Professional Documents
Culture Documents
Weber Euroflor Design
Weber Euroflor Design
Weber Euroflor Design
Rapid hardening tension relieved self-leveling design floor, with a layer thickness
from 2 to 50 mm.
UAE
PACKAGING 23 kg
ADVANTAGES
• Unlimited colors and designs
• UV stable suitable for outside
• Crack free
• Low carbon foot print
• Eco-Binder technology
• Environmentally friendly
• Dimensionally stable
• High abrasion resistance
• High surface tensile strength
• Mineral based, single component
• Very low emission, meets EMICODE EC1PLUS
PRODUCT • Resistance against salt water and chemicals
euroflor Design is a rapid hardening self-leveling, • Can be exposed to a temperature of -40°C to 500°C
dimensionally stable, eco green system, carefully produced • Water vapor permeable
based on environmentally friendly binder, to bring out an
incomparable esthetically pleasing surface design floor. CHARACTERISTICS
euroflor Design can be used internally and externally, Bulk density approx. 1.2 kg/Lit
for leveling differences in thicknesses from 2 to 50 mm, on Color Unlimited colors
new or existing substrates. Fresh mortar density approx. 2.0 kg/Lit
Strength class CT-C35-F10 according
SCOPE OF USE to DIN EN 13813
euroflor Design flooring mortar is highly flowable, Abrasion resistance High
harden without stress creating a seamless crack free Compressive strength > 35 Mpa
hygienic, easy to clean surface and suitable: Flexural strength – EN approx. 10.0 N/mm2
13813:2003
• For Internal and external applications (standard precautions Application temperature Min. +15 °C, max. +40 °C
to be taken for hot weather application, please refer to our Application thickness 2 – 50 mm
technical department for advice). Walkable / Ready for Sealer after 3 hours
• As a decorative covering of concrete and screed, (when cured @ 20 °C)
applicable in layer thicknesses up to 50mm. Fully loadable 3 days
Mixing ratio 4.2 – 4.4 Lit water
*Note: for large areas, a layer thickness of approx. 3 – 5 mm per 23 kg powder
is recommended. Workability time approx. 30 min (at 20°C)
approx. 15 min (at 40°C)
• As an overlayement for: Concrete, cement, heated and Consumption approx. 1.8 kg / m² at 1 mm
non-heated floor, dry screed and adhered tiles coverings layer thickness
(Please contact the technical department). VOC emission Very low emission EC1plus
OUTDOOR APPLICATION
For outdoor application, the following precautions should be
restrictedly taken into consideration:
• It is recommended to work during evening time.
• The application area should be shaded.
• After surface preparation, the application area should be
protected from any kind of dust and heavy wind (during
application and for the first 24 hours).
• The temperature of the freshly mixed material should be
in the range of 20 °C to 30 °C. (use cold water or ice if
necessary).
• The freshly applied material should be protected from
any kind of water precipitation (dew drops, water
condensation, rain, etc..).
• Application area should be divided into manageable parts.
APPLICABLE STANDARDS
EN 13813:2003 ; EN 13892-8:2002 ; EN 13872.
PROTECTION
euroflor Design must be sealed with euroflor seal
which can be applied after initial hardness and acceptance
of light foot traffic normally between 4-6 hours (Please refer
to technical data sheet of euroflor seal for more
information).