Professional Documents
Culture Documents
FAQLoad - Rockshox SID Race Service
FAQLoad - Rockshox SID Race Service
FAQLoad - Rockshox SID Race Service
com Bicycle Components Bikes Cars Cycle touring and bushwalking Music Photography Technology What's New Search
FAQs / Bicycle Components / Suspension / Rockshox SID Race Service 20" air forks for kids
I use CT18 truckwash, a soft brush and lots of water to get all of the dirt, oil and grime off. Don't worry about getting water into places Building a weight weenie coil spring
you don't want it, we're going to pull it all appart anyway. shock
Before doing anything on your air fork, make sure all of the air pressure is let out. The SID has two air springs:
Fox Float R Rear Shock - 2010
positive air spring accessed on the top of the left fork crown; and Model
Frankenforks
Lauf fork
Invert the forks and using a long/deep 10mm socket, undo the retaining nut from around the negative air spring valve. Once you've
Magura Hugin Rear Shock
backed the nut out level with the top of the air spring valve use a rubber mallet to give the 10mm socket a tap to free the air spring from
the stanchion lowers.
Magura Hugin Rear Shock Bleed
Remove the rebound adjuster by pulling on it (it is held in place with an o-ring). Procedure and IFP Depth Setting
Then use a 5mm allen key to remove the rebound rod retaining bolt. Manitou Mattoc
Grab the lowers by the brake arch and the uppers by the fork crown and separate them. Modifying 26" fork for 24" wheels
Clean the inside of the lowers using isopropyl alcohol and dry with a clean cloth. Monarch RT3 (2016 Rapid
Recovery)
Remove the foam wipers and wash in isopropyl alcohol.
Carefully clean the seals and inspect for damage. Monarch shock service
Inspect the bushings for wear and/or damage.
Monarch XX shock
Set the lowers aside for reassembly.
Motorex racing fork oil 2.5Wt
Step 5 - air spring service Mountain bike suspension fork axle
Undo the positive air spring cap using a 24mm socket. to crown measurements
Remove the negative air spring rod by removing the circlip and then pulling the assembly from the bottom of the stanchion.
Offset shock bushings
Give everything a good clean and inspect each of the o-rings to see if they are perished or damaged.
Re-assemble the air spring by giving everything a liberal coating with 15W fork oil. Put in 5ml of 15W fork oil into the positive air spring Real World Cycling Shock Eye
chamber before screwing the air cap back on. Needle Bearing Kit Install on Anthem
X
Undo the motion control damper using a 24mm socket and put it into a clean oil drain pan. Tip the oil out of the fork. Rockshox air spring maintenance
essentials
Remove the retaining circlip from the bottom of the stanchion and remove the rebound damper.
Rockshox fork service kit part
numbers
Lay the lowers on you bench and prop up the open end slightly. Use a syringe to put 5ml of 15W fork oil into each leg. Because you've
Rockshox Reba Race 2007
got them propped up on a slight angle the fork oil should not run out the top or the holes in the bottoms of the legs.
Soak the foam rings in fork oil and re-install. Give the seams a liberal coating of fork oil. Rockshox Reba RL 2019
Insert the stanchions into the lowers and re-install the negative air spring retaining nut and the rebound piston retaining bolt. Put the
rebound adjuster back into place. Rockshox SID 120mm RLT damper
Rockshox Mag 21 Rockshox SID SL Rockshox SID Race Rockshox SID Damping Fluid Leak
My daughter uses this Mag 21 on Quickfacts: What does it weigh? Rockshox SID problem diagnosis
her 24" full suspension mountain
bike . Its an old fork which is flexy Rockshox SID Race 2001
Read more » Read more »
and of limited travel for a full grown
adult, but works fantastically for a ... Rockshox SID Race 2007
Rockshox SID Race Rockshox SID Race Monarch shock Rockshox SID Race Rebound
Damper Upgrade
2007 2001 service
Rockshox SID Race Service
Fork with 215mm steerer, starnut Have just done a complete service of What you need
installed and v-brake bosses weighs a SID XC 2001 that I got for my next Rockshox SID Setup Tips
1318g. kids bike project. I don't think this
Read more » Rockshox SID SL 1999
thing has ever had a service. The
damper oil looked like this:
Read more » Rockshox SID Wheel Not Sitting
Straight
Read more »
Rockshox SID XX 120mm 2012
© 25 September 2010