Professional Documents
Culture Documents
Executive Software Programming Procedure - R2
Executive Software Programming Procedure - R2
Version 1.0
Table of Contents
1 Checklist before programming...........................................................................................3
2 Executive SW Programming...............................................................................................4
2.1 Requirements.....................................................................................................................4
2.2 Executive SW Programming Procedure............................................................................4
2.2.1 Programming Procedure:......................................................................................4
3Configuration settings for Executive Software programming..................................................11
3.1 CCC- Card Settings.........................................................................................................11
3.2 CVC- Card Settings.........................................................................................................12
3.3 PCC- Card Settings..........................................................................................................13
Programming of Cards
SL. No Details Yes /No Remarks
1 Insert the cards into respective slot of
programming Jig
2 Programming tool FRC cable connector is
properly inserted into the respective processor
connector.
3 USB cable one end connected to Pc other end
connected to Programming tool.
4 Switch on Power Supply of programming jig
5 Ensure Power On led indication on
programming tool.
6 Selected appropriate file to do programming
(follow procedure of software programming).
(CCC, PCC & CVC – VP1,VP2 & SVP)
7 Ensure Executive SW file selected - CCC
8 Ensure Executive SW file selected – PCC
2 Executive SW Programming
2.1 Requirements
1. PC/Laptop
2. Programming tools
3. Executive SW Ver 1.2 files.
Image 1: CF Flasher
5. Click “Target Config” button to open the “Target configuration” then window will be opened
6. Scroll down the target configuration option to select “M5282EVB(CFM)” as target device.
9. Then in the main CF Flasher window click “Erase” button. Erase window should be opened.
Press “Erase” button in this window.
Image 5: Erase
13. Now in the program window, tick the “Verify after program” check box and Click
“Program” button after appropriate selection as shown in Fig.8.
14. Progress bar will be displayed indicating programming status as shown in fig.9.
15. After successful programming the CF flasher s/w declares “Verify O.K !” message will be
displayed as shown in fig.10. Which indicates the successful programming of the micro-
controller with selected “.elf” program file.
16. Press “OK” button and then press “Done” button in program window to complete the
programming procedure. .
Note : To do another processor programming repeat the same procedure as described above.
Note: Hold the card in such a way Medha logo facing toward your side.
CCC Card Programming - Insert FRC Connector into K18 Connector to do program
Note: Hold the card in such a way medha logo facing toward your side.
Note: Hold the card in such a way Medha logo facing toward your side