Professional Documents
Culture Documents
New Microsoft Word Document
New Microsoft Word Document
New Microsoft Word Document
need to pass your Cisco certification exams is to identify situations where you
need to enable or disable split horizon. EIGRP commands tend to be a little
different than those used with other protocols, so let’s take a look at how EIGRP
and split horizon interoperate.
R1 is our hub router, with R2 and R3 as the spokes. There are no subinterfaces, and
each router is advertising a single loopback network using its router number for
each octet. R1 will see both R2 and R3’s loopback network, but the spokes will not
have a route to the other spoke’s loopback. “show ip route eigrp” verifies this.
R1(config)#int serial0
R1(config-if)#no ip split-horizon ?
eigrp Enhanced Interior Gateway Routing Protocol (EIGRP)
Note that disabling split horizon resulted in the EIGRP adjacencies being torn
down. They came back up 20 – 35 seconds after being torn down according to the
timestamps, but that’s a good detail to keep in mind!
The routing tables of each spoke should now show the loopback network
configured on the remote spoke.
Be careful when disabling split horizon. In this scenario, R1 can and will advertise
routes out Serial0 that were learned about on that interface in the first place, and
that’s not always desirable. Split horizon is enabl