cz soMOWOPD- Ropar: Stn
REPAIR : SEAT TRIM
swrscm
[EssenTiat Observe ho safety and coarness recommendations @.
‘CAUTION : Follow the user irstuetons inthe sea tim repa kit
1. Tooling
Seat trim repair kit
2, Preparing the zone to be repait
Fine Osea
CCulthe edges ofthe hole tobe repaired cleanly (ata) ; Using a pair of sessors.
NB. tthe hole “ais deop, lit with foam,
‘Soparate the fabric from the foam (Approx. 10 mm around the hol a") ; Using phos (Twoozers).
apt seated cSOMONEIPO CSCO De ir ePIDcz soMOWOPD- Ropar: Stn
swrscm
be repaired
CCuta piace out ofthe backing fabric (1), somewhat bigger than the hole
Make a mark in the centre of the piece of backing fabric (1).
Put the piece of backing fabric (1) n place
Fine CED
‘Apply the backing fabric with the tweezers and holt in postion.
Fie see
withthe spatula, take some powder adhesive,
apt seated cSOMONEIPO CSCO De ir ePIDswrscm cz soMOWOPD- Ropar: Stn
‘Apply the adhesive on the edges ony.
Instructions for use.
NB. : Prepare the smoothing ron to the temperatuce indicated bythe supaler;
Remove the teflon and then use the smaothing iron ta stick down the edges around the hole, aking the time indicated by the suppl
[CAUTION : Quickly inspect the repair afer he intial heating to make sure thatthe adhesive is nt drying around the hole
3, Finding the colour
Find the colour that most approximates tothe colour ofthe seat: Following the supple’ instructions.
“Take th fibre from the pot corresponding tothe material being repaired.
Place the fore (or a mixture) in the fre sprayer.
4. Applying the repair fibre
‘Apply te ropa fire: Se insrucons for use.
apt eae dec SOMONEPO CSNY PDE DF eFCTIOEswrscm cz soMOWOPD- Ropar: Stn
Place a smal quanti of powder adhesive in the hol.
‘Overlay the fibre uniformity, using the twoezers
Fae CSMTED
Heat withthe ron at index 25, protecting the hole with the shest of teton, forthe duration indicated by the
jpper; See user instructions.
Fie SEATED
(Cut outa template the same size as the hole
‘Spray the surface adhesive from the aerosol in short bursts
5,
ish
apt eae dec SOMONEPO CSNY PDE DF eFCTIOEswrscm cz soMOWOPD- Ropar: Stn
‘Apply the finishing fibre with the sprayer (at): See instructions for use,
‘Smoath out the area using the brush.
NB. : You can reproduce the texture or the design by moistening the lead ofa pencil (except for velours mater).
apt eae dec SOMONEPO CSNY PDE DF eFCTIOE