Professional Documents
Culture Documents
SAP2000 Final Project - 2022-2023
SAP2000 Final Project - 2022-2023
Stairwell
In the concept of the Term Project of CE 482, 10-storey (ground floor + 9-storey) reinforced concrete structure
will be designed and analysed, whose ground floor plan is given in Figure 1. Slab thicnesses is 13 cm and the
beam cross section sizes are 25x50 cm2 on all floors. Column cross sections are constant for all stories and
cross section dimensions on x and y directions are given in Table 1. Height of the storey is constant for each
student as given in Table 2. Also, design concrete compressive strength values are given in Table 2. You will
determine the reinforcement diameters and strength according to the code (TS500, TBDY) yourself. The
ductility level will be choosen as high.
Table 2. Design concete compressive strength values and constant storey heights
Student Name fc (MPa) Storey Height (m)
METİN AYTEKİN 27 2,5
M. OGHOR BATTAL 29 2,6
AHMET İNCE 31 2,7
ABDÜL SAMET OVA 33 2,8
MEHMET ALİ PAYAM 35 2,9
YUSUF ZİYA YAMAK 37 3
HÜSEYİN YILGIN 39 2,5
SERKAN YİĞİT 28 2,6
(For each student, the concrete compressive strength and height of the storey are given as above regarding the
surname order of the students.)
Loading:
There will no extra dead and live loads. For the Project, only self-weight of the structure will be used.
Tasks:
1. Using SAP2000 the modal analysis of the structure will be done by the student. After the analysis,
student will control the system and, when only one digit number considered, if natural period for
the first mode is higher than 0.1 sn for each storey and mass participation ratio is lower than 90%,
material properties and beam/column cross section dimensions will be changed by the student and
do the modal analysis again.
2. Using SAP2000 the response spectrum analysis of the structure will be done by the student.
Response spectrum properties will be given to the student by the lecturer.*
3. Using SAP2000 the modal time history analysis of the structure will be done by the student.*
4. Presentation*
5. Report
Note: To analyze and to design the structure, the other needed data, which were not be defined by this project,
can be assumed by the students.