Cable Preparation
b. Cable with metal tape shield
Table 2
Max. system at *L
voltage indoor indoor outdoor
crossed
connection
ay) {om] [mm
72 450 450
12 300 450 650
175 350 500 650
24 50 550 ‘800
36 600 800 ‘800
*L = min. length required,
[mm
130
130
480
180
210
according 1
depth of
cable lug
barrel hole
+5mm
The actual length willbe determined by the overall geometry of the equipment.
‘Separate the cores, Wrap an earth Bend and shape the cores into their
lead round each core and soldertack it final position.
to the metal tape shield (or attach the Cut the cores to the required length.
earth lead by any other equivalent Place a temporary wire binder around
method). Fil the earth lead with solder the cores atthe postion shown in the
to form a 30 mm moisture block drawing, Tear off the tape shield
‘30 mm from the oversheath end. against the wire binder.
Remove the release paper and wrap Remove the metal tape shield
one layer of sealant tape (red) round according to dimension b (see table 2).
the oversheath end for 80 mm Thoroughly remove the core screen to
underneath the earth lead. 20 mm above the metal tape shield
For eables with tape armour also. cut. The surface ofthe insulation
connect the earth lead to the armour. should be free from all traces of
For cables with wire armour follow conductive material
the instruction as supplied in separate Smooth out any irregularities.
armour earthing kit
B2= |,
Y
\
FTI
Y
Tao] Earth lead
ks Moisture
ba block
1 Sealant
10 not nick the insulation.
EPP-0277-12102 page 4/6
Clean 100 mm
Bi eee
Cut the cable to the required length
‘and remove the oversheath.
Leave enough length to set the cores
into the final position.
Clean and degrease the end of the
oversheath for about 100 mm,
Note: The minimum termination length
(U)is given in Table 2
Remove the wire binder from the
‘end of the metal tape shield.
Remove the release paper and wrap
the void filing strip (yellow) for 5 mm
tonto the metal tape shield, continuing
ver the core screen and 10 mm onto
the insulation
Stretch the strip to half ofits original
Width to achieve a fine, thin edge onto
the insulation.
B4_