Professional Documents
Culture Documents
DCB64DL
DCB64DL
MODEL: DCB64DL
1 x Mounting Template
Features
ATTENTION - Test the camera prior to selecting a permanent 1. Connect the BNC connector of the camera to Image Sensor 1/3” Sony EX-View™ II 960H
mounting location by temporarily connecting the camera(s) and the video cable.
cables to the DVR. Video Format NTSC
2. Connect power source to the power terminal
Effective Pixels H: 976 V: 494
1. Use the included mounting template to block.
Horizontal Resolution 700+ TVL
mark mounting points.
Video connector Scan System 2:1 Interlace
NOTE: If mounting the camera on a wall, ensure Sync System Internal
that the TOP label on the camera base faces up. Power connector
S / N Ratio >52dB (AGC Off)
Iris Auto Iris
Removable power
AES Shutter Speed 1/60 ~ 1/100,000 sec.
terminal block
(pre-attached) Min. Illumination 0.03 LUX @ F1.2 (IR Off)
0 LUX (IR LEDs ON)
NOTE: Make sure to follow correct polarity as marked
Video Output Composite 1.0Vpp @ 75ohm
on the power connector. For AC power, connect multiple
cameras using consistent wiring polarity to prevent Lens Focal Length / Type 2.8–12mm F1.6 / Varifocal
2. Mount the camera to the wall using the video rolling. FOV (Diagonal) 33–104°
included screws.
Termination Video: BNC Female
3. “Use the allen key to remove the cover plate on IR Range / Qty. 110ft / 34m; 8 Super Flux & 2 High
the bottom of the camera housing. Power LED’s
Power Requirement 12V DC ± 10% / 24V AC ± 10%
5. Move the camera to the desired position. 5. When adjustments are finished, tighten the
6. Tighten the stand screw and the adjustment knobs to lock in place. Reattach the cover
ring to secure the camera in place. plate and tighten cover plate screws.