Professional Documents
Culture Documents
15 P-135 (Earthing Platform)
15 P-135 (Earthing Platform)
y
nl
O
021
-2
0A
01
B-
rW
EARTHING PLATFORM
Fo
DESIGN DEPARTMENT
1
CONTENTS
0. Foreword
1. Scope
2. Material
3. Fabrication
4. Sample Tests
5. Sampling Acceptance and Rejection
y
6. Markings
nl
7. Drawings
O
0 21
-2
0A
PRINTINGS HISTORY
01
B-
Reprinted on May,1986.
Fo
2
SPECIFICATION P-135:80
EARTHING PLATRFORM
0 FOREWORD
This specification has been prepared by the Design Department of Power Wing
WAPDA.
This specification is intended for the procurement of material and does not
include all the necessary provisions of a contract.
y
nl
This specification is subject to revision as and when required.
O
1 SCOPE
21
This specification describes the earthing platform as voltage equalizing device
provided on energized apparatus with moving handles, such as line and bus
0
isolators. The purpose is to protect the personnel operating the device from
-2
electrical shocks.
0A
2 MATERIAL
01
The zinc used for galvanizing shall have chemical composition as specified in
rW
3 FABRICATION
Fo
Before being laid out or worked in any manner, structural material shall be
straight and shall be cleaned of all rust and dirt. If straightening is necessary, it
shall be done by methods that will not injure the metal. Shearing and cutting
shall be performed carefully and all portion of the work which will be exposed
to view after completion shall be finished neatly.
The strips shall be welded continuous on one side of members as shown on the
drawing No. PDW/DF-303.
3
Holes
Galvanizing
After all the shop work is complete the platform shall be hot dip
galvanized to confirm to WAPDA Specification P-82. Prior to
galvanizing the platforms shall be fabricated and welded as required:
freed form burrs, cleaned and thoroughly prepared, so that zinc coating
y
shall be adherent, dense, smooth, continuous and uniform. Care shall be
nl
taken to completely remove all welding scale. The galvanizing shall be
completely free form humps, blusters, uncoated or porous spots, black
O
spots, dross, flux or any other imperfection. The material shall not be
hammered or otherwise straightened after galvanizing in a manner which
21
may injure the galvanizing.
0
-2
4 SAMPLE TESTS
0A
The following sample tests shall be carried out on lots offered for acceptance:
01
i) Visual Inspection
ii) Verification of Dimensions and Weights
B-
Visual Inspection
4
Verification of Dimensions and Weight
Galvanizing Test
y
galvanizing test adherence of
nl
or thickness of coating test
zinc coatings
O
100 Units or 3 Units 2 2
less
6 MARKINGS
0 21
-2
0A
7 DRAWINGS
Fo
5
Fo
rW
B-
01
0A
-2
021
O
nl
y