Professional Documents
Culture Documents
RMS Configurations
RMS Configurations
RMS Configurations
and TM
Introduction
This presentation covers the
maintenance.
2
Helios Towers | Private & Confidential
Teltonika Configuration
Major Tools required
3
Helios Towers | Private & Confidential
Teltonika Configuration
Cables information
Cables
4
Helios Towers | Private & Confidential
Teltonika Layout
Layout Panel 1
5
Helios Towers | Private & Confidential
Teltonika Layout
Layout Panel 2
6
Helios Towers | Private & Confidential
Hardware installation
1. Locate and secure the RUT955 in the rectifier cabinet in a location which is not subjected with
direct temperature rise and has space for suitable installation. See below Images
2. Insert the SIM card(s) and SD Card as appropriate.
3. Attach Mobile Antenna Position 3 and other antennas as appropriate.
4. Install the 12 or 24VDC Power Supply to the RUT955
7
Helios Towers | Private & Confidential
Hardware installation
1. Locate and secure the RUT955 in the rectifier cabinet in a convenient location for cable
access.
2. Insert the SIM card(s) and SD Card as appropriate.
3. Attach Mobile Antenna Position 3 and other antennas as appropriate.
4. Install the 12 or 24VDC Power Supply to the RUT955
8
Helios Towers | Private & Confidential
9
Helios Towers | Private & Confidential
Controller configuration
Modbus TCP Connections
The three LAN ports are used for Modbus TCP connections using ethernet cable. Connect
the rectifier controller using ethernet cable to the one of the three LAN ports and configure
the IP address and port number as below. In order to login to rectifier controller, use one of
the three LAN ports of the RUT device and not disconnecting the cable from RMS to
controller.
10
Helios Towers | Private & Confidential
Controller configuration
Major Controllers we focus on
11
Helios Towers | Private & Confidential
Controller configuration
Orion Modbus Mapping
Loading Mapping so that the Modbus data can be transmitted. Login to the controller and follow
below instruction.
Configuration > System > File Manager > File Type > Modbus Slave Mapping
Choose File > HT_ModbusSlave_Mapping_02
12
Helios Towers | Private & Confidential
Controller configuration
Changing Modbus Slave Mode and listen port to 502
Once the mapping file installed change modbus slave mode as per below
Configuration > System > Interface Set Up > Remote Monitoring > Modbus Slave and then
change mode to TCP
IF TCP not enabled, we would Not Get the rectifier Data
13
Helios Towers | Private & Confidential
Deepsea configuration
The maximum recommended length of RS232 cable is 15m, if the cable run from the
Teltonika to the Deepsea is 15m or less, then RS232 is preferred. The RS232 cable is a
straight through cable with one male and one female D9 connector
The installation is the same for a DSE7320 MkI and DSE7320 MkII controllers.
14
Helios Towers | Private & Confidential
Deepsea configuration
Login to Deepsea and go to Communication and basic. Select respective port type.
15
Helios Towers | Private & Confidential
Deepsea configuration
RS232 connection
Once the cable is installed properly go to RS232 Port – Basic and select as per below.
Important: Make sue the baud rate selected matches the one on Teltonika device settings
.
16
Helios Towers | Private & Confidential
Deepsea configuration
RS485 connection
The RS485 Connector is a 6 way terminal block and if used with a single single
device it is necessary to link out the connector as below.
17
Helios Towers | Private & Confidential
Deepsea Connection
The Deepsea is connected as below
RUT955 DP / RP to Deepsea PIN56 (Orange Cable)
RUT955 DN / RN to Deepsea PIN57 (Blue Cable)
RUT955 Ground to Deepsea PIN 58 (Brown cable)
18
Helios Towers | Private & Confidential
Deepsea Connection
The Deepsea is connected as below
RUT955 DP / RP to Deepsea PIN56 (Orange Cable)
RUT955 DN / RN to Deepsea PIN57 (Blue Cable)
RUT955 Ground to Deepsea PIN 58 (Brown cable)
19
Helios Towers | Private & Confidential
20
Dataminer RMS Configuration
Dataminer
Layout
Helios Towers | Private & Confidential
Dataminer Configuration
IP Configuration
When configuring dataminer to controller, make sure IP addresses are filled and saved as per below. This is found
on below category;
Configuration>System>Interface>Setup>TCP/IP
23
Helios Towers | Private & Confidential
Dataminer Configuration
IP Configuration
After adding the IP address save the new settings and reboot the controller for the changes to reflect.
Configuration>System>Interface>Setup>TCP/IP
24
Helios Towers | Private & Confidential
Dataminer Configuration
Checking License key
❑ In order for controller to send data to Dataminer, controller must have license key. Check the status using below path.
Configuration>Option
❑ If the controller has license key, then SNMP Protocol check box will be ticked.
25
Helios Towers | Private & Confidential
Dataminer Configuration
Processing License key
❑ If the controller do not have license key, get the MAC address and request. Go through below path to get MAC address
Configuration>System>Interface>Setup>TCP/IP
❑ RMS SPOC Send email containing MAC address to HTT System Engineering(Jrunyoro@httanzania.co.tz or
Ishauri@httanzania.co.tz ) team to be provided with license key
26
Helios Towers | Private & Confidential
Labelling:
What?
Where?
When?
Why?
27
Helios Towers | Private & Confidential
LABELLING
What is Labelling?
28
Helios Towers | Private & Confidential
LABELLING
Where do we label?
29
Helios Towers | Private & Confidential
LABELLING
When do we label?
or not readable.
updated.
30
Helios Towers | Private & Confidential
LABELLING
Elteck Monitoring Kit
31
Helios Towers | Private & Confidential
Troubleshooting Fig 1
Online
Offline Teltonika
Not activated
Fig 3
32
Helios Towers | Private & Confidential
33
Helios Towers | Private & Confidential
then we cannot see rectifier data.. Team must make sure the LAN/Ethernet cable
is always in controller.
34
Helios Towers | Private & Confidential
35
Helios Towers | Private & Confidential
36
Helios Towers | Private & Confidential
❑ Communication
Port Then Basic setup make sure the baud rate set is the
37
Helios Towers | Private & Confidential
38
Helios Towers | Private & Confidential
The Temper will be recorded in RTL list, SWO issued and Sending escalation
Second Attempt:
management
Third Attempt:
Responsible FE will be blocked from Accessing the site, Updated in Master RTL
list , Apply SLA -4 and sending escalation mail to HTT & MP ops Management
39
Thank you