Download as pdf or txt
Download as pdf or txt
You are on page 1of 100

OWNER’S MANUAL

XV19CTSW(C)
XV19CTW(C)
XV19CTMW(C)
LIT-11626-20-41 2C5-28199-11
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

EAU10041

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

INTRODUCTION
EAU10080

Congratulations on your purchase of the Yamaha XV19CTSW(C)/XV19CTW(C)/XV19CTMW(C). This model is the result of
Yamaha’s vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high
degree of craftsmanship and reliability that have made Yamaha a leader in these fields.
This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. If you
have any questions concerning the operation or maintenance of your motorcycle, please consult a Yamaha dealer.
The design and manufacture of this Yamaha motorcycle fully comply with the emissions standards for clean air applicable at
the date of manufacture. Yamaha has met these standards without reducing the performance or economy of operation of the
motorcycle. To maintain these high standards, it is important that you and your Yamaha dealer pay close attention to the
recommended maintenance schedules and operating instructions contained within this manual.

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

IMPORTANT MANUAL INFORMATION


EAU10131

Particularly important information is distinguished in this manual by the following notations:


The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS
INVOLVED!

Failure to follow WARNING instructions could result in severe injury or death to the
WARNING motorcycle operator, a bystander or a person inspecting or repairing the motor-
cycle.

A CAUTION indicates special precautions that must be taken to avoid damage to


CAUTION: the motorcycle.

NOTE: A NOTE provides key information to make procedures easier or clearer.

NOTE:
● This manual should be considered a permanent part of this motorcycle and should remain with it even if the motorcycle
is subsequently sold.
● Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most
current product information available at the time of printing, there may be minor discrepancies between your motorcycle
and this manual. If you have any questions concerning this manual, please consult your Yamaha dealer.
EWA10010

WARNING
PLEASE READ THIS MANUAL AND THE “YOU AND YOUR MOTORCYCLE: RIDING TIPS” BOOKLET CAREFULLY
AND COMPLETELY BEFORE OPERATING THIS MOTORCYCLE. DO NOT ATTEMPT TO OPERATE THIS MOTOR-
CYCLE UNTIL YOU HAVE ATTAINED ADEQUATE KNOWLEDGE OF ITS CONTROLS AND OPERATING FEATURES

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

IMPORTANT MANUAL INFORMATION


AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS
AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE THAT YOU SAFELY ENJOY
THE CAPABILITIES AND THE RELIABILITY OF THIS MOTORCYCLE.
*Product and specifications are subject to change without notice.

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

IMPORTANT MANUAL INFORMATION

EAU10192

AFFIX DEALER
LABEL HERE

XV19CTSW(C)/XV19CTW(C)/XV19CTMW(C)
OWNER’S MANUAL
©2006 by Yamaha Motor Corporation, U.S.A.
1st edition, July 2006
All rights reserved.
Any reprinting or unauthorized use
without the written permission of
Yamaha Motor Corporation, U.S.A.
is expressly prohibited.
Printed in Japan.
P/N LIT-11626-20-41

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

TABLE OF CONTENTS
SAFETY INFORMATION ..................1-1 Auxiliary DC connector ................ 3-23 Accessories and replacement
Location of important labels ...........1-5 parts .......................................... 6-16
PRE-OPERATION CHECKS ............. 4-1 Clutch lever .................................. 6-16
DESCRIPTION ..................................2-1 Pre-operation check list ................. 4-2 Adjusting the rear brake light
Left view ..........................................2-1 switch ........................................ 6-17
Right view ........................................2-2 OPERATION AND IMPORTANT Checking the front and rear
Controls and instruments ................2-3 RIDING POINTS ................................ 5-1 brake pads ................................ 6-17
Starting the engine ......................... 5-1 Checking the brake and clutch
INSTRUMENT AND CONTROL Shifting ........................................... 5-2 fluid levels ................................. 6-18
FUNCTIONS .......................................3-1 Engine break-in .............................. 5-3 Changing the brake and clutch
Main switch/steering lock ................3-1 Parking ........................................... 5-4 fluids ......................................... 6-19
Indicator and warning lights ............3-2 Drive belt slack ............................. 6-19
Multi-function meter unit .................3-3 PERIODIC MAINTENANCE AND Checking and lubricating the
Handlebar switches ........................3-7 MINOR REPAIR................................. 6-1 cables ....................................... 6-20
Clutch lever ....................................3-9 PERIODIC MAINTENANCE .......... 6-1 Checking and lubricating the
Shift pedal ......................................3-9 Owner’s tool kit .............................. 6-1 throttle grip and cable ............... 6-20
Brake lever .....................................3-9 Periodic maintenance chart for the Checking and lubricating the
Brake pedal ..................................3-10 emission control system ............. 6-3 brake and shift pedals ............... 6-21
Fuel tank cap ................................3-10 General maintenance and Checking and lubricating the
Fuel ..............................................3-11 lubrication chart .......................... 6-4 brake and clutch levers ............. 6-21
Catalytic converter ........................3-12 Checking the spark plugs .............. 6-8 Checking and lubricating the
Rider seat .....................................3-12 Canister (for California only) .......... 6-9 sidestand .................................. 6-22
Passenger backrest ......................3-13 Engine oil and oil filter cartridge ..... 6-9 Lubricating the rear suspension ... 6-22
Helmet holder ...............................3-14 Transfer case oil .......................... 6-12 Checking the front fork ................. 6-23
Windshield ....................................3-15 Air filter element ........................... 6-13 Checking the steering .................. 6-23
Sidebags ......................................3-17 Checking the throttle cable free Checking the wheel bearings ....... 6-24
Adjusting the shock absorber play ........................................... 6-13 Battery .......................................... 6-24
assembly ...................................3-19 Valve clearance ........................... 6-13 Replacing the fuses ...................... 6-26
EXUP system ...............................3-20 Tires ............................................. 6-14 Replacing a headlight bulb ........... 6-27
Sidestand .....................................3-21 Cast wheels ................................. 6-15 Tail/brake light .............................. 6-30
Ignition circuit cut-off system ........3-21

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

TABLE OF CONTENTS
Replacing a turn signal light
bulb ...........................................6-30
License plate light .........................6-31
Supporting the motorcycle ............6-31
Troubleshooting ............................6-32
Troubleshooting chart ...................6-33

MOTORCYCLE CARE AND


STORAGE ..........................................7-1
Matte color caution .........................7-1
Care ................................................7-1
Storage ...........................................7-4

SPECIFICATIONS .............................8-1

CONSUMER INFORMATION.............9-1
Identification numbers ....................9-1
Reporting safety defects .................9-3
Motorcycle noise regulation ............9-4
Maintenance record ........................9-5
YAMAHA MOTOR CORPORATION,
U.S.A. STREET AND ENDURO
MOTORCYCLE LIMITED
WARRANTY ................................9-7
YAMAHA EXTENDED SERVICE
(Y.E.S.) ........................................9-9

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION
EAU10281
AND/OR WHEN MADE NECES- • Ride where other motorists can
SARY BY MECHANICAL CONDI- see you. Avoid riding in another
MOTORCYCLES ARE SINGLE TIONS. motorist’s blind spot.
TRACK VEHICLES. THEIR SAFE USE ● Many accidents involve inexperi- 1
AND OPERATION ARE DEPENDENT Safe riding enced operators. In fact, many op-
UPON THE USE OF PROPER RIDING ● Always make pre-operation erators who have been involved in
TECHNIQUES AS WELL AS THE EX- checks. Careful checks may help accidents do not even have a cur-
PERTISE OF THE OPERATOR. EV- prevent an accident. rent motorcycle license.
ERY OPERATOR SHOULD KNOW ● This motorcycle is designed to car- • Make sure that you are qualified
THE FOLLOWING REQUIREMENTS ry the operator and a passenger. and that you only lend your
BEFORE RIDING THIS MOTOR- ● The failure of motorists to detect motorcycle to other qualified op-
CYCLE. and recognize motorcycles in traf- erators.
HE OR SHE SHOULD: fic is the predominating cause of • Know your skills and limits.
● OBTAIN THOROUGH INSTRUC- automobile/motorcycle accidents. Staying within your limits may
TIONS FROM A COMPETENT Many accidents have been caused help you to avoid an accident.
SOURCE ON ALL ASPECTS OF by an automobile driver who did • We recommend that you prac-
MOTORCYCLE OPERATION. not see the motorcycle. Making tice riding your motorcycle
● OBSERVE THE WARNINGS AND yourself conspicuous appears to where there is no traffic until you
MAINTENANCE REQUIRE- be very effective in reducing the have become thoroughly famil-
MENTS IN THE OWNER’S MAN- chance of this type of accident. iar with the motorcycle and all of
UAL. Therefore: its controls.
● OBTAIN QUALIFIED TRAINING • Wear a brightly colored jacket. ● Many accidents have been caused
IN SAFE AND PROPER RIDING • Use extra caution when you are by error of the motorcycle opera-
TECHNIQUES. approaching and passing tor. A typical error made by the op-
● OBTAIN PROFESSIONAL TECH- through intersections, since in- erator is veering wide on a turn
NICAL SERVICE AS INDICATED tersections are the most likely
BY THE OWNER’S MANUAL places for motorcycle accidents
to occur.

1-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION
due to EXCESSIVE SPEED or un- ● This motorcycle is designed for on- cause burns. Always wear protec-
dercornering (insufficient lean an- road use only. It is not suitable for tive clothing that covers your legs,
gle for the speed). off-road use. ankles, and feet.
1 • Always obey the speed limit and ● A passenger should also observe
never travel faster than warrant- Protective apparel the above precautions.
ed by road and traffic conditions. The majority of fatalities from motor-
• Always signal before turning or cycle accidents are the result of head Modifications
changing lanes. Make sure that injuries. The use of a safety helmet is Modifications made to this motorcycle
other motorists can see you. the single most critical factor in the pre- not approved by Yamaha, or the re-
● The posture of the operator and vention or reduction of head injuries. moval of original equipment, may ren-
passenger is important for proper ● Always wear an approved helmet. der the motorcycle unsafe for use and
control. ● Wear a face shield or goggles. may cause severe personal injury.
• The operator should keep both Wind in your unprotected eyes Modifications may also make your
hands on the handlebar and could contribute to an impairment motorcycle illegal to use.
both feet on the operator foot- of vision that could delay seeing a
rests during operation to main- hazard. Loading and accessories
tain control of the motorcycle. ● The use of a jacket, heavy boots, Adding accessories or cargo to your
• The passenger should always trousers, gloves, etc., is effective in motorcycle can adversely affect stabili-
hold onto the operator, the seat preventing or reducing abrasions ty and handling if the weight distribution
strap or grab bar, if equipped, or lacerations. of the motorcycle is changed. To avoid
with both hands and keep both ● Never wear loose-fitting clothes, the possibility of an accident, use ex-
feet on the passenger footrests. otherwise they could catch on the treme caution when adding cargo or
• Never carry a passenger unless control levers, footrests, or wheels accessories to your motorcycle. Use
he or she can firmly place both and cause injury or an accident. extra care when riding a motorcycle
feet on the passenger footrests. ● Never touch the engine or exhaust that has added cargo or accessories.
● Never ride under the influence of system during or after operation. Here are some general guidelines to
alcohol or other drugs. They become very hot and can follow if loading cargo or adding acces-
sories to your motorcycle:

1-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION
Loading bags, duffel bags, or tents, can limit suspension travel, steering
The total weight of the operator, pas- create unstable handling or a slow travel or control operation, or ob-
senger, accessories and cargo must steering response. scure lights or reflectors.
not exceed the maximum load limit. Accessories • Accessories fitted to the handle- 1
Genuine Yamaha accessories have bar or the front fork area can
Maximum load: been specifically designed for use on create instability due to improper
186 kg (410 lb) this motorcycle. Since Yamaha cannot weight distribution or aerody-
test all other accessories that may be namic changes. If accessories
When loading within this weight limit,
available, you must personally be re- are added to the handlebar or
keep the following in mind:
sponsible for the proper selection, in- front fork area, they must be as
● Cargo and accessory weight
stallation and use of non-Yamaha lightweight as possible and
should be kept as low and close to
accessories. Use extreme caution should be kept to a minimum.
the motorcycle as possible. Make
when selecting and installing any ac- • Bulky or large accessories may
sure to distribute the weight as
cessories. seriously affect the stability of
evenly as possible on both sides of
Keep the following guidelines in mind, the motorcycle due to aerody-
the motorcycle to minimize imbal-
as well as those provided under “Load- namic effects. Wind may at-
ance or instability.
ing” when mounting accessories. tempt to lift the motorcycle, or
● Shifting weights can create a sud-
● Never install accessories or carry the motorcycle may become un-
den imbalance. Make sure that ac-
cargo that would impair the perfor- stable in cross winds. These ac-
cessories and cargo are securely
mance of your motorcycle. Care- cessories may also cause
attached to the motorcycle before
fully inspect the accessory before instability when passing or being
riding. Check accessory mounts
using it to make sure that it does passed by large vehicles.
and cargo restraints frequently.
not in any way reduce ground • Certain accessories can dis-
● Never attach any large or heavy
clearance or cornering clearance, place the operator from his or
items to the handlebar, front fork,
her normal riding position. This
or front fender. These items, in-
improper position limits the free-
cluding such cargo as sleeping
dom of movement of the opera-

1-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION
tor and may limit control ability, ● Always turn the engine off before or clothing, immediately wash the
therefore, such accessories are leaving the motorcycle unattended affected area with soap and water
not recommended. and remove the key from the main and change your clothes.
1 ● Use caution when adding electri- switch. When parking the motor-
cal accessories. If electrical acces- cycle, note the following:
sories exceed the capacity of the • The engine and exhaust system
motorcycle’s electrical system, an may be hot, therefore, park the
electric failure could result, which motorcycle in a place where pe-
could cause a dangerous loss of destrians or children are not like-
lights or engine power. ly to touch these hot areas.
• Do not park the motorcycle on a
Gasoline and exhaust gas slope or soft ground, otherwise it
● GASOLINE IS HIGHLY FLAMMA- may fall over.
BLE: • Do not park the motorcycle near
• Always turn the engine off when a flammable source, (e.g., a ker-
refueling. osene heater, or near an open
• Take care not to spill any gaso- flame), otherwise it could catch
line on the engine or exhaust fire.
system when refueling. ● When transporting the motorcycle
• Never refuel while smoking or in in another vehicle, make sure that
the vicinity of an open flame. it is kept upright. If the motorcycle
● Never start the engine or let it run should lean over, gasoline may
for any length of time in a closed leak out of the fuel tank.
area. The exhaust fumes are poi- ● If you should swallow any gaso-
sonous and may cause loss of line, inhale a lot of gasoline vapor,
consciousness and death within a or allow gasoline to get into your
short time. Always operate your eyes, see your doctor immediately.
motorcycle in an area that has ad- If any gasoline spills on your skin
equate ventilation.
1-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 5 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION
EAU10381

Location of important labels


Please read the following important labels carefully before operating this vehicle.
1

1-5
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 6 Friday, July 14, 2006 2:51 PM

SAFETY INFORMATION

1-6
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

DESCRIPTION
EAU10410

Left view

1. Headlight (page 6-27) 9. Sidebag (page 3-17)


2. Windshield (page 3-15) 10.License plate light (page 6-31)
3. Clutch fluid reservoir (page 6-18) 11.Tail/brake light (page 6-30)
4. Seat lock (page 3-12) 12.Engine oil drain bolt B (crankcase) (page 6-9)
5. Main fuse (page 6-26) 13.Engine oil drain bolt A (crankcase) (page 6-9)
6. Battery (page 6-24) 14.Shift pedal (page 3-9)
7. Owner’s tool kit (page 6-1)
8. Passenger backrest (page 3-13)

2-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

DESCRIPTION
EAU10420

Right view

1. Helmet holder (page 3-14) 9. Engine oil filter cartridge (page 6-9)
2. Fuel injection system fuse (page 6-26) 10.Engine oil drain bolt (oil tank) (page 6-9)
3. Rear brake fluid reservoir (page 6-18) 11.Shock absorber assembly spring preload adjusting nut (page 3-19)
4. Fuse box (page 6-26)
5. Engine oil filler cap (page 6-9)
6. Fuel tank cap (page 3-10)
7. Front brake fluid reservoir (page 6-18)
8. Brake pedal (page 3-10)

2-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

DESCRIPTION
EAU10430

Controls and instruments

1. Clutch lever (page 3-9)


2. Left handlebar switches (page 3-7)
3. Multi-function meter unit (page 3-3)
4. Main switch/steering lock (page 3-1)
5. Right handlebar switches (page 3-7)
6. Throttle grip (page 6-13)
7. Brake lever (page 3-9)

2-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU38390 EAU10540
To lock the steering
Main switch/steering lock ON
The main switch/steering lock is locat- All electrical circuits are supplied with
ed under the main switch/steering lock power, and the meter lighting, taillight,
cover. To access the main license plate light and position lights
switch/steering lock, slide the cover for- come on, and the engine can be start-
ward. ed. The key cannot be removed.
NOTE:
3 The headlight comes on automatically
when the engine is started and stays on
until the key is turned to “OFF”, even if 1. Push.
the engine stalls. 2. Turn.

1. Turn the handlebars all the way to


EAU10660
OFF the left.
All electrical systems are off. The key 2. Push the key in from the “OFF” po-
1. Main switch/steering lock cover can be removed. sition, and then turn it to “LOCK”
2. Main switch/steering lock while still pushing it.
EAU10680 3. Remove the key.
The main switch/steering lock controls LOCK
the ignition and lighting systems, and is The steering is locked, and all electrical
used to lock the steering. The various systems are off. The key can be re-
positions are described below. moved.

3-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


To unlock the steering EAU11003 EAU11080

Indicator and warning lights High beam indicator light “ ”


This indicator light comes on when the
high beam of the headlight is switched
on.

EAU11361
Fuel level warning light “ ”
This warning light comes on when the
fuel level drops below approximately 3
3.0 L (0.79 US gal) (0.66 Imp.gal).
1. Push. When this occurs, refuel as soon as
2. Turn. 1. Neutral indicator light “ ” possible.
2. High beam indicator light “ ” The electrical circuit of the warning light
Push the key in, and then turn it to 3. Right turn signal indicator light “ ” can be checked by turning the key to
“OFF” while still pushing it. 4. Left turn signal indicator light “ ” “ON”.
EWA10060 5. Engine trouble warning light “ ”
If the warning light does not come on
WARNING 6. Fuel level warning light “ ”
for a few seconds, and then go off,
Never turn the key to “OFF” or have a Yamaha dealer check the elec-
EAU11030
“LOCK” while the vehicle is moving, Turn signal indicator lights “ ” and trical circuit.
otherwise the electrical systems will “ ”
be switched off, which may result in NOTE:
The corresponding indicator light flash-
loss of control or an accident. Make This model is also equipped with a self-
es when the turn signal switch is
sure that the vehicle is stopped be- diagnosis device for the fuel level de-
pushed to the left or right.
fore turning the key to “OFF” or tection circuit. If the fuel level detection
“LOCK”. EAU11060
circuit is defective, the following cycle
Neutral indicator light “ ” will be repeated until the malfunction is
This indicator light comes on when the corrected: The fuel level warning light
transmission is in the neutral position.

3-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


will flash eight times, and then go off for EAU38423
● an odometer (which shows the to-
3.0 seconds. If this occurs, have a Multi-function meter unit tal distance traveled)
Yamaha dealer check the vehicle. ● two tripmeters (which show the
distance traveled since they were
EAU11530
last set to zero)
Engine trouble warning light “ ” ● a fuel reserve tripmeter (which
This warning light comes on or flashes shows the distance traveled on the
when an electrical circuit monitoring the fuel reserve)
3 engine is defective. When this occurs, ● a clock
have a Yamaha dealer check the self- ● a self-diagnosis device
diagnosis system. (See page 3-3 for an ● a brightness control mode
explanation of the self-diagnosis de- 1. Speedometer
2. Fuel gauge
NOTE:
vice.)
3. Odometer/tripmeter/fuel reserve tripme- ● Be sure to turn the key to “ON” be-
The electrical circuit of the warning light
ter/clock fore using the “SELECT” and “RE-
can be checked by turning the key to
4. Tachometer SET” switches, except for setting
“ON”. If the warning light does not come
the brightness control mode.
on for a few seconds, then go off, have EWA12421

WARNING ● To switch the odometer, the trip-


a Yamaha dealer check the electrical
meters and the fuel reserve trip-
circuit. Be sure to stop the vehicle before
meter displays between kilometers
making any setting changes to the
and miles, press the “SELECT”
multi-function meter unit.
switch for at least two seconds.
The multi-function meter unit is
equipped with the following:
● a speedometer (which shows the
riding speed)
● a tachometer (which shows the en-
gine speed)
● a fuel gauge

3-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


Speedometer Tachometer

3
1. “SELECT” switch
1. Speedometer 1. Tachometer
2. Tachometer red zone
The speedometer shows the riding
speed. The electric tachometer allows the rider
When the key is turned to “ON”, the to monitor the engine speed and keep it
speedometer needle will sweep once within the ideal power range.
across the speed range and then return When the key is turned to “ON”, the ta-
to zero in order to test the electrical cir- chometer needle will sweep once
cuit. across the r/min range and then return
to zero r/min in order to test the electri-
1. “RESET” switch
cal circuit.
ECA10031

CAUTION:
Do not operate the engine in the ta-
chometer red zone.
Red zone: 5000 r/min and above

3-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 5 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


Fuel gauge ● The fuel gauge does not indicate start counting the distance traveled
the correct fuel level for the first 5 from that point. In that case, push the
km/h (3 mi/h) after refueling. “SELECT” switch to switch the display
between the various tripmeter, odome-
ter, and clock modes in the following or-
Odometer, tripmeter, and clock
der:
modes
F-TRIP → TRIP 1 → TRIP 2 → Clock
→ ODO → F-TRIP
3 To reset a tripmeter, select it by push-
ing the “SELECT” switch, and then
1. Fuel gauge push the “RESET” switch for at least
one second. If you do not reset the fuel
The fuel gauge indicates the amount of reserve tripmeter manually, it will reset
fuel in the fuel tank. The needle moves itself automatically, and the display will
towards “E” (Empty) as the fuel level return to the prior mode after refueling
decreases. When the needle reaches and traveling 5 km (3 mi).
“E”, approximately 3.0 L (0.79 US gal) 1. Odometer/tripmeter/fuel reserve tripme-
(0.66 Imp.gal) remain in the fuel tank. If ter/clock
Clock mode
this occurs, refuel as soon as possible. Push the “SELECT” switch to switch
When the key is turned to “ON”, the fuel the display between the odometer
gauge needle will sweep once across mode “ODO”, the tripmeter modes
the fuel level range and then return to “TRIP 1” and “TRIP 2” and the clock
the current amount in order to test the mode in the following order:
electrical circuit. ODO → TRIP 1 → TRIP 2 → Clock →
NOTE: ODO
● Do not allow the fuel tank to empty If the fuel level warning light comes on
itself completely. (see page 3-2), the odometer display
will automatically change to the fuel re- 1. Clock
serve tripmeter mode “F-TRIP” and
3-5
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 6 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


To set the clock: If the odometer/tripmeter/clock display ● the multi-function meter unit panel
1. Push the “SELECT” switch to indicates any error codes, note the (item number “1”)
change the display to the clock code number, and then have a Yamaha ● the LCD (item number “2”)
mode. dealer check the vehicle. ● the speedometer, tachometer, and
2. Push the “SELECT” and “RESET” ECA11590
the fuel gauge needles (item num-
switches together for at least two CAUTION: ber “3”)
seconds. If the display indicates an error Select the brightness control mode as
3. When the hour digits start flashing, code, the vehicle should be checked follows.
push the “RESET” switch to set the as soon as possible in order to avoid 1. Turn the key to “OFF”. 3
hours. engine damage. 2. Push and hold the “SELECT”
4. Push the “SELECT” switch, and switch.
the minute digits will start flashing. 3. Turn the key to “ON”, and then re-
Brightness control mode
5. Push the “RESET” switch to set lease the “SELECT” switch after
the minutes. five seconds.
6. Push the “SELECT” switch and Item number “1” is displayed.
then release it to start the clock.

Self-diagnosis devices
This model is equipped with a self-diag-
nosis device for various electrical cir-
cuits.
If any of those circuits are defective, the
engine trouble warning light will come 1. Multi-function meter unit panel
on, and then the odometer/tripme- 2. LCD
3. Speedometer needle
ter/clock display will indicate a two-digit 1. Multi-function meter unit panel
4. Tachometer needle
error code (e.g., 12, 13, 14). 2. Item number
5. Fuel gauge needle
3. Brightness level
The brightness can be adjusted for the
following:
3-6
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 7 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


4. Adjust the multi-function meter unit EAU12347

panel brightness level by pushing Handlebar switches


the “RESET” switch. Left
5. Push the “SELECT” switch to se-
lect the LCD.
Item number “2” is displayed.
Adjust the LCD brightness level by
pushing the “RESET” switch.
3
1. Speedometer needle
2. Tachometer needle
3. Fuel gauge needle
4. Item number 1. Dimmer switch “ / ”
5. Brightness level 2. Turn signal switch “ / ”
3. Horn switch “ ”
7. Push the “SELECT” switch.
The odometer/tripmeter/clock dis- Right
play will return to the prior mode.
1. LCD
2. Item number
3. Brightness level

6. Push the “SELECT” switch to se-


lect the speedometer, tachometer,
and the fuel gauge needles.
Item number “3” is displayed.
Adjust the brightness level of the
speedometer, tachometer, and the 1. Engine stop switch “ / ”
fuel gauge needles by pushing the 2. Light switch (for optional lights) “ ”
3. Start switch “ ”
“RESET” switch.
3-7
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 8 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU12400 EAU12500 EAU12710
Dimmer switch “ / ” Horn switch “ ” Start switch “ ”
Set this switch to “ ” for the high Press this switch to sound the horn. Push this switch to crank the engine
beam and to “ ” for the low beam. with the starter.
EAU12660 ECA10050

EAU12430
Engine stop switch “ / ” CAUTION:
Turn signal switch “ / ” Set this switch to “ ” before starting
See page 5-1 for starting instruc-
To signal a right-hand turn, push this the engine. Set this switch to “ ” to
tions prior to starting the engine.
switch to “ ”. To signal a left-hand stop the engine in case of an emergen-
turn, push this switch to “ ”. When re- cy, such as when the vehicle overturns 3
EAU41700
leased, the switch returns to the center or when the throttle cable is stuck.
The engine trouble warning light will
position.
come on when the key is turned to “ON”
Since this model is equipped with a EAU38331
Light switch (for optional lights) and the start switch is pushed, but this
self-canceling system, the turn signal
“ ” does not indicate a malfunction.
lights will self-cancel after the vehicle
This model can be equipped with op-
has traveled both about 150 m (490 ft)
tional lights available at a Yamaha
and for approximately 15 seconds.
dealer.
However, the turn signal lights can also
Push this switch to the left to turn the
be canceled manually by pushing the
optional lights on and to the right to turn
switch in after it has returned to the cen-
them off.
ter position. ECA15321

NOTE: CAUTION:
The self-canceling system only oper- Do not install a bulb which exceeds
ates when the vehicle is moving, so that 12 V, 35 W in either light, otherwise
the turn signal lights will not self-cancel the headlight fuse may blow or the
while you are stopped at an intersec- battery may discharge.
tion.

3-8
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 9 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU12820 EAU12880 EAU12890

Clutch lever Shift pedal Brake lever

1. Clutch lever 1. Shift pedal 1. Brake lever

The clutch lever is located at the left The shift pedal is located on the left The brake lever is located at the right
handlebar grip. To disengage the side of the engine and is used in com- handlebar grip. To apply the front
clutch, pull the lever toward the handle- bination with the clutch lever when brake, pull the lever toward the handle-
bar grip. To engage the clutch, release shifting the gears of the 5-speed con- bar grip.
the lever. The lever should be pulled stant-mesh transmission equipped on
rapidly and released slowly for smooth this motorcycle.
clutch operation.
NOTE:
The clutch lever is equipped with a
Use your toes or heel to shift up and
clutch switch, which is part of the igni-
your toes to shift down.
tion circuit cut-off system. (See page
3-21.)

3-9
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 10 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU12941 EAU13120
2. Turn the key counterclockwise to
Brake pedal Fuel tank cap the original position, remove it, and
then close the lock cover.
NOTE:
The fuel tank cap cannot be installed
unless the key is in the lock. In addition,
the key cannot be removed if the cap is
not properly installed and locked. 3
EWA10130

WARNING
1. Brake pedal 1. Fuel tank cap lock cover Make sure that the fuel tank cap is
2. “ ” mark properly installed before riding.
The brake pedal is on the right side of 3. Unlock.
the motorcycle. To apply the rear 4. Lock.
brake, press down on the brake pedal.
To remove the fuel tank cap
Slide the lock cover open, insert the key
into the lock, and then turn it 1/4 turn
clockwise. The lock will be released
and the fuel tank cap can be removed.

To install the fuel tank cap


1. Insert the fuel tank cap into the
tank opening with the key inserted
in the lock and with the “ ” mark
facing forward.

3-10
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 11 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU13211 ECA10070
octane number of 95 or higher. If
Fuel CAUTION: knocking (or pinging) occurs, use a
Immediately wipe off spilled fuel gasoline of a different brand. Use of un-
with a clean, dry, soft cloth, since leaded fuel will extend spark plug life
fuel may deteriorate painted surfac- and reduce maintenance costs.
es or plastic parts. Gasohol
There are two types of gasohol: gaso-
EAU13380 hol containing ethanol and that contain-
3 ing methanol. Gasohol containing
ethanol can be used if the ethanol con-
Recommended fuel: tent does not exceed 10%. Gasohol
1. Fuel tank filler tube PREMIUM UNLEADED GASOLINE containing methanol is not recom-
ONLY
2. Fuel level
Fuel tank capacity: mended by Yamaha because it can
17.0 L (4.49 US gal) (3.74 Imp.gal) cause damage to the fuel system or ve-
Make sure that there is sufficient fuel in
Fuel reserve amount (when the fuel hicle performance problems.
the tank. Fill the fuel tank to the bottom level warning light comes on):
of the filler tube as shown. 3.0 L (0.79 US gal) (0.66 Imp.gal)
EWA10880

WARNING ECA11400

● Do not overfill the fuel tank, oth- CAUTION:


erwise it may overflow when the Use only unleaded gasoline. The use
fuel warms up and expands. of leaded gasoline will cause severe
● Avoid spilling fuel on the hot en- damage to internal engine parts,
gine. such as the valves and piston rings,
as well as to the exhaust system.
Your Yamaha engine has been de-
signed to use premium unleaded gaso-
line with a pump octane number
[(R+M)/2] of 91 or higher, or a research
3-11
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 12 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU13431 EAU34042

Catalytic converter Rider seat


This model is equipped with a catalytic
converter in the exhaust system. To remove the rider seat
EWA10860
1. Insert the key into the seat lock,
WARNING and then turn it counterclockwise.
The exhaust system is hot after op-
eration. Make sure that the exhaust
system has cooled down before do- 3
ing any maintenance work.
1. Projection
ECA10700
2. Seat holder
CAUTION:
The following precautions must be 2. Push the front of the seat down to
observed to prevent a fire hazard or lock it in place.
other damages. 3. Remove the key.
● Use only unleaded gasoline. 1. Seat lock NOTE:
The use of leaded gasoline will 2. Unlock.
Make sure that the seat is properly se-
cause unrepairable damage to 2. While holding the key in that posi- cured before riding.
the catalytic converter. tion, lift the front of the seat up, and
● Never park the vehicle near pos- then pull the seat off.
sible fire hazards such as grass
or other materials that easily To install the rider seat
burn. 1. Insert the projection on the rear of
● Do not allow the engine to idle the seat into the seat holder as
too long. shown.

3-12
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 13 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU39154
To install the backrest
Passenger backrest 1. Open the sidebag lids. (See page
3-17.)
To remove the backrest 2. Fit the slot on each backrest brack-
1. Open the sidebag lids. (See page et (left and right side) into the
3-17.) groove of its holder.
2. Insert the key into the passenger ECA15371

backrest lock, turn it counterclock- CAUTION:


3 wise, and then remove the key. Be careful not to scratch the fender
1. Backrest lever when fitting the slot into the groove.
2. Passenger backrest

1. Key
2. Unlock.
1. Slot
3. Pull the lever on each side of the 2. Holder
backrest upward. 4. While holding the levers in the up-
ward position, lift the backrest up- 3. Push the rear of the backrest down
ward and remove it by pulling it to smoothly but forcefully to lock it in
the rear. place and make sure that the lever
5. Close the sidebag lids. hook on each side is securely fit
over its holder.

3-13
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 14 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


4. Insert the key into the passenger EAU38341

backrest lock, turn it clockwise, Helmet holder


and then remove the key.
5. Close the sidebag lids.

1. Helmet holder
2. Helmet holding cable

The helmet holder is located under the


rider seat. A helmet holding cable is
provided beside the owner’s tool kit to
secure a helmet to the helmet holder.

To secure a helmet to the helmet


1. Holder
holder
2. Lever hook
1. Remove the rider seat. (See page
EWA14282 3-12.)
WARNING 2. Pass the helmet holding cable
Both lever hooks must be securely through the buckle on the helmet
fitted over their holder. If the back- strap as shown, and then hook the
rest is loose, a passenger might lose cable loop over the helmet holder.
balance and fall.

3-14
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 15 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


To release the helmet from the hel- EAU39140

met holder Windshield


Remove the rider seat, remove the hel-
met holding cable from the helmet hold- To remove the windshield
er and the helmet, and then install the 1. Insert the key into the windshield
seat. lock, turn it clockwise and then re-
move the key.

3
1. Helmet holding cable
2. Helmet

3. Place the helmet on the left side of


the vehicle, and then install the rid-
er seat.
ECA15330

CAUTION:
1. Key
Be sure to place the helmet on the 2. Unlock.
left side of the vehicle. Some hel-
mets may contact the muffler when 2. Remove the windshield by push-
placed on the right side because of ing it forward, and then pulling it
their size or shape. upward as shown.
EWA10160

WARNING
Never ride with a helmet attached to
the helmet holder, since the helmet
may hit objects, causing loss of con-
trol and possibly an accident.

3-15
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 16 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EWA14300
3. Insert the key into the windshield
WARNING lock, turn it counterclockwise until
Make sure that the throttle cables it stops to lock the fastener, and
are not pinched. then remove the key.
EWA14270

WARNING
Make sure that the fastener is locked
in place as shown.
3

EWA14320

WARNING
Be careful not push the motorcycle
forward when removing the wind-
shield. The motorcycle could fall off 1. Slot
the sidestand. 2. Holder
3. Throttle cable
ECA15350

CAUTION: 2. Push the windshield backward un-


1. Lock.
Securely hold the windshield to pre- til it snaps into place.
2. Fastener
vent it from falling when removing. 3. Holder

To install the windshield


1. Fit the slot in each windshield
bracket (left and right side) into its
holder.

3-16
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 17 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU39132 ECA15380

Sidebags CAUTION:
EWA14340

WARNING To avoid locking the key in, never


lock either sidebag and remove the
Improper loading or overloading can key from the lock before closing the
cause loss of control and possibly lid.
an accident or personal injury. See
pages 1-5 and 6-14 for important
3 loading and tire pressure informa- To open a sidebag lid
tion. 1. Insert the key into the sidebag
● Always securely close the side- lock, and then turn the key coun-
terclockwise. To close a sidebag lid
bags before riding.
1. Fold the sidebag lid down so that
● Distribute weight evenly on
the latch snaps into place.
each side of the motorcycle.
2. Turn the key clockwise, and then
● Do not exceed the load limit of 5
remove it.
kg (11 lb) for each sidebag.
● Do not exceed the maximum
To remove a sidebag
load of 186 kg (410 lb) for the ve-
1. Open the sidebag lid.
hicle.
2. Turn the fasteners counterclock-
● Do not exceed 120 km/h (80
wise, and then remove the side-
mi/h) when riding with luggage
bag by pulling it upward.
in the sidebags, otherwise han- 1. Key
dling could be affected. Improp- 2. Unlock. NOTE:
er loading, poor tire or overall The fasteners will come loose after the
2. Push the key in, and then fold the
motorcycle conditions, poor sidebags are removed. Be sure not to
sidebag lid up.
road surfaces or adverse weath- lose the fasteners.
er conditions may make it nec-
essary to further reduce the
riding speed.
3-17
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 18 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


3. Insert the fasteners through the EWA14311

holes in the sidebag into their hold- WARNING


ers, and then turn them clockwise Make sure that all the fasteners in
until they stop. both sidebags are turned complete-
ly clockwise before riding.

NOTE:
Water can be harmful to untreated
leather. Use Yamaha Saddle Soap or 3
1. Fastener
another quality brand according to the
manufacturer's directions to clean the
To install a sidebag leather on the sidebags. Polish the dry
1. Open the sidebag lid. leather with a soft cloth, and then treat
2. Place the sidebag on the bracket, 1. Fastener
with Yamaha Mink Oil or another high-
and then align all holes in the side- quality leather protectant for increased
bag with the holes in the holders water resistance.
on the bracket.

1. Fastener

4. Close the sidebag lid.


1. Hole
2. Holder

3-18
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 19 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU38401
load and thereby soften the sus- With each complete turn of the ad-
Adjusting the shock absorber pension, turn the adjusting nut in justing nut, distance A is changed
assembly direction (b). by 2.0 mm (0.08 in).
This shock absorber assembly is
equipped with a spring preload adjust-
ing nut.
ECA10100

CAUTION:
3 Never attempt to turn an adjusting
mechanism beyond the maximum or
minimum settings.
Adjust the spring preload as follows.
1. Special wrench
1. Distance A

NOTE: Spring preload:


● To make the adjustment, use the Minimum (hard):
special wrench included in the ad- Distance A = 162 mm (6.38 in)
ditional tool kit, which was handed Standard:
out separately at the purchase of Distance A = 165 mm (6.50 in)
Maximum (soft):
the vehicle. Distance A = 171 mm (6.73 in)
● The spring preload setting is deter-
1. Locknut mined by measuring distance A, 3. Tighten the locknut to the specified
2. Spring preload adjusting nut shown in the illustration. The short- torque.
er distance A is, the higher the
1. Loosen the locknut. spring preload; the longer distance Tightening torque:
2. To increase the spring preload and A is, the lower the spring preload. Locknut:
thereby harden the suspension, 30 Nm (3.0 m·kgf, 22 ft·lbf)
turn the adjusting nut in direction
(a). To decrease the spring pre-
3-19
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 20 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


ECA10120
● Always have a Yamaha dealer EAU15281

CAUTION: service the shock absorber. EXUP system


Always tighten the locknut against This model is equipped with Yamaha’s
the adjusting nut, and then tighten EXUP (EXhaust Ultimate Power valve)
the locknut to the specified torque. system. This system boosts engine
power by means of a valve that regu-
EWA10220
lates the diameter of the exhaust pipe.
WARNING
The EXUP system valve is constantly
This shock absorber contains highly adjusted in accordance with the engine 3
pressurized nitrogen gas. For prop- speed by a computer-controlled servo-
er handling, read and understand motor.
the following information before ECA10191

handling the shock absorber. The CAUTION:


manufacturer cannot be held re- ● The EXUP system has been set
sponsible for property damage or and extensively tested at the
personal injury that may result from Yamaha factory. Changing
improper handling. these settings without sufficient
● Do not tamper with or attempt to technical knowledge may result
open the gas cylinder. in poor performance of or dam-
● Do not subject the shock ab- age to the engine.
sorber to an open flame or other ● If the EXUP system cannot be
high heat sources, otherwise it heard when the main switch is
may explode due to excessive turned on, have a Yamaha deal-
gas pressure. er check it.
● Do not deform or damage the
gas cylinder in any way, as this
will result in poor damping per-
formance.

3-20
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 21 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU15301
below and have a Yamaha dealer re- EAU15311

Sidestand pair it if it does not function proper- Ignition circuit cut-off system
The sidestand is located on the left side ly. The ignition circuit cut-off system (com-
of the frame. Raise the sidestand or prising the sidestand switch, clutch
lower it with your foot while holding the switch and neutral switch) has the fol-
vehicle upright. lowing functions.
● It prevents starting when the trans-
NOTE:
mission is in gear and the side-
The built-in sidestand switch is part of
3 stand is up, but the clutch lever is
the ignition circuit cut-off system, which
not pulled.
cuts the ignition in certain situations.
● It prevents starting when the trans-
(See further down for an explanation of
mission is in gear and the clutch le-
the ignition circuit cut-off system.)
ver is pulled, but the sidestand is
EWA10240
still down.
WARNING ● It cuts the running engine when the
The vehicle must not be ridden with transmission is in gear and the sid-
the sidestand down, or if the side- estand is moved down.
stand cannot be properly moved up Periodically check the operation of the
(or does not stay up), otherwise the ignition circuit cut-off system according
sidestand could contact the ground to the following procedure.
EWA10250
and distract the operator, resulting
in a possible loss of control. WARNING
Yamaha’s ignition circuit cut-off If a malfunction is noted, have a
system has been designed to assist Yamaha dealer check the system be-
the operator in fulfilling the respon- fore riding.
sibility of raising the sidestand be-
fore starting off. Therefore, check
this system regularly as described

3-21
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 22 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS

With the engine turned off:


NOTE:
1. Move the sidestand down.
2. Make sure that the engine stop switch is turned on.
This check is most reliable if performed with
3. Turn the key on. a warmed-up engine.
4. Shift the transmission into the neutral position.
5. Push the start switch.
Does the engine start?
The neutral switch may be defective. 3
YES NO The motorcycle should not be ridden until
checked by a Yamaha dealer.
With the engine still running:
6. Move the sidestand up.
7. Keep the clutch lever pulled.
8. Shift the transmission into gear.
9. Move the sidestand down.
Does the engine stall?
The sidestand switch may be defective.
YES NO The motorcycle should not be ridden until
checked by a Yamaha dealer.
After the engine has stalled:
10. Move the sidestand up.
11. Keep the clutch lever pulled.
12. Push the start switch.
Does the engine start?
The clutch switch may be defective.
YES NO The motorcycle should not be ridden until
checked by a Yamaha dealer.
The system is OK. The motorcycle can be ridden.

3-22
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 23 Friday, July 14, 2006 2:51 PM

INSTRUMENT AND CONTROL FUNCTIONS


EAU38350 EWA12531

Auxiliary DC connector WARNING


To prevent electrical shock or short-
circuiting, make sure that the cap is
installed when the auxiliary DC con-
nector is not being used.

1. Auxiliary DC connector

A 12-V accessory connected to the


auxiliary DC connector under the rider
seat can be used when the key is in the
“ON” position.
ECA15310

CAUTION:
The accessory connected to the
auxiliary DC connector should not
be used with the engine turned off,
and the load must never exceed 36
W (3 A), otherwise the battery may
discharge.

3-23
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

PRE-OPERATION CHECKS
EAU15591

The condition of a vehicle is the owner’s responsibility. Vital components can start to deteriorate quickly and unexpectedly,
even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss
of tire air pressure could have serious consequences. Therefore, it is very important, in addition to a thorough visual inspec-
tion, to check the following points before each ride.
NOTE:
Pre-operation checks should be made each time the vehicle is used. Such an inspection can be accomplished in a very short
time; and the added safety it assures is more than worth the time involved.
EWA11150
4
WARNING
If any item in the Pre-operation check list is not working properly, have it inspected and repaired before operating
the vehicle.

4-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

PRE-OPERATION CHECKS
EAU15605

Pre-operation check list


ITEM CHECKS PAGE

• Check fuel level in fuel tank.


Fuel • Refuel if necessary. 3-11
• Check fuel line for leakage.
• Check oil level in oil tank.
Engine oil • If necessary, add recommended oil to specified level. 6-9
• Check vehicle for oil leakage.
Transfer case oil • Check vehicle for oil leakage. 6-12

4 • Check operation.
• If soft or spongy, have Yamaha dealer bleed hydraulic system.
• Check brake pads for wear.
Front brake • Replace if necessary. 6-17, 6-18
• Check fluid level in reservoir.
• If necessary, add recommended brake fluid to specified level.
• Check hydraulic system for leakage.
• Check operation.
• If soft or spongy, have Yamaha dealer bleed hydraulic system.
• Check brake pads for wear.
Rear brake • Replace if necessary. 6-17, 6-18
• Check fluid level in reservoir.
• If necessary, add recommended brake fluid to specified level.
• Check hydraulic system for leakage.
• Check operation.
• If soft or spongy, have Yamaha dealer bleed hydraulic system.
Clutch • Check fluid level in reservoir. 6-16, 6-18
• If necessary, add recommended fluid to specified level.
• Check hydraulic system for leakage.
• Make sure that operation is smooth.
• Check cable free play.
Throttle grip 6-13, 6-20
• If necessary, have Yamaha dealer adjust cable free play and lubricate cable and
grip housing.

4-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

PRE-OPERATION CHECKS
ITEM CHECKS PAGE

• Make sure that operation is smooth.


Control cables 6-20
• Lubricate if necessary.
• Check for damage.
• Check tire condition and tread depth.
Wheels and tires 6-14, 6-15
• Check air pressure.
• Correct if necessary.
• Make sure that operation is smooth.
Brake and shift pedals 6-21
• Lubricate pedal pivoting points if necessary.
• Make sure that operation is smooth.
Brake and clutch levers 6-21
• Lubricate lever pivoting points if necessary.
4
• Make sure that operation is smooth.
Sidestand 6-22
• Lubricate pivot if necessary.
• Make sure that all nuts, bolts and screws are properly tightened.
Chassis fasteners —
• Tighten if necessary.
Instruments, lights, signals • Check operation.

and switches • Correct if necessary.
• Check operation of ignition circuit cut-off system.
Sidestand switch 3-21
• If system is defective, have Yamaha dealer check vehicle.

4-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

OPERATION AND IMPORTANT RIDING POINTS


EAU15950 EAU16241
off. If a warning light does not go off,
Starting the engine see page 3-2 for the corresponding
EWA10270
In order for the ignition circuit cut-off warning light circuit check.
WARNING system to enable starting, one of the
● Become thoroughly familiar following conditions must be met: 2. Shift the transmission into the neu-
with all operating controls and ● The transmission is in the neutral tral position.
their functions before riding. position. NOTE:
Consult a Yamaha dealer re- ● The transmission is in gear with When the transmission is in the neutral
garding any control or function the clutch lever pulled and the sid- position, the neutral indicator light
that you do not thoroughly un- estand up. should be on, otherwise have a
derstand. EWA10290
Yamaha dealer check the electrical cir-
● Never start the engine or oper- WARNING
cuit.
ate it in a closed area for any ● Before starting the engine,
5 length of time. Exhaust fumes check the function of the igni- 3. Start the engine by pushing the
are poisonous, and inhaling tion circuit cut-off system ac- start switch.
them can cause loss of con- cording to the procedure NOTE:
sciousness and death within a described on page 3-21. If the engine fails to start, release the
short time. Always make sure ● Never ride with the sidestand start switch, wait a few seconds, and
that there is adequate ventila- down. then try again. Each starting attempt
tion. should be as short as possible to pre-
1. Turn the key to “ON” and make
● Before starting out, make sure serve the battery. Do not crank the en-
sure that the engine stop switch is
that the sidestand is up. If the gine more than 10 seconds on any one
set to “ ”.
sidestand is not raised com- ECA11560 attempt.
pletely, it could contact the CAUTION:
ground and distract the opera-
The fuel level warning light and en-
tor, resulting in a possible loss
gine trouble warning light should
of control.
come on for a few seconds, then go

5-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

OPERATION AND IMPORTANT RIDING POINTS


ECA11130 EAU16671 ECA10260

CAUTION: Shifting CAUTION:


For maximum engine life, always ● Even with the transmission in
warm the engine up before starting the neutral position, do not
off. Never accelerate hard when the coast for long periods of time
engine is cold! with the engine off, and do not
tow the motorcycle for long dis-
NOTE: tances. The transmission is
The engine is warm when it quickly re- properly lubricated only when
sponds to the throttle. the engine is running. Inade-
quate lubrication may damage
1. Shift pedal the transmission.
2. Neutral position ● Always use the clutch while 5
Shifting gears lets you control the changing gears to avoid damag-
amount of engine power available for ing the engine, transmission,
starting off, accelerating, climbing hills, and drive train, which are not
etc. designed to withstand the
The gear positions are shown in the il- shock of forced shifting.
lustration.
EAU16680
NOTE: To start out and accelerate
To shift the transmission into the neu- 1. Pull the clutch lever to disengage
tral position, press the shift pedal down the clutch.
repeatedly until it reaches the end of its 2. Shift the transmission into first
travel, and then slightly raise it. gear. The neutral indicator light
should go out.
3. Open the throttle gradually, and at
the same time, release the clutch
lever slowly.
5-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

OPERATION AND IMPORTANT RIDING POINTS


4. At the recommended shift points 3. Shift the transmission into the neu- EAU16841

shown in the following table, close tral position when the motorcycle Engine break-in
the throttle, and at the same time, is almost completely stopped. The There is never a more important period
quickly pull the clutch lever in. neutral indicator light should come in the life of your engine than the period
5. Shift the transmission into second on. between 0 and 1600 km (1000 mi). For
gear. (Make sure not to shift the this reason, you should read the follow-
transmission into the neutral posi- EAU16720 ing material carefully.
Recommended shift points Since the engine is brand new, do not
tion.)
The recommended shift points during put an excessive load on it for the first
6. Open the throttle part way and
acceleration and deceleration are 1600 km (1000 mi). The various parts in
gradually release the clutch lever.
shown in the table below. the engine wear and polish themselves
7. Follow the same procedure when
shifting to the next higher gear. to the correct operating clearances.
Shift up points: During this period, prolonged full-throt-
5 NOTE: 1st → 2nd: 20 km/h (13 mi/h)
2nd → 3rd: 30 km/h (19 mi/h) tle operation or any condition that might
Always shift gears at the recommended 3rd → 4th: 40 km/h (25 mi/h) result in engine overheating must be
shift points. 4th → 5th: 50 km/h (31 mi/h) avoided.
Shift down points:
5th → 4th: 25 km/h (16 mi/h) EAU17111
EAU16700
To decelerate 4th → 3rd: 25 km/h (16 mi/h)
3rd → 2nd: 25 km/h (16 mi/h) 0–1000 km (0–600 mi)
1. Apply both the front and the rear 2nd → 1st: 25 km/h (16 mi/h)
brakes to slow the motorcycle. Avoid prolonged operation above 2500
2. Shift the transmission into first r/min.
gear when the motorcycle reaches 1000–1600 km (600–1000 mi)
25 km/h (16 mi/h). If the engine is Avoid prolonged operation above 3000
about to stall or runs very roughly, r/min.
pull the clutch lever in and use the
brakes to stop the motorcycle.

5-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

OPERATION AND IMPORTANT RIDING POINTS


ECA10891 EAU17212

CAUTION: Parking
After 1000 km (600 mi) of operation, When parking, stop the engine, and
the engine oil and transfer case oil then remove the key from the main
must be changed, and the oil filter switch.
EWA10310
cartridge or element replaced. WARNING
1600 km (1000 mi) and beyond ● Since the engine and exhaust
The vehicle can now be operated nor- system can become very hot,
mally. park in a place where pedestri-
ECA10310
ans or children are not likely to
CAUTION:
touch them.
● Keep the engine speed out of ● Do not park on a slope or on soft
the tachometer red zone. ground, otherwise the vehicle 5
● If any engine trouble should oc- may overturn.
cur during the engine break-in ECA10380
period, immediately have a CAUTION:
Yamaha dealer check the vehi-
cle. Never park in an area where there
are fire hazards such as grass or
other flammable materials.

5-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU17231 EAU17301 EAU17350

PERIODIC MAINTENANCE Owner’s tool kit


Safety is an obligation of the owner. Pe- PROPER PERIODIC MAINTENANCE
riodic inspection, adjustment and lubri- OF YOUR VEHICLE IS IMPORTANT
cation will keep your vehicle in the IN ORDER TO ENJOY LONG, PLEA-
safest and most efficient condition pos- SURABLE SERVICE. ESPECIALLY
sible. The most important points of IMPORTANT ARE THE MAINTE-
motorcycle inspection, adjustment, and NANCE SERVICES RELATED TO
lubrication are explained on the follow- EMISSIONS CONTROL. THESE
ing pages. CONTROLS NOT ONLY FUNCTION
Maintenance, replacement, or repair TO ENSURE CLEANER AIR, BUT
of the emission control devices and ARE ALSO VITAL TO PROPER EN- 1. Owner’s tool kit
systems may be performed by any GINE OPERATION AND MAXIMUM
repair establishment or individual PERFORMANCE. IN THE FOLLOW- The owner’s tool kit is located under the
that is certified (if applicable). ING PERIODIC MAINTENANCE rider seat. (See page 3-12.)
6 EWA10320
CHARTS, THE SERVICES RELATED The service information included in this
WARNING TO EMISSIONS CONTROL ARE manual and the tools provided in the
If you are not familiar with mainte- GROUPED SEPARATELY. THESE owner’s tool kit are intended to assist
nance work, have a Yamaha dealer SERVICES REQUIRE SPECIALIZED you in the performance of preventive
do it for you. DATA, KNOWLEDGE, AND EQUIP- maintenance and minor repairs. How-
MENT. YAMAHA DEALERS ARE ever, additional tools such as a torque
TRAINED AND EQUIPPED TO PER- wrench may be necessary to perform
FORM THESE PARTICULAR SER- certain maintenance work correctly.
VICES. NOTE:
If you do not have the tools or experi-
ence required for a particular job, have
a Yamaha dealer perform it for you.

6-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EWA10340

WARNING
Modifications not approved by
Yamaha may cause loss of perfor-
mance, excessive emissions, and
render the vehicle unsafe for use.
Consult a Yamaha dealer before at-
tempting any changes.

6-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU17600

Periodic maintenance chart for the emission control system


INITIAL ODOMETER READINGS
600 mi 4000 mi 8000 mi 12000 mi 16000 mi 20000 mi
No. ITEM ROUTINE (1000 km) (7000 km) (13000 km) (19000 km) (25000 km) (31000 km)
or or or or or or
1 month 6 months 12 months 18 months 24 months 30 months

• Check fuel hoses for cracks or


1 * Fuel line damage. √ √ √ √ √
• Replace if necessary.
• Check condition.
• Adjust gap and clean.
2 * Spark plugs √ Replace. √ Replace. √
• Replace every 8000 mi (13000
km) or 12 months.
• Check and adjust valve clearance
3 * Valve clearance when engine is cold. Every 16000 mi (25000 km)
• Adjust if necessary.
6
• Check breather hose for cracks or
Crankcase breather
4 * damage. √ √ √ √ √
system
• Replace if necessary.
5 * Fuel injection • Adjust synchronization. √ √ √ √ √
• Check for leakage.
6 * Exhaust system • Tighten if necessary. √ √ √ √ √
• Replace gasket(s) if necessary.
Evaporative emis- • Check control system for dam-
7 * sion control system age. √ √
(For California only) • Replace if necessary.
* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service.

6-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU32183

General maintenance and lubrication chart


INITIAL ODOMETER READINGS
600 mi 4000 mi 8000 mi 12000 mi 16000 mi 20000 mi
No. ITEM ROUTINE (1000 km) (7000 km) (13000 km) (19000 km) (25000 km) (31000 km)
or or or or or or
1 month 6 months 12 months 18 months 24 months 30 months

• Check condition and damage.


1 * Air filter element √ √ √ √ √
• Replace if necessary.
• Check operation and fluid leak-
2 * Clutch age. √ √ √ √ √ √
• Correct if necessary.
• Check operation, fluid level, and
3 * Front brake for fluid leakage. √ √ √ √ √ √
• Replace brake pads if necessary.
• Check operation, fluid level, and
4 * Rear brake for fluid leakage. √ √ √ √ √ √ 6
• Replace brake pads if necessary.
• Check for cracks or damage. √ √ √ √ √
5 * Brake hoses
• Replace. Every 4 years
• Check runout and for damage.
6 * Wheels √ √ √ √ √
• Replace if necessary.
• Check tread depth and for dam-
age.
7 * Tires • Replace if necessary. √ √ √ √ √
• Check air pressure.
• Correct if necessary.
• Check bearings for smooth oper-
8 * Wheel bearings ation. √ √ √ √ √
• Replace if necessary.

6-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 5 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


INITIAL ODOMETER READINGS
600 mi 4000 mi 8000 mi 12000 mi 16000 mi 20000 mi
No. ITEM ROUTINE (1000 km) (7000 km) (13000 km) (19000 km) (25000 km) (31000 km)
or or or or or or
1 month 6 months 12 months 18 months 24 months 30 months

Swingarm pivot • Check bearing assemblies for


9 * √ √ √ √ √
bearings looseness.
• Check belt tension.
10 * Drive belt √ Every 2500 mi (4000 km)
• Adjust if necessary.
• Check bearing assemblies for
looseness.
11 * Steering bearings • Moderately repack with lithium- √ √ √ √ Repack. √
soap-based grease every 16000
mi (25000 km) or 24 months.
• Check all chassis fitting and fas-
12 * Chassis fasteners teners. √ √ √ √ √
6 • Correct if necessary.
Brake and clutch le- • Apply lithium-soap-based grease
13 √ √ √ √ √
ver pivot shafts (all-purpose grease) lightly.
Brake and shift ped- • Apply lithium-soap-based grease
14 √ √ √ √ √
al pivot shafts (all-purpose grease) lightly.
• Check operation.
15 Sidestand pivot • Apply lithium-soap-based grease √ √ √ √ √
(all-purpose grease) lightly.
• Check operation and replace if
16 * Sidestand switch √ √ √ √ √ √
necessary.
• Check operation and for oil leak-
17 * Front fork age. √ √ √ √ √
• Replace if necessary.

6-5
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 6 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


INITIAL ODOMETER READINGS
600 mi 4000 mi 8000 mi 12000 mi 16000 mi 20000 mi
No. ITEM ROUTINE (1000 km) (7000 km) (13000 km) (19000 km) (25000 km) (31000 km)
or or or or or or
1 month 6 months 12 months 18 months 24 months 30 months

• Check operation and for oil leak-


Shock absorber as-
18 * age. √ √ √ √ √
sembly
• Replace if necessary.
Rear suspension • Apply lithium-soap-based grease
19 * √
link pivots lightly.
• Change (warm engine before
20 Engine oil √ √ √ √ √ √
draining).
Engine oil filter car-
21 * • Replace. √ √ √
tridge
• Check for leakage.
• Change at initial 600 mi (1000
22 * Transfer case oil km) or 1 month, and thereafter Change. √ Change. 6
every 16000 mi (25000 km) or 24
months.
Front and rear brake
23 * • Check operation. √ √ √ √ √ √
switches
• Apply Yamaha chain and cable
24 * Control cables lube or engine oil SAE 10W-30 √ √ √ √ √ √
thoroughly.
• Check operation and free play.
• Adjust the throttle cable free play
Throttle grip hous-
25 * if necessary. √ √ √ √ √
ing and cable
• Lubricate the throttle grip housing
and cable.
Lights, signals and • Check operation.
26 * √ √ √ √ √ √
switches • Adjust headlight beam.
* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service.
6-6
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 7 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


NOTE:
From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months.

EAU38440

NOTE:
● Air filter
• This model’s air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with com-
pressed air to avoid damaging it.
• The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas.
● Hydraulic brake and clutch systems
• After disassembling the brake or clutch master cylinders, caliper cylinders or clutch release cylinder, always change
the fluid. Regularly check the brake and clutch fluid levels and fill the reservoirs as required.
• Replace the oil seals on the inner parts of the brake or clutch master cylinders, caliper cylinders and clutch release
6 cylinder every two years.
• Replace the brake and clutch hoses every four years or if cracked or damaged.

6-7
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 8 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU19642

Checking the spark plugs Specified spark plug: Tightening torque:


NGK/DPR8EA-9 Spark plug:
The spark plugs are important engine DENSO/X24EPR-U9 17.5 Nm (1.75 m·kgf, 12.7 ft·lbf)
components, which should be checked
periodically, preferably by a Yamaha Before installing a spark plug, the spark
dealer. Since heat and deposits will NOTE:
plug gap should be measured with a
cause any spark plug to slowly erode, If a torque wrench is not available when
wire thickness gauge and, if necessary,
they should be removed and checked installing a spark plug, a good estimate
adjusted to specification.
in accordance with the periodic mainte- of the correct torque is 1/4–1/2 turn
nance and lubrication chart. In addition, past finger tight. However, the spark
the condition of the spark plugs can re- plug should be tightened to the speci-
veal the condition of the engine. fied torque as soon as possible.
The porcelain insulator around the cen-
ter electrode of each spark plug should
be a medium-to-light tan (the ideal color
when the vehicle is ridden normally), 6
and all spark plugs installed in the en-
gine should have the same color. If any
1. Spark plug gap
spark plug shows a distinctly different
color, the engine could be operating im- Spark plug gap:
properly. Do not attempt to diagnose 0.8–0.9 mm (0.031–0.035 in)
such problems yourself. Instead, have
a Yamaha dealer check the vehicle. Clean the surface of the spark plug
If a spark plug shows signs of electrode gasket and its mating surface, and then
erosion and excessive carbon or other wipe off any grime from the spark plug
deposits, it should be replaced. threads.

6-8
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 9 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU19681 EAU38361

Canister (for California only) Engine oil and oil filter car- NOTE:
tridge To achieve the proper engine oil tem-
The engine oil level should be checked perature for an accurate oil level read-
before each ride. In addition, the oil ing, the engine must have first
must be changed and the oil filter car- completely cooled down, and then
tridge replaced at the intervals speci- warmed up again for several minutes to
fied in the periodic maintenance and normal operating temperature.
lubrication chart. 4. Wait a few minutes until the oil set-
tles, remove the oil filler cap, wipe
To check the engine oil level the dipstick clean, insert it back
1. Place the vehicle on a level sur- into the oil filler hole (without
This model is equipped with a canister face and hold it in an upright posi-
to prevent the discharging of fuel vapor screwing it in), and then remove it
tion. again to check the oil level.
into the atmosphere. Before operating
this vehicle, make sure to check the fol- NOTE: NOTE:
6
lowing: Make sure that the vehicle is positioned The engine oil should be between the
● Check each hose connection. straight up when checking the oil level. minimum and maximum level marks.
● Check each hose and canister for A slight tilt to the side can result in a
cracks or damage. Replace if dam- false reading.
aged.
2. Remove the rider seat. (See page
● Make sure that the canister breath-
3-12.)
er is not blocked, and if necessary,
3. Start the engine, warm it up until
clean it.
the engine oil has reached a nor-
mal temperature of 60 °C (140 °F),
let it continue to idle for ten sec-
onds, and then turn the engine off.
1. Engine oil filler cap

6-9
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 10 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


ECA10900

CAUTION:
Make sure that the oil filler cap is se-
curely tightened, otherwise oil may
seep out when the engine is run-
ning.

To change the engine oil (with or


without oil filter cartridge replace-
1. Maximum level mark ment) 1. Engine oil drain bolt (oil tank)
2. Minimum level mark 1. Remove the rider seat. (See page
3. Dipstick 5. Place an oil pan under the engine
3-12.) to collect the used oil.
5. If the engine oil is at or below the 2. Start the engine, warm it up for 6. Remove engine oil drain bolts A
minimum level mark, add sufficient several minutes, and then turn it and B to drain the oil from the
oil of the recommended type to off. crankcase. 6
raise it to the correct level. 3. Place an oil pan under the oil tank
to collect the used oil.
NOTE: 4. Remove the engine oil filler cap
When adding oil, be careful not to over- and drain bolt to drain the oil from
fill the engine oil tank; the oil level rises the oil tank.
faster starting from the half level portion
on the dipstick.
6. Insert the dipstick into the oil filler
hole, and then tighten the oil filler
cap.
1. Engine oil drain bolt A (crankcase)
7. Install the rider seat. 2. Engine oil drain bolt B (crankcase)

6-10
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 11 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


NOTE:
Skip steps 7–9 if the oil filter cartridge is
not being replaced.
7. Remove the oil filter cartridge with
an oil filter wrench.

1. O-ring 1. Oil filter cartridge


2. Torque wrench
NOTE:
Make sure that the O-ring is properly Tightening torque:
Oil filter cartridge:
seated.
17 Nm (1.7 m·kgf, 12 ft·lbf)
6 9. Install the new oil filter cartridge
1. Oil filter cartridge 10. Install the engine oil drain bolts,
2. Oil filter wrench
with an oil filter wrench, and then
tighten it to the specified torque and then tighten them to the spec-
with a torque wrench. ified torque.
NOTE:
An oil filter wrench is available at a Tightening torques:
Yamaha dealer. Engine oil drain bolt A (crankcase):
43 Nm (4.3 m·kgf, 31 ft·lbf)
8. Apply a thin coat of engine oil to Engine oil drain bolt B (crankcase):
the O-ring of the new oil filter car- 43 Nm (4.3 m·kgf, 31 ft·lbf)
tridge. Engine oil drain bolt (oil tank):
43 Nm (4.3 m·kgf, 31 ft·lbf)

6-11
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 12 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


11. Pour only 2.5 L (2.6 US qt) (2.2 er quality than specified. In EAU20051

Imp.qt) of the specified amount of addition, do not use oils labeled Transfer case oil
recommended engine oil through “ENERGY CONSERVING II” or The transfer case must be checked for
the filler hole, insert the dipstick, higher. oil leakage before each ride. If any
and then tighten the oil filler cap. ● Make sure that no foreign mate- leakage is found, have a Yamaha deal-
12. Start the engine, rev it several rial enters the oil tank. er check and repair the vehicle. In addi-
times, and then turn it off. tion, the transfer case oil level should
14. Install the engine oil filler cap. be checked and the oil must be
13. Remove the engine oil filler cap,
15. Start the engine, and then let it idle changed by a Yamaha dealer at the in-
and then gradually fill the oil tank
for several minutes while checking tervals specified in the periodic mainte-
with the remaining oil quantity
it for oil leakage. If oil is leaking, im- nance and lubrication chart.
while regularly checking the oil lev-
mediately turn the engine off and
el on the dipstick.
check for the cause.
16. Turn the engine off, and then
Recommended engine oil:
See page 8-1. check the oil level and correct it if
Oil quantity: necessary. 6
Without oil filter cartridge replace- 17. Install the rider seat.
ment:
4.10 L (4.33 US qt) (3.61 Imp.qt)
With oil filter cartridge replacement:
4.90 L (5.18 US qt) (4.31 Imp.qt)

ECA15080

CAUTION:
● In order to prevent clutch slip-
page (since the engine oil also
lubricates the clutch), do not
mix any chemical additives. Do
not use oils with a diesel speci-
fication of “CD” or oils of a high-
6-12
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 13 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU36762 EAU21381 EAU21401

Air filter element Checking the throttle cable Valve clearance


The air filter element must be replaced free play The valve clearance changes with use,
at the intervals specified in the periodic resulting in improper air-fuel mixture
maintenance and lubrication chart. and/or engine noise. To prevent this
Have a Yamaha dealer replace the air from occurring, the valve clearance
filter element. must be adjusted by a Yamaha dealer
at the intervals specified in the periodic
maintenance and lubrication chart.

1. Throttle cable free play

The throttle cable free play should mea-


6 sure 4.0–6.0 mm (0.16–0.24 in) at the
throttle grip. Periodically check the
throttle cable free play and, if neces-
sary, have a Yamaha dealer adjust it.

6-13
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 14 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU32541
Tire air pressure (measured on cold LOAD YOUR VEHICLE. Make sure
Tires that the total weight of the cargo, rid-
tires):
To maximize the performance, durabil- 0–90 kg (0–198 lb): er, passenger, and accessories
ity, and safe operation of your motor- Front: (cowling, saddlebags, etc. if ap-
cycle, note the following points 250 kPa (36 psi) (2.50 kgf/cm²) proved for this model) does not ex-
regarding the specified tires. Rear:
280 kPa (41 psi) (2.80 kgf/cm²) ceed the maximum load of the
90–186 kg (198–410 lb): vehicle. Operation of an overloaded
Tire air pressure Front: vehicle could cause tire damage, an
The tire air pressure should be checked 250 kPa (36 psi) (2.50 kgf/cm²) accident, or even injury.
and, if necessary, adjusted before each Rear:
ride. 280 kPa (41 psi) (2.80 kgf/cm²)
EWA10500 Maximum load*: Tire inspection
WARNING 186 kg (410 lb)
* Total weight of rider, passenger, car-
● The tire air pressure must be go and accessories
checked and adjusted on cold
tires (i.e., when the temperature EWA10510
6
of the tires equals the ambient WARNING
temperature). Proper loading of your vehicle is im-
● The tire air pressure must be ad- portant for several characteristics of
justed in accordance with the your vehicle, such as handling,
riding speed and with the total braking, performance and safety. Do
weight of rider, passenger, car- not carry loosely packed items that 1. Tire sidewall
go, and accessories approved can shift. Securely pack your heavi- 2. Tire wear indicator
for this model. est items close to the center of the 3. Tire tread depth
vehicle, and distribute the weight
Always check the tires before operating
evenly from side to side. Properly
the motorcycle. If a tire tread shows
adjust the suspension for your load,
crosswise lines (minimum tread depth),
and check the condition and pres-
if the tire has a nail or glass fragments
sure of your tires. NEVER OVER-
6-14
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 15 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


in it, or if the sidewall is cracked, con- ● After extensive tests, only the EAU21960

tact a Yamaha dealer immediately and tires listed below have been ap- Cast wheels
have the tire replaced. proved for this model by To maximize the performance, durabil-
Yamaha Motor Co., Ltd. ity, and safe operation of your vehicle,
Minimum tire tread depth (front and note the following points regarding the
rear): specified wheels.
1.0 mm (0.04 in) Front tire: ● The wheel rims should be checked
Size:
EWA10520 130/70R18M/C 63H for cracks, bends or warpage be-
Manufacturer/model: fore each ride. If any damage is
WARNING
DUNLOP/D251F found, have a Yamaha dealer re-
It is dangerous to ride with a worn- BRIDGESTONE/G851 RADIAL G place the wheel. Do not attempt
out tire. When a tire tread begins to Rear tire: even the smallest repair to the
show lines, have a Yamaha dealer Size:
190/60R17M/C 78H wheel. A deformed or cracked
replace the tire immediately. Brakes, wheel must be replaced.
Manufacturer/model:
tires and related wheel parts re- DUNLOP/D251 ● The wheel should be balanced
6 placement should also be left to a BRIDGESTONE/G850 RADIAL G whenever either the tire or wheel
Yamaha dealer. has been changed or replaced. An
unbalanced wheel can result in
Tire information poor performance, adverse han-
This motorcycle is equipped with cast dling characteristics, and a short-
wheels and tubeless tires. ened tire life.
EWA10460 ● Ride at moderate speeds after
WARNING changing a tire since the tire sur-
● The front and rear tires should face must first be “broken in” for it
be of the same make and de- to develop its optimal characteris-
sign, otherwise the handling tics.
characteristics of the vehicle
cannot be guaranteed.

6-15
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 16 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU22011
any consequences caused by the EAU22072

Accessories and replacement use of items which have not been Clutch lever
parts approved by Yamaha. Since this model is equipped with a hy-
EWA10621 draulic clutch, adjusting the clutch lever
WARNING free play is not needed. However, it is
This vehicle is not designed to pull a necessary to check the clutch fluid level
trailer or to be attached to a sidecar. and check the hydraulic system for
The accessories or replacement leakage before each ride. If the clutch
parts you choose for your vehicle lever free play does become excessive,
should be designed specifically for and shifting becomes rough or clutch
this model, and they must be se- slippage occurs, causing poor acceler-
curely mounted to maintain the in- ation, there may be air in the clutch sys-
herent stability of the original tem. If there is air in the hydraulic
design. Genuine Yamaha Parts and system, have a Yamaha dealer bleed
Accessories are designed and test- the system before operating the motor-
ed to be compatible with your vehi- cycle. 6
cle. Please consider Genuine
Yamaha Parts and Accessories be-
fore making a purchase. Use of non-
Yamaha-approved accessories or
replacement parts may cause loss of
handling stability and riding safety.
Since Yamaha cannot control the
quality of accessories or parts man-
ufactured by other companies,
Yamaha cannot be held liable for

6-16
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 17 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU22270 EAU22390
indicator grooves have almost disap-
Adjusting the rear brake light Checking the front and rear peared, have a Yamaha dealer replace
switch brake pads the brake pads as a set.
The front and rear brake pads must be
checked for wear at the intervals spec- EAU22500

ified in the periodic maintenance and Rear brake pads


lubrication chart.

EAU22430
Front brake pads

1. Rear brake light switch


2. Rear brake light switch adjusting nut

6 The rear brake light switch, which is ac- 1. Lining thickness


tivated by the brake pedal, is properly
adjusted when the brake light comes Check each rear brake pad for damage
on just before braking takes effect. If and measure the lining thickness. If a
necessary, adjust the brake light switch 1. Brake pad wear indicator groove brake pad is damaged or if the lining
as follows. thickness is less than 0.8 mm (0.03 in),
Turn the adjusting nut while holding the Each front brake pad is provided with have a Yamaha dealer replace the
rear brake light switch in place. To wear indicator grooves, which allow brake pads as a set.
make the brake light come on earlier, you to check the brake pad wear with-
turn the adjusting nut in direction (a). To out having to disassemble the brake.
make the brake light come on later, turn To check the brake pad wear, check
the adjusting nut in direction (b). the wear indicator grooves. If a brake
pad has worn to the point that the wear

6-17
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 18 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU38630
Clutch Observe these precautions:
Checking the brake and clutch ● When checking the brake and
fluid levels clutch fluid levels, make sure that
Front brake the top of each reservoir is level.
● Use only the recommended quality
brake fluid, otherwise the rubber
seals may deteriorate, causing
leakage and poor braking or clutch
performance.

1. Minimum level mark Recommended brake and clutch flu-


id:
Insufficient brake or clutch fluid may al- DOT 4 brake fluid
low air to enter the brake or clutch sys-
1. Minimum level mark tems, possibly causing them to become ● Refill with the same type of brake
ineffective. fluid. Mixing fluids may result in a 6
Rear brake
harmful chemical reaction and
NOTE: lead to poor braking or clutch per-
The rear brake fluid reservoir is located formance.
under the rider seat. (See page 3-12.) ● Be careful that water does not en-
Before riding, check that the brake and ter the brake or clutch fluid reser-
clutch fluids are above the minimum voir when refilling. Water will
level marks and replenish if necessary. significantly lower the boiling point
A low brake or clutch fluid level may in- of the fluid and may result in vapor
dicate brake or clutch system leakage lock.
and/or worn brake pads. If the brake or ● Brake fluid may deteriorate paint-
1. Minimum level mark
clutch levels are low, be sure to check ed surfaces or plastic parts. Al-
the brake or clutch systems for leakage ways clean up spilled fluid
and the brake pads for wear. immediately.

6-18
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 19 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


● As the brake pads wear, it is nor- EAU22750 EAU23040

mal for the brake fluid level to grad- Changing the brake and Drive belt slack
ually go down. However, if the clutch fluids The drive belt slack should be checked
brake fluid level goes down sud- Have a Yamaha dealer change the and adjusted at the intervals specified
denly, have a Yamaha dealer brake and clutch fluids at the intervals in the periodic maintenance and lubri-
check the cause. specified in the NOTE after the periodic cation chart.
maintenance and lubrication chart. In
EAU38410
addition, have the oil seals of the brake To check the drive belt slack
and clutch master cylinders and cali- 1. Place the vehicle on the sidestand.
pers as well as the brake and clutch 2. Note the current position of the
hoses replaced at the intervals listed drive belt using the marks near the
below or whenever they are damaged drive belt check hole.
or leaking.
● Oil seals: Replace every two NOTE:
years. The marks near the drive belt check
6 ● Brake and clutch hoses: Replace hole are 5.0 mm (0.2 in) apart.
every four years.

1. Drive belt
2. Marks
3. Drive belt slack

6-19
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 20 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


3. Note the position of the drive belt EAU23091 EAU23111

with a force of 45 N (4.5 kgf, 10 lbf) Checking and lubricating the Checking and lubricating the
applied to the belt with a belt ten- cables throttle grip and cable
sion gauge as shown. The operation of all control cables and The operation of the throttle grip should
the condition of the cables should be be checked before each ride. In addi-
NOTE: checked before each ride, and the ca- tion, the cable should be lubricated at
A belt tension gauge is available at a bles and cable ends should be lubricat- the intervals specified in the periodic
Yamaha dealer. ed if necessary. If a cable is damaged maintenance chart.
or does not move smoothly, have a
Yamaha dealer check or replace it.

Recommended lubricant:
Yamaha Chain and Cable Lube or
engine oil SAE 10W-30

EWA10710

WARNING 6
Damage to the outer housing of ca-
1. Belt tension gauge bles may result in internal rusting
and cause interference with cable
4. Calculate the drive belt slack by movement. Replace damaged ca-
subtracting the measurement not- bles as soon as possible to prevent
ed in step 2 from the measurement unsafe conditions.
noted in step 3.

Drive belt slack:


7.5–13.0 mm (0.30–0.51 in)

5. If the drive belt slack is incorrect,


have a Yamaha dealer adjust it.

6-20
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 21 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU23131 EAU23140

Checking and lubricating the Recommended lubricant: Checking and lubricating the
Lithium-soap-based grease (all-pur-
brake and shift pedals pose grease) brake and clutch levers
Brake lever

Clutch lever
6

The operation of the brake and shift


pedals should be checked before each
ride, and the pedal pivots should be lu- The operation of the brake and clutch
bricated if necessary. levers should be checked before each
ride, and the lever pivots should be lu-
bricated if necessary.

6-21
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 22 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU23200 EAU23250
Recommended lubricant: Checking and lubricating the Lubricating the rear suspen-
Lithium-soap-based grease (all-pur-
pose grease) sidestand sion

The operation of the sidestand should The pivoting points of the rear suspen-
be checked before each ride, and the sion must be lubricated at the intervals
sidestand pivot and metal-to-metal specified in the periodic maintenance 6
contact surfaces should be lubricated if and lubrication chart.
necessary.
EWA10730 Recommended lubricant:
WARNING Lithium-soap-based grease
If the sidestand does not move up
and down smoothly, have a Yamaha
dealer check or repair it.

Recommended lubricant:
Lithium-soap-based grease (all-pur-
pose grease)

6-22
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 23 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU23271 EAU23280

Checking the front fork Checking the steering


The condition and operation of the front Worn or loose steering bearings may
fork must be checked as follows at the cause danger. Therefore, the operation
intervals specified in the periodic main- of the steering must be checked as fol-
tenance and lubrication chart. lows at the intervals specified in the pe-
riodic maintenance and lubrication
To check the condition chart.
EWA10750
1. Place a stand under the engine to
WARNING raise the front wheel off the
Securely support the vehicle so that ECA10590 ground.
there is no danger of it falling over. CAUTION: EWA10750

If any damage is found or the front WARNING


Check the inner tubes for scratches,
fork does not operate smoothly, Securely support the vehicle so that
damage and excessive oil leakage.
have a Yamaha dealer check or re- there is no danger of it falling over.
6 To check the operation pair it. 2. Hold the lower ends of the front
1. Place the vehicle on a level sur- fork legs and try to move them for-
face and hold it in an upright posi- ward and backward. If any free
tion. play can be felt, have a Yamaha
2. While applying the front brake, dealer check or repair the steering.
push down hard on the handlebars
several times to check if the front
fork compresses and rebounds
smoothly.

6-23
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 24 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU23290 EAU33650

Checking the wheel bearings Battery


The front and rear wheel bearings must
be checked at the intervals specified in
the periodic maintenance and lubrica-
tion chart. If there is play in the wheel
hub or if the wheel does not turn
smoothly, have a Yamaha dealer check
the wheel bearings.

1. Negative battery terminal


2. Positive battery terminal
3. Battery

This model is equipped with a sealed- 6


type (MF) battery, which does not re-
quire any maintenance. There is no
need to check the electrolyte or to add
distilled water.
EWA10760

WARNING
● Electrolyte is poisonous and
dangerous since it contains sul-
furic acid, which causes severe
burns. Avoid any contact with
skin, eyes or clothing and al-
ways shield your eyes when

6-24
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 25 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


working near batteries. In case battery tends to discharge more quickly If you do not have access to a
of contact, administer the fol- if the vehicle is equipped with optional sealed-type (MF) battery charg-
lowing FIRST AID. electrical accessories. er, have a Yamaha dealer
• EXTERNAL: Flush with plenty charge your battery.
of water. To store the battery
• INTERNAL: Drink large quan- 1. If the vehicle will not be used for
tities of water or milk and im- more than one month, remove the
mediately call a physician. battery, fully charge it, and then
• EYES: Flush with water for 15 place it in a cool, dry place.
minutes and seek prompt 2. If the battery will be stored for more
medical attention. than two months, check it at least
● Batteries produce explosive hy- once a month and fully charge it if
drogen gas. Therefore, keep necessary.
sparks, flames, cigarettes, etc., 3. Fully charge the battery before in-
away from the battery and pro- stallation.
6 vide sufficient ventilation when 4. After installation, make sure that
charging it in an enclosed the battery leads are properly con-
space. nected to the battery terminals.
● KEEP THIS AND ALL BATTER- ECA10630

IES OUT OF THE REACH OF CAUTION:


CHILDREN. ● Always keep the battery
charged. Storing a discharged
To charge the battery battery can cause permanent
Have a Yamaha dealer charge the bat- battery damage.
● To charge a sealed-type (MF)
tery as soon as possible if it seems to
have discharged. Keep in mind that the battery, a special (constant-volt-
age) battery charger is required.
Using a conventional battery
charger will damage the battery.
6-25
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 26 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU38372

Replacing the fuses Specified fuses:


Main fuse:
The main fuse, the fuel injection system 50.0 A
fuse, and the fuse box, which contains Headlight fuse:
the fuses for the individual circuits, are 20.0 A
located under the rider seat. (See page Signaling system fuse:
3-12.) 10.0 A
Ignition fuse:
25.0 A
Fuel injection system fuse:
15.0 A
1. Fuse box ECU fuse:
2. Auxiliary DC connector fuse 10.0 A
3. Signaling system fuse Auxiliary DC connector fuse:
4. Ignition fuse 3.0 A
5. Backup fuse (for odometer and clock) Taillight fuse:
6. ECU fuse 10.0 A
7. Headlight fuse Backup fuse: 6
8. Taillight fuse
10.0 A
1. Main fuse
2. Fuel injection system fuse 9. Spare fuse ECA10640

3. Fuel injection system spare fuse


If a fuse is blown, replace it as follows. CAUTION:
4. Fuse box
1. Turn the key to “OFF” and turn off Do not use a fuse of a higher amper-
the electrical circuit in question. age rating than recommended to
2. Remove the blown fuse, and then avoid causing extensive damage to
install a new fuse of the specified the electrical system and possibly a
amperage. fire.
3. Turn the key to “ON” and turn on
the electrical circuit in question to
check if the device operates.

6-26
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 27 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


4. If the fuse immediately blows EAU39121

again, have a Yamaha dealer Replacing a headlight bulb


check the electrical system.

1. Bolt
2. Main switch/steering lock cover
1. Low beam headlight bulb
2. High beam headlight bulb 3. Disconnect the coupler shown.

This model features a headlight


6 equipped with two quartz bulbs. If the
high beam or the low beam bulb burns
out, replace it as follows.

Removing the headlight unit


1. Remove the windshield. (See
page 3-15.)
2. Remove the main switch/steering
1. Coupler
lock cover by removing the bolts.
4. Remove the headlight unit by re-
moving the screws.

6-27
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 28 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


2. Disconnect the headlight coupler, ECA10650

and then unhook the headlight CAUTION:


bulb holder. Take care not to damage the follow-
ing parts:
● Headlight bulb
Do not touch the glass part of
the headlight bulb to keep it free
from oil, otherwise the transpar-
ency of the glass, the luminosity
1. Screw of the bulb, and the bulb life will
be adversely affected. Thor-
To replace the high beam headlight oughly clean off any dirt and fin-
bulb 1. Headlight coupler gerprints on the headlight bulb
1. Remove the headlight bulb holder 2. Headlight bulb holder using a cloth moistened with al-
cover by turning it counterclock- cohol or thinner.
3. Remove the defective bulb. ● Headlight lens 6
wise. EWA10790
Do not affix any type of tinted
WARNING
film or stickers to the headlight
Headlight bulbs get very hot. There- lens.
fore, keep flammable products away Do not use a headlight bulb of a
from a lit headlight bulb, and do not wattage higher than specified.
touch the bulb until it has cooled
down.
4. Place a new headlight bulb into po-
sition, and then secure it with the
bulb holder.
1. Headlight bulb holder cover

6-28
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 29 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


● Headlight bulb
Do not touch the glass part of
the headlight bulb to keep it free
from oil, otherwise the transpar-
ency of the glass, the luminosity
of the bulb, and the bulb life will
be adversely affected. Thor-
oughly clean off any dirt and fin-
gerprints on the headlight bulb
1. Do not touch the glass part of the bulb. 1. Headlight coupler using a cloth moistened with al-
2. Headlight bulb cohol or thinner.
5. Connect the coupler, and then in- ● Headlight lens
EWA10790
stall the headlight bulb holder cov- Do not affix any type of tinted
er by turning it clockwise. WARNING
film or stickers to the headlight
Headlight bulbs get very hot. There- lens.
6 To replace the low beam headlight bulb fore, keep flammable products away Do not use a headlight bulb of a
1. Disconnect the headlight coupler, from a lit headlight bulb, and do not wattage higher than specified.
and then remove the defective touch the bulb until it has cooled
bulb by turning it counterclock- down.
wise. 2. Install the bulb by turning it clock-
wise.
ECA10650

CAUTION:
Take care not to damage the follow-
ing parts:

1. Do not touch the glass part of the bulb.

6-29
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 30 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


3. Connect the headlight coupler. EAU24180 EAU38380

Tail/brake light Replacing a turn signal light


Installing the headlight unit This model is equipped with an LED bulb
1. Install the headlight unit by install- type of tail/brake light. 1. Remove the turn signal light lens
ing the screws. If the tail/brake light does not come on, by removing the screw, and then
2. Connect the coupler to the main have a Yamaha dealer check it. turning the lens counterclockwise.
switch/steering lock cover.
3. Install the main switch/steering
lock cover by installing the bolts.
4. Install the windshield.
5. Have a Yamaha dealer adjust the
headlight beam if necessary.

1. Screw
6

2. Remove the defective bulb by


pushing it in and turning it counter-
clockwise.
3. Insert a new bulb into the socket,
push it in, and then turn it clock-
wise until it stops.
4. Install the lens by turning it clock-
wise, and then installing the screw.
ECA11190

CAUTION:
Do not overtighten the screw, other-
wise the lens may break.
6-30
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 31 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU24330 EAU24350
a jack either under each side of the
License plate light Supporting the motorcycle frame in front of the rear wheel or under
If the license plate light does not come Since this model is not equipped with a each side of the swingarm.
on, have a Yamaha dealer check the centerstand, follow these precautions
electrical circuit or replace the bulb. when removing the front and rear
wheel or performing other maintenance
requiring the motorcycle to stand up-
right. Check that the motorcycle is in a
stable and level position before starting
any maintenance. A strong wooden
box can be placed under the engine for
added stability.

To service the front wheel


1. Stabilize the rear of the motorcycle
6 by using a motorcycle stand or, if
an additional motorcycle stand is
not available, by placing a jack un-
der the frame in front of the rear
wheel.
2. Raise the front wheel off the
ground by using a motorcycle
stand.

To service the rear wheel


Raise the rear wheel off the ground by
using a motorcycle stand or, if a motor-
cycle stand is not available, by placing

6-31
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 32 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU25850

Troubleshooting
Although Yamaha motorcycles receive
a thorough inspection before shipment
from the factory, trouble may occur dur-
ing operation. Any problem in the fuel,
compression, or ignition systems, for
example, can cause poor starting and
loss of power.
The following troubleshooting chart
represents a quick and easy procedure
for checking these vital systems your-
self. However, should your motorcycle
require any repair, take it to a Yamaha
dealer, whose skilled technicians have
the necessary tools, experience, and 6
know-how to service the motorcycle
properly.
Use only genuine Yamaha replace-
ment parts. Imitation parts may look like
Yamaha parts, but they are often inferi-
or, have a shorter service life and can
lead to expensive repair bills.

6-32
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 33 Friday, July 14, 2006 2:51 PM

PERIODIC MAINTENANCE AND MINOR REPAIR


EAU42600

Troubleshooting chart
EWA10840

WARNING
Keep away open flames and do not smoke while checking or working on the fuel system.

1. Fuel
There is enough fuel. Check the compression.
Check the fuel level in
the fuel tank.
The engine does not start.
There is no fuel. Supply fuel.
Check the compression.

2. Compression
There is compression. Check the ignition.
Operate the electric starter.
Have a Yamaha dealer
There is no compression.
check the vehicle.
6

3. Ignition Wipe off with a dry cloth and correct the


Wet Operate the electric starter.
spark plug gaps, or replace the spark plugs.
Remove the spark plugs
and check the electrodes.
The engine does not start.
Dry Have a Yamaha dealer check the vehicle.
Check the battery.

4. Battery The engine turns over


The battery is good.
quickly. The engine does not start.
Operate the electric starter. Have a Yamaha dealer
The engine turns over Check the battery lead connections, check the vehicle.
slowly. and charge the battery if necessary.

6-33
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

MOTORCYCLE CARE AND STORAGE


EAU37833 EAU39163
ucts onto seals, gaskets, the drive
Matte color caution Care belt and wheel axles. Always rinse
ECA15192
While the open design of a motorcycle the dirt and degreaser off with wa-
CAUTION: reveals the attractiveness of the tech- ter.
Some models are equipped with nology, it also makes it more vulnera-
matte colored finished parts. Be ble. Rust and corrosion can develop Cleaning
sure to consult a Yamaha dealer for even if high-quality components are ECA10770

advice on what products to use be- used. A rusty exhaust pipe may go un- CAUTION:
fore cleaning the vehicle. Using a noticed on a car, however, it detracts ● Avoid using strong acidic wheel
brush, harsh chemical products or from the overall appearance of a motor- cleaners, especially on spoked
cleaning compounds when cleaning cycle. Frequent and proper care does wheels. If such products are
these parts will scratch or damage not only comply with the terms of the used on hard-to-remove dirt, do
their surface. Wax also should not warranty, but it will also keep your not leave the cleaner on the af-
be applied to any matte colored fin- motorcycle looking good, extend its life fected area any longer than in-
ished parts. and optimize its performance. structed. Also, thoroughly rinse
the area off with water, immedi-
Before cleaning ately dry it, and then apply a cor-
1. Cover the muffler outlets with plas- rosion protection spray. 7
tic bags after the engine has ● Improper cleaning can damage
cooled down. windshields, cowlings, panels
2. Make sure that all caps and covers and other plastic parts. Use only
as well as all electrical couplers a soft, clean cloth or sponge
and connectors, including the with mild detergent and water to
spark plug caps, are tightly in- clean plastic.
stalled. ● Do not use any harsh chemical
3. Remove extremely stubborn dirt, products on plastic parts. Be
like oil burnt onto the crankcase, sure to avoid using cloths or
with a degreasing agent and a sponges which have been in
brush, but never apply such prod- contact with strong or abrasive
7-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

MOTORCYCLE CARE AND STORAGE


cleaning products, solvent or After normal use ECA10790

thinner, fuel (gasoline), rust re- Remove dirt with warm water, a mild CAUTION:
movers or inhibitors, brake flu- detergent, and a soft, clean sponge, Do not use warm water since it in-
id, antifreeze or electrolyte. and then rinse thoroughly with clean creases the corrosive action of the
● Do not use high-pressure wash- water. Use a toothbrush or bottlebrush salt.
ers or steam-jet cleaners since for hard-to-reach areas. Stubborn dirt
2. After drying the motorcycle, apply
they cause water seepage and and insects will come off more easily if
a corrosion protection spray on all
deterioration in the following ar- the area is covered with a wet cloth for
metal, including chrome- and nick-
eas: seals (of wheel and swing- a few minutes before cleaning.
el-plated, surfaces to prevent cor-
arm bearings, fork and brakes),
rosion.
electric components (couplers, After riding in the rain, near the sea or
connectors, instruments, on salt-sprayed roads
After cleaning
switches and lights), breather Since sea salt or salt sprayed on roads
1. Dry the motorcycle with a chamois
hoses and vents. during winter are extremely corrosive in
or an absorbing cloth.
● For motorcycles equipped with combination with water, carry out the
2. Use a chrome polish to shine
a windshield: Do not use strong following steps after each ride in the
chrome, aluminum and stainless-
cleaners or hard sponges as rain, near the sea or on salt-sprayed
steel parts, including the exhaust
7 they will cause dulling or roads.
system. (Even the thermally in-
scratching. Some cleaning com-
NOTE: duced discoloring of stainless-
pounds for plastic may leave
Salt sprayed on roads in the winter may steel exhaust systems can be re-
scratches on the windshield.
remain well into spring. moved through polishing.)
Test the product on a small hid-
3. To prevent corrosion, it is recom-
den part of the windshield to 1. Clean the motorcycle with cold wa-
mended to apply a corrosion pro-
make sure that it does not leave ter and a mild detergent, after the
tection spray on all metal,
any marks. If the windshield is engine has cooled down.
including chrome- and nickel-plat-
scratched, use a quality plastic
ed, surfaces.
polishing compound after
4. Use spray oil as a universal clean-
washing.
er to remove any remaining dirt.

7-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

MOTORCYCLE CARE AND STORAGE


5. Touch up minor paint damage ● Never apply oil or wax to the may leave scratches on surfaces of the
caused by stones, etc. drive belt. windshield. Before using them, make a
6. Wax all painted and chrome-plat- ● Never apply oil or wax to any test by polishing an area which does
ed surfaces. Avoid combination rubber and plastic parts, but not affect your visibility.
cleaner waxes, many of which treat them with a suitable care
contain abrasives that may mar product. Cleaning the sidebags
the paint or protective finish. ● Avoid using abrasive polishing Water can be harmful to untreated
7. Let the motorcycle dry completely compounds as they will wear leather. Use Yamaha Saddle Soap or
before storing or covering it. away the paint. another quality brand according to the
EWA11130
manufacturer’s directions to clean the
WARNING NOTE: leather on the sidebags. Polish the dry
● Make sure that there is no oil or Consult a Yamaha dealer for advice on leather with a soft cloth, and then treat
wax on the brakes or tires. what products to use. with Yamaha Mink Oil or another high-
● If necessary, clean the brake quality leather protectant for increased
Special care is needed for cleaning
discs and brake linings with a water resistance.
the windshield and sidebags on this
regular brake disc cleaner or ac-
model. Be sure to follow the instruc-
etone, and wash the tires with
tions below.
warm water and a mild deter- 7
gent. Before riding at higher
Cleaning the windshield
speeds, test the motorcycle’s
Avoid using any alkaline or strong acid
braking performance and cor-
cleaner, gasoline, brake fluid, or any
nering behavior.
other solvent. Clean the windshield with
ECA10950
a cloth or sponge dampened with a
CAUTION: neutral detergent, and after cleaning,
● Apply spray oil and wax spar- thoroughly wash it off with water. For
ingly and make sure to wipe off additional cleaning, use Yamaha Wind-
any excess. shield Cleaner or other quality cleaner.
Some cleaning compounds for plastics

7-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

MOTORCYCLE CARE AND STORAGE


EAU26280
3. Perform the following steps to pro- 4. Lubricate all control cables and the
Storage tect the cylinders, piston rings, etc. pivoting points of all levers and
from corrosion. pedals as well as of the side-
Short-term a. Remove the spark plug caps stand/centerstand.
Always store your motorcycle in a cool, and spark plugs. 5. Check and, if necessary, correct
dry place and, if necessary, protect it b. Pour a teaspoonful of engine oil the tire air pressure, and then lift
against dust with a porous cover. into each spark plug bore. the motorcycle so that both of its
ECA10810
c. Install the spark plug caps onto wheels are off the ground. Alterna-
CAUTION:
the spark plugs, and then place tively, turn the wheels a little every
● Storing the motorcycle in a the spark plugs on the cylinder month in order to prevent the tires
poorly ventilated room or cover- head so that the electrodes are from becoming degraded in one
ing it with a tarp, while it is still grounded. (This will limit spark- spot.
wet, will allow water and humid- ing during the next step.) 6. Cover the muffler outlet with a
ity to seep in and cause rust. d. Turn the engine over several plastic bag to prevent moisture
● To prevent corrosion, avoid times with the starter. (This will from entering it.
damp cellars, stables (because coat the cylinder walls with oil.) 7. Remove the battery and fully
of the presence of ammonia) e. Remove the spark plug caps charge it. Store it in a cool, dry
7 and areas where strong chemi- from the spark plugs, and then place and charge it once a month.
cals are stored. install the spark plugs and the Do not store the battery in an ex-
spark plug caps. cessively cold or warm place [less
Long-term
EWA10950
than 0 °C (30°F) or more than 30
Before storing your motorcycle for sev- WARNING °C (90°F)]. For more information
eral months: To prevent damage or injury from on storing the battery, see page
1. Follow all the instructions in the sparking, make sure to ground the 6-24.
“Care” section of this chapter. spark plug electrodes while turning
NOTE:
2. Fill up the fuel tank and add fuel the engine over.
Make any necessary repairs before
stabilizer (if available) to prevent storing the motorcycle.
the fuel tank from rusting and the
fuel from deteriorating.
7-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

SPECIFICATIONS
Dimensions: Engine oil: Manufacturer/model:
Overall length: Type: DENSO/X24EPR-U9
2580 mm (101.6 in) YAMALUBE 4 (20W40) or SAE20W40 Spark plug gap:
Overall width: Recommended engine oil grade: 0.8–0.9 mm (0.031–0.035 in)
1100 mm (43.3 in) API service SG type or higher, JASO Clutch:
Overall height: standard MA Clutch type:
1515 mm (59.6 in) Engine oil quantity: Wet, multiple-disc
Seat height: Without oil filter cartridge replacement: Transmission:
735 mm (28.9 in) 4.10 L (4.33 US qt) (3.61 Imp.qt) Primary reduction system:
Wheelbase: With oil filter cartridge replacement: Spur gear
1715 mm (67.5 in) 4.90 L (5.18 US qt) (4.31 Imp.qt) Primary reduction ratio:
Ground clearance: Transfer gear oil: 72/51 (1.412)
155 mm (6.10 in) Type: Secondary reduction system:
Minimum turning radius: SAE80 API GL-4 Hypoid gear oil Belt drive
3480 mm (137.0 in) Quantity: Secondary reduction ratio:
Weight: 0.55 L (0.58 US qt) (0.48 Imp.qt) 37/30 × 70/31 (2.785)
With oil and fuel: Air filter: Transmission type:
364.0 kg (802 lb) Air filter element: Constant mesh 5-speed
Engine: Oil-coated paper element Operation:
Engine type: Fuel: Left foot operation
Air cooled 4-stroke, OHV Recommended fuel: Gear ratio:
Cylinder arrangement: Premium unleaded gasoline only 1st:
V-type 2-cylinder Fuel tank capacity: 38/16 (2.375)
Displacement: 17.0 L (4.49 US gal) (3.74 Imp.gal) 2nd: 8
1854.0 cm³ Fuel reserve amount: 33/21 (1.571)
Bore × stroke: 3.0 L (0.79 US gal) (0.66 Imp.gal) 3rd:
100.0 × 118.0 mm (3.94 × 4.65 in) Fuel injector: 29/25 (1.160)
Compression ratio: Manufacturer: 4th:
9.48 :1 NIPPON INJECTOR 26/28 (0.929)
Starting system: Model/quantity: 5th:
Electric starter INP-101/2 24/30 (0.800)
Lubrication system: Spark plug (s): Chassis:
Dry sump Manufacturer/model: Frame type:
NGK/DPR8EA-9 Double cradle

8-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

SPECIFICATIONS
Caster angle: Rear: Front suspension:
31.30 ° 280 kPa (41 psi) (2.80 kgf/cm²) Type:
Trail: Loading condition: Telescopic fork
152.0 mm (5.98 in) 90–186 kg (198–410 lb) Spring/shock absorber type:
Front tire: Front: Coil spring/oil damper
Type: 250 kPa (36 psi) (2.50 kgf/cm²) Wheel travel:
Tubeless Rear: 130.0 mm (5.12 in)
Size: 280 kPa (41 psi) (2.80 kgf/cm²) Rear suspension:
130/70R18M/C 63H Front wheel: Type:
Manufacturer/model: Wheel type: Swingarm (link suspension)
DUNLOP/D251F Cast wheel Spring/shock absorber type:
Manufacturer/model: Rim size: Coil spring/gas-oil damper
BRIDGESTONE/G851 RADIAL G 18M/C x MT4.00 Wheel travel:
Rear tire: Rear wheel: 110.0 mm (4.33 in)
Type: Wheel type: Electrical system:
Tubeless Cast wheel Ignition system:
Size: Rim size: Transistorized coil ignition (digital)
190/60R17M/C 78H 17M/C x MT5.50 Charging system:
Manufacturer/model: Front brake: AC magneto
DUNLOP/D251 Type: Battery:
Manufacturer/model: Dual disc brake Model:
BRIDGESTONE/G850 RADIAL G Operation: GT14B-4
Loading: Right hand operation Voltage, capacity:
8 Maximum load: Recommended fluid: 12 V, 12.0 Ah
186 kg (410 lb) DOT 4 Headlight:
(Total weight of rider, passenger, cargo and Rear brake: Bulb type:
accessories) Type: Halogen bulb
Tire air pressure (measured on cold Single disc brake Bulb voltage, wattage × quantity:
tires): Operation: Low beam headlight:
Loading condition: Right foot operation 12 V, 51.0 W × 1
0–90 kg (0–198 lb) Recommended fluid: High beam headlight:
Front: DOT 4 12 V, 55.0 W × 1
250 kPa (36 psi) (2.50 kgf/cm²) Tail/brake light:
LED
8-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

SPECIFICATIONS
Front turn signal/position light: Auxiliary DC connector fuse:
12 V, 23 W/8.0 W × 2 3.0 A
Rear turn signal light: Backup fuse:
12 V, 21.0 W × 2 10.0 A
License plate light:
12 V, 5.0 W
Meter lighting:
LED
Neutral indicator light:
LED
High beam indicator light:
LED
Turn signal indicator light:
LED
Fuel level warning light:
LED
Engine trouble warning light:
LED
Fuses:
Main fuse:
50.0 A
Headlight fuse:
20.0 A
Taillight fuse: 8
10.0 A
Signaling system fuse:
10.0 A
Ignition fuse:
25.0 A
ECU fuse:
10.0 A
Fuel injection system fuse:
15.0 A

8-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26351 EAU26381 EAU26400

Identification numbers Key identification number Vehicle identification number


Record the key identification number,
vehicle identification number and mod-
el label information in the spaces pro-
vided below for assistance when
ordering spare parts from a Yamaha
dealer or for reference in case the vehi-
cle is stolen.
KEY IDENTIFICATION NUMBER:

1. Key identification number 1. Vehicle identification number

The key identification number is The vehicle identification number is


stamped into the key tag. Record this stamped into the steering head pipe.
VEHICLE IDENTIFICATION number in the space provided and use Record this number in the space pro-
NUMBER: it for reference when ordering a new vided.
key.
NOTE:
The vehicle identification number is
used to identify your motorcycle and
may be used to register your motor-
MODEL LABEL INFORMATION: cycle with the licensing authority in your
9 area.

9-1
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26470
Model label

1. Model label

The model label is affixed to the frame


under the rider seat. (See page 3-12.)
Record the information on this label in
the space provided. This information
will be needed when ordering spare
parts from a Yamaha dealer.

9-2
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 3 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26550

Reporting safety defects


If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately
inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Yamaha Motor Corporation,
U.S.A. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group
of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems
between you, your dealer, or Yamaha Motor Corporation, U.S.A.
To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in Washington, D.C.
area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information
about motor vehicle safety from the Hotline.

9-3
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 4 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26560

Motorcycle noise regulation


TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED:
Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other
than for purposes of maintenance, repair, or replacement of any device or element of design incorporated into any new ve-
hicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use or (2) the use of
the vehicle after such device or element of design has been removed or rendered inoperative by any person.
“AMONG THOSE ACTS PRESUMED TO CONSTITUTE TAMPERING ARE THE ACTS LISTED BELOW”.
These acts include tampering with the following systems; i.e., modification, removal, etc.
Exhaust system
• Muffler
• Exhaust pipe
• Silencer
Intake system
• Air cleaner case
• Air cleaner element
• Intake duct

9-4
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 5 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26632

Maintenance record
Copies of work orders and/or receipts for parts purchased and installed on your vehicle will be required to document that
maintenance has been completed in accordance with the emissions warranty. The chart below is printed only as a reminder
that maintenance work is required. It is not acceptable proof of maintenance work.
Maintenance Date of Servicing dealer
Mileage Remarks
interval service name and address
600 mi
(1000 km) or
1 month
4000 mi
(7000 km) or
6 months
8000 mi
(13000 km) or
12 months
12000 mi
(19000 km) or
18 months
16000 mi
(25000 km) or
24 months
20000 mi
(31000 km) or
30 months
24000 mi
9 (37000 km) or
36 months
28000 mi
(43000 km) or
42 months
32000 mi
(49000 km) or
48 months

9-5
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 6 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
Maintenance Date of Servicing dealer
Mileage Remarks
interval service name and address
36000 mi
(55000 km) or
54 months
40000 mi
(61000 km) or
60 months

9-6
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 7 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26663

YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED


WARRANTY
Yamaha Motor Corporation, U.S.A. hereby warrants that THE CUSTOMER’S RESPONSIBILITY under this Engine
new Yamaha motorcycles will be free from defects in warranty shall be to: Displacement Period
material and workmanship for the period of time stated 1. Operate and maintain the motorcycle as specified in Under 50cc 6,000 km (3,750 miles)
herein, subject to certain stated limitations. the appropriate Owner’s Manual, and or five years, whichever occurs first
2. Give notice to an authorized Yamaha motorcycle
THE PERIOD OF WARRANTY for Yamaha motorcycles dealer of any and all apparent defects within ten (10) 50cc to 169cc 12,000 km (7,465 miles)
originally equipped with headlight, stoplight, and turn days after discovery, and make the machine available or five years whichever occurs first
signals shall be one (1) year from the date of purchase, at that time for inspection and repairs at such dealer’s
with no mileage limitation. place of business. 170cc to 279cc 18,000 km (11,185 miles)
or five years, whichever occurs first
MODELS EXCLUDED FROM WARRANTY include WARRANTY TRANSFER: To transfer the warranty from
those used for non-Yamaha-authorized renting, leasing the original purchaser to any subsequent purchaser, it is 280cc and over 30,000 km (18,641 miles)
or other commercial purposes, and TZ models. imperative that the machine be inspected and registered or five years, whichever occurs first
for warranty by an authorized Yamaha motorcycle dealer.
DURING THE PERIOD OF WARRANTY, any authorized In order for this warranty to remain in effect, this YAMAHA MOTOR CORPORATION, U.S.A. MAKES NO
Yamaha motorcycle dealer will, free of charge, repair or inspection and registration must take place within ten OTHER WARRANTY OF ANY KIND, EXPRESSED OR
replace any part adjudged defective by Yamaha due to (10) days after transfer. An inspection and registration fee IMPLIED. ALL IMPLIED WARRANTIES OF
faulty workmanship or material from the factory. Parts used will be charged for this service. MERCHANTABILITY AND FITNESS FOR A
in warranty repairs will be warranted for the balance of the PARTICULAR PURPOSE WHICH EXCEED THE
product’s warranty period. All parts replaced under EMISSION CONTROL SYSTEM WARRANTY: OBLIGATIONS AND TIME LIMITS STATED IN THIS
warranty become property of Yamaha Motor Corporation, Yamaha Motor Corporation, U.S.A. also warrants to the WARRANTY ARE HEREBY DISCLAIMED BY YAMAHA
U.S.A. ultimate purchaser and each subsequent purchaser of MOTOR CORPORATION, U.S.A. AND EXCLUDED
each Yamaha motorcycle covered by this warranty with a FROM THIS WARRANTY.
GENERAL EXCLUSIONS from this warranty shall displacement of 50cc or greater, that the vehicle is
include any failures caused by: designed, built, and equipped so as to conform at the SOME STATES DO NOT ALLOW LIMITATIONS ON
a) Competition or racing use. time of sale with all U.S. emissions standards applicable HOW LONG AN IMPLIED WARRANTY LASTS, SO THE
b) Installation of parts or accessories that are not at the time of manufacture and that it is free from defects ABOVE LIMITATION MAY NOT APPLY TO YOU. ALSO
qualitatively equivalent to genuine Yamaha parts. in materials and workmanship which would cause it not EXCLUDED FROM THIS WARRANTY ARE ANY
c) Abnormal strain, neglect, or abuse. to meet these standards within the period listed INCIDENTAL OR CONSEQUENTIAL DAMAGES
d) Lack of proper maintenance. immediately below. Failures other than those resulting INCLUDING LOSS OF USE. SOME STATES DO NOT
e) Accident or collision damage. from defects in material or workmanship, which arise ALLOW THE EXCLUSION OR LIMITATION OF
f) Modification to original parts. solely as a result of owner abuse and/or lack of proper INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO
9 maintenance, are not covered by this warranty. THE ABOVE EXCLUSION MAY NOT APPLY TO YOU.
SPECIFIC EXCLUSIONS from this warranty shall
include parts replaced due to normal wear or routine THIS WARRANTY GIVES YOU SPECIFIC LEGAL
maintenance. RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS
WHICH VARY FROM STATE TO STATE.

YAMAHA MOTOR CORPORATION, U.S.A.


P.O. Box 6555
Cypress, California 90630

9-7
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 8 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION

WARRANTY QUESTIONS AND ANSWERS CUSTOMER SERVICE


Q. What costs are my responsibility during the warranty period? If your machine requires warranty service, you must take it to any authorized Yamaha
A. The customer’s responsibility includes all costs of normal maintenance services, motorcycle dealer within the continental United States. Be sure to bring your warranty
non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, registration card or other valid proof of the original date of purchase. If a question or
spark plugs, and brake shoes. problem arises regarding the warranty, first contact the owner of the dealership. Since
all warranty matters are handled at the dealer level, this person is in the best position to
Q. What are some examples of “abnormal” strain, neglect, or abuse? help you. IF you are still not satisfied and require additional assistance, please write to:
A. These terms are general and overlap each other in areas. Specific examples
include: Running the machine out of oil, sustained high rpm, full-throttle, operating YAMAHA MOTOR CORPORATION, U.S.A.
the machine with a broken or damaged part which causes another part to fail, CUSTOMER RELATIONS DEPARTMENT
damage or failure due to improper or careless transportation and/or tie-down. If P.O. Box 6555
you have any specific questions on operation or maintenance, please contact your Cypress, California 90630
dealer for advice.
When contacting Yamaha Motor Corporation, U.S.A., don’t forget to include any
Q. Does the warranty cover incidental costs such as towing or transportation due to important information such as names, addresses, model, V.I.N. (frame number),
a failure? dates, and receipts.
A. No. The warranty is limited to repair of the machine itself.
CHANGE OF ADDRESS
Q. May I perform any or all of the recommended maintenance shown in the Owner’s
Manual instead of having the dealer do them? The federal government requires each manufacturer of a motor vehicle to maintain a
A. Yes, if you are a qualified mechanic and follow the procedures specified in the complete, up-to-date list of all first purchasers against the possibility of a safety-
Owner’s and Service Manual. We do recommend, however, that items requiring related defect and recall. This list is compiled from the purchase registrations sent to
special tools or equipment be done by a Yamaha motorcycle dealer. Yamaha Motor Corporation, U.S.A. by the selling dealer at the time of your purchase.
Q. Will the warranty be void or cancelled if I do not operate or maintain my new If you should move after you have purchased your new motorcycle, please advise us
motorcycle exactly as specified in the Owner’s Manual? of your new address by sending a postcard listing your motorcycle model name, V.I.N.
A. No. The warranty on a new motorcycle cannot be “voided” or “cancelled.” However, (frame number), dealer number (or dealer’s name) as it is shown on your warranty
if a particular failure is caused by operation or maintenance other than as card, your name and new mailing address. Mail to:
described in the Owner’s Manual, that failure may not be covered under
warranty. YAMAHA MOTOR CORPORATION, U.S.A.
P.O. Box 6555
Q. What responsibility does my dealer have under this warranty? Cypress, California 90630
A. Each Yamaha motorcycle dealer is expected to: Attention: Warranty Department
1. Completely set up every new machine before sale.
2. Explain the operation, maintenance, and warranty requirements to your This will ensure that Yamaha Motor Corporation, U.S.A. has an up-to-date registration
9
satisfaction at the time of sale, and upon your request at any later date. record in accordance with federal law.
3. Each Yamaha motorcycle dealer is held responsible for his setup, service and
warranty repair work.

Q. Is the warranty transferable to second owners?


A. Yes. The remainder of the existing warranty can be transferred upon request. The
unit has to be inspected and re-registered by an authorized Yamaha motorcycle
dealer for the policy to remain effective.

9-8
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 9 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
EAU26750

YAMAHA EXTENDED SERVICE (Y.E.S.)


Keep your Yamaha protected even after your warranty In addition, Travel and Recreation Interruption Protection
expires with genuine Yamaha Extended Service (Y.E.S.). (TRIP) is included at no extra cost. TRIP gives you up to
$150 reimbursement per occurrence for any reasonable
Y.E.S. is designed and administered by Yamaha Motor
expenses you incur because your Yamaha needs
Corporation to provide maximum owner satisfaction. You
covered service: replacement vehicle rental, emergency
get uninterrupted factory-backed coverage for extra
towing, phone calls, even food and lodging when you are
peace of mind.
away from home. This superb coverage goes into effect
Y.E.S. is flexible. You choose the plan that’s right for when you purchase Y.E.S., so it applies to any warranty
you: 12 months, 24 months, 36 months or, on certain repairs as well as covered repairs during your entire
models, even 48 months beyond your warranty period. Y.E.S. plan period.
Y.E.S. is designed and administered by the same Y.E.S. coverage is honored at any authorized Yamaha
Yamaha people who handle your warranty – and it dealer nationwide.
shows in the comprehensive coverage benefits. There
Y.E.S. coverage is transferable to a new owner if you
are no mileage limitations. Coverage isn’t limited to
sell or trade-in. That can make your Yamaha much more
“moving parts” or the “drive train” like many other plans.
valuable!
And Y.E.S. covers manufacturing defects just like the
warranty. See the sample contract at your Yamaha This excellent Y.E.S. plan coverage is only available to
dealer to see how comforting uninterrupted factory- Yamaha owners like you, and only while your Yamaha is still
backed protection can be. within the Yamaha Limited Warranty period. So visit your
authorized Yamaha dealer to get all the facts. He can show
You don’t have to pay anything for covered repairs.
you how easy it is to protect your investment with Yamaha
There’s no deductible to pay, and repairs aren’t
Extended Service.
“pro-rated.” You don’t have any “out-of-pocket” expenses
for covered repairs.

9-9
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 10 Friday, July 14, 2006 2:51 PM

CONSUMER INFORMATION
We urge you to act now. You’ll get the excellent benefits of
TRIP coverage right away, and you’ll rest easy knowing
you’ll have strong factory-backed protection even after your
Yamaha Limited Warranty expires.
A special note:
If visiting your dealer isn’t convenient, contact Yamaha with
your Primary ID number (your frame number). We’ll be
happy to help you get the Y.E.S. coverage you need.
Yamaha Service Marketing
P.O. Box 6555
Cypress, CA 90630
1-(866)-YES-EXTD (1-866-937-3983)

9-10
Downloaded from www.Manualslib.com manuals search engine
U2C511E0.book Page 1 Friday, July 14, 2006 2:51 PM

INDEX
A Fuel level warning light ........................... 3-2 Part locations .......................................... 2-1
Accessories and replacement parts...... 6-16 Fuel tank cap ........................................ 3-10 Passenger backrest .............................. 3-13
Air filter element .................................... 6-13 Fuses, replacing ................................... 6-26 Pre-operation check list...........................4-2
Auxiliary DC connector ......................... 3-23 H R
B Handlebar switches ................................ 3-7 Rear brake light switch, adjusting ......... 6-17
Battery................................................... 6-24 Headlight bulb, replacing ...................... 6-27 Rear suspension, lubricating................. 6-22
Brake and clutch fluid levels, Helmet holder ....................................... 3-14 Rider seat..............................................3-12
checking ............................................. 6-18 High beam indicator light ........................ 3-2 S
Brake and clutch fluids, changing ......... 6-19 Horn switch............................................. 3-8 Safety defects, reporting .........................9-3
Brake and clutch levers, checking I Safety information ...................................1-1
and lubricating .................................... 6-21 Identification numbers ............................ 9-1 Shifting ....................................................5-2
Brake and shift pedals, checking Ignition circuit cut-off system ................ 3-21 Shift pedal ............................................... 3-9
and lubricating .................................... 6-21 Indicator and warning lights.................... 3-2 Shock absorber assembly, adjusting ....3-19
Brake lever.............................................. 3-9 K Sidebags ............................................... 3-17
Brake pedal........................................... 3-10 Key identification number ....................... 9-1 Sidestand ..............................................3-21
C L Sidestand, checking and lubricating......6-22
Cables, checking and lubricating .......... 6-20 Labels, location of................................... 1-5 Spark plugs, checking .............................6-8
Canister (for California only) ................... 6-9 License plate light................................. 6-31 Specifications .......................................... 8-1
Care ........................................................ 7-1 Light switch (for optional lights) .............. 3-8 Starting the engine .................................. 5-1
Catalytic converter ................................ 3-12 M Start switch..............................................3-8
Clutch lever .................................... 3-9, 6-16 Main switch/steering lock........................ 3-1 Steering, checking.................................6-23
D Maintenance and lubrication, periodic .... 6-4 Storage....................................................7-4
Dimmer switch ........................................ 3-8 Maintenance, emission control Supporting the motorcycle .................... 6-31
Drive belt slack...................................... 6-19 system.................................................. 6-3 T
E Maintenance, periodic ............................ 6-1 Tail/brake light....................................... 6-30
Engine break-in....................................... 5-3 Maintenance record................................ 9-5 Throttle cable free play, checking ......... 6-13
Engine oil and oil filter cartridge.............. 6-9 Matte color, caution ................................ 7-1 Throttle grip and cable, checking
Engine stop switch .................................. 3-8 Model label ............................................. 9-2 and lubricating .................................... 6-20
Engine trouble warning light.................... 3-3 Multi-function meter unit ......................... 3-3 Tires ......................................................6-14
EXUP system........................................ 3-20 N Tool kit..................................................... 6-1
F Neutral indicator light.............................. 3-2 Transfer case oil.................................... 6-12
Front and rear brake pads, checking .... 6-17 Noise regulation...................................... 9-4 Troubleshooting .................................... 6-32
Front fork, checking .............................. 6-23 P Troubleshooting chart ...........................6-33
Fuel ....................................................... 3-11 Parking ................................................... 5-4 Turn signal indicator lights ...................... 3-2

Downloaded from www.Manualslib.com manuals search engine


U2C511E0.book Page 2 Friday, July 14, 2006 2:51 PM

INDEX
Turn signal light bulb, replacing............ 6-30
Turn signal switch................................... 3-8
V
Valve clearance .................................... 6-13
Vehicle identification number.................. 9-1
W
Warranty, extended ................................ 9-9
Warranty, limited..................................... 9-7
Wheel bearings, checking .................... 6-24
Wheels.................................................. 6-15
Windshield ............................................ 3-15

Downloaded from www.Manualslib.com manuals search engine


YAMAHA MOTOR CO., LTD.
PRINTED ON RECYCLED PAPER PRINTED IN JAPAN
2006.07-0.6×1 CR
Downloaded from www.Manualslib.com manuals search engine (E)

You might also like