Professional Documents
Culture Documents
Potassium Chloride Solution 1.2M
Potassium Chloride Solution 1.2M
com
1.2 Relevant identified uses of the substance or mixture and uses advised against
Identified uses : Laboratory chemical/reagent
2. HAZARDS IDENTIFICATION
2.3 Hazards not otherwise classified (HNOC) or not covered by GHS – none
3. COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Mixtures
Formula: KCl
74.55 g/mol
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration.
If swallowed
Never give anything by mouth to an unconscious person. Rinse mouth with water.
4.2 Most important symptoms and effects, both acute and delayed
The most important known symptoms and effects are described in the labelling section 2.2 and/or in section 11
4.3 Indication of any immediate medical attention and special treatment needed
No data available
5. FIREFIGHTING MEASURES
Eye/face protection
Use equipment for eye protection tested and approved under appropriate government standards such as
NIOSH (US) or EN 166(EU).
Skin protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching
glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in
accordance with applicable laws and good laboratory practices. Wash and dry hands.
10.1 Reactivity
No data available
Acute toxicity
No data available
Skin corrosion/irritation
No data available
Carcinogenicity
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as
probable, possible or confirmed human carcinogen by IARC.
ACGIH: No component of this product present at levels greater than or equal to 0.1% is identified as a
carcinogen or potential carcinogen by ACGIH.
NTP: No component of this product present at levels greater than or equal to 0.1% is identified as a known
or anticipated carcinogen by NTP.
OSHA: No component of this product present at levels greater than or equal to 0.1% is identified as a
carcinogen or potential carcinogen by OSHA.
Reproductive toxicity
No data available (2-Amino-2-(hydroxymethyl)propane-1,3-diol hydrochloride)
Specific target organ toxicity - single exposure
PN000934 SDS KCL (R_REG_SDS_0019) Page 4 of 6
Associates of Cape Cod, Inc. acciusa.com
No data available
Aspiration hazard
No data available
Additional Information
RTECS: Not available
Weakness, May cause irritation of the Gastrointestinal tract, Disturbance of circulatory system
HMIS Rating
Health hazard: 1
Flammability: 0
Physical Hazard: 0
NFPA Rating
Health hazard: 0
Fire Hazard: 0
Reactivity Hazard: 0
Further information
Associates of Cape Cod, Inc. (ACC). All rights reserved. The above information is believed to be current and
accurate; however, ACC makes no warranty of any type with respect to such information and assumes no liability
for any loss or injury which may result from the use of this information. Users should conduct their own
investigations to determine the suitability of the information for their intended use.
Preparation Information
Associates of Cape Cod, Inc. Version: 8 SDS KCl