Professional Documents
Culture Documents
AEC IA2 October 2023
AEC IA2 October 2023
Course Name Analog Electronics Circuits (July-Dec 2023) Year S.Y B.Tech
Department EXCP Semester III
IA component IA2 DOS 27.10.2023
Q1. Simulate a MOSFET differential amplifier, the value of RD & RS will be the last two
digits of roll no. times kΩ. For eg: For Roll no: 1000020 then RD1 = RD2 = 20kΩ , RS =
20KΩ. If your last digits are from 01 to 10, kindly add 10 to your last two digits, so roll no with
last two digits with 01 will become 11, then RD1 = RD2 = 11kΩ , RS = 11KΩ
Assume: VTN1 = VTN2 = 1V, kN1 = kN2 = 100µA/V2, VDD = 5V, VSS = -5V, Vin = 40 mVp-p
Attention: Students with ODD roll no will attempt DIUO configuration and EVEN roll no will
attempt DIBO configuration
b) Simulate the circuit and determine Q point parameters (Attach print screen of Q point
parameters) 2M
c) Simulate the circuit and determine Differential mode gain (Attach print screen of input-output
waveforms) 2M
e) Compare the Q point parameters and Differential mode gain with simulated value obtained in
b) and c) 3M
Q2. Simulate single –stage BJT CE Amplifier circuit, measure its Q point parameters and
perform transient analysis
Consider R1 = 90kΩ, R2 = 22kΩ, RC= 2.7 kΩ, RE = 820 Ω, RL= 10 kΩ, CC1 = 1µF, CC2 =
1µF, CE = 120µF, BJT: 2N2222, VCC = 12V (ODD ROLL Number consider these values)
Consider R1 = 120kΩ, R2 = 24kΩ, RC= 3.3 kΩ, RE = 1000 Ω, RL= 10 kΩ, CC1 = 1µF, CC2 =
1µF, CE = 120µF, BJT: 2N2222, VCC = 12V (EVEN ROLL Number consider these values)
a) Make a circuit schematic of BJT CE amplifier in LT SPICE as per above information and give
suitable input (Attach print screen image of circuit) 2M
c) Simulate the circuit, Perform transient analysis and plot Vin(t) and Vout(t), then determine
voltage gain @ 10KHz (Attach print screen of input-output waveforms) 3M
d) Compare theoretical value of Q point parameters and Voltage gain with simulated value
obtained in b) and c) 3M
Q3. For the single –stage MOSFET CS Amplifier circuit, determine the following:
a) Create a circuit schematic of MOSFET CS amplifier in LT SPICE as per above information and give
suitable AC input (Attach print screen image of circuit) 2M
b) Simulate the circuit, Perform frequency response i.e Av Vs frequency, then determine mid-band
voltage gain @ 10KHz (Attach print screen of frequency response and measure fL, fH, and BW) 4M
c) Compare theoretical value of mid-band voltage gain and fH with simulated value obtained in b) 4M