Professional Documents
Culture Documents
Foster PDS 85 00 R0719 1
Foster PDS 85 00 R0719 1
WET FLAMMABILITY:
No flash to boiling, >200°F (93°C)
LINE-FAS™ ADHESIVE is produced under the classification
SURFACE BURNING CHARACTERISTICS (ASTM E84): and follow-up service of Underwriter’s Laboratories, Inc.
Flame Spread: 5
Smoke Developed: 0 LIMITATIONS
Coverage Rate: 400 sq. ft./gal. (9.8 m2/l) Store and apply between 40°F (4°C) and 100°F
Applied to 1/4 inch (6.4 mm) inorganic reinforced cement (38°C), protect from freezing until dry.
board. The flame spread may vary at different product
thicknesses and/or when applied over other surfaces. Not suggested for sealing vapor barrier jackets.
Overhead applications may require mechanical fasteners.
85-00
MATERIAL PREPARATION
DO NOT THIN. Apply only to clean, dry, oil-free surfaces. Keep container closed when not in use. Before using for the first time,
existing systems must be completely cleaned and free of the old adhesive and solvents. Corrosion resistant pumps and fittings are
suggested.
APPLICATION
Uniformly apply LINE-FAS™ adhesive to the metal surface at 400 – 500 sq. ft./gal. (9.8 – 12.3 m2/l). While still wet, press the
insulation into place, making sure that complete contact is made with applied adhesive.
SPRAY
The following equipment combinations are suggested:
MODEL FLUID NOZZLE AIR CAP FLUID PRESSURE ATOMIZATION
SPRAYGUN PRESSURE
Binks 2001SS 68SS 68PB 25 psi 60 psi
DeVilbiss JGA-510 E 777 25 psi 60 psi
Airless, electric, 30:1 or equivalent. Tip: 0.019 – 0.025. Average viscosity range: 3,000 to 5,000 cps. All adhesive systems should
have a fluid filter of at least a 50-mesh size at the pump, inline or at the gun.
CLEAN UP
To clean up, use hot soapy water if still wet. When dry, use xylene (flammable) or chlorinated solvent (non-flammable).
ADHESIVES
SURFACE BURNING CHARACTERISTICS
312U
ADEQUATE TESTS: The information contained herein we believe is correct to the best of our knowledge and tests. The recommendations and suggestions herein are
made without guarantee or representation as to results. We recommend that adequate tests be performed by you to determine if this product meets all of your
requirements. The warranted shelf life of our products is twelve months from date of shipment to the original purchaser or as otherwise provided on the certificate of
analysis.