Professional Documents
Culture Documents
구매 금형자산 관리 규정- Purchasing mold asset management regulations
구매 금형자산 관리 규정- Purchasing mold asset management regulations
제 1장 총 칙
Chapter 1: General Provisions
Article 1 [Purpose] The purpose of this regulation is to promote efficient mold asset
management by prescribing the overall mold procedures of our company.
Article 2 [Scope of Application] Except for cases where there is a special stipulation in other
regulations regarding mold management in our company, this regulation applies.
Article 3 [Definition of terms] The definitions of terms used in these regulations are as
follows.
① A mold is a tool for mass-producing parts necessary to construct a product, and refers to a
mold that forms certain parts by injecting metal and non-metal materials.
② Idle mold refers to a mold that cannot be directly donated to current production, such as
process change or business withdrawal, and can be reused immediately or through partial
repair. says)
③ Unused molds refer to molds that cannot be donated to production and cannot be used
internally due to wear, deterioration, failure, damage, etc.
(Among the idle molds, it refers to molds that have passed more than one year.)
④ Discarded molds refer to molds that are completely unusable or that cannot be
transferred and utilized by other partners among disused molds.
(Including molds older than 1 year among disused molds.
⑤ Storage refers to identifying available, idle, and disuse and managing them in a
designated location for each partner company.
⑥ Disposal refers to discarding a mold determined as a discarded mold by losing its
function.
Article 4 [Types and scope of managed molds] ① Tangible fixed mold assets
1. Courage
2. Lid (cap or stopper)
3. tray
4. Other
제 2 장 금형자산의 관리
Article 7 [Duty to Report] The person in charge of mold management in each department
must immediately report to the Production Technology Office when any of the following
causes occur with respect to mold management assets.
① When rights have been infringed or are likely to be infringed
② When disused mold occurs
③ When there is an increase or decrease in other mold assets
제 3 장 금형자산의 취득
제 5 장 금형의 보관 및 처분
Article 10 [Storage of Idle and Unused Molds] The production technology room has
subcontractors move idle and unused molds to a storage location, manage and supervise them
to be stored according to the 'Storage Method' (Appendix Table 1), and place idle/unused
stickers on them. Attach and manage identification.
Article 11 [Movement of idle and disused molds] ① In case of moving idle molds (or
disused molds) to another partner company, the relevant department prepares an 'asset
transfer report' (Appendix Table 7-business contact) in the production technology room.
After approval is obtained, the Production Technology Office ensures that the assets can
safely move to the site to be acquired. However, the business site to be acquired shall be
responsible for the cost incurred due to the transfer of assets.