Professional Documents
Culture Documents
2.2 Ricwil Pre-Insulated
2.2 Ricwil Pre-Insulated
2.2 Ricwil Pre-Insulated
AS/NZS 1571
ESPECIALLY PRODUCED TO MEET THE REQUIREMENTS OF
THE NEW GENERATION OZONE FRIENDLY REFRIGERANTS
www.ricwil.com
“RICWIL – COPPER” AIR CONDITIONING
& REFRIGERATION TUBE TO AS/NZ 1571
“Ricwil-Copper” seamless copper tubes are manufactured under OEM by
Hailiang Co. Ltd., China’s largest copper tube manufacturer, to Austral-
ian/New Zealand Standard AS/NZS 1571. These tubes are conventionally
used for Air Conditioning, Refrigeration & Medical Gas applications. Work-
ing with Hailiang, we are confident of our tubes’ quality and performance.
Our tubes are suitable for a wide range of liquids and gases including
R410A. Sizes available are from 6.35mm (1/4”) to 53.98mm (2-1/8”) di-
ameters with thicknesses ranging from 0.51mm to 2.64mm. The tubes
are available in 15m pancake coils or 5.8m straight length pipes, details
of products available as per table on the following page. All our tubes
come protected with end caps to prevent contamination within the pipes
during transit, prior to commissioning.
Copper 99.90
TEMPERS
Element Hardness HV
Annealed 75 maximum
Special temper 48 - 56
Special temper usually specified for applications where straight length are expended into crossfin coils.
DIMENSIONS AND TOLERANCES
OUTSIDE DIAMETER (OD)
The mean outside diameter for tube in all tempers, either coiled or in straight length should not vary from
the specified diameter by more than the tolerance specified.
TOLERANCE ON OD
SPECIFIED OD (mm)
PLUS NIL,MINUS(mm)
UP TO AND STRAIGHT
OVER COILS
INCLUDING LENGTH
3.18 12.70 0.08 0.13
12.70 19.05 0.08 0.20
19.05 25.40 0.08 0.31
23.40 31.75 0.08 0.38
31.75 50.80 0.08 0.46
50.80 101.60 0.15 -
101.60 155.58 0.30 -
THICKNESS
The standard thickness at any point tolerance for tube either coiled or in straight length is ±10% of the
specified thickness.
LENGTH
Tube ordered to a specified length should not vary from that length by more than tolerances specified.
CLEANNESS
Tubes are manufactured to meet the internal residue requirement of ≤ 38mg/m 2
The three major activities of Ricwil (Malaysia) Sdn Bhd are in manufacturing, contracting and engi
neering trading. Incorporated in year 1984, Ricwil (Malaysia) Sdn Bhd, was then with 51% Malaysian
Shareholdings and Ricwil Japan had 49% equity, is licensed to manufacture preinsulated pipes un-
der the Industrial Co-ordination Act 1975. Since December 2007 Ricwil (Malaysia) Sdn Bhd is 100%
wholly owned by Malaysians.
Competent Japanese engineers were in Malaysia to train our local technicians for one and a half
years. Ricwil (Malaysia) Sdn Bhd provides services world wide to countries such as Singapore, Indo-
nesia, Nepal, Brunei, Philippines, Middle East, Hong Kong, Taiwan, Myanmar, Vietnam, Cambodia, Sri
Lanka, Bangladesh and Thailand, etc.
No. 122, Jalan 4D, Kampung Baru Subang,Seksyen U6, 40150 Shah Alam,
Selangor Darul Ehsan, Malaysia