Professional Documents
Culture Documents
E Use
E Use
Model code No. Product No. -eDrawings format (e.g.) -PDF (e.g.)
(e.g.) ILLUSTRATION
1. Confirm the display setting.
When the viewer software is installed, "shadow" is displayed for the illustrations as default.
Cancel this setting.
Note: For details about each function of the eDrawings, refer to the HELP of eDrawings.
Select "Tools" , "Options" and "General" in this order from the tool bar, and remove the check mark
from "Display shadow".
However, this setting may vary depending on the version of the viewer software.
(e.g.) ILLUSTRATION
・Refer to ***._***参照 -1
…*** shows the reference page.
Supplementary Explanation
Type of ring (E-3, S-8, R-8, etc.)
…Check the parts number in APPENDIX.
,
…These two arrows with the same
symbol connect the parts.
Wire Number
Connector Number
Parts Number
・The cables can be found with their wire number or connector number in the cable table.
・This table includes the cable assembly, the SCSI cable, the ground wire, the Starter jumper and the optical fiber cable.
・Check the connector number or the wire number of the cable to be ordered, then find out the parts number via the numbers.
5. How to search the parts
Note
If you directly browse the part No. page and description page, click the unit title of bookmark.
-eDrawings format
On the view menu, click UI mode. Confirm that the check box of "complete" is checked,
or click at the left side of the screen.
Put the pointer on the desired part. The part No. is displayed.
If the part is hidden in other parts, click "Move component" button to move the parts.
-PDF
Part No. is described in the illustration.
Note
-For details of pdf parts list, click here.
5-2-1. How to confirm the figure of the part
If you know the part No., you can confirm the figure of the part following the procedures below.
-eDrawings format
On the view menu, click UI mode. Confirm that the check box of "complete" is checked,
or click at the left side of the screen.
Procedure 2-1
Click the part No. in the list (bookmark).
The color of the corresponding part changes.
If it is difficult to distinguish the part by its color, confirm the part by other method.
You can also confirm the part by changing the highlight color of "Options" in "Tools".
If the part is hidden in other parts, click "Move component" button to move the parts.
Procedure 2-2
If it is still difficult to distinguish the color even though the highlight color is changed,
click (shaded) to change the illustration to the line drawing.
Procedure 2-3
Click (Disassembly/Assembly) to show the parts when confirming the figure of the
Version 2007
Click at the left side of the screen.
-PDF
Part No. is described in the illustration.
Note
-For details of pdf parts list, click here.