Professional Documents
Culture Documents
2013-03-08 035329 Remote Start
2013-03-08 035329 Remote Start
Vehicle Preparation
1. Outlander, and all Lancer based vehicles - Close all doors (inc. rear passenger’s doors and trunk lid).
Galant, Endeavor and Eclipse/Eclipse Spyder - Close all doors, and trunk lid/liftgate. Open the hood.
Outlander Sport – Instructions begin on page 2.
2. Remove the ignition key from the ignition key cylinder. (On vehicles with Keyless Operation System,
turn the ignition knob to LOCK (OFF) and remove the ignition knob cap.).
3. Insert the ignition key into the key cylinder.
For K.O.S. equipped vehicles, remove the emergency key from the transmitter and insert it into the key
cylinder.
Step Procedure System Response
1 Turn the key from LOCK (OFF) to ACC When the key is returned to the LOCK (OFF) position,
to LOCK (OFF). Perform this operation 5 one beep is heard. Remove the key.
times within 10 seconds.
Do not turn the key to the ON position.
You will have to start over.
2 Within 10 seconds after the beep in the The remote transmitter indicator will flash (on for
above step, push all three buttons of the approx. 1 second and off for approx. 1 second).
remote controller simultaneously for 2 Release the transmitter buttons.
seconds or longer. NOTE:
If it is difficult to press all three buttons together, first
push the Start and Stop buttons and hold them. Then
push the Request button and hold all three for at least
2 seconds..
3 Insert the ignition or emergency key into When the key (or knob) is returned to the LOCK (OFF)
the key cylinder and turn the key from position, the ECU will beep once. Remove the key.
LOCK (OFF) to ACC and return to LOCK
(OFF). Do not turn the key to the ON position.
You will have to start over.
4 Press the engine stop button on the ….you will hear two beeps.
remote transmitter.
If the transmitter is operated correctly,
5 For Outlander/Lancer Models Only After this procedure, the door locks should
Using the keyless-entry key (or keyless automatically lock and unlock once and after several
operation key) registered to the vehicle, seconds, lock and unlock again.
press the unlock button three times
successively.
6 Check remote engine start operation.
Press Request button then Start button.
3 Within 5 seconds of finishing step 2, depress and The buzzer on the remote sounds
hold the 3 buttons on the RES remote for 1 once and the “Start” and “Stop”
second or more in the following order (press and lights on the remote start blinking.
hold Stop, then add Start, then add Function).
5 Depress the “Stop” button on the remote for 1 ECU beeps twice.
second or more
2
6 Within 10 seconds after the ECU beep, press the After the above steps, the door
unlock button on the vehicle KOS transmitter 3 locks should automatically lock
times. and unlock once, and then after
several seconds lock and unlock
again.
7 Registration Complete
3 Within 5 seconds of finishing step 2, depress and The buzzer on the remote sounds
hold the 3 buttons on the accessory remote for 1 once and the “Start” and “Stop”
second or more in the following order (press and lights on the remote start blinking.
hold Start, then add Stop, then add Function).
3
4 While “Start” and “Stop” are blinking, insert the The ECU beeps once.
ignition key to the ignition switch and turn from
LOCK (OFF) to ACC, then back to LOCK and
remove the key.
6 Within 10 seconds after the ECU beeps, press After the above steps, the door
the unlock button on the multi-function key 3 locks should automatically lock
times. and unlock once, then after several
seconds, lock and unlock again.
7 Registration Complete