IF ON SKIN (or hair): Take off immediately all contaminated clothing and wash
before reuse. Rinse skin with water/shower.
P310: Immediately seek medical advice.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing.
P391 Collect spillage.
Disposal: P501 Dispose of contents and containers in accordance with local, regional and international regulations.
Technowrap H.T. Hardener (Part B)
Page 2/6
Revision 1
Revision date 2020-03-13
2.3 Other hazards
No data available.
Chemical Name CAS Number EC Number REACH Number Content Hazard Classification
2-Ethyl-4-methylimidazole 931-36-2 213-235-5 - 75-100% H302, H312, H314
3.2 Mixtures
Not applicable.
4.1.1 General information: No action should be taken involving any personal risk or without suitable training. If potential for exposure exist refer to
Section 8 for specific personal protective equipment. Show this SDS to medical professionals.
4.1.2 Following inhalation: If affected, remove to fresh air. If breathing is difficult, give oxygen. If not breathing, give artificial respiration and seek
medical attention.
4.1.3 Following skin contact: Immediately remove contaminated clothing and shoes. Wash the affected area with plenty of soap and water until no
evidence of the chemical remains (at least 15-20 minutes). Launder clothing before reuse. Seek medical attention immediately.
4.1.4 Following eye contact: Immediately flush eyes with plenty of clean water for an extended time, not less than fifteen (15) minutes. Flush longer if
there is any indication of residual chemical in the eye. Ensure adequate flushing of the eyes by separating the eyelids with fingers and roll eyes in a
circular motion. Get medical attention immediately.
4.1.5 Following ingestion: Do not induce vomiting. Never give anything by mouth to an unconscious person. Rinse out the mouth with water. Seek
medical attention immediately.
4.1.6 Self-protection of the First Aider: First aider to adopt relevant PPE (see Section 8) if the hazard still exists.
4.3 Indication of any immediate medical attention and special treatment needed
Treat symptomatically.
Appearance Liquid
Colour Yellow amber
Odour Amine
Odour threshold Not available
pH 10.7 at 100g.L-1
Melting point/Freezing point 36-42 oC, 97-108 oC
Initial boiling point and boiling point range 270-276 oC,518-529 oC
Flash point >155 oC (Closed cup)
Evaporation rate Not available
Flammability (solid, gas) Not available
Upper/lower flammability or explosive limits LEL 1.5 vol%, UEL 13 vol%
Vapour pressure <1 mmHg at 25 oC
Vapour density Heavier than air
Specific gravity >1 (20 oC)
Solubility 180 g.L-1
Partition coefficient n-octanol/water 1.64 (Calculated)
Auto-ignition temperature 474 oC (887 oF)
Decomposition temperature Not available
Viscosity 5950 cP at 20 oC, 569 cP at 40 oC
Acute Toxicity
Oral: Harmful if swallowed.
Inhalation: Harmful if inhaled. Exposure to vapours or mists may cause severe irritation and burns of the nose. Throat and respiratory tract.
Chemical Name LC50 Inhalation (Rat) LD50 Oral (Rat) LD50 Dermal (Rabbit)
2-Ethyl-4-methylimidazole Not available 731 mg.kg-1 >400 mg.kg-1
14.1 UN Number
ADR/RID: 2735
IMDG: 2735
ICAO-TI/IATA-DGR: 2735
ADN: Not relevant
14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
No information available.
Disclaimer: The data set forth in this sheet are based on information provided by the suppliers of the raw materials and chemicals used in the manufacture
of the aforementioned product. ICR Integrity Ltd makes no warranty with respect to the accuracy of the information provided by their suppliers, and
disclaims all liability of reliance thereof.