Professional Documents
Culture Documents
Echometer Gas Separator With Packer and Tubing Anchor Running Instructions 20130816
Echometer Gas Separator With Packer and Tubing Anchor Running Instructions 20130816
info@echometer.com .
The separator is 8 feet long and maximum 3.75 inches OD at the ends.
Caution
Two 1 1/8 inch round holes are at the bottom of separator to allow
liquid flow into the pump seating assembly. The 1 inch by 5 inch slot
is at the top of the separator to allow the formation fluids to flow up
through the separator and out of the top of the separator.
At least partially fill the tubing with liquid to seat the pump and reduce
stuffing box problems after running the tubing string and before
pumping the well.
Do not use power tongs on the separator since the collars should be
tightened with a pipe wrench manually. The separator barrel is not
designed for pipe wrench use.
Associated equipment to use with Separator - Packer and Tubing anchor
Running procedure:
The tubing anchor is at the bottom.
Then the packer
Then the seating nipple for a short spacer
Then the separator
Then the tubing
Note that the short seating nipple is used to connect the packer to the separator
and is not used for seating the pump. The pump seating nipple is in the lower
portion of the separator. Do not run a seating nipple above the separator since
the separator contains the seating nipple. The bottom of the separator has two
1 1/8 inch round holes and the top has one slot that is 1 inch wide and 5 inches
long.
LLER
Brochure on Watson Tubing Anchor
The standard separators are made to run with a conventional 3 cup seating
assembly for a pump to run in 2 7/8 inch tubing. The bottom of the separator has
a N11-25 seating nipple for a S11-25 seating assembly on the bottom of the
pump. The seating assembly is marked on the separator in the slot at the upper
end as shown.
The separator is also available with a seating assembly N11-20 in the bottom of
the separator. It is marked with the N11-20 designation and is to be used with a
pump for 2 3/8 inch tubing having a conventional 3 cup S11-20 seating assembly
on the bottom. The ID of the seating nipple in the bottom of the separator
marked N11-20 is 1.780 inches.
Be sure to specify and order the smaller seating assembly in the separator for
the smaller seating assembly on the pump if the separator is used with 2 3/8 inch
tubing.
The standard seating nipple in the separator is for the 3 cup S11-25 seating
assembly on the bottom of most pumps for 2 7/8 inch tubing.
If a mechanical seating assembly is run on the bottom of the
pump, put a mechanical seating assembly above the gas
separator for the pump to seat into.
See table for proper torque on Tubing Connections.