Download as pdf or txt
Download as pdf or txt
You are on page 1of 21

Original BMW Accessories.

Installation Instructions.
Alarm system retrofit
BMW 5 Series Saloon (E 60)

Retrofit kit no.: 65 73 0 304 463 Alarm system retrofit kit

Installation time
The installation time is approx. 5.0–5.5 hours. This may vary depending on the condition of the car and the
equipment in it.
In general the car must be upgraded to the latest I stage status by flashing before starting the conversion work.
Differing programming times may be necessary depending on the production age of the vehicle and on work
previously performed on the vehicle.
The installation time specified does not include the time spent on programming / coding.
The calculation of the total costs for the programming time must be factored into the calculation of retrofitting costs
(no invoicing via warranty).

Important information
These installation instructions are primarily designed for use within the BMW dealership organisation and by
authorised BMW service companies.
In any event, the target group for these installation instructions is specialist personnel trained on BMW cars with
the appropriate specialist knowledge.
All work must be completed using the latest BMW repair manuals, circuit diagrams, servicing manuals and work
instructions, in a rational order, using the prescribed tools (special tools) and observing current safety regulations.
If you experience installation or function problems, limit troubleshooting to approx. 0.5 hours for
mechanical or 1.0 hour for electrical work.
In order to reduce costs and avoid any additional expense, send a query immediately to the Technical Parts Support
via the Aftersales Assistance Portal (ASAP).
Specify the following information:
- Chassis number,
- Part number of the retrofit kit,
- A precise description of the problem,
- Work steps already carried out.
Do not archive the hard copy of these installation instructions since daily updates are provided via ASAP!

Pictograms
Denotes instructions that draw your attention to dangers.
!

Denotes instructions that draw your attention to special features.

Denotes the end of the instruction or other text.

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 1


Installation information
All pictures show LHD cars; proceed accordingly on RHD cars.
Additional cables/lines that you install must be secured with cable ties.
Ensure that the cables and/or lines are not kinked or damaged as you install them in the car. The costs incurred as
a result will not be reimbursed by BMW AG.
If the specified PIN chambers are occupied, bridges, double crimps or twin-lead terminals must be used.
After the installation work, the retrofit must be programmed / coded using ISSS (Integrated Software Service
Station) via the – Conversions – path.

Ordering instructions
The interior roof light cover G is not supplied with the retrofit kit and must be ordered separately for individual colour
variants (for part number and instructions see EPC).

List of special equipment


The following special equipment must be taken into consideration when installing the retrofit kit:
SA 431 Automatic anti-glare interior mirror
SA 610 Head-up display
SA 5AD Lane Departure Warning

Special tools required


00 9 317 Panel wedge
61 9 040 Crimping pliers

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 2


Table of contents

Section Page

1. Parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2. Preparatory work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

3. Connection diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

4. Installation and cabling diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

5. Routing wiring harness B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

6. Routing wiring harness A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

7. Fitting the siren, ultrasound module and electric chrome mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

8. Concluding work and coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

9. Alarm system system circuit diagram cars built before 09/05 only . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

10. Alarm system system circuit diagram cars built after 09/05 only . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

11. Legend and cable colours . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 3


1. Parts list

A B C

D E F G H I J K L
060 0931 Z

Legend

A Wiring harness A
B Wiring harness B
C Electric chrome mirror
D Ultrasound module
E Emergency power siren
F Engine compartment lid contact switch
G Ceiling light cover (not supplied with the retrofit kit)
H Cable tie L = 50 mm (2x)
I Cable tie L = 200 mm (20x)
J Nut M6
K Miniature connector (4x)
L Cable eyelet M6 (only for cars built after 03/05)

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 4


2. Preparatory work

ISTA No.
Conduct a brief test ---
Disconnect the negative pole of the battery 12 00 ...

First, the following components must be removed


Microfilter cover 64 31 010
The bottom section of the microfilter casing on the right 64 31 061
E-Box lid ---
Glove box, right 51 16 366
Trim at the bottom right of the dashboard 51 45 181
Storage compartment on the left-hand side of the car 51 16 ...
Pedal trim 51 45 185
Inside mirror ---
Sun visors left and right ---
Front ceiling light 63 31 000
Rear ceiling light 63 31 003
Right grab handles ---
Roof pillar trim on the right 51 43 201
B-pillar trim at the top right ---
Rear seat 52 24 005
Rear seat backrest side section, right 52 26 008
Fold down the rear seat backrest on the right ---
C-pillar trim at the top right ---
C pillar trim at the bottom right ---
Luggage compartment trim on the right ---
Rear bumper trim ---
Bumper trim holder on the right ---

Lower the roofliner on the right ---

Also on cars built after 03/07 without SA 5AD/SA 610


Left roof pillar trim 51 43 201

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 5


3. Connection diagram

A2 A3 A4 A5 A6 A7 A8
A

A9

A1 A10

A11

060 0911 Z

Item Designation Signal Cable colour / Connection location in the car Abbreviation /
cross-section slot
A Wiring harness A --- --- --- ---
A1 Socket casing --- SW Electric chrome mirror X18246
A2 Cable open CAN HIGH SW Only cars built before 03/07 or with SA 5AD/SA 610
0.50 mm2 To the rain/light sensor
Only cars built after 03/07 without SA 5AD/ X15011
SA 610
To the light module
X15001
PIN14
A3 Cable open CAN LOW GE Only cars built before 03/07 or with SA 5AD/SA 610
0.50 mm2 To the rain/light sensor
Only cars built after 03/07 without SA 5AD/SA 610 X15012
To the light module

X15002
PIN 32
A4 Socket casing --- SW Ultrasound module X1582
A5 Cable eyelet M6 Terminal 31 BR Right comb connector on the C-pillar X13790
0.50 mm²
A6 Socket contact Terminal 30 RT/SW Cars built before 09/05 only
0.50 mm2 Rear fuse holder X11012
SW 32-pin plug PIN 6
Cars built after 09/05 only
Rear fuse holder X11015
SW 16-pin plug PIN 12
A7 Socket contact Terminal 15 GN/GE Cars built before 09/05 only
0.35 mm2 Rear fuse holder X11012
SW 32-pin plug PIN 15
Cars built after 09/05 only
Rear fuse holder X11012
SW 41-pin plug PIN 28
A8 Cable open RFS BL/GE Right rear light X318
0.35 mm2 PIN 3
A9 Socket contact Terminal 31 BR Emergency power siren X372
0.50 mm² PIN 1
A10 Socket contact DWAH SW/BL Emergency power siren X372
0.50 mm² PIN 2
A11 Socket contact Terminal 30 RT/SW Emergency power siren X372
0.50 mm² PIN 3

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 6


3. Connection diagram

B1 B B2 B3

060 0912 Z

Item Designation Signal Cable colour / Connection location in the car Abbreviation /
cross-section slot
B Wiring harness B --- --- --- ---
B1 SW 3-pin socket plug --- --- Engine compartment lid contact switch X161
B2 Comb connector contact Terminal 31 BR Cars built before 03/05 only X1816
0.50 mm2 To the comb connector behind the glove compartment
Cars built after 03/05 only
With cable eyelet L to the earth support point on the X13782
bottom right A-pillar
B3 Socket contact MHK VI/GN To the CAS control unit X10318
0.50 mm2 SW 41-pin plug PIN 38

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 7


4. Installation and cabling diagram

7
F B 1 2 C A D 3 E 4 5

E65

8
060 1419 Z

Legend

A Wiring harness A
B Wiring harness B
C Electric chrome mirror
D Ultrasound module
E Emergency power siren
F Engine compartment lid contact switch

1 Comb connector X1816 (cars built before 03/05 only)


2 CAN high/low pick-up X15011 and X15012 (cars built before 03/07 or with SA 5AD/SA 610 only)
3 Joint connector X13790
4 Rear fuse holder X11012/X11015
5 Reversing light signal pick-up X318
6 CAS control unit connection X10318
7 Earth support point X13782 (cars built after 03/05 only)
8 CAN high/low pick-up X12 on the light module (cars built after 03/07 without SA 5AD/SA 610 only)

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 8


5. Routing wiring harness B

Route wiring harness B under the equipment


1 holder (1) through the bulkhead into the interior
of the car.

B 060 0041 Z

Connect the engine compartment lid contact


switch F to the holder on the microfilter lid (1).

1 Connect branch B1 to the engine compartment lid


contact switch F.

B1
060 0042 Z

Route branch B3, VI/GN cable, to the left-hand side


of the car to the CAS control unit.
Cars built before 03/05 only

B3 Route branch B2, BR cable, to the comb connector


and connect it to plug X1816.

X1816
B2

060 0043 Z

Cars built after 03/05 only


Cut the comb connector contact from branch B2 (it
is no longer required) and crimp on cable eyelet L.
Connect branch B2, BR cable, to earth support
B2 point X13782.

X13782
L

060 00934 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 9


5. Routing wiring harness B

All cars
M

Disconnect plug X10318 from the CAS control


W
B

1 unit (1) and unlock it.


Connect branch B3, VI/GN cable, to plug X10318
PIN 38.

X10318 B3
060 0044 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 10


6. Routing wiring harness A

Cars without SA 431 only


Route branch A1 to the connection point for the
inside mirror.

A1
060 0045 Z

Cars with SA 431 only


Route branch A1 to the connection point for the
electric chrome mirror.
Disconnect the cables from branch A1.
Insulate the BL/GE, BR and GN/GE cables and tie
them back.
Connect the remaining cables as follows to
plug X18246:
A1
- RT/SW to PIN 8
X18246 060 0046 Z - GR/SW/GE to PIN 9

Only cars built before 03/07 or with SA 5AD/


K SA 610
Connect branch A2, SW cable, to the same colour
CAN high on the rain/light sensor using miniature
connector K.
Connect branch A3, GE cable, to the same colour
A3
CAN low on the rain/light sensor using miniature
A2 connector K.
Tie back the excess length of branches A2 and A3.

060 0047 Z

Only cars built after 03/07 without SA 5AD/


SA 610
Route branches A2 and A3 along the left-hand
A-pillar to the installation point for the light
module X12.

A2
A3

0601420 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 11


6. Routing wiring harness A

Disconnect plug X12 on the light module.


Connect branch A2, SW cable, to the same colour
CAN high on the light module using miniature
connector K.

X12 Connect branch A3, GE cable, to the same colour


CAN low on the light module using miniature
connector K.

K
A2/A3
060 1421 Z

All cars
Route wiring harness A to the right-hand B-pillar.

060 0048 Z

Route branch A4 to the centre of the roof in the


A4 area of the rear ceiling light.
Route wiring harness A to the right-hand C-pillar.

060 0049 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 12


6. Routing wiring harness A

Connect branch A5, BR cable, to comb


connector X13790 and tie back the excess.
A
Route wiring harness A to the luggage
compartment.

A5

X13790

060 0050 Z

Cars without SA 431 built before 09/05


A6 K
A8 Disconnect plug X11012 on the rear fuse holder
and unlock it.
Connect branch A6, RT/SW cable,
X318 to plug X11012 PIN 6.
Connect branch A7, GN/GE cable, to plug X11012
PIN 15.

A Connect branch A8, BL/GE cable, to plug X318


A7 X11012 PIN 3 using miniature connector K.
Route wiring harness A to the tail panel.
060 0051 Z

Cars with SA 431 built before 09/05


A7-A8
Disconnect plug X11012 on the rear fuse holder
and unlock it.
A Connect branch A6, RT/SW cable,
to plug X11012 PIN 6.
Insulate and tie back branches A7 and A8.
Route wiring harness A to the tail panel.
X11012
A6
060 0052 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 13


6. Routing wiring harness A

Cars without SA 431 built after 09/05


Connect branch A6, RT/SW cable,
to plug X11015 PIN 12.
Connect branch A7, GN/GE cable, to plug X11012
PIN 28.
Connect branch A8, BL/GE cable, to plug X318
PIN 3 using miniature connector K.
Route wiring harness A to the tail panel.

Cars with SA 431 built after 09/05


A7-A8 Connect branch A6, RT/SW cable,
to plug X11015 PIN 12.
Insulate and tie back branches A7 and A8.
X11015 Route wiring harness A to the tail panel.

A
A6
060 1423 Z

All cars
Draw the dimensions as follows on the tail panel (1):
1 - 35 mm from the outside of the cable duct (4)
- 55 mm from the bottom edge (3)
35mm Drill a drill hole (2) with an arbor-type cutter to
2 40 mm diameter.
Deburr the hole and coat the bare surfaces with
55mm

preservative.

3 4 060 0017 Z

Guide branches A9–A11 through the hole (1).

A9-A11

060 0053 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 14


7. Fitting the siren, ultrasound module and electric chrome mirror

Screw the emergency power siren E to the bumper


mount on the right (1) using nut J.
J

E 1

060 0057 Z

Secure branches A9–A11 using cable ties H to


1 H H threaded bolts (1).
Connect branches A9–A11 to plug X372:

1 - Branch A9, BR cable, to PIN 1


A9-A11
- Branch A10, SW/BL cable, to PIN 2
- Branch A11, RT/SW cable, to PIN 3
X372
Connect plug X372 to emergency power siren E.

E
060 0058 Z

Clip ultrasound module D to ceiling light cover G.

D
000 0055 Z

Connect branch A4 and plug X1582 to ultrasound


X1582 module D.
Fit the ceiling light cover G.

D G A4

060 0056 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 15


7. Fitting the siren, ultrasound module and electric chrome mirror

Install the electric chrome mirror C and connect


plug X18246 / branch A1.

X18246/A1

060 0054 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 16


8. Concluding work and coding

This retrofit system requires coding


- Connect the battery
- Program/encode the retrofit with ISSS (Integrated Software Service Station) via the – Conversions – path
- Conduct a function test
- Re-assemble the car.

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 17


9. Alarm system system circuit diagram cars built before 09/05 only

A46 A22 A149

6 15 X11012 3 10 8 9 1 X18246 38
X10318

RFS
30 DWA

15

D
30 IR
15

31
A6 A7
GN/GE 0,35

GR/SW/GE 0,35
RT/SW 0,5

BL/GE 0,35

VI/GN 0,50
BR 0,35

RT/SW 0,5
A8
RT/SW 0,5
X318
X16009

X15011
X15012
A2 A3
SW 0,35

GE 0,35
SW/BL 0,5

BR 0,5

BR 0,5

A11 A10 A9
CAN HIGH

CAN LOW
30 DWA

30
31
31

D
S

3 2 1 X372 8 7 1 5 3 2
X1582 1 X161

S19

H1 A121
2
X161
BR 0,50

A5

X13790 X1816/X13782
060 0937 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 18


10. Alarm system system circuit diagram cars built after 09/05 only

A46 A22 A149

38
12 28 3 10 8 9 1

X18246 X10318

RFS
X11015
30 DWA

15

D
30 IR
15

31
X11012
A6 A7
GN/GE 0,35

GR/SW/GE 0,35
RT/SW 0,5

BL/GE 0,35

VI/GN 0,50
BR 0,35

RT/SW 0,5
A8
RT/SW 0,5
X318
X16009

X15011 / X12
X15012 / X12
A2 A3
SW 0,35

GE 0,35
SW/BL 0,5

BR 0,5

BR 0,5

A11 A10 A9
CAN HIGH

CAN LOW
30 DWA

30
31
31

D
S

3 2 1 X372 8 7 1 5 3 2
X1582 1 X161

S19

H1 A121
2
X161
BR 0,50

A5

X13790 X1816/X13782
060 1422 Z

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 19


11. Legend and cable colours

Legend

A2 Cable open, CAN-HIGH pick-up


A3 Cable open, CAN-LOW pick-up
A5 Cable eyelet
A6 Socket contact
A7 Socket contact
A8 Cable open, RFS pick-up
A9 Socket contact
A10 Socket contact
A11 Socket contact
A22 Electric chrome mirror
A46 Rear fuse holder
A121 Ultrasound module
A149 CAS control unit

H1 DWA emergency power siren

S19 Engine compartment lid contact switch

X12 CAN High/Low (cars built after 03/07 without SA 5AD/SA 610 only)
X161 SW 3-pin plug
X318 SW 6-pin plug
X372 SW 3-pin plug
X1582 SW 8-pin plug
X1816 Comb connector (cars built before 09/05 only)
X10318 SW 41-pin plug
X11012 SW 32-pin plug (cars built before 09/05)
X11012 SW 41-pin plug (cars built after 09/05)
X11015 SW 16-pin plug (cars built after 09/05)
X13782 Earth support point (cars built after 03/05 only)
X13790 Comb connector
X15011 CAN high (cars built before 03/07 or with SA 5AD/SA 610 only)
X15012 CAN low (cars built before 03/07 or with SA 5AD/SA 610 only)
X16009 Terminal 30 connector
X18246 SW 10-pin plug

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 20


11. Legend and cable colours

Cable colours

BL Blue
BR Brown
GE Yellow
GN Green
GR Grey
RT Red
SW Black
VI Violet
WS White

© BMW AG, Munich 01 29 0 304 523 4/2009 (Z/Z) 21

You might also like