Section C
Electrics
Section C
50-5
Calibration - LMI System
‘The LED indications described are in addition to the green
power-on LED G at the bottom of the display, which remains
‘on whenever power is supplied to the display unit
‘The display unit must be calibrated by setting the "100%"
point using a known load and boom extension.
A WARNING
During the following procedure, do not raise the lond
more than 600mm above ground level otherwise the
machine may be able to tip forward at a dangerous
angle. Keep all personnel clear of the front and rear of
the machine.
Safe Load Indicator & Load Moment Indicator
50-5
1 Park the machine on firm level ground.
2 Turn the starter key to the OFF position. Press and hold
display button A. Start the engine with button A held
dow, Hold the button for approximately 30 seconds
after the engine has started. All display LEDs will
ituminate during this time,
Note: i the button is release during this time, the entire
process must be repeated.
After approximately 30 seconds, the display will show
‘the red LED E only and the alarm will emit short
intermittent bleeps.
3 Release botton A.
4 With the boom fully retracted, pick up a load between
1800 kg and 2000 kg. Use either pallet forks loaded
with a test weight, or a bucket filed with a high density
material
5 Slowly extend the boom. Keep the load close to the
‘ground until the machine is balanced about the front,
‘axle with the rear wheels offthe ground.
Note: Ifthe following actions are not completed within ative
minute period, the display will automatically leave the
calibration mode and the memory will revert to the previous
settings. Ifthe transducer signal is out of range, the display
will indicate the appropriate error code. Calibration cannot
continue unt the fault Is rectified
6 Press and release the display button A. The display will
change to show the amber LED D and red LED E only.
7 Lower the load to the ground and measure the distance
the boom is extended (in milimetres)
B Refer to the correct load chart for the machine (this
section).
9 Read up from the extension figure obtained at step 7
(example line X) tothe tipping line AA.
10 Read horizontally (example line Y) to the maximum
‘working lit fine BB,
41. Read down tothe horizontal axis (example ine Z) to gat
the dimension for the boom extension (maximum
working limi)
12. Draw a mark on the boom at the dimension obtained
above. Raise and retract the boom to the mark drawn
‘on the boom.
13 Press and release the display button. The display will
revert to normal operation. The setting of the 100%
pposition is now complete.
‘9908/8800
issue?Section C Electrics Section C
50-4 Safe Load Indicator & Load Moment Indicator 50-4
LMI Chart - 520-50
1200 1400 1600
0 200 400-600. BOD.-« 1000 1200 1400 1600 1800
B venaraez0 Tevet