Professional Documents
Culture Documents
Jobsheet 4
Jobsheet 4
Jobsheet 4
Bintulu, Sarawak
JOBSHEET 4
PROGRAMME DEE 6
Page 1 of 6
STUDENT NAME :
MATRIX NO :
TOOLS/
EQUIPMENTS/ PLC Workstation and Simulation Kit
MATERIALS
INSTRUCTION 1. Read and understand the instruction before starting any work.
2. Make sure that all work SOP and safety precautions are followed.
3. Make sure your work place are clean and tidy before, during and
after each work.
TASK:
1. Identify all the input and output elements will be used:
(i) switch (ii) lamp (iii) pump
2. Identify and decide all the input and output PLC port can be used.
3. Draw a wiring block diagram and make a connection between the elements to PLC
port based on that drawing.
4. Create a logic table for every situation at above.
5. Sketch a set of ladder diagram suitable with the requested system as explain ABOVE.
6. Compile and verify the finish sketch of ladder diagram. Make sure there is no error or
warning showed.
7. Upload the finish sketch of the ladder diagram into PLC device.
8. Check and make sure all the connection are in right place first. Then start the PLC
system to test the created program.
Page 2 of 6
CASE 1
Page 3 of 6
CASE 2
CASE 3
Page 4 of 6
LADDER DIAGRAM:
OPERATION :
Page 5 of 6
CONCLUSION:
DISCUSSION :
Verified By:
Date :
Page 6 of 6