Professional Documents
Culture Documents
Instrumentation Project Description 2023
Instrumentation Project Description 2023
Instrumentation Project Description 2023
Title:
Development of Instrumentation System for System Monitoring and Data Logging.
Objective:
1. To design and develop and instrumentation for system monitoring and data logging.
2. To calibrate the proposed instrumentation system.
3. To investigate the accuracy of the developed instrumentation system.
However, student is encouraged to work in group for information sharing and project discussion.
Assessment:
1. Report – 30%
Every student needs to submit the project report at the end of semester. The report should
consist of:
Chapter 1 (3%) – Project Background: introduction, objective, scopes, review on most
recent technologies used in the selected instrumentation system.
Chapter 2 (5%) – Mechanical Design: overall system description (block diagram), physical
design of enclosure, engineering drawing with proper enclosure dimensioning, material
selection and fabrication techniques used to produce the enclosure.
Chapter 3 (10%) – Electrical Design: sensor selection, signal conditioning system design
(sample calculation, schematic diagram, circuit drawing), components selection and
remote monitoring system setup.
Chapter 4 (5%) – Sensor calibration procedures and results (calibration charts / graphs).
Chapter 5 (5%) – Instrumentation system accuracy testing procedures and results
(accuracy charts / graphs), analysis and discussion of instrumentation system accuracy.
Chapter 6 (2%) – Conclusion.
2. Presentation (In Class / Video) – 10%
In 3 – 5 minutes, each student should present the following information clearly:
Project background
Instrumentation system design and how it works.
Functionality demonstration of the instrumentation system.
Hardware:
Jumper wires.
Breadboard 830 holes points.
AAA Batteries + battery holder (x2)
Resistors (depends on design)
Operational Amplifier (741)
Arduino UNO / NANO
SD card module
Multimeter
Software:
Arduino IDE (C-Programming platform): https://www.arduino.cc/en/software
Tinkercad (for simulation): https://www.tinkercad.com/join