Professional Documents
Culture Documents
HV Exit Exam Questions - ALL
HV Exit Exam Questions - ALL
Two gen with same power and different power factor is running on parallel, the gen with less
power factor will run
a) slower
b) faster
c) hotter
d) cooler
5. Dielectric absorption is a method of testing IR test for a period of 10 min (True or False)
6. Isolator is locked and the key is kept with the person issuing the permit as in the key box.
(True or False)
8. Cyclo converters and synchronous motor is mostly used in new ice breakers (True or False)
11. Blown fuse used be replaced with -Fuses of the rated voltage and current
***********************************xxxx*************************
1) The winding insulation shall be designed to withstand the overvoltages which may arise from
manoeuvres, Switching operations, converter operations, and earth faults.
a) True
b) False
2) Current relays: It is a protective device which takes voltage as input to its current coil for the
purpose of interruption.
a) True
b) False
3) What will happen to a given transformer if it made to run at its rated voltage but reduced
frequency
a) Flux density remains unaffected.
b) Iron losses are reduced.
c) Core flux density is reduced.
d) Core flux density is increased.
Explanation: E=4.44fNAB is the emf equation for a transformer, now as E is kept constant we can say
frequency is inversely proportional to the B value. Thus, as frequency increases we will get less core
flux density and vice-versa.
14)The effects of the harmonics of currents and voltages shall be taken into consideration for the
design of the proper
a)True
b)False
15)The PMS monitors the total power demand and compares it to the available supply
a)True
b)False
18)Preferable load shedding solution will include a low number of consumers. With low number of
consumers, the......🤔...up to some point.
a)True
b)False
20) Electrical equipment shall be designed to withstand a single pole short circuit current up to the
activation of.....
a)True
b)False
21)How is the initiation of electric arc at the instant of contact separation caused
a)Thermionic emission of electrons.
b)Field emission of electrons.
c)Both A and B above.
d)None of these.
22)For insulators and bushings of power transformers, circuit breakers and instrument transformers.
a)Epoxy resin
b)Polyesters resin
c)Porcelain.
d)Silicon rubber
23)Frequency relay: Combined voltage and current of supply is measured by this relay using trigger
a)True
b)False
28) Additional earths May be applied at the point of work after the issue of a permit to work by the
competent person in charge
a)True
b)False
26)While doing racking in. If the VCB is “ON” then the racking handle can be inserted.
a)True
b)False.
28) An ideal transformer will have maximum efficiency at a load such that
A. copper loss = iron loss
B. copper loss < iron loss
C. copper loss > iron loss
D. none of the above
30) When the 3-phase system is not grounded and if Single Line to Ground fault occurs, the voltage of
the other two healthy phases will
A. Increases
B. Decreases
C. Remains unaffected
D. none of the above
31) For an EHV equipment for maintenance first it should be isolated and connected to ground
because
A. to provide low impedance
B. to discharge the charging capacitance to ground
C. protection for operating personnel
D. both (B) and (C)
33) When the 3-phase system is not grounded and if Single Line to Ground fault occurs, the voltage of
the other two healthy phases will
A. Increases
B. Decreases
C. Remains unaffected
D. none of the above