Professional Documents
Culture Documents
3d Training
3d Training
Beginer
Installation
Before installation 1.D: drive should be Separate partition and free space required. 2.If windows 7 , install by right click then run as administrator. 3.If not installed, pause the anti-virus for few seconds. 4.Insert cd and double click the "exe" file 5.Insert softkey or Dongle in USB port. 6.Finally open the software. 7.This software will not work in windows vista.
Pitch Test
Pitch is the exact count of lenticules per inch (LPI). This refers to matching the rendered 3dfile with the frequency and spacing of the lens material. Take print of the following Pitch files C:/program file/Antz Technologies/ pitch/ PitchRange_8_60_420 C:/program file/Antz Technologies/ pitch/ PitchRange_8_40_480 Print the file in any Desktop photo printer i.e: epson/canon/HP/ Brother
The above image is an example of one type pitch testfile. It consists of various different frequencies of lines for a certain LPI. It may be necessary to resize an rendered image to fit the lens more appropriately. The alignment bars are used for aligning the image and the lens as well as adjusting the pitch.
Lentricks_3D Tutorial
After choosing the parameters Play for view Choose the Lens and Depth
.5
Depth can be kept as .5" for 8"x10" sizes The depth can be adjusted according to the size of the images too.
Draw line
Go to draw line and using the draw tool, you can now choose the area of the image which should be higlighted. For example if you want adjustments there are15 steps to be taken for volumetric effects
After another layer to create the volumetric effect Set layer/ Select to another Layer.
Preview
Stop
Preview
Stop
After Setting the Value, play the preview to see over all depth
Resampling Pitch
After Rendering the file. Open in Photoshop
418.505
480
Change the Value as per your original out put resolutions 480
Printing
Use tapes at both side edges, for easy releasing self adhesive.
This image illustrates bad alignment The alignment bars have "zebra" type pattern
This image illustrates good alignment The alignment appear as either solid black or white
3D is Ready,
Lentricks_Merge
Click and choose the another file and continue from 7 to 12 frames of same image
Click merge
Click ok
"ON" the Alignment Bar
Resampling Pitch
Open Merged File in Photoshop for Resampling image
Printing
Paste the tape at both side edges, for easy releasing self adhesive.
This image illustrates bad alignment The alignment bars have "zebra" type pattern
This image illustrates good alignment The alignment appear as a solid black or white
Release the tape for one inch down and paste slowly