Professional Documents
Culture Documents
Acc Bu
Acc Bu
Acc Bu
1|BUILDIN G UTILITIES
15. Any of a variety of soft floor finishes made of 22. A valve in which the flow of liquid is controlled by
synthetic materials such as nylon or natural material a rotating drilled ball that fits tightly against a
such as wool. It is either glued directly to the floor or resilient (flexible) seat in the valve body.
installed over an underlayment of hair felt or foam a. Angle valve
rubber. What is it? b. Check valve
a. Panel absorber c. Float valve
b. Carpet d. Ball valve
c. Curtain and fabrics 23. What is the minimum distance between the
d. Volume resonator handrails of escalators?
16. A general term used for any vertical line of soil, a. 600mm
waste or vent piping. b. 558mm
a. Vent pipe c. 658mm
b. Waste pipe d. 650mm
c. Stack 24. Which material would exhibit the highest sound
d. Soil pipe absorption coefficient (SAC) value?
17. A receptacle attached to a plumbing system a. Marble
other than a trap in which water or wastes may be b. Wood
collected or obtained for ultimate into the plumbing c. Plastic
system. d. Carpet
a. Valve 25. A vertical pipe which conveys only wastewater or
b. Waste pipe liquid waste free of fecal matter.
c. Fitting a. Waste pipe
d. Fixture b. Soil pipe
18. A water supply pipe that extends vertically one c. Soil stack
full storey or more to convey water to fixture d. Waste stack
branches or group of fixtures. 26. A bathroom containing a water closet, a lavatory,
a. Up pipe and a bathtub.
b. Riser a. Full bath
c. Stack pipe b. Half bath
d. Water stack pipe c. Three quarter bath
19. A cylindrical conduit or conductor, the wall d. Quarter bath
thickness is sufficient to receive a standard pipe. 27. Which is the following characterizes centrallized
a. Conduit airconditioning system?
b. Pipe a. It uses ducts
c. Fitting b. Has cooling tower
d. Leader c. Provided with air handling unit
20. Wallace Clement Sabine, an American physicist d. All of these
who pioneered work on sound is said to be the 28. It is analogous to pressure in water flow.
father of ____? a. Resistance
a. Environmental acoustics b. Voltage
b. Room acoustics c. Current
c. Architectural acoustics d. Power
d. Acoustical science 29. A suction created by the flow of liquids in pipe, a
21. That part of the drainage system that extends pressure less than the atmospheric pressure.
from the end of the building drain and conveys its a. Backflow
discharge to the public sewer, private sewer, b. Backpressure
individual sewage disposal system or other c. Siphonage
appropriate point of disposal. d. Flow pressure
a. Building sewer 30. It characterizes short circuit
b. Building drain a. High resistance, high current
c. Building storm drain b. Low resistance, low current
d. Building sewage pipe c. Low resistance, high current
d. High resistance, low current
2|BUILDIN G UTILITIES