Professional Documents
Culture Documents
MS 06 114
MS 06 114
MS 06 114
com
see what the corresponding changes in outlet pressure will inlet pressure is not shown on the graph, one can interpolate
2.0
be. Is that range of pressures acceptable? If not, a different within a control range, but not between different control
regulator is needed. ranges.
1.5 JAPA
There is one additional variable that affects the shape of a
curve—the
1.0 inlet pressure (i.e., pressure going into a pressure-
reducing regulator on the upstream side). Note that for each
of the0.5two sets of curves in Fig. 1, there are three curves
representing a range of inlet pressures.
0 400 800 1200 1600
0 10 20 30 40 50 60 70
25 2.5
20 2.0
15 1.5 CHIN
10 1.0
2 Pressure-Reducing Regulator Flow Curves
60
Droop, Seat-Load Drop, Choked Flow, the inlet pressure rating results in a flow curve with more
droop than flow curves for regulators whose inlet pressure
Supply-Pressure Effect, and Hysteresis rating closely matches actual system pressure (Fig. 3). In
As mentioned, it is best to operate a regulator along the addition, selecting a regulator that closely matches inlet
flattest—or most horizontal—part of a flow curve. Indeed, 0 an 20 pressure
40 requirements
60 80 provides
100 the
120 best140
handle 160
resolution
ideal flow curve would be a flat line. However, no regulator 80
(smaller amount of pressure change per turn of the handle)
can produce a perfectly flat line over its full range of
5.0 and control, enabling a broader ideal operating range. 70
pressures because its internal components have limitations.
Typically, a flow curve consists of three parts (Fig. 2.):
4.0 Seat-Load Drop or Lockup 60
■ The ideal operating range, a relatively flat part in the middle Seat-load drop occurs on the far left of the regulator50curve
■ A steep drop on the far left, which shows seat-load
3.0 drop or (Fig. 2), where there is initially a steep drop in pressure. If EURO
lockup reading the curve from left to right, imagine that the40 system is
in a no-flow state. The regulator is set to a certain pressure,
■ A steep drop on the far right, which shows the choked-flow
2.0 30
but there is no flow. Then, imagine that an operator slowly
area. opens a downstream valve to initiate flow. Immediately, 20
1.0 there is a sharp drop in pressure because it is difficult for a
Droop 10
regulator to maintain pressure at this location. A regulator
The flat part in the middle is not perfectly flat. It slopes
0 operating along this steep drop in the curve may emit 0
downward, which is called droop. As flow increases, outlet 0 500 chattering
1000 1500 or 2000
pulsating
2500sounds
3000 as 3500
it fluctuates
4000 between
4500 flow
pressure will drop some—or a lot, depending on the regulator and no-flow conditions.
design. While droop is relatively modest along the flat part of
Now read the curve from right to left. Imagine that the system
the curve, it is quite steep at the far ends of the curve.
is operating along the flat part of the curve. Then, imagine
Supplying a regulator with pressures substantially lower than that an operator slowly closes a downstream valve, reducing
flow to near zero. We are moving up the curve. As the no-flow
60
50 Increasing Fig. 4. T
he phenomenon of hysteresis
Flow 3.0 revealsUSA
that at the same flow volume,
40 outlet pressure is higher with
30 decreasing flow than with increasing
2.0
flow. Hysteresis is shown larger than
20 normal for illustration purposes.
1.0
10
Flow
0 0
0 20 40 60 80 100 120 140 160
Nitrogen Flow, std ft3/min
state nears, the regulator has difficulty maintaining the set Hysteresis results from dynamic friction forces within the
pressure. Again, the regulator may emit a chattering sound. regulator, but is usually not an issue when evaluating the
Eventually, the regulator snaps shut, stopping flow. This is performance of a regulator. However, it can be a point of
called lockup. (Lockup may not be shown on all flow data. confusion during system operation. Suppose an operator sets
Typiclaly, lockup
0 pressures
20 40are less
60 than 5%
80 of control
100 range.)
120 140up a system
160 to deliver an outlet pressure of 50 psig (3.4 bar)
at 110 std 3
The terms seat-load drop and lockup are essentially 80ft /min (3115 std L/min). The next day, the pressure
interchangeable.
5.0 Sometimes, lockup is used to describe both is now 50.5 psig (3.48 bar), but the flow is still 110 std ft3/min
conditions. It is not advisable to operate a regulator under (3115 std70L/min). It is likely that something in the system
these conditions. Some regulator flow data will not reflect temporarily
60
created more flow demand downstream.
4.0
lock-up, especially for higher flow models. Typically, lock-up Moving from left to right on the curve, the temporary flow
pressures will be less than 5 % of the total control range for a increase50 slightly reduced the outlet pressure. Then, as the
3.0
given model. flow demand returned to EURO
110 std ft3/min (3115 std L/min),
40
hysteresis caused the outlet pressure to return to a point
Choked
2.0 Flow slightly higher
30 than the initial set point.
Choked flow occurs on the far right of a curve. See the It is recommended
20
to approach set pressure from a lower
choked-flow
1.0 area in Fig. 2, where pressure begins to droop pressure. Another best practice is to employ pressure gauges
sharply at 140 std ft3/min (3960 std L/min). At this point, in the system
10 to help fine tune regulator settings to achieve
the flow demand has exceeded the pressure-controlling desired operating pressures.
0 0
capabilities0 of the500
regulator.
1000 Here,
1500 the regulator
2000 2500 is wide
3000 3500 4000 4500
open and is no longer regulating pressure. Essentially, it Supply-Pressure Effect
has changed from a pressure-controlling device to an open Supply-pressure effect (SPE) or dependency is a ratio
orifice. Increasing downstream flow to this point or beyond describing the change in outlet pressure per 100 psi (6.8 bar)
renders the regulator ineffective. It is not advisable to operate change in inlet pressure. In other words, for every 100 psi
a regulator in the choked-flow area due to the sharp pressure (6.8 bar) drop in inlet pressure, the outlet pressure will increase
drop. by X psi. X is the SPE. For standard pressure-reducing
Note that Cv is measured at the regulator’s fully open regulators, the outlet pressure increases as supply pressure
position, and that is why it cannot describe the overall decreases. The opposite is true as supply pressure increases.
performance of the regulator. This effect can also be realized on system startup or shutdown.
0.5
In fact, selecting a regulator based solely on its flow The regulator should be set to the “off” position
coefficient (Cv) can result in unsatisfactory performance. If before turning the supply pressure on or off to prevent
0.4 overpressurization of regulator diaphragms, outlet pressure
the system flow is within range of the regulator’s Cv, one may
believe that the regulator is the right “size.” But that is not gauges, or other equipment downstream. When selecting
0.3 true. The C represents the regulator’s maximum an antitamper model, it is important to make sure that SPE
necessarily v JPN
will not cause excessive overpressurization on opening and
flow capacity. At maximum flow, a regulator can no longer
control 0.2
pressure. closing of the supply pressure.
Hysteresis
0.1
See Fig. 4, above. When reading left to right, flow is
increasing.
0 And the reverse is true when reading right to left.
Depending0on whether
500 flow is1500
1000 increasing
2000 or 2500
decreasing,
3000 the
3500 4000 4500
curve differs slightly. Outlet pressure does not follow the
same “droop line” or end at the original set pressure. This
phenomenon is called hysteresis.
4 Pressure-Reducing Regulator Flow Curves
Flow Curves
KPR Series KCP Series
■ Flow coefficients of 0.02, 0.06, 0.20, and 0.50 ■ Flow coefficients of 0.02, 0.06, 0.20, and 0.50
■ Pressure control ranges from 0 to 10 psig (0 to 0.68 bar) ■ Pressure control ranges from 0 to 10 psig (0.68 bar) through
through 0 to 500 psig (0 to 34.4 bar) 0 to 1500 psig (103 bar)
■ Maximum inlet pressures from 100 to 6000 psig (6.8 to ■ Maximum inlet pressures from 100 to 3600 psig (6.8 to
413 bar) 248 bar)
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
■ Flow coefficients of 0.06, 0.20, and 0.50 ■ Flow coefficients of 0.02 and 0.06
■ Pressure control ranges from 0 to 10 psig (0 to 0.68 bar) ■ Pressure control ranges from 0 to 1000 psig (68.9 bar)
through 0 to 500 psig (0 to 34.4 bar) through 0 to 3600 psig (248 bar)
■ Maximum inlet pressures from 3000 to 6000 psig (206 to ■ Maximum inlet pressures from 2000 to 6000 psig (137 to
413 bar) 413 bar)
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
■ Flow coefficients of 0.02, 0.06, 0.20, and 0.50 ■ Flow coefficient of 1.0
■ Pressure control ranges from 0 to 2.0 psig (0 to 0.13 bar) ■ Pressure control ranges from 0 to 1000 psig (68.9 bar)
through 0 to 250 psig (0 to 17.2 bar) through 0 to 4000 psig (275 bar)
■ Maximum inlet pressures from 15 to 3600 psig (1.0 to ■ Maximum inlet pressure of 6000 psig (413 bar)
248 bar)
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Liquid Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Liquid Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
KHP Series and KHR Series
KHF Series
■ Flow coefficients of 0.06 and 0.25
■ Flow coefficient of 1.0 ■ Pressure control ranges from 0 to 500 psig (34.4 bar)
■ Pressure control ranges from 0 to 10 psig (0.68 bar) through through 100 to 10 000 psig (6.8 to 689 bar)
0 to 250 psig (17.2 bar) ■ Maximum inlet pressure of 10 000 psig (689 bar)
■ Maximum inlet pressures from 100 to 3600 psig (6.8 to
KHP Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
248 bar)
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 KHR Liquid Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Pressure-Reducing Regulator Flow Curves 7
Flow Curves
RS(H)2 Series LPRS10, and LPRS15 Series
■ Flow coefficients of 1.84, 1.95 and 2.07 ■ RDH: 0 to 3625 psig (0 to 250 bar)
■ Pressure control ranges from 1.4 to 14.5 psig ■ Maximum inlet pressures:
(0.10 to 1.0 bar) through 4.3 to 43 psig (0.30 to 3.0 bar) ■ RD: 1015 psig (70.0 bar)
■ Maximum inlet pressure: 218 psig (15.0 bar) ■ RDH: 5800 psig (400 bar)
■ Pressure control ranges from 0 to 43 psig (0 to 3.0 bar) ■ Pressure control ranges from 0 to 145 psig (0 to 10.0 bar)
through through 5075 psig (0 to 350 bar)
■ RD20 and RD25: 0 to 1015 psig (0 to 70.0 bar) ■ Maximum inlet pressures:
■ RDH20 and RDH25: 0 to 2900 psig (0 to 200 bar) ■ BS2: 5800 psig (400 bar)
■ Maximum inlet pressures: ■ BSH2: 10 150 psig (700 bar)
■ RD20 and RD25: 1015 psig (70.0 bar) Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
■ RDH20: 5800 psig (400 bar)
■ RDH25: 4060 psig (280 bar)
BS(H)4, BS(H)6, and BS(H)8 Series
■ Flow coefficient from 0.49 to 2.07
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
■ Pressure control ranges from 0 to 5220 psig (0 to 360 bar)
RD(H)30 and RD(H)40 Series through 0 to 5220 psig (0 to 360 bar)
■ Maximum inlet pressure: 5800 psig (400 bar)
■ Flow coefficients of 36 and 73
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
■ Pressure control ranges from 0 to 43 psig (0 to 3.0 bar)
through BS(H)10 and BS(H)15 Series
■ RD30 and RD40: 1015 psig (70.0 bar)
■ Flow coefficient from 3.84 to 7.3
■ RDH30 and RDH40: 0 to 2900 psig (0 to 200 bar)
■ Pressure control ranges from 0 to 203 psig (0 to 14.0 bar)
■ Maximum inlet pressures:
through 0 to 5220 psig (0 to 360 bar)
■ RD30 and RD30: 1015 psig (70.0 bar)
■ Maximum inlet pressure: 5800 psig (400 bar)
■ RDH30 and RDH40: 4060 psig (280 bar)
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Gas Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 188
LBS4 Series
RA4, RA6 and RA8 Series
■ Flow coefficient of 1.3
■ Flow coefficient of 1.84 ■ Pressure control ranges from 0 to 43 psig (0 to 3.0 bar)
■ Pressure ratios from 1:15 through 1:70 through 0 to 290 psig (0 to 20.0 bar)
■ Maximum inlet pressure: 5800 psig (400 bar) ■ Maximum inlet pressure: 507 psig (35.0 bar)
BS(H)2 Series
■ Flow coefficient of 0.10
■ Pressure control ranges from 0 to 145 psig (0 to10.0 bar)
through
■ BS2: 0 to 5075 psig (0 to 350 bar)
■ BSH2: 0 to 10 150 psig (0 to 700 bar)
■ Maximum inlet pressures:
■ BS2: 5800 psig (400 bar)
■ BSH2: 10 150 psig (700 bar)
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.02, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
Pressure Control Range A Nitrogen Flow, std L/min
0 to 25 psig (0 to 1.7 bar)
0 50 100 150 200 250 300 350 400 450
0 to 10 psig (0 to 0.68 bar) 30
2.0
25
1.5
Outlet Pressure, psig
30
2,0
25
1.5
25
Outlet Pressure, psig
20
1,5 50 (3.4), 100 (6.8) 500 (34.4), 1000 (68.9), 20
15 3600 (248), 6000 (413)
1.0
USA
3.4 (50), 6.8 (100)
34.4 (500), 68.9 (1000)
1,0 1000 (68.9),
15 EURO
10
3600 (248),
6000
248 (3600), 413 (413)
(6000)
0.5
50 (3.4), 100 (6.8) 500 (34.4) 10
5.0
0,5 68.9 (1000),
3.4 (50), 248 (3600), 500 (34.4), 1000 (68.9),
50 (3.4), 34.4
6.8 (100) 100 (6.8)
(500)
3600 (248), 6000 (413) 5,0
0 413 (6000) 0
0 3.4 (50), 6.8 (100) 1.0 2.0 248 (3600), 413
34.4 (500), 68.9 (1000), 3.0(6000) 4.0 5.0
0 3 0
0 50 100 150Nitrogen
200Flow, std
250ft /min300 350 400 450
Flow Coefficient 0.02, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
20
500 (34.4) 1.0
3600 (248), 6000 (413)
50 (3.4), 100 (6.8) 1000 (68.9)
0 0
0 5.0 10 15 20 25 30 35 40
Nitrogen Flow, std ft3/min
100 0 7.0
5,0 10 15 20 25 30 35 40
7,0 100
0.7
6,0 34.4 (500) 68.9 (1000),
248 (3600),
0.6 0.34
6.89 413 (6000) 80
5,0
6.8 (100)
0.5
0.68 60
4,0 24.8 41.3
68.9, (1000),
0.4
248 (3600), EURO
413 (6000)
3,0 JPN
34.4 (500) 40
0.3
3.44 3.4 (50), 6.8 (100) 68.9 (1000),
2,0
6.89 24.8, 41.3 248 (3600),
Pressure-Reducing Regulator Flow Curves 11
Flow Coefficient 0.02, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
30
1000 (68.9) 3600 (248), 6000 (413)
400 500 (34.4)
25
Outlet Pressure, psig
100
5.0
1000 (68.9)
100 (6.8) 500 (34.4) 3600 (248), 6000 (413)
0 0
0 2.0 4.0 6.0 8.0 10 12 14 16 18 20
Nitrogen Flow, std ft3/min
500 0 35
2,0 4,0 6,0 8,0 10 12 14 16 18 20
35 500
3.5
68.9 (1000),
30
248 (3600),
3.0 34.4 (500) 413 (6000) 400
3.44 24.8, 41.3
25 6.89
2.5
20 300
2.0
EURO
15 68.9 (1000),
JPN
200
1.5 34.4 (500) 248 (3600),
10 3.44 24.8 41.3
413 ,(6000)
6.89
12 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0
USA
50 (3.4), 100 (6.8), 500 (34.4)
10
3600 (248), 6000 (413) 1000 (68.9)
0.5
5.0
50 (3.4) 100 (6.8), 500 (34.4), 1000 (68.9), 3600 (248), 6000 (413)
0 0
0 2.0 4.0 6.0 8.0 10 12
1.5
25
Outlet Pressure, psig
1,5
0.15 20
68.9 (1000)
1,0 15 EURO
0.10 3.4 (50), 6.8 (100), 34.4 (500)
248 (3600), JPN
413 (6000)
0.34, 0.68, 3.44 10
0,5
Pressure-Reducing Regulator Flow Curves 13
Flow Coefficient 0.06, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
6.0
80
Outlet Pressure, psig
5.0
100 0 7.0
5,0 10 15 20 25 30500 (34.4),35
1000 (68.9),40
3600 (248), 6000 (413)
7,0 100
6.0
80
6,0
Outlet Pressure, psig
5.0
7,0 100
34.4 (500), 68.9 (1000),
0.7 248 (3600), 413 (6000)
6,0
0.6 80
5,0
0.5 6.8 (100)
4,0 60
0.68
0.4
68.9 (1000), EURO
3.44 248 (3600),
3,0
413
JPN
24.8(6000)
, 41.3 40
0.3
2,0 6.8 (100)
68.9 (1000), 68.9 (1000),
14 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
30
400
1000 (68.9) 3600 (248), 6000 (413) 25
Outlet Pressure, psig
500 35
0 10 20 30 40 50 60 70 80 90 100
3600 (248), 6000 (413)
35 500
30
400 1000 (68.9)
30
25
Outlet Pressure, psig
0 5,0 10 15 20 25
35 500
3.5 248 (3600), 413 (6000)
30
3.0 68.9 (1000) 400
25
6.89
2.5
34.4 (500) 24.8, 41.3 300
20
2.0
3.44 EURO
15
68.9 (1000), 248 (3600), 413 (6000) JPN
200
1.5 34.4 (500)
10 6.89
3.44
Pressure-Reducing Regulator Flow Curves 15
Flow Coefficient 0.20, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
500 (34.4)
15 1.0
USA
1000 (68.9)
10
50 (3.4) 3600 (248) 0.5
100 (6.8)
5.0
500 (34.4)
1.5
25
500 (34.4), 1000 (68.9)
Outlet Pressure, psig
1,5
34.4 (500), 68.9 (1000) 20
0.15
248 (3600)
1,0 15 EURO
0.10 6.8 (100)
JPN
3.44
10
6.8 (100), 34.4 (500), 68.9 (1000)
3.4 (50) 6.89
0,5
16 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
6.0
80
5.0
Outlet Pressure, psig
100 0 7.0
5,0 10 15 20 25 30 35 40
7,0 100
1000 (68.9), 3600 (248), 6000 (413) 6.0
80
6,0
5.0
Outlet Pressure, psig
7,0 100
0.7
6,0 68.9 (1000), 248 (3600), 413 (6000)
0.6 80
5,0
6.8 (100),
0.5
34.4 (500) 60
4,0
0.4
EURO
3,0 34.4 (500), 68.9 (1000),
3.44 248 (3600), 413 (6000)
JPN
40
0.3 0.68
2,0
6.89, 24.8, 41.3
3.4 (50)
Pressure-Reducing Regulator Flow Curves 17
Flow Coefficient 0.20, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
30
400
25
Outlet Pressure, psig
500 35
0 20 40 60 80 100 120 140 160 180
35 3600 (248), 6000 (413)
500
30
400
30 1000 (68.9)
25
Outlet Pressure, psig
0 10 20 30 40 50 60
35 500
3.5
248 (3600), 413 (6000)
30
3.0 400
68.9 (1000)
25
2.5
20 300
34.4 (500)
2.0
EURO
248 (3600), 413 (6000)
15 JPN
200
1.5 24.8, 41.3
10 6.89 68.9 (1000)
18 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0
USA
1000 (68.9)
10
100 (6.8), 500 (34.4)
3600 (248), 6000 (413) 0.5
5.0
1000 (68.9)
100 (6.8) 3600 (248), 6000 (413)
50 (3.4)
0 0
0 2.0 4.0 6.0 8.0 10 12
Nitrogen Flow, std ft3/min
1.5
25
Outlet Pressure, psig
1,5
0.15 20
6.8 (100), 34.4 (500)
0,5 6.89
Pressure-Reducing Regulator Flow Curves 19
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
6.0
80
5.0
Outlet Pressure, psig
100 7.0
0 5,0 10 15 20 25 30 35 40
1000 (68.9), 3600 (248), 6000 (413)
7,0 6.0
100
80
6,0 5.0
Outlet Pressure, psig
0.6 80
5,0 6.8 (100), 34.4 (500)
0.5
4,0 3.44 60
Flow Coefficient 0.50, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
30
400
25
Outlet Pressure, psig
500 0 35
20 40 60 80 100 120 140 160 180
35 500
30
400 3600 (248), 6000 (413)
30
25
Outlet Pressure, psig
200
500 (34.4) 15 EURO
15 34.4 (500)
248 (3600), 413
1000(6000) 20
(68.9), 200
68.9 (1000) 500 (34.4)
100 3600 (248),
10
248 (3600), 413 (6000) 6000 (413) 10
34.4 (500) 3600 (248), 6000 (413) 100
5,0 100 (6.8) 68.9 (1000)
500 (34.4), 1000 (68.9)
0 248 (3600), 413 (6000) 0
0 10 20 30 40 50 60
0 6.8 (100) 34.4 (500), 68.9 (1000) 0
Nitrogen Flow, std ft3/min
0 500 1000 1500 2000 2500 3000 3500 4000 4500 5000
0 10 20 30 40 50 60
35 500
3.5
30
3.0 248 (3600), 413 (6000) 400
25
2.5
68.9 (1000)
20 300
2.0 EURO
15 34.4 (500) JPN
3.44 200
1.5
24.8, 41.3
10 6.89 68.9 (1000),
Pressure-Reducing Regulator Flow Curves 21
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0 USA
500 (34.4), 1000 (68.9), 3600 (248)
10
0.5
5.0 500 (34.4),
500 (34.4), 1000 (68.9), 3600 (248) 1000 (68.9),
3600 (248)
0 0
0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0
Nitrogen Flow, std ft3/min
20 25
500 (34.4), 1000 (68.9), 3600 (248)
1,5
15 20
1.0
USA
10
1,0 15 EURO
34.4 (500), 68.9 (1000), 248 (3600) 0.5
500 (34.4), 1000 (68.9), 3600 (248)
5.0 10
0,5
500 (34.4), 1000 (68.9), 3600 (248)
0 0
5,0
34.4 (500),
0 0.2 0.4 0.6 0.8 68.9 (1000), 1.0
34.4 (500), 68.9 (1000), 248 (3600) 3 248 (3600)
Nitrogen Flow, std ft /min
0 0
0 20 40 60 80 100
22 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100 6.0
5.0
Outlet Pressure, psig
4.0
60 500 (34.4),
1000 (68.9), USA
3.0
3600 (248)
40
500 (34.4), 2.0
1000 (68.9),
20 3600 (248) 500 (34.4),
500 (34.4), 1.0
1000 (68.9), 1000 (68.9),
3600 (248) 3600 (248)
0 0
0 10 20 30 40
4.0
5,0
60 80
USA
3.0
4,0 500 (34.4), 1000 (68.9), 3600 (248)
40 34.4 (500), 60
2.0
EURO
3,0 68.9 (1000),
248 (3600)
500 (34.4), 1000 (68.9), 3600 (248) 40
20 1.0
2,0 34.4 (500),
68.9 (1000), 500 (34.4), 1000 (68.9), 3600 (248)
0 248 (3600) 34.4 (500), 0
20
1,0 34.4 (500),
0 1.0 2.0 68.94.0
(1000),
68.9 (1000),3.0 5.0
248 (3600)
248 (3600)
Nitrogen Flow, std ft3/min
0 0
0 200 400 600 800 1000
6,0 100
0.6
4,0
0.4
60 EURO
JPN
3,0
0.3 34.4 (500), 68.93.44, 6.89,
(1000), 24824.8
(3600)
40
2,0
Pressure-Reducing Regulator Flow Curves 23
Flow Coefficient 0.06, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
200
500 (34.4), 1000 (68.9), 3600 (248)
10
100
500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 5.0 10 15 20
300
400
20
USA
20
200
34.4 (500), 68.9 (1000), 248 (3600)
500 (34.4), 1000 (68.9), 3600 (248)
300 EURO
10
200
100
34.4 (500), 68.9 (1000), 248 (3600)
10 500 (34.4), 1000 (68.9), 3600 (248)
100
0 34.4 (500), 68.9 (1000), 248 (3600) 0
0 1.0 2.0 3.0 4.0 5.0
500
30
3.0 34.4 (500), 68.9 (1000), 248 (3600)
400
20
2.0 3.44, 6.89, 24.8 300 EURO
JPN
Flow Coefficient 0.20, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0
USA
500 (34.4), 1000 (68.9), 3600 (248)
10
0.5
5.0
500 (34.4), 1000 (68.9), 3600 (248)
500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10
0 20 40 60 80 100
30
2.0
0 2,0 4,0 6,0 8,0 10
25 30
2,0
1.5
Outlet Pressure, psig
25
0.15
1,5
20
34.4 (500), 68.9 (1000), 248 (3600)
1,0
0.10 15 JPN
EURO
3.44, 6.89, 24.8
10
Pressure-Reducing Regulator Flow Curves 25
Flow Coefficient 0.20, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 4.0
USA
40
500 (34.4),
500 (34.4),
1000 (68.9), 2.0
1000 (68.9),
20 3600 (248) 500 (34.4), 3600 (248)
500 (34.4), 1000 (68.9),
1000 (68.9), 3600 (248)
3600 (248)
0 0
0 5.0 10 15 20 25 30 35
5.0
6,0 4.0
60 80
USA
3.0
500 (34.4), 1000 (68.9), 3600 (248)
40
EURO
4,0 60
2.0
20
500 (34.4), 1000 (68.9), 3600 (248)
40
1.0
34.4 (500), 34.4 (500),
2,0 500 (34.4), 1000 (68.9), 3600 (248)
68.9 (1000),
68.9 (1000),
0 248 (3600) 34.4 (500), 248 (3600) 0
34.4 (500), 20
0 1.0 68.9 (1000),
68.9 (1000),2.0 3.0 4.0 5.0
248 (3600)
248 (3600)
Nitrogen Flow, std ft3/min
0 0
0 200 400 600 800
6,0 100
4,0
0.4 60 JPN
EURO
3,0
34.4 (500), 68.9 (1000), 248 (3600)
40
26 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 20 USA
30
500
Outlet Pressure, psig
20
200
300 EURO
500 (34.4), 1000 (68.9), 3600 (248)
10
34.4 (500), 200
100
68.9 (1000),
10
500 (34.4), 1000 (68.9), 248
3600(3600)
(248)
100
0 0
34.4 (500), 68.9 (1000), 248 (3600)
0 5.0 10 15 20
34.4 (500), 68.9 (1000), 248 (3600)
0 Nitrogen Flow, std ft3/min 0
0 400 800 1200 1600 2000
0 5,0 10 15 20
600
40
4.0
500
30
3.0
400
34.4 (500), 68.9 (1000), 248 (3600)
20
2.0
300 EURO
JPN
200
34.4 (500), 68.9 (1000), 248 (3600)
Pressure-Reducing Regulator Flow Curves 27
Flow Coefficient 0.50, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0 USA
10
500 (34.4), 1000 (68.9), 3600 (248)
0.5
5.0
500 (34.4), 1000 (68.9), 3600 (248)
500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 1.0 2.0 3.0 4.0 5.0 6.0 7.0 8.0
10
1,0 15 EURO
500 (34.4), 1000 (68.9), 3600 (248) 0.5
5.0 10
34.4 (500), 68.9 (1000), 248 (3600)
0,5 500 (34.4),
1000 (68.9), 3600 (248)
0 05,0
0 0.5 34.4
1.0 (500), 68.9 (1000), 248
1.5(3600) 2.0
Nitrogen
34.4 (500), 68.9 Flow,
(1000), 248 std ft3/min
(3600)
0 0
0 40 80 120 160 200
25
1,5
0.15
20
34.4 (500), 68.9 (1000), 248 (3600)
1,0
0.10
15 EURO
JPN
10
28 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
6.0
75
5.0
Outlet Pressure, psig
2.0
25
500 (34.4), 1000 (68.9), 3600 (248) 1.0
500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10 12 14 16 18 20
100 7.0
0 2,0 4,0 6,0 8,0 10 12 14 16 18 20
500 (34.4), 1000 (68.9), 3600 (248) 6.0
7,0 100
75
5.0
Outlet Pressure, psig
4.0
75
5,0
50
USA
34.4 (500), 68.9 (1000), 248 (3600) 3.0
4,0
500 (34.4), 1000 (68.9), 3600 (248)
50
2.0
EURO
3,0
25
1.0
2,0 500 (34.4), 1000 (68.9), 3600 (248)
25
0 34.4 (500), 68.9 (1000), 248 (3600) 0
1,0
0 1.0 2.0 3.0 4.0 5.0
34.4 (500), 68.9 (1000), 248 (3600)
Nitrogen Flow, std ft3/min
0 0
0 80 160 240 320 400 480 560
7,0
0.7 100
75
5,0
0.5
Flow Coefficient 0.50, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 20
USA
10
100 500 (34.4), 1000 (68.9), 3600 (248)
30
300 400
20 USA
500
30
3.0 34.4 (500), 68.9 (1000), 248 (3600)
400
20
2.0
300 JPN
EURO
34.4 (500), 68.9 (1000), 248 (3600)
3.44, 6.89, 24.8 200
30 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
12 0.8
10
Outlet Pressure, psig
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5 4,0 4,5 5,0
12 0.8
14
10
12
Outlet Pressure, psig
0,8
0.6
8.0 500 (34.4), 1000 (68.9),
3600 (248) 10
USA
0,6
6.0 0.4
8,0
50 (3.4)
100 (6.8)
4.0
0,4
6,0 EURO
50 (3.4) 0.2
3.4 (50) 6.8 (100)
2.0 500 (34.4), 1000 (68.9), 100 (6.8)
4,0
3600 (248)
3.4 (50) 34.4 (500), 68.9 (1000),
0,2
0 6.8 (100) 248 (3600) 0
2,0
0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1.0
34.4 (500), 68.9 (1000),
3/min
Nitrogen Flow, std ft248 (3600)
0 0
0 20 40 60 80 100 120 140
Pressure-Reducing Regulator Flow Curves 31
Flow Coefficient 0.02, Pressure Control Range 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
50
3.0
100 (6.8)
Outlet Pressure, psig
30 2.0 USA
3600 (248)
20 50 (3.4),
100 (6.8) 1.0
500 (34.4) 1000 (68.9), 3600 (248)
10
50 (3.4),
100 (6.8) 500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10 12 14
1,0
6.8 (100) 500 (34.4), 1000 (68.9),
50 (3.4), 100 (6.8) 34.4 (500) 68.9 (1000), 248 (3600)
3600 (248)
0 010
0 3.4 (50), 1.0 2.0 3.0 4.0 5.0
6.8 (100) 34.4 (500), 68.9 (1000), 248 (3600)
0 Nitrogen Flow, std ft3/min 0
0 80 160 240 320
50
68.9 (1000), 248 (3600)
0.3
3,0 6.8 (100)
0.68 34.4 (500)
3.44 40
6.89
0.2
2,0
24.8
30 JPN
EURO
68.9 (1000), 248 (3600)
0.34, 3.4 (50), 6.8 (100) 20
32 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.02, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
500 (34.4) 1000 (68.9)
Outlet Pressure, psig
3600 (248)
60 4.0 USA
40 100 (6.8)
500 (34.4) 1000 (68.9)
2.0
3600 (248)
20
50 (3.4), 1000 (68.9),
100 (6.8) 500 (34.4) 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10 12 14 16 18 20
100 120
8,0 1000 (68.9), 3600 (248)
6.0
500 (34.4) 100
Outlet Pressure, psig
100
68.9 (1000), 248 (3600)
0.6
6,0
3.44 6.89 34.4 (500)
80
24.8
0.4 JPN
4,0 60
EURO
68.9 (1000), 248 (3600)
0.68
6.8 (100)
3.44 34.4 (500) 40
6.89
Pressure-Reducing Regulator Flow Curves 33
Flow Coefficient 0.02, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
3000 (206) 15
1000 (68.9)
Outlet Pressure, psig
150 10 USA
100
1000 (68.9) 3000 (206) 5.0
500 (34.4) 3600 (248)
50
3000 (206) 3600 (248)
500 (34.4) 1000 (68.9)
0 0
0 5.0 10 15 20 25 30 35 40 45 50
0 5,0 10 15 20 25 30 35 40 45 50
250 300
20
1000 (68.9), 3000 (206), 3600 (248) 15
Outlet Pressure, psig
15
68.9 (1000) 206 (3000)
150
248 (3600)
10
200 USA
100
10
1000 (68.9), 3000 (206), 3600 (248)
150 EURO
500 (34.4) 5.0
50 100
500(1000)
68.9 (34.4) 1000 (68.9) 3000 (206), 3600 (248)
5,0 206 (3000)
34.4 (500) 248 (3600) 050
0
0 1.0
206 (3000) 2.0 (3600)
248 3.0 4.0 5.0
250
15
1.5 20.6 68.9 (1000), 206 (3000), 248 (3600)
6.89 200
24.8
10
1.0
150 JPN
EURO
100
34 Pressure-Reducing Regulator Flow Curves
10
0.6
Outlet Pressure, psig
6.0 0.4
USA
50 (3.4)
4.0 100 (6.8), 3600 (248)
500 (34.4), 0.2
2.0 1000 (68.9)
500 (34.4), 1000 (68.9)
50 (3.4) 100 (6.8),
0
3600 (248) 0
0 1.0 2.0 3.0 4.0 5.0
4.0
0,4 500 (34.4), 1000 (68.9) 6,0 EURO
3.4 (50) 0.2
50 (3.4), 100 (6.8), 3600 (248)
2.0 4,0
6.8 (100), 248 (3600)
0,2 34.4 (500),
0 68.9 (1000) 0
2,0
34.4 (500), 68.9 (1000)
0 0.2 0.4 0.6 0.8 1.0
3.4 (50) 6.8 (100),
248
Nitrogen Flow, std ft3/min
(3600)
0 0
0 20 40 60 80 100 120 140
10
34.4 (500), 68.9 (1000)
0,6
0.06
8,0
3.4 (50), 6.8 (100), 248 (3600)
0,4
0.04
6,0 JPN
EURO
0.34
34.4 (500), 68.9 (1000) 4,0
0.68, 24.8
Pressure-Reducing Regulator Flow Curves 35
Flow Coefficient 0.06, Pressure Control Ranges 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
50
3.0
Outlet Pressure, psig
1.0
500 (34.4), 1000 (68.9),
50 (3.4) 100 (6.8)
10 3600 (248)
0.2
2,0 30 JPN
EURO
34.4 3.44, 6.89,(1000),
(500), 68.9 24.8
248 (3600)
20
36 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
0 5,0 10 15 20
100 120
8,0
500 (34.4), 1000 (68.9), 6.0
3600 (248)
Outlet Pressure, psig
100
Flow Coefficient 0.06, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
150
3600 (248)
10
USA
100
200
15
150
34.4 (500)
200
10 USA
68.9 (1000),
248 (3600)
100 150
10 1000 (68.9), 3600 (248) EURO
5.0
500 (34.4), 1000 (68.9),
50 3600 (248) 100
5,0 68.9 (1000), 248 (3600)
100 (6.8)
0 34.4 (500) 050
0 2.0 4.0 6.0 8.0 10
6.8 (100) 34.4 (500) 68.9 (1000), 248 (3600)
0 Nitrogen Flow, std ft3/min 0
0 400 800 1200 1600
15
1.5
34.4 (500) 200
3.44 6.89
24.8
10
1.0 150 JPN
EURO
10
0.6
Outlet Pressure, psig
6.0 0.4
USA
500 (34.4),
4.0 1000 (68.9)
100 (6.8), 0.2
50 (3.4) 3600 (248)
2.0
100 (6.8),
50 (3.4) 500 (34.4), 1000 (68.9),
3600 (248)
0 0
0 1.0 2.0 3.0 4.0 5.0
10
0,6
0.06
8,0
34.4 (500), 68.9 (1000)
0,4
0.04 3.4 (50), 6.8 (100), 6,0 JPN
EURO
248 (3600)
6.8 (100), 34.4 (500),
68.9 (1000), 248 (3600) 4,0
Pressure-Reducing Regulator Flow Curves 39
Flow Coefficient 0.20, Pressure Control Ranges 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
50
3.0
Outlet Pressure, psig
30 2.0 USA
500 (34.4),
100 (6.8) 1000 (68.9),
20
3600 (248)
500 (34.4), 1000 (68.9), 1.0
3600 (248)
10 50 (3.4) 100 (6.8)
500 (34.4), 1000 (68.9),
50 (3.4) 100 (6.8) 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10 12 14
50
4,0
100 (6.8), 500 (34.4), 60
1000 (68.9), 3600 (248)
3.0
50
Outlet Pressure, psig
3,0
30
40
2.0 USA
100 (6.8), 500 (34.4),
1000 (68.9), 3600 (248)
2,0
20
30 EURO
50 (3.4)
34.4 (500),
1.0
6.8 (100) 68.9 (1000),
10 100 (6.8), 500 (34.4), 1000 (68.9), 248 (248) 20
3600(3600)
34.4 (500), 68.9 (1000),
1,0
248 (3600) 50 (3.4)
3.4 (50) 10
0 6.8 (100) 0
0 0.5 1.0 1.5 2.0
34.4 (500), 68.9 (1000),
3.4 (50) 6.8 (100) 248 (3600)
0 Nitrogen Flow, std ft3/min 0
0 80 160 240 320
0.2
2,0
6.8 (100), 34.4 (500),
30 JPN
EURO
3.44, 6.89,
68.9 (1000),24.8
248 (3600)
0.68
20
40 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
1000 (68.9),
Outlet Pressure, psig
60 100 (6.8)
500 (34.4)
4.0 USA
40
50 (3.4) 500 (34.4), 1000 (68.9),
3600 (248) 2.0
20 100 (6.8)
500 (34.4), 1000 (68.9),
100 (6.8)
50 (3.4) 3600 (248)
0 0
0 5.0 10 15 20 25 30 35 40
Nitrogen Flow, std ft3/min
0 5.0 10 15 20 25 30
500 (34.4), 35
1000 (68.9),40
100 120
8,0 3600 (248)
6.0
Outlet Pressure, psig
40
4,0 6.8 (100)
34.4 (500)
60 EURO
100 (6.8) 2.0
50 (3.4)
20 40
3.4 (50) 34.4 (500), 68.9 (1000),
2,0 248 (3600) 50 (3.4) 100 (6.8)
0 6.8 (100) 0
20
0 2.0 4.0 6.0 8.0 10
34.4 (500), 68.9 (1000),
6.8 (100) Nitrogen Flow, std ft3/min
248 (3600)
3.4 (50)
0 0
0 200 400 600 800 1000
Flow Coefficient 0.20, Pressure Control Range Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
150
500 (34.4)
10 USA
3600 (248)
100 1000 (68.9)
5.0
100 (6.8) 500 (34.4), 1000 (68.9), 3600 (248)
50
1000 (68.9), 3600 (248)
100 (6.8) 500 (34.4)
0 0
0 20 40 60 80 100
0 20 40 60 80 100
250 1000 (68.9), 3600 (248) 300
20
15
500 (34.4)
Outlet Pressure, psig
15
150 200
10 USA
500 (34.4), 1000 (68.9),
100
10
34.4 (500)
3600 (248) 150 EURO
248 (3600) 5.0
50 100 (6.8) 68.9 (1000) 100
5,0
100 (6.8) 500 (34.4) 1000 (68.9),
3600 (248)
0 6.8 (100) 34.4 (500), 68.9 (1000), 248 (3600) 0
50
0 68.95.0
(1000), 248 (3600) 10 15 20
6.8 (100) 34.4 (500)
3
Nitrogen Flow, std ft /min
0 0
0 400 800 1200 1600 2000 2400 2800
0 5,0 10 15 20
300
20
2.0
15
1.5 34.4 (500)
200
10 150 EURO
JPN
1.0 3.44
24.8
34.4 (500), 68.9 (1000),
100
6.89
248 (3600)
42 Pressure-Reducing Regulator Flow Curves
10
0.6
Outlet Pressure, psig
6.0 0.4
USA
500 (34.4)
4.0
500 (34.4)
0.2
2.0 1000 (68.9),
50 (3.4),
100 (6.8), 1000 (68.9), 100 (6.8) 3600 (248)
50 (3.4)
3600 (248)
0 0
0 1.0 2.0 3.0 4.0 5.0 6.0
0,6
50 (3.4), 100 (6.8), 1000 (68.9),
3600 (248)
8,0
6.0 0.4 USA
500 (34.4) EURO
4.0
0,4 6,0
34.4 (500)
0.2
100 (6.8), 1000 (68.9),
2.0 3600 (248) 50 (3.4) 4,0
34.4 (500)
0,2
10
0,6
0.06 34.4 (500)
8,0
3.4 (50), 6.8 (100), 68.9 (1000),
248 (3600)
0,4
0.04 6,0 JPN
EURO
34.4 (500)
4,0
Pressure-Reducing Regulator Flow Curves 43
Flow Coefficient 0.50, Pressure Control Ranges 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
25
1.5
Outlet Pressure, psig
15 1.0
USA
10 100 (6.8),
3600 (248)
500 (34.4), 0.5
5.0 500 (34.4), 50 (3.4) 1000 (68.9)
1000 (68.9)
50 (3.4)
100 (6.8), 3600 (248)
0 0
0 2.0 4.0 6.0 8.0 10 12
25
0.15
1.5 34.4 (500), 68.9 (1000)
20
3.4 (50), 6.8 (100),
248 (3600)
0.10
1.0 15 JPN
EURO
0.68, 10
44 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
Outlet Pressure, psig
2.0
20 50 (3.4) 500 (34.4), 1000 (68.9),
100 (6.8) 3600 (248)
0 5,0 10 15 20 25 30
100 500 (34.4), 1000 (68.9), 120
8,0 3600 (248)
6.0
Outlet Pressure, psig
6.8 (100)
4,0
0.4 0.68 60
EURO
JPN
34.4 (500), 68.9 (1000), 248, (3600)
3.44, 6.89 24.8
40
Pressure-Reducing Regulator Flow Curves 45
Flow Coefficient 0.50, Pressure Control Range Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
0 10 20 30 40 50 60 70 80
300
20
250
15
200
2.0
1.5
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 1.0, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
3600
15 (248)
100 (6.8) 3600 500 (34.4), 1.0 USA
25 (1.7), (248) 1000 (68.9)
50 (3.4) 25 (1.7)
10
100 (6.8) 50 (3.4)
25 (1.7) 0.5
5.0 500 (34.4), 1000 (68.9), 3600 (248)
100 (6.8)
50 (3.4)
500 (34.4), 1000 (68.9)
0 0
0 5.0 10 15 20
0 5.0 10 15 20
25 30
2,0
100 (6.8), 500 (34.4), 1000 (68.9), 3600 (248) 1.5
Outlet Pressure, psig
20 25
50 (3.4)
1,5
15 1.0
20
USA
25 (1.7)
248
10
1,0
(3600)
6.8 (100) 248 34.4 (500), 15 EURO
1.7 (25), (3600)
500 (34.4), 1000 68.9
(68.9), (1000)
3600 (248) 0.5
3.4 (50) 1.7 (25)
5.0 3600 (248)
25 (1.7), 50 (3.4) 100 (6.8) 10
6.8 (100) 3.4 (50) 25 (1.7) 50 (3.4)
0,5 1.7 (25)
100 (6.8) 500 (34.4), 1000 (68.9)
0 0
5,0
6.8 (100) 34.4 (500), 68.9 (1000), 248 (3600)
0 1.0 2.0 3.0 4.0 5.0
3.4 (50)
34.4 (500), 68.9Nitrogen
(1000) Flow, std ft3/min
0 0
0 100 200 300 400 500
Pressure-Reducing Regulator Flow Curves 47
50
3.0
Outlet Pressure, psig
0 5,0 10 15 20 25 30
50 60
4,0
100 (6.8), 500 (34.4), 1000 (68.9), 3600 (248)
3.0
Outlet Pressure, psig
50
6.8 (100), 34.4 (500), 68.9 (1000), 248 (3600)
3,0
0.3 40
3.44,
3.4 (50)
6.89,
2,0
0.68
24.8 30 EURO
JPN
0.2
0.34 6.8 (100), 34.4 (500), 68.9 (1000), 248 (3600)
20
3.44,
48 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 1.0, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
Outlet Pressure, psig
6,0
100 (6.8)
60
68.9 (1000), 4.0
80 USA
248 (3600)
500 (34.4), 1000 (68.9), 3600 (248)
40 34.4 (500) EURO
4,0 60
100 (6.8)
6.8 (100) 2.0
50 (3.4)
20 34.4 (500), 68.9 (1000), 248 (3600) 40
2,0 6.8 (100)
500 (34.4), 10003.4
(68.9), 3600 (248) 25 (1.7) 50 (3.4) 100 (6.8)
0 (50)
020
0 2.0
34.4 (500),
4.0
68.9 (1000), 248
6.0
(3600)
8.0 10
6.8 (100)
1.7 (25) 3.4 (50) Nitrogen Flow, std ft3/min
0 0
0 400 800 1200 1600
100
34.4 (500), 68.9 (1000), 248 (3600)
6,0
0.6
6.89, 80
24.8
Flow Coefficient 1.0, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
1000 (68.9)
150 10 USA
500 (34.4)
100
1000 (68.9), 3600 (248) 5.0
500 (34.4) 15
250
Outlet Pressure, psig
15
150 248 (3600)
200
10
USA
68.9 (1000)
10
100 500 (34.4), 1000 (68.9), 3600 (248) 150
34.4 (500)
EURO
100 (6.8) 5.0
500 (34.4), 1000 (68.9), 3600 (248)
50 100
1.5
15 34.4 (500)
24.8 200
6.89
1.0
10
3.44
150 EURO
JPN
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.02, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
50 (3.4),
Outlet Pressure, psig
15 1.0 USA
500 (34.4),
10 1000 (68.9)
1000 (68.9), 1000 (68.9), 0.5
50 100 (6.8) 3600 (248) 3600 (248)
5.0 (3.4)
50 3600 (248)
(3.4) 100 (6.8) 500 (34.4)
0 0
0 2.0 4.0 6.0 8.0
20 25
1,5
3.4 (50),
15
6.8 (100)
20
1.0 USA
34.4 (500)
10
1,0 15 EURO
500 (34.4), 1000 (68.9), 3600 (248)
100 (6.8) 0.5
50 (3.4) 34.4 (500),
5.0 10
68.9 (1000)
68.9 (1000), 1000 (68.9), 3600
68.9 (248)
(1000),
0,5 100 (6.8) 248 (3600)
34.4 6.8 (100)50 (3.4) 248 (3600)
500 (34.4)
0 (500) 5,0
0
0 0.5 1.0 1.5 2.0
34.4
0 (500) 6.8 (100) 34.4 (500) Nitrogen Flow, std248 (3600)
ft3/min 0
0 40 80 120 160 200
Pressure-Reducing Regulator Flow Curves 51
Flow Coefficient 0.02, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
100
4,0
0.4 0.34, 0.68 3.44 68.9 (1000),
60
EURO
JPN
6.89 248 (3600)
34.4 (500) 40
24.8
52 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.02, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
1000 (68.9) 30
Outlet Pressure, psig
200
0 5,0 10 15 20 25 30 35
500
600
40
1000 (68.9) 3600 (248) 30
Outlet Pressure, psig
30 68.9 (1000)
300 500 (34.4) 20
USA
400
248 (3600)
200
34.4 (500)
EURO
20 300
500 (34.4) 1000 (68.9) 3600 (248)
10
100
200
10 34.4 (500) 68.9 (1000)
500 (34.4) 1000 (68.9) 248 (3600)
3600 (248)
0 0
100
0 2.0 4.0 6.0 8.0 10
500
30 248 (3600)
3.0 6.89 68.9 (1000)
400
24.8
34.4 (500)
20
2.0 3.44
300 EURO
JPN
200
Pressure-Reducing Regulator Flow Curves 53
Flow Coefficient 0.02, Pressure Control Ranges 0 to 1500 psig (0 to 103 bar) and 0 to 1000 psig (0 to 68.9 bar)
100
1400
400
1000 (68.9)
3600 (248) 20
200
0 0
0 5.0 10 15 20 25 30 35
0 5,0 10 15 20 25 30 35 100
1400
3600 (248) 1600
1200
100
80
1400
Outlet Pressure, psig
60
600
1000248
(68.9)
(3600)
40
EURO
800
100
10
1400
248 (3600)
24.8 1200
80
8.0
1000
60 24.8 248 (3600)
6.0
800 EURO
JPN
68.9 (1000)
40
4.0
6.89 600
54 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0 USA
50 (3.4) 50
10 (3.4) 3600
100 (6.8) (248)
100
(6.8) 0.5
500 (34.4),
5.0 1000 (68.9),
500 (34.4), 1000 (68.9) 3600 (248)
50 (3.4) 100 (6.8) 500 (34.4), 1000 (68.9), 3600 (248)
0 0
0 2.0 4.0 6.0 8.0
1.5
500 (34.4), 1000 (68.9), 3600 (248) 25
Outlet Pressure, psig
25
1,5
0.15 34.4 (500), 68.9 (1000), 248 (3600)
20
1,0
0.10
34.4 (500),
15 EURO
JPN
3.4 (50),
68.9 (1000), 248 (3600) 6.8 (100) 3.4 (50)
0.34
248 (3600) 6.8 (100)
10
0.68 0.34
Pressure-Reducing Regulator Flow Curves 55
Flow Coefficient 0.06, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
0 5,0 10 15 20
100 120
8,0
500 (34.4), 1000 (68.9), 3600 (248) 6.0
Outlet Pressure, psig
100
34.4 (500), 68.9 (1000), 248 (3600)
6,0
0.6 80
6.8 (100)
4,0 0.68 3.44 6.89 24.8
60
EURO
0.4 JPN
34.4 (500), 68.9 (1000), 248 (3600)
40
6.8 (100)
56 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
500 (34.4)
300 3600 (248) 20
USA
200
500 (34.4) 10
100 3600 (248)
1000 (68.9)
3600 (248)
0 500 (34.4), 1000 (68.9) 0
0 20 40 60 80 100
500 (34.4)
30
300
68.9 (1000) 400
20
USA
34.4 (500)
3600 (248)
20
200 248 (3600) 300 EURO
500 (34.4), 1000 (68.9)
10
100 200
3600 (248)
10 34.4 (500)
248 (3600) 500 (34.4), 1000 (68.9) 100
0 68.9 (1000) 0
0 2482.0
(3600) 4.0 6.0 8.0 10
3.44
20 300 EURO
2.0 24.8 JPN
248 (3600)
200
34.4 (500), 68.9 (1000)
Pressure-Reducing Regulator Flow Curves 57
Flow Coefficient 0.06, Pressure Control Ranges 0 to 1500 psig (0 to 103 bar) and 0 to 1000 psig (0 to 68.9 bar)
100
1400
0 0
0 20 40 60 80 100 120 140 160
100
1400 0 20 40 60 80 100 120 140
3000 (206),160
3600 (248) 1600
1200
100 80
1400
Outlet Pressure, psig
100
10 1400
206 (3000),
248 (3600)
1200
80
8.0
20.6
1000
24.8
60 206 (3000),
6.0 248 (3600) 800 EURO
JPN
20.6(1000)
68.9 24.8
40 600
4.0 6.89
58 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
100 (6.8)
15
50 (3.4), 1.0 USA
100 (6.8), 50 (3.4)
3600 (248) 500 (34.4),
10 50 (3.4),
1000 (68.9) 100 (6.8)
500 (34.4), 0.5
1000 (68.9) 1000 (68.9),
5.0
3600 (248)
500 (34.4)
3600 (248)
0 0
0 2.0 4.0 6.0 8.0
1.5
25
Outlet Pressure, psig
25
1.5
0.15
20
34.4 (500), 68.9 (1000), 248 (3600)
0.68
1.0
0.10 0.34,
15 EURO
JPN
0.34 6.8 (100)
0.68,
24.8 3.44, 34.4 (500),
0.34,248 (3600) 3.4 (50) 10
6.89 0.68
Pressure-Reducing Regulator Flow Curves 59
Flow Coefficient 0.20, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
500 (34.4),
60 1000 (68.9), 4.0 USA
3600 (248)
100 (6.8)
40
2.0
20 50 (3.4) 100 (6.8) 3600 (248)
500 (34.4), 1000 (68.9)
6,0
0.6
80
6.8 (100)
4,0 3.44, 6.89, 24.8 60 EURO
0.4 JPN
6.8 (100), 34.4 (500), 68.9 (1000),
0.68 248 (3600) 40
60 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 20
USA
1000 (68.9)
500 (34.4)
200 3600 (248)
500 10
(34.4)
100 1000
(68.9) 3600 (248)
1000 (68.9)
500 (34.4)
3600 (248)
0 0
0 20 40 60 80 100 120
30 500 (34.4)
300 400
20 USA
0 5,0 10 15 20
600
40
4.0
500
34.4 (500)
20
2.0
300 EURO
JPN
6.89
3.44 248 (3600) 200
24.8
Pressure-Reducing Regulator Flow Curves 61
Flow Coefficient 0.20, Pressure Control Ranges 0 to 1500 psig (0 to 103 bar) and 0 to 1000 psig (0 to 68.9 bar)
1400 100
3600 (248)
1200
80
Outlet Pressure, psig
60
800
3600 (248)
USA
600
1000 (68.9) 40
400
1000 (68.9) 20
200 3600 (248)
0 0
0 20 40 60 80 100 120 140 160
1200
100
80
1400
Outlet Pressure, psig
0 10 20 30 40 50
1600
100
10 1400
248 (3600)
24.8
1200
80
8.0
1000
248 (3600)
60
6.0 800 EURO
24.8
JPN
68.9 (1000)
40 600
4.0 6.89
62 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 25 psig (0 to 1.7 bar) and 0 to 10 psig (0 to 0.68 bar)
25
1.5
Outlet Pressure, psig
15 1.0
USA
500 (34.4),
50 (3.4), 1000 (68.9), 50 (3.4)
10
100 (6.8) 3600 (248) 500 (34.4),
1000 (68.9) 100 (6.8) 1000 (68.9),
3600 (248) 0.5
5.0
500 (34.4)
25
34.4 (500), 68.9 (1000), 248 (3600)
1,5
0.15
20
3.4 (50), 6.8 (100)
34.4 (500),
1,0
68.9 (1000),
3.4 (50), 15 EURO
JPN
0.10 3.44, 6.8 (100),
6.89, 248 0.34
(3600)
0.34, 248 (3600)
0.68 24.8 34.4 (500), 10
3.44, 6.89, 24.8
68.9 (1000)
Pressure-Reducing Regulator Flow Curves 63
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60
100 (6.8)
500 (34.4)
4.0
USA
40
500 (34.4), 1000 (68.9),
1000 (68.9) 2.0
50 (3.4) 100 (6.8) 3600 (248)
20
500 (34.4), 1000 (68.9), 3600 (248)
50 (3.4)
100 (6.8) 3600 (248)
0 0
0 5.0 10 15 20 25 30
0 5,0 10 15 20 25 30
100 500 (34.4), 1000 (68.9), 3600 (248) 120
8,0
6.0
Outlet Pressure, psig
6,0
0.6
80
6.8 (100), 6.8 (100)
34.4 (500), 34.4 (500),
4,0 68.93.44
(1000), 68.9 (1000), 60
EURO
JPN
0.4 248 (3600)
248 (3600)
0.68
40
64 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 20
USA
0 20 40 60 80 100 120
500 600
40
500 (34.4), 1000 (68.9), 3600 (248) 30
Outlet Pressure, psig
30
300 20
400
USA
1000 (68.9), 3600 (248)
200
20 500 (34.4) 300 EURO
10
100
34.4 (500) 200
10 34.4 500 (34.4), 1000 (68.9),248
3600 (248)
(3600)
(500)
0 0
100
34.4 (500) 68.9 (1000) 2.0 248 (3600)
0 1.0 3.068.9 (1000) 4.0 5.0
500
30
3.0 34.4 (500), 68.9 (1000), 248 (3600)
400
20
2.0
300 EURO
JPN
68.9 (1000), 248 (3600)
200
3.44 34.4 (500)
Pressure-Reducing Regulator Flow Curves 65
Flow Coefficient 0.50, Pressure Control Ranges 0 to 1500 psig (0 to 103 bar) and 0 to 1000 psig (0 to 68.9 bar)
100
1400
1200
80
Outlet Pressure, psig
0 0
0 50 100 150 200 250 300
0 10 20 30 40 50
1600
10
100
1400
1000
6.0
60 6.89, 24.8
68.9 (1000), 248 (3600) 800 EURO
JPN
4.0
40 600
66 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.02, Pressure Control Range 0 to 1000 psig (0 to 68.9 bar)
1000
60
3600 (248), 6000 (413)
Outlet Pressure, psig
800
60
248 (3600), 413 (6000)
800
1000 (68.9)
600 40
USA
68.9 (1000)
EURO
40 3600 (248), 6000 (413) 600
400 1000 (68.9)
500 (34.4)
20
400
68.9 (1000) 248 (3600), 413 (6000)
200
20 34.4 (500)
500 (34.4) 1000 (68.9) 3600 (248),
6000 (413) 200
34.4 (500) 68.9 (1000)
0 0
0 2.0 4.0 6.0 248 (3600), 4138.0
(6000) 10
0 0
0 100 200 Nitrogen Flow,
300 3/min
400 std ft500 600 700 800
Flow Coefficient 0.02, Pressure Control Range 0 to 1500 psig (0 to 103 bar)
100
1400
400
500 (34.4) 1000 (68.9) 3600 (248), 6000 (413) 20
200
500 (34.4) 1000 (68.9)
3600 (248), 6000 (413)
0 0
0 5.0 10 15 20 25 30
40 600
JPN
248 (3600),
4.0 413 (6000)
400
68 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.02, Pressure Control Range 0 to 2000 psig (0 to 137 bar)
120
3600 (248),
1500 6000 (413)
100
3000 (206)
Outlet Pressure, psig
3000 (206)
40
500
1000 (68.9)
1000 (68.9)
500 3000 (206), 3000 (206) 20
(34.4) 500
(34.4) 1000 (68.9) 3600 (248), 3600 (248),
6000 (413) 6000 (413)
0 0
0 5.0 10 15 20 25 30
120
1500
248 (3600), 100
Outlet Pressure, psig
1000
80 3000 (206), 3600 (248), 6000 (413) USA
248 (3600), 60
1000 (68.9) 413 (6000)
1000 EURO
60
3000 (206), 3600 (248), 40
500 6000 (413)
40
206 (3000)
68.9 (1000) 1000 (68.9)
500
20
500 (34.4) 500 (34.4) 1000 (68.9) 3000 (206), 3600 (248),
68.9 (1000)
20 34.4 206 (3000)6000 (413)
(500) 34.4 206 (3000),
0 (500) 68.9 (1000) 248 (3600), 248 (3600), 0
0 2.0 4.0 6.0 8.0
413 (6000) 413 (6000)10
0 J 0
0 100 200 Nitrogen
300 Flow, 3/min
400 std ft500 600 700 800
1500
100
12
24.8, 41.3
80
10
20.6
206 (3000), 248 (3600), 413 (6000) 1000 EURO
8.0
60
68.9 (1000) JPN
40
6.0 206 (3000), 248 (3600),
413 (6000) 500
Pressure-Reducing Regulator Flow Curves 69
Flow Coefficient 0.02, Pressure Control Ranges 0 to 3600 psig (0 to 248 bar) and 0 to 3000 psig (0 to 206 bar)
250
3500
3000
200
Outlet Pressure, psig
250
3500
25 248 (3600), 413 (6000)
3000
200
206 (3000), 248 (3600), 413 (6000)
20 2500
150
24.8, 41.3
206 (3000), 248 (3600), 413 (6000) 2000 EURO
15
100
206 (3000),
1500
JPN
248 (3600),
20.6248 (3600), 206 (3000),
24.8, 41.3248 (3600),
68.9 (1000) 413 (6000) 413 (6000)
10 20.6 413 (6000) 1000
70 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Range 0 to 1000 psig (0 to 68.9 bar)
1000
60
Outlet Pressure, psig
400
1000 (68.9)
20
3600 (248), 6000 (413)
200
60
1000
3600 (248), 6000 (413)
Outlet Pressure, psig
0 10 20 30 40 50
1200
80
8.0
1000
60
248 (3600), 413 (6000)
800
6.0
24.8, 41.3
68.9 (1000)
40
600
EURO
6.89
4.0
JPN
400
68.9 (1000) 248 (3600),
20 413 (6000)
Pressure-Reducing Regulator Flow Curves 71
Flow Coefficient 0.06, Pressure Control Range 0 to 1500 psig (0 to 103 bar)
100
1400
3600 (248),
1200 6000 (413)
80
Outlet Pressure, psig
400
0
3600 (248), 6000 (413) 0
0 20 40 60 80 100 120 140 160
0 10 20 30 40
1600
100
10 1400
Flow Coefficient 0.06, Pressure Control Ranges 0 to 3600 psig (0 to 248 bar), 0 to 3000 psig (0 to 206 bar),
and 0 to 2000 psig (0 to 137 bar)
3600 (248),
3000 6000 (413) 200
Outlet Pressure, psig
150
2000 3000 (206) 3600 (248), USA
6000 (413)
1500
3600 (248), 100
6000 (413) 3000 (206) 3600 (248),
1000 6000 (413)
50
500 1000 (68.9) 3000 (206), 3600 (248), , 6000 (413)
500 (34.4), 1000 (68.9)
0
3000 (206), 3600 (248), , 6000 (413) 0
0 20 40 60 80 100 120 140 160
R, W
Nitrogen Flow, std ft3/min
0 10 20 30 40 50
4000
250
3500
25
248 (3600), 413 (6000)
3000
200
20
248 (3600), 413 (6000) 2500
150
15 24.8
248 (3600), , 41.3
413 (6000)
2000
EURO
20.6 JPN
24.8, 41.3 1500
100
10 248 (3600), 413 (6000)
Pressure-Reducing Regulator Flow Curves 73
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 1.0, Pressure Control Range 0 to 1000 psig (0 to 68.9 bar)
1000
60
Outlet Pressure, psig
1000 (68.9)
400
3600 (248), 6000 (413) 20
200 1000 (68.9)
500 (34.4)
0 0
0 100 200 300 400 500
1000
Outlet Pressure, bar
800
1000 (68.9)
60
600 800
40
USA
0 10 20 30 40 50
1200
80
8.0
1000
74 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 1.0, Pressure Control Range 0 to 2000 psig (0 to 137 bar)
150
2000
125
Outlet Pressure, psig
50
3600 (248), 6000 (413)
500
1000 (68.9) 25
3600 (248), 6000 (413)
500 (34.4) 1000 (68.9) 0
0
0 100 200 300 400 500 600
Nitrogen Flow, std ft3/min
2000 2500
125
150 3600 (248), 6000 (413)
Outlet Pressure, psig
0 10 20 30 40 50
2500
150
15.0
2000
125
12.5 248 (3600), 413 (6000)
1500
100
10.0
75 JPN
EURO
7.5 24.8, 41.3 1000
68.9 (1000)
50
248 (3600), 413 (6000)
Pressure-Reducing Regulator Flow Curves 75
Flow Coefficient 1.0, Pressure Control Ranges 0 to 4000 psig (0 to 275 bar), and 0 to 3000 psig (0 to 206 bar)
250
3500
3000
200
Outlet Pressure, psig
2000
150
USA
3000 (206), 6000 (413)
1500
100
3600 (248), 6000 (413) 3600 (248),
6000 (413)
1000
50
500
3600 (248), 6000 (413)
1000 (68.9)
0 0
0 100 200 300 400 500 600
0 10 20 30 40 50
4000
250
25 3500
248 (3600), 413 (6000)
3000
200
20
206 (3000), 413 (6000)
2500
150
15
2000
EURO
JPN
248 (3600), 413 (6000)
20.6, 41.3
100 1500
10
24.8,
24.8, 41.3
76 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.035 std ft3/min (1 std L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Ranges 0 to 750 psig (0 to 51.6 bar) and 0 to 500 psig (0 to 34.4 bar)
50
700
1000 (68.9)
600
40
3600 (248), 6000 (413),
Outlet Pressure, psig
200
500 (34.4) 3600 (248), 6000 (413), 10
1000 (68.9)
100 10 000 (689)
3600 (248), 6000 (413), 10 000 (689)
500 (34.4) 1000 (68.9)
0 0
0 20 40 60 80 100 120 140 160 180
Nitrogen Flow, std ft3/min
700
Outlet Pressure, bar
Flow Coefficient 0.06, Pressure Control Ranges 15 to 2500 psig (1.0 to 172 bar) and
10 to 1500 psig (0.68 to 103 bar)
2500
150
Outlet Pressure, psig
3600 (248),
1500 6000 (413), 100
USA
10 000 (689)
150
1500 100
2000
USA
3600 (248), 6000 (413), 10 000 (689)
248 (3600),
1000 413 (6000),
EURO
100 1500
689
1000 (68.9), 3600 (248), 6000 (413), 10 (10(689)
000 000)
50
500 248 (3600),
1000
500 (34.4) 1000 (68.9), 413
3600(6000),
(248),
50 689000
6000 (413), 10 (10 (689)
000)
0 68.9 (1000) 0
500
248 (3600), 248 (3600),
0 10 (1000)
68.9 20 30 40 50
34.4 (500) 413 (6000), 413 (6000),
Nitrogen Flow,689
std(103
ft 000)
/min 689 (10 000)
0 0
0 2000 4000 6000 8000
0 10 20 30 40 50
3000
200
20
2500
Flow Coefficient 0.06, Pressure Control Ranges 50 to 6000 psig (3.4 to 413 bar) and
25 to 3600 psig (1.7 to 248 bar)
250
3500
3000
200
Outlet Pressure, psig
0 0
0 50 100 150 200 250 300
0 10 20 30 40 50
4000
250
25 3500
248 (3600), 413 (6000), 689 (10 000)
3000
200
20
2500
150
15
24.8(10
248 (3600), 413 (6000), 689 , 000)
41.3, 2000
EURO
JPN
68.9
100 1500
Pressure-Reducing Regulator Flow Curves 79
Flow Coefficient 0.06, Pressure Control Range 100 to 10 000 psig (6.8 to 689 bar)
250
3500
3000
200
Outlet Pressure, psig
3600 (248),
1000
50
500
0 0
0 50 100 150 200 250 300
0 10 20 30 40 50
4000
250
25 3500
150
15
248 (3600), 413 (6000), 689 (10 000)
24.8, 41.3, 68.9
2000
EURO
JPN
100 1500
10 24.8, 41.3, 68.9
80 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.25, Pressure Control Ranges 0 to 750 psig (0 to 51.6 bar) and 0 to 500 psig (0 to 34.4 bar)
50
700
600
50
40
700
Outlet Pressure, psig
0 10 20 30 40 50
800
50
5.0
700
248 (3600), 413 (6000), 689 (10 000)
6.89 600
40
4.0
24.8, 41.3, 68.9
248 (3600), 413 (6000), 689 (10 000) 500
30
3.0
400
JPN
EURO
6.89 24.8, 41.3, 68.9 68.9 (1000) 300
20
2.0
3.44 68.9 (1000), 248 (3600), 413 (6000), 689 (10 000)
Pressure-Reducing Regulator Flow Curves 81
Flow Coefficient 0.25, Pressure Control Ranges 15 to 2500 psig (1.0 to 172 bar) and
10 to 1500 psig (0.68 to 103 bar)
2500
3600 (248),
6000 (413), 150
Outlet Pressure, psig
10 000 (689)
1500
3600 (248), 100 USA
6000 (413),
10 000 (689)
1000
3600 (248), 50
6000 (413),
500
10 000 (689)
500 (34.4) 1000 (68.9) 1000 (68.9)
3600 (248), 6000 (413), 10 000 (689)
0 0
0 50 100 150 200 250 300 350 400
2500
1000
100
248 (3600),
1500 EURO
3600 (248), 6000 (413), 413
10 000 (689) 50
(6000),
6891000
(10 000)
(68.9) 1000
500
1000 (68.9), 3600 (248),
50 500 (34.4)248 (3600),
6000 (413), 10 000 (689)
413 (6000), 500
0 0
689 (10 000)
0 20
10 34.4 (500) 35 40
68.9 (1000) 68.9 (1000) 50 60 70 80 90 100
248 (3600), 413 (6000), 689 (10 000)
0 Nitrogen Flow, std ft3/min 0
0 2000 4000 6000 8000 10000
0 10 20 30 40 50 60 70 80 90 100
20 3000
200
2500
248 (3600), 413 (6000), 689 (10 000)
15
150
24.8, 41.3, 68.9 2000
10
100 1500 JPN
EURO
248 (3600), 413 (6000), 689 (10 000)
82 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.25, Pressure Control Ranges 50 to 6000 psig (3.4 to 413 bar) and
25 to 3600 psig (1.7 to 248 bar)
250
3500
3000
200
Outlet Pressure, psig
2000
150
USA
3600 (248), 6000 (413), 10 000 (689)
1500
100
1000
3600 (248), 6000 (413), 10 000 (689) 50
500
0 0
0 100 200 300 400 500 600
0 10 20 30 40 50
4000
250
25 3500
248 (3600), 413 (6000), 689 (10 000)
3000
200
20
24.8, 41.3, 68.9 2500
150
15 248 (3600), 413 (6000), 689 (10 000)
2000
EURO
JPN
24.8, 41.3, 68.9
100 1500
10
Pressure-Reducing Regulator Flow Curves 83
Flow Coefficient 0.25, Pressure Control Range 10 to 10 000 psig (0.68 to 689 bar)
3500 250
3000
200
Outlet Pressure, psig
150
2000 3600 (248),
6000 (413),
USA
1500 10 000 (689)
100
3600 (248), 6000 (413), 10 000 (689)
1000
50
500
0 0
0 100 200 300 400 500
250
3600 (248), 6000 (413), 10 000 (689)
3000
3500
200
Outlet Pressure, psig
0 10 20 30 40 50
4000
250
25 3500
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
2.5
35
30 2.0
Outlet Pressure, psig
15 1.0
500 (34.4), 1000 (68.9)
10
100 (6.8)
0.5
5.0
0 0
0 0.2 0.4 0.6 0.8 1.0
2,5
35
30
2,0
25
1,5 EURO
20
1,0 15
34.4 (500), 68.9 (1000)
6.8 (100) 10
0,5
5,0
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5
0.25
0.20
0.15
Pressure-Reducing Regulator Flow Curves 85
Flow Coefficient 0.06, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 US
4.0
500 (34.4)
40
100 (6.8) 1000 (68.9) 2.0
20
500 (34.4)
100 (6.8) 500 (34.4) 1000 (68.9)
1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
100
100
6.0
Outlet Pressure, psig
6,0
60
EUR
US
4.0
60
4,0
34.4 (500)
40
40
100 (6.8) 500 (34.4), 1000 (68.9) 2.0
2,0 6.8 (100) 68.9 (1000)
20
20
34.4 (500)
100 (6.8)
6.8 (100) 500 (34.4), 68.9
1000(1000)
(68.9)
0 34.4 (500) 68.9 (1000) 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
100
0.6
6,0
80
34.4 (500), 68.9 (1000)
EUR
JPN
0.4 60
4,0
3.44
40
0.2 0.68 6.89
2,0 6.8 (100) 34.4 (500), 68.9 (1000)
3.44 20
86 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
200
10
500 (34.4)
100
1000 (68.9)
500 (34.4) 1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
500
500
1000 (68.9)
30
Outlet Pressure, psig
30
500
68.9 (1000)
3.0
30
400
6.89
34.4 (500) EURO
JPN
2.0 300
20 3.44
68.9 (1000)
200
1.0
10 34.4 (500)
3.44
100
Pressure-Reducing Regulator Flow Curves 87
25
1.5
Outlet Pressure, psig
500 (34.4),
15 1000 (68.9)
US
1.0
100 (6.8)
10
0.5
5.0
0 0
0 0.2 0.4 0.6 0.8 1.0
25
1,5
20
0,5
5,0
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5
0.20
0.15
3.44, 6.89
0.10
0.68
JPN
0.05
88 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 USA
4.0
100 (6.8)
40 500 (34.4),
1000 (68.9)
2.0
20 500 (34.4), 500 (34.4),
1000 (68.9) 100 (6.8)
1000 (68.9)
100 (6.8)
0 0
0 0.5 1.0 1.5 2.0 2.5
100
100
6.0
Outlet Pressure, psig
6,0
60
EURO
USA
4.0
60
4,0
100 (6.8), 500 (34.4),
1000 (68.9)
40 6.8 (100) 34.4 (500), 40
68.9 (1000) 2.0
2,0
20
34.4 (500), 20
68.9 (1000)
34.4 (500), 100 (6.8), 500 (34.4),
6.8 (100)
100 (6.8), 500 (34.4), 100068.9 (1000)
(68.9) 1000 (68.9)
6.8 (100)
0 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
100
0.6
6,0
80
EURO
JPN
0.4 60
4,0
6.8 (100), 34.4 (500),
0.68 68.9 (1000)
3.44, 6.89 40
0.2
2,0
20
Pressure-Reducing Regulator Flow Curves 89
Flow Coefficient 0.20, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 US
20
200
10
100
500 (34.4)
500 (34.4), 1000 (68.9) 500 (34.4) 1000 (68.9) 1000 (68.9)
0 0
0 2.0 4.0 6.0 8.0 10
500
500
30
Outlet Pressure, psig
30
300
EUR
US
20
300
20
200
200
30
3.0 400
34.4 (500), 68.9 (1000)
20
300 EU
2.0
JPN
200
25
1.5
Outlet Pressure, psig
15 USA
100 (6.8) 1.0
10
500 (34.4), 1000 (68.9) 0.5
5.0
0 0
0 0.2 0.4 0.6 0.8 1.0
25
1,5
20
EURO
15
1,0
6.8 (100)
10
34.4 (500), 68.9 (1000)
0,5
5,0
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5
0.20
0.15
3.44, 6.89
0.05
Pressure-Reducing Regulator Flow Curves 91
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 US
4.0
40
100 (6.8)
500 (34.4)
2.0
20 100 (6.8), 500 (34.4)
1000 (68.9)
1000 (68.9)
100 (6.8), 500 (34.4), 1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
100
100
6.0
Outlet Pressure, psig
6,0
60
EUR
US
100 (6.8), 500 (34.4), 1000 (68.9) 4.0
60
4,0
40
40
6.8 (100)
2,0
34.4 (68.9)
100 (6.8), 500 (34.4), 1000 (500) 2.0
20
6.8 (100), 34.4 (500) 20
68.9 (1000)
100 (6.8), 500 (34.4), 1000 (68.9) 68.9 (1000)
0 6.8 (100), 34.4 (500), 68.9 (1000) 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
100
0.6
6,0
80
EUR
JPN
0.4 60
4,0
6.8 (100), 34.4 (500), 68.9 (1000)
0.68 40
3.44
0.2
2,0
0.68, 3.44
20
92 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 USA
20
200
10
100
500 (34.4), 1000 (68.9) 500 (34.4), 1000 (68.9)
500 (34.4), 1000 (68.9)
0 0
0 2.0 4.0 6.0 8.0 10
500
500
30
Outlet Pressure, psig
30
300
EURO
USA
20
300
20
500 (34.4), 1000 (68.9)
200
200
10
10
100
500 (34.4), 1000 (68.9) 100
34.4 (500), 68.9 (1000) 34.4 (500), 68.9 (1000)
500 (34.4), 1000 (68.9)
0 34.4 (500), 68.9 (1000) 0
0 0.5 1.0 2.0 0
0 1.5
0 5,0 10 15 20 25 30 35
Hydraulic Oil Flow, U.S. gal/min
30
3.0 400
20
300 EURO
2.0
34.4 (500), 68.9 (1000) JPN
200
10
1.0
100
34.4 (500), 68.9 (1000)
Pressure-Reducing Regulator Flow Curves 93
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
25
1.5
Outlet Pressure, psig
15 US
1.0
750 (51.6)
10
0.5
5.0
0 0
0 0.2 0.4 0.6 0.8 1.0
100
EUR
15
1,0
6.0
Outlet Pressure, psig
80 51.6 (750) 10
0,5
60 US
4.0
5,0
40
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 7503,5
(51.6) 2.0
20
750 (51.6)
750 (51.6)
0 0
0 0.5 1.0 1.5 2.0
Flow Coefficient 0.06, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300
USA
20
750 (51.6)
200
10
100 750 (51.6)
750 (51.6)
0 0
0.5 1.0 1.5
500
30
400
20
300 EURO
51.6 (750)
200
10
51.6 (750) 100
51.6 (750)
0 0
0 1,0 2,0 3,0 4,0 5,0
4.0
3.0
2.0
5.16
JPN
1.0
5.16
Pressure-Reducing Regulator Flow Curves 95
2.5
30 2.0
Outlet Pressure, psig
1.0
750 (51.6)
10
0.5
0 0
0 0.2 0.4 0.6 0.8 1.0
2,5
30
2,0
1,5 EUR
20
1,0
51.6 (750)
10
0,5
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5
0.25
0.20
0.15
0.10
JPN
5.16
0.05
96 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.20, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 USA
4.0
750 (51.6)
40
2.0
750 (51.6)
20
750 (51.6)
0 0
0 0.5 1.0 1.5 2.0 2.5
100
100
6.0
Outlet Pressure, psig
6,0
60
EURO
USA
4.0
60
4,0
40 51.6 (750)
40
750 (51.6) 2.0
2,0
51.6 (750)
20
20
100
0.6
6,0
80
51.6 (750)
EURO
JPN
0.4 60
4,0
5.16
40
0.2 51.6 (750)
2,0 5.16
Pressure-Reducing Regulator Flow Curves 97
Flow Coefficient 0.20, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 US
20
200
750 (51.6) 10
100
500
500
30
30
Outlet Pressure, psig
400
20
300
300 EU
US
20
200
200
10 750
51.6(51.6)
(750)
10
100
100
4.0
0 0,2 0,4 0,6 0,8 1,0
600
40
3.0 500
30
400
51.6 (750)
2.0
EUR
300
20
JPN
1.0
5.16 200
51.6 (750)
10
5.16 5.16 100
98 Pressure-Reducing Regulator Flow Curves
25
1.5
Outlet Pressure, psig
15 USA
1.0
750 (51.6)
10
0.5
5.0
0 0
0 0.2 0.4 0.6 0.8 1.0
25
1,5
20
EURO
15
1,0
51.6 (750)
10
0,5
5,0
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5
0.20
0.15
0.10
5.16 JPN
0.05
Pressure-Reducing Regulator Flow Curves 99
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
60 US
4.0
750 (51.6)
40
0 0
0 0.5 1.0 1.5 2.0 2.5
100
100
6.0
Outlet Pressure, psig
6,0
60
EUR
US
4.0
60
4,0
51.6 (750)
40
40
750 (51.6)
51.6 (750) 2.0
2,0
20
20
51.6 (750) 750 (51.6)
0 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
100
0.6
6,0
80
51.6 (750)
EUR
JPN
0.4 60
4,0
5.16
40
5.16 51.6 (750)
0.2
2,0
20
100 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 500 psig (0 to 34.4 bar) and 0 to 250 psig (0 to 17.2 bar)
500
30
Outlet Pressure, psig
300 USA
20
200
10
100
750 (51.6)
750 (51.6) 750 (51.6)
0 0
0 1.0 2.0 3.0 4.0 5.0
500
500
30
30
Outlet Pressure, psig
300
EURO
USA
20
300
20
200
200
750 (51.6)
10
10
100
100
51.6
750(750)
(51.6)
0 51.6 (750) 51.6 (750) 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 3,0 6,0 9,0 12 15 18
Hydraulic Oil Flow, U.S. gal/min
500
3.0
30
400
51.6 (750)
EURO
JPN
2.0 300
20
200
1.0 51.6 (750)
10
100
Pressure-Reducing Regulator Flow Curves 101
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
0.75
10
Outlet Pressure, psig
5.0
100 (6.8)
0.25
0 0
0 0.2 0.4 0.6 0.8 1.0
50
EUR
0,50
3.0
Outlet Pressure, psig
40
Outlet Pressure, bar
5,0
6.8 (100)
0,25
30
100 (6.8) 500 (34.4), 1000 (68.9) US
2.0
34.4 (500), 68.9 (1000)
20
0 0
0 0,5 1,0 1,5 2,0 2,5 3,0 3,5 1.0
10 500 (34.4), 1000 (68.9)
100 (6.8)
0 0
0.5 1.0 1.5
50
0.050
JPN
102 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
80
Outlet Pressure, psig
60
USA
4.0
40
500 (34.4) 1000 (68.9) 2.0
20
500 (34.4) 1000 (68.9)
0 0
0.5 1.0 1.5
250
4,0
60 EURO
15
40
Outlet Pressure, psig
200
0 0
100
0 1,0 2,0 3,0 4,0 5,0
5.0
500 (34.4) 1000 (68.9)
50
0.8
Hydraulic Oil Flow, U.S. gal/min
3.44 (500)
34.4 68.9 (1000)
0.2 6.89
10 150 EURO
3.44 6.89
Pressure-Reducing Regulator Flow Curves 103
Flow Coefficient 0.20, Pressure Control Ranges 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
50
3.0
Outlet Pressure, psig
30
US
2.0
100 (6.8)
20
1.0
10
100 (6.8), 500 (34.4), 1000 (68.9)
0 0
0.5 1.0 1.5
100
2,0
30 EUR
6.8 (100)
6.0
Outlet Pressure, psig
60
1000 (68.9)
10 USA
4.0
6.8 (100), 34.4 (500), 68.9 (1000)
0
40 500 (34.4), 0
0 1,0 2,0 3,0 4,0 5,0 (68.9)
1000
2.0
100 (6.8)
20
500 (34.4),
100 (6.8) 1000 (68.9)
0 0
0.5 1.0 1.5
Flow Coefficient 0.20, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
500 (34.4),
1000 (68.9) 15
Outlet Pressure, psig
150
USA
10
100
500 (34.4),
1000 (68.9) 5.0
50 100 (6.8)
250
34.4 (500),
15
68.9 (1000)
200
10
150 EURO
100
34.4 (500),
5,0 68.9 (1000)
6.8 (100) 50
2.0
1.5
3.44, 6.89
1.0
JPN
Flow Coefficient 0.50, Pressure Control Ranges 0 to 50 psig (0 to 3.4 bar) and 0 to 25 psig (0 to 1.7 bar)
50
3.0
Outlet Pressure, psig
30 US
2.0
20
1.0
100 (6.8)
10 500 (34.4),
500 (34.4), 1000 (68.9)
100 (6.8)
1000 (68.9)
0 0
0 1.0 2.0 3.0 4.0
30
20 US
2.0
1,0
6.8 (100)
500 (34.4), 34.4
1000(500),
(68.9) 10
20 34.4 (500), 68.9 (1000)
6.8 (100) 68.9 (1000)
1.0
0 100 (6.8) 0
10 0 2,0 4,0 6,0 8,0 10 12 14
0 0
0 0.2 0.4 0.6 0.8 1.0
50
0.2 34.4 (500), 68.9 (1000)
3,0
40
6.8 (100)
JPN
0.1
EUR
0.68 30
2,0
3.44, 6.89
0.68 3.44, 6.89
34.4 (500), 68.9 (1000)
20
106 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Range 0 to 100 psig (0 to 6.8 bar)
100
6.0
Outlet Pressure, psig
80
40
2.0
500 (34.4)
20
100 (6.8) 1000 (68.9)
500 (34.4), 1000 (68.9)
100 (6.8) 500 (34.4) 1000 (68.9)
0 0
0 1.0 2.0 3.0 4.0 5.0 6.0
60
40
USA
4.0
2,0
34.4500 (34.4), 1000 (68.9)
(500) 20
40 6.8 (100) 68.9 (1000)
34.4 (500), 68.9 (1000) 100 (6.8)
6.8 (100) 68.9 (1000) 2.0
0
34.4 (500) 0
20 0 500 (34.4), 1000 (68.9)
4,0 8,0 12 16 20
100 (6.8)
0 0
0 0.2 0.4 0.6 0.8 1.0
0.8
100
34.4 (500), 68.9 (1000)
6,0
0.4
80 JPN
EURO
0.2 60
4,0
3.44
0.68 34.4 (500), 68.9 (1000)
Pressure-Reducing Regulator Flow Curves 107
Flow Coefficient 0.50, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
150 US
10
100
250
250
1000 (68.9) 15
Outlet Pressure, psig
15
100
100
500 (34.4), 1000 (68.9)
68.9 (1000) 5.0
5,0
50
500 (34.4), 1000 (68.9) 50
15
68.9 (1000)
1.5 200
34.4 (500)
10
150 EUR
1.0
JPN
100
34.4 (500), 68.9 (1000)
5,0
0.5
50
34.4 (500), 68.9 (1000)
108 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
25
1.5
Outlet Pressure, psig
15 USA
100 (6.8) 1.0
500 (34.4)
10 1000 (68.9)
0.5
5.0
0 0
0 0.5 1.0 1.5 2.0
100
1,0
15 EURO
6.8 (100)
34.4 (500) 6.0
Outlet Pressure, psig
68.9 (1000)
Outlet Pressure, bar
80 10
0,5
500 (34.4)
60 5,0 USA
1000 (68.9) 4.0
0
40 0
0 1,0 2,0 3,0 4,0 5,0 6,0 7,0
100 (6.8) 2.0
500 (34.4), 1000 (68.9)
20
100 (6.8) 1000 (68.9)
500 (34.4)
0 0
0.20 0.5 1.0 1.5
0.15
0 0,5 1,0 1,5
120
8,0
Flow Coefficient 0.06, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
150
US
1000 (68.9) 10
100
5.0
1000 (68.9)
50 500 (34.4)
0 0
0.5 1.0 1.5
30
Outlet Pressure, psig
100
0 0
200
0 1,0 2,0 3,0 4,0 5,0
500 (34.4) 10
1000 (68.9)
100
3.44
500
6.89
1.0
30 JPN
400
68.9 (1000)
0.5
20
6.89 300 EUR
3.44
110 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Range 0 to 1000 psig (0 to 68.8 bar)
500
30
Outlet Pressure, psig
300
USA
20
0 0
0.5 1.0 1.5
500
30
400
20
300 EURO
10
100
0 0
0 1,0 2,0 3,0 4,0 5,0
4.0
3.0
2.0
JPN
6.89
1.0
Pressure-Reducing Regulator Flow Curves 111
25
1.5
Outlet Pressure, psig
15 US
100 (6.8) 1.0
500 (34.4)
10 1000 (68.9)
0.5
5.0
0 0
0 0.5 1.0 1.5 2.0
50
1,0
15 EUR
6.8 (100)
34.4 (500) 3.0
Outlet Pressure, psig
30 500 (34.4)
5,0 US
2.0
1000 (68.9)
0
20 0
0 1,0 2,0 3,0 4,0 5,0 6,0 7,0
1.0
10 100 (6.8)
500 (34.4) 1000 (68.9)
0 0
0.20 0 0.5 1.0 1.5 2.0
0.15
0 0,5 1,0 1,5 2,0
60
4,0
0.10
0.68 50
3.44
3,0 6.89 JPN
40
0.05 6.8 (100)
Flow Coefficient 0.20, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
500 (34.4)
150 1000 (68.9) USA
10
100
5.0
500 (34.4)
50 1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0
0
200 0
0 1,0 2,0 3,0 4,0 5,0 6,0 7,0
500 (34.4) 1000 (68.9) 10
100
1000 (68.9)
500 (34.4)
0 0
2.0 0 0.5 1.0 1.5 2.0
1.5
0 0,5 1,0 1,5 2,0
600
40 3.44
6.89
1.0
500
30 JPN
400
0.5
3.44 68.9 (1000) 6.89
20
300 EURO
Pressure-Reducing Regulator Flow Curves 113
Flow Coefficient 0.20, Pressure Control Range 0 to 1000 psig (0 to 68.8 bar)
500
30
Outlet Pressure, psig
300 US
20
200
10
100
1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5 3.0
500
500
30
30
Outlet Pressure, psig
300
EUR
US
20
300
20
200
200
10
10
100
100
68.9 (1000)
0 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 2,0 4,0 6,0 8,0 10
Hydraulic Oil Flow, U.S. gal/min
500
3.0
30
68.9 (1000) 400
EUR
2.0 300
20
JPN
200
1.0
10
100
114 Pressure-Reducing Regulator Flow Curves
25
1.5
Outlet Pressure, psig
100 (6.8)
15 USA
1.0
0 0
0 0.5 1.0 1.5 2.0 2.5
25
25
1.5
Outlet Pressure, psig
1,5
10
68.9 (1000) 10
34.4 (500)
0.5
0,5
5.0
5,0
0 0
0 0 0.2 0.4 0.6 0.8 1.0 0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
25
0.15
1,5
20
0.68 34.4 (500), 68.9 (1000)
6.8 (100)
EURO
JPN
0.10 15
1,0
3.44 6.89
10
0.05
0,5
5,0
Pressure-Reducing Regulator Flow Curves 115
Flow Coefficient 0.50, Pressure Control Ranges 0 to 100 psig (0 to 6.8 bar) and 0 to 50 psig (0 to 3.4 bar)
100
6.0
Outlet Pressure, psig
80
60 US
4.0
1000 (68.9)
40
100 (6.8)
500 (34.4) 2.0
20
100 100
100
0.6
6,0 34.4 (500), 68.9 (1000)
80
3.44
JPN
EUR
0.4 60
4,0
6.89
40
0.68 34.4 (500), 68.9 (1000)
0.2 6.8 (100)
2,0 3.44
20
116 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Range 0 to 250 psig (0 to 17.2 bar)
250
15
Outlet Pressure, psig
100
5.0
50
1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
500 (34.4) 15
Outlet Pressure, psig
15
100
100
1000 (68.9) 5.0
5,0
50
50
68.9 (1000)
0 0
0 0.2 0.4 0.6 0.8 1.0 0
0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
1.5
15 34.4 (500)
200
100
0.5
5,0 68.9 (1000)
50
Pressure-Reducing Regulator Flow Curves 117
Flow Coefficient 0.50, Pressure Control Range 0 to 500 psig (0 to 34.4 bar)
500
30
Outlet Pressure, psig
1000 (68.9)
300 US
20
200
500 (34.4) 1000 (68.9) 10
100
500
500
1000 (68.9) 30
Outlet Pressure, psig
30
500
3.0
30 68.9 (1000)
400
6.89
EUR
JPN
2.0 300
20
68.9 (1000)
200
34.4
6.89(500)
1.0 3.44
10
100
118 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.50, Pressure Control Ranges 0 to 1500 psig (0 to 103 bar) and 0 to 1000 psig (0 to 68.9 bar)
1000
60
800
Outlet Pressure, psig
20
200 1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
1000
1000
60
60
Outlet Pressure, psig
800
600
EURO
USA
40
600
40
68.9 (1000)
400 1000 (68.9) 400
20
20
200
68.9 (1000) 200
0 0
0 0
0 0.2 0.4 0.6 0.8 1.0
0 1,5 3,0 4,5 6,0 7,5 9,0
1000
6.0
60
800
68.9 (1000)
JPN
EURO
4.0 600
40
6.89
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Range 0 to 1000 psig (0 to 68.9 bar)
1000
60
Outlet Pressure, psig
600
2500 (172) USA
40
1000 (68.9)
400
0 0
0 0.5 1.0 1.5 2.0 2.5
60
0 0
0 0 0.2 0.4 0.6 0.8 1.0 0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
1000
60
6.0 172 (2500)
800
17.2 EUR
120 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 0.06, Pressure Control Range 0 to 1500 psig (0 to 103 bar)
1500
90
Outlet Pressure, psig
900 USA
2500 (172) 60
600
30
300
2500 (172)
1000 (68.9)
0 0
0 0.5 1.0 1.5 2.0 2.5
90
900 USA
EURO
60
900
60 172 (2500)
600
600
30
30
300 1000 (68.9), 2500 (172)
172 (2500) 300
68.9 (1000)
0 0
0 0 0.2 0.4 0.6 0.8 1.0 0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
1500
90
9.0 172 (2500)
1200
EURO
JPN
900
60
6.0 17.2
600
30
3.0
68.9 (1000), 172
17.2
(2500) 300
Pressure-Reducing Regulator Flow Curves 121
Flow Coefficient 0.06, Pressure Control Ranges 0 to 3600 psig (0 to 248 bar), 0 to 3000 psig (0 to 206 bar),
and 0 to 2000 psig (0 to 137 bar)
2500
150
Outlet Pressure, psig
1500 US
100
2500
2500
2500 (172)
150
Outlet Pressure, psig
150
1500 US
EUR
100
1500
100
1000
1000 (68.9), 2500 (172) 1000
172 (2500)
172 (2500) 50
50
500
68.9 (1000) 1000 (68.9), 2500 (172) 500
172 (2500)
68.9 (1000) 500 (34.4)
0 34.4 (500) 172 (2500) 0
0 0 0.2 0.4 0.6 0.8 1.0 0
0 1,5 3,0 4,5 6,0 7,5 9,0
Hydraulic Oil Flow, U.S. gal/min
2500
15
150
172 (2500)
2000
172 (2500)
EUR
JPN
10 1500
100
17.2 1000
68.9 (1000), 172 (2500)
5.0
50 17.2
122 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Range 0 to 1000 psig (0 to 68.9 bar)
1000
60
Outlet Pressure, psig
600 USA
40
400
20
200
1000 (68.9), 2500 (172)
1000
1000
60
60
1000 (68.9), 2500 (172) 800
Outlet Pressure, psig
40
600
600 EURO
USA
40
400
400
500 (34.4), 1000 (68.9), 2500 (172)
20
20
68.9 (1000), 172 (2500) 200
200
1000
6.0
60
68.9 (1000), 172 (2500) 800
Pressure-Reducing Regulator Flow Curves 123
Flow Coefficient 1.0, Pressure Control Range 0 to 2000 psig (0 to 137 bar)
150
2000
Outlet Pressure, psig
50
2500 (172)
500
150 150
2000
2000
Outlet Pressure, psig
50
50 1000 (68.9), 2500 (172)
500 172 (2500) 500
500 (34.4),68.9
1000(1000), 172
(68.9), 2500
(2500)
(172)
0 34.4 (500), 68.9 (1000), 172 (2500) 0
0 0
0 1.0 2.0 3.0 4.0 5.0
0 15 30 45 60 75 90
Hydraulic Oil Flow, U.S. gal/min
150
150
2000
2000
100
172 (2500) 1500
1500
100
JPN
EUR
1000
1000
50
50
68.9 (1000), 172 (2500)
17.2 500
500
124 Pressure-Reducing Regulator Flow Curves
Flow Coefficient 1.0, Pressure Control Range 0 to 3000 psig (0 to 206 bar)
150
2000
Outlet Pressure, psig
50
500
500 (34.4),
1000 (68.9), 2500 (172)
2500 (172) 1000 (68.9). 2500 (172)
0 0
0 5.0 10 15 20 25
15
150 172 (2500)
2000
10 1500
100
JPN
EURO
1000
500
Pressure-Reducing Regulator Flow Curves 125
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Ranges 0 to 750 psig (0 to 51.6 bar), 0 to 500 psig (0 to 34.4 bar),
and 0 to 250 psig (0 to 17.5 bar)
600
40
Outlet Pressure, psig
30
400 US
300 20
20 68.9 (1000) 300
172 (2500)
200
200
500 (34.4), 1000 (68.9), 2500 (172) 10
10
100 34.4 (500) 68.9 (1000) 172 (2500) 100
500 (34.4), 1000 (68.9), 2500 (172)
0
172 (2500) 0
34.4 (500) 68.9 (1000)
0 0 0.2 0.4 0.6 0.8 1.0 0
0 3,0 6,0 9,0 12 15 18
Hydraulic Oil Flow, U.S. gal/min
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Ranges 0 to 2500 psig (0 to 172 bar) and 0 to 1500 psig (0 to 103 bar)
2500
150
Outlet Pressure, psig
1500 USA
100
2500
2500
2500 (172) 150
Outlet Pressure, psig
1500 EURO
USA
100
1500
100 2500 (172)
2500
15
150 172 (2500)
2000
EURO
JPN
10 1500
100
172 (2500)
17.2
1000
Pressure-Reducing Regulator Flow Curves 127
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Ranges 0 to 6000 psig (0 to 413 bar) and 0 to 3600 psig (0 to 248 bar)
2500
150
Outlet Pressure, psig
1500 US
100
1000
2500 (172)
2500 (172) 50
500
2500
2500
2500 (172) 150
Outlet Pressure, psig
1500 EU
US
100
1500
100 2500 (172)
1000
1000
172 (2500)
50
50 172 (2500)
500 1000 (68.9), 2500 (172)
500
68.9 (1000) 172 (2500)
0 0
0 0 0.2 0.4 0.6 0.8 1.0 0
0 3,0 6,0 9,0 12 15 18
Hydraulic Oil Flow, U.S. gal/min
2500
15
150 172 (2500)
2000
EU
JPN
10 1500
100
172 (2500)
17.2 1000
128 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.06, Pressure Control Range 0 to 10 000 psig (0 to 689 bar)
2500
150
Outlet Pressure, psig
1500 USA
100
1000
2500 (172) 50
2500 (172)
500
1000 (68.9)
2500 (172)
0 0
0 1.0 2.0 3.0 4.0 5.0
2500
2500
150
2500 (172)
Outlet Pressure, psig
1500 USA
EURO
100
1500
100
2500 (172)
1000
1000
2500 (172) 50
172 (2500)
50 172 (2500)
500
1000 (68.9) 500
68.9 (1000)
0 172 (2500) 0
0 0 0.2 0.4 0.6 0.8 1.00
0 3,0 6,0 9,0 12 15 18
Hydraulic Oil Flow, U.S. gal/min
2500
15
150
172 (2500)
2000
EURO
JPN
10 1500
100
172 (2500)
1000
17.2
Pressure-Reducing Regulator Flow Curves 129
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.25, Pressure Control Ranges 0 to 750 psig (0 to 51.6 bar), 0 to 500 psig (0 to 34.4 bar),
and 0 to 250 psig (0 to 17.5 bar)
600 40
Outlet Pressure, psig
300 20
1000 (68.9)
2500 (172)
200
10
100 500 (34.4) 1000 (68.9)
2500 (172)
500 (34.4) 1000 (68.9)
0 0
0 2.0 4.0 6.0 8.0 10 12 14
600 40
600
Outlet Pressure, psig
40
300 20
20 300
68.9 (1000)
17.2 500
3.0
30 68.9 (1000), 172 (2500) EUR
400
JPN
2.0 6.89 300
20
130 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.25, Pressure Control Ranges 0 to 2500 psig (0 to 172 bar) and 0 to 1500 psig (0 to 103 bar)
2500
150
Outlet Pressure, psig
1500 USA
100
1000 2500
(172)
1000 (68.9) 50
2500 (172)
500
2500 (172)
500 (34.4) 1000 (68.9) 2500 (172)
0 0
0 2.0 4.0 6.0 8.0 10 12 14
2500
2500
2500 (172) 150
Outlet Pressure, psig
1500 USA
EURO
100
1500
100
2500 (172)
1000
172 1000
1000 (68.9), 2500(2500)
(172) 50
50 68.9 (1000)
500 172 (2500)
500
500 (34.4), 1000 (68.9), 2500 (172)
172 (2500)
0 34.4 (500) 68.9 (1000) 172 (2500) 0
0 0 0.5 1.0 1.5 2.0 0
0 10 20 30 40 50
Hydraulic Oil Flow, U.S. gal/min
20
2500
100
1500 EURO
172 (2500)
10 JPN
1000
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.25, Pressure Control Ranges 0 to 6000 psig (0 to 413 bar) and 0 to 3600 psig (0 to 248 bar)
2500
150
Outlet Pressure, psig
1500 US
100
1000
2500 (172) 50
500
2500 2500
1000 (68.9) (172) (172)
0 0
0 2.0 4.0 6.0 8.0 10 12 14
2500
2500
150
2500 (172)
Outlet Pressure, psig
1500 US
EU
100
1500
100
2500 (172)
1000
1000
172 (2500) 50
50
500
1000 (68.9), 2500 (172) 500
172 172
0 68.9 (1000) (2500) (2500) 0
0 0 0.5 1.0 1.5 2.0 0
0 10 20 30 40 50
Hydraulic Oil Flow, U.S. gal/min
20
2500
100
1500 EU
10 172 (2500) JPN
1000
50
132 Pressure-Reducing Regulator Flow Curves
Flow Curves
The flow curves assume an initial set flow rate of 0.1 U.S. gal/min (3.78 L/min) and an initial temperature of 70°F (20°C).
Flow Coefficient 0.25, Pressure Control Range 0 to 10 000 psig (0 to 689 bar)
2500
150
Outlet Pressure, psig
1500 USA
100
1000
50
2500 (172)
500
2500
2500
150
Outlet Pressure, psig
1500 USA
EURO
100
1500
100
2500 (172)
1000
1000
50
50
500 172 (2500)
1000 (68.9), 2500 (172) 500
20
2500
150
2000
15 172 (2500)
100
1500 EURO
10
172 (2500)
JPN
1000
50
Pressure-Reducing Regulator Flow Curves 133
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.05, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar) and 0 to 362 psig (0 to 25.0 bar)
120
580 (40.0) 7.5
Outlet Pressure, psig
0 0
0 15 30 45 60 75
725 1015
250 (50.0) (70.0) 70,0 (1015) 90
5800
(400) 15
5,0
200 200 (2900),
2900 400 (5800)
(200) 60
150 10
200 (2900),
5800 400 (5800)
2,5
100 40,0 (580)
(400)70,0 (1015) 30
580 5.0
(40.0) 2900
50 1015
(200)
(70.0)
00 00
0 20
30 40
60 60
90 80
120 100
150 180
0
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.05, Pressure Control Ranges 0 to 1450 psig (0 to 100 bar) and 0 to 2537 psig (0 to 175 bar)
1200
2900 (200) 5800 (400)
75
Outlet Pressure, psig
US
50
600
1015 (70.0)
2900 (200)
5800 (400) 25
300
600 40,0
70,0 (1015) 200 (2900) 400 (5800)
(580) 30
0 0
0 75 150 225 300 375 450
0 0
0 60 120 180 240 300
180
20.0 40.0 2400
7.5
150
Pressure-Reducing Regulator Flow Curves 135
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.05, Pressure Control Ranges 0 to 5075 psig (0 to 350 bar) and 0 to 10 150 psig (0 to 700 bar)
180
2400
120
2900 (200) 5800 (400)
1200
60
0 0
0 60 120 180 240 300
RSH2 Series
Pressure Control Range:
0 60 Nitrogen
120 Flow, Nm3180
/h 240 300
0 to 10 150 psig (0 to 700 bar) Nitrogen Flow, Nm3/h 6000
3600
30
136 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS4 Series
Flow Coefficient 1.84, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 101 psig (0 to 7.0 bar),
0 to 203 psig (0 to 14.0 bar), and 0 to 406 psig (0 to 28.0 bar)
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 406 psig (0 to 28.0 bar) 0 100 200 300 400 500 600 700
0 to 203 psig (0 to 14.0 bar) 400
0 to 101 psig (0 to 7.0 bar) Inlet Pressure, psig (bar)
0 to 43 psig (0 to 3.0 bar) 24
1015 (70.0)
300
20
Outlet Pressure, psig
8.0
100 1015 (70.0)
580 (40.0)
218 (15.0)
4.0
1015 (70.0)
1015 (70.0) 218 (15.0) 580 (40.0)
218 (15.0) 580 (40.0)
0 0
0 75 150 225 300 375 450
0 to 1160 psig (0 to 80.0 bar) 0 300 600 900 1200 1500 1800
24
1000
0 to 580 psig (0 to 40.0 bar)
0 to 406 psig (0 to 28.0 bar) 70,0(bar)
(1015)
Inlet Pressure, psig 300
60
20
800 40,0 (580)
50
16
70,0 (1015) EUR
Outlet Pressure, psig
0 0
0 200 400 600 800 1000 1200
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RSH4 Series
Flow Coefficient 1.84, Pressure Control Ranges 0 to 2175 psig (0 to 150 bar), 0 to 4060 psig (0 to 280 bar),
and 0 to 5800 psig (0 to 400 bar)
RSH4 Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 5800 psig (0 to 400 bar) Nitrogen Flow, Nm3/h
0 to 4060 psig (0 to 280 bar)
0 3000 6000 9000 12 000 15 000
0 to 2175 psig (0 to 150 bar) 6000
3000
5800 (400)
180
2000
5800 (400)
120
5800 (400)
1000
2900 (200) 60
0 0
0 2000 4000 6000 8000 10 000
360
5000
300
Outlet Pressure, psig
Outlet Pressure, bar
4000
240
Flow Coefficient: 1.84
Maximum Inlet Pressure: 3000
400 (5800)
RSH4—5800 psig (400 bar) 180
Outlet Pressure Control
Range: 0 to 5800 psig 400 (5800) 2000
(0 to 400 bar) 120
400 (5800)
1000
60
200 (2900)
0 0
0 3000 6000 9000 12 000 15 000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS6 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 101 psig (0 to 7.0 bar),
0 to 203 psig (0 to 14.0 bar), and 0 to 406 psig (0 to 28.0 bar)
300
20
Outlet Pressure, psig
RS(H)6 Series
0 100 200 300 400 500 600 700 800
Flow Coefficient 1.95, Pressure Control Ranges 0 to 406 psig (0 to 28.0 bar), 0 to 580 psig (0 to 40.0 bar),
400
and 0 to 1160 psig (0 to 80.0 bar)
24
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1160 psig (0 to 80.0 bar) 0 300 600 900 1200 1500 1800 300
20
1000
0 to 580 psig (0 to 40.0 bar)
0 to 406 psig (0 to 28.0 bar) 70,0
Inlet Pressure, psig (1015)
(bar)
60
16
70,0 (1015) 40,0 (580)
EUR
800 200
40,0 (580) 50
12
70,0 (1015)
Outlet Pressure, psig
40,0 (580)
600
8,0 40
15,0 (218)
100
USA
4,0 15,0 (218) 70,0 (1015) 1015 (70.0) 30
400 40,0 (580) 15,0 (218) 40,0 (580)
70,0 (1015) 1015 (70.0)
0 1015 (70.0) 20
0
0 200 400 600 580
800(40.0) 1000 1200
200
1015 (70.0)
580 (40.0) 10
0 0
0 200 400 600 800 1000 1200
2.4
0 200 400 600 800 1000 1200
1000
Pressure-Reducing Regulator Flow Curves 139
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RSH6 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 2175 psig (0 to 150 bar), 0 to 4060 psig (0 to 280 bar), and
0 to 5800 psig (0 to 400 bar)
RSH6 Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 5800 psig (0 to 400 bar) Nitrogen Flow, Nm3/h
0 to 4060 psig (0 to 280 bar)
0 3000 6000 9000 12 000 15 000
0 to 2175 psig (0 to 150 bar) 6000
0 0
0 2000 4000 6000 8000 10 000
360
5000
300
4000
240
Flow Coefficient: 1.95
Maximum Inlet Pressure: 400 (5800) 3000
RSH6—5800 psig (400 bar) 180
Outlet Pressure Control 400 (5800)
Range: 0 to 5800 psig 2000
(0 to 400 bar) 120
60
200 (2900) 400 (5800) 1000
0 0
0 3000 6000 9000 12 000 15 000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS8 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 101 psig (0 to 7.0 bar),
0 to 203 psig (0 to 14.0 bar), and 0 to 406 psig (0 to 28.0 bar)
300
20
Outlet Pressure, psig
RS(H)8 Series
Flow Coefficient 1.95, Pressure Control
0 Ranges200
0 to 580 psig400(0 to 40.0 bar)
600 and 0 to 1160
800 psig (0 to1000
80.0 bar)
400
24
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1160 psig (0 to 80.0 bar) 0 400 800 1200 1600 2000 300
20
1000
0 to 580 psig (0 to 40.0 bar)
40,0 (580)
600 40
8,0
15,0 (218) 1015
70,0 (70.0)
(1015)
100 US
4,0 40,0 (580) 40,0 (580) 30
400 70,0 (1015) 1015 (70.0)
15,0 (218)
70,0 (1015) 40,0 (580)
15,0 (218) 1015 (70.0)
0 020
0 300 600 580 (40.0)
900 1200 1500
200
1015 (70.0) 10
580 (40.0)
0 0
0 200 400 600 800 1000 1200 1400
2.4
0 200 400 600 800 1000 1200 1400
1000
Pressure-Reducing Regulator Flow Curves 141
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RSH8 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 2175 psig (0 to 150 bar), 0 to 4060 psig (0 to 280 bar), and
0 to 5800 psig (0 to 400 bar)
RSH8 Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 5800 psig (0 to 400 bar) Nitrogen Flow, Nm3/h
0 to 4060 psig (0 to 280 bar)
0 3000 6000 9000 12 000 15 000
0 to 2175 psig (0 to 150 bar) 6000
1000
2900 (200) 5800 (400) 60
0 0
0 2000 4000 6000 8000 10 000
360
5000
300
4000
240
Flow Coefficient: 2.07
400 (5800)
Maximum Inlet Pressure: 3000
RSH8—5800 psig (400 bar) 180
Outlet Pressure Control 400 (5800)
Range: 0 to 5800 psig 2000
(0 to 400 bar) 120
0 0
0 3000 6000 9000 12 000 15 000
36
142 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS10 Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 145 psig (0 to 10.0 bar),
0 to 290 psig (0 to 20.0 bar), and 0 to 580 psig (0 to 40.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range
0 300 600 900 1200 1500 1800
0 to 580 psig (0 to 40.0 bar) 300
0 to 290 psig (0 to 20.0 bar) 20
Inlet Pressure, psig (bar)
0 to 145 psig (0 to 10.0 bar)
250
0 to 43 psig (0 to 3.0 bar)
1015 (70.0) 15
Outlet Pressure, psig
200
Outlet Pressure, psig
EUR
Outlet Pressure, bar
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 72 psig (0 to 5.0 bar),
and 0 to 145 psig (0 to 10.0 bar)
RS15 Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 72 psig (0 to 5.0 bar)
0 300 600 900 1200 1500
0 to 43 psig (0 to 3.0 bar) 90
6.0
Pressure Control Range Inlet Pressure, psig (bar)
0 to 72 psig (0 to 5.0 bar) 75
5.0
0 to 43 psig (0 to 3.0 bar)
Outlet Pressure, psig
45 3.0
1015 (70.0)
30 2.0
580 (40.0)
218 (15.0)
1015 (70.0)
15 580 (40.0) 1.0
218 (15.0)
0 0
0 200 400 600 800 1000
psig
bar
Pressure,bar
4.0
Outlet Pressure, psig
120
OutletPressure,
8.0
Pressure,
45
3.0
90 6.0
Outlet
218 (15.0)
70.0 (1015)
Outlet
Outlet
2.0 30
40.0 (580)
60 580 (40.0)
15.0, 1015
(218) (70.0) 4.0
70.0 (1015)
1.0 40.0 (580) 15
15.0 (218)
30 2.0
0 0
0 0 300 600 900 1200 1500 0
0 400 800 1200 1600 2000
NitrogenFlow,
Nitrogen Flow,std
Nmft33/h
/min
Nitrogen Flow, std ft3/min
Flow Coefficient: 7.30 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RS15—1015 psig (70.0 bar)
Outlet Pressure Control 0.6 0 400 800 1200 1600 2000
180
Range: 0 to 145 psig 12
(0 to 10.0 bar)
0.5
144 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 290 psig (0 to 20.0 bar) and 0 to 580 psig (0 to 40.0 bar)
RS15 Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 580 psig (0 to 40.0 bar)
0 1500 3000 4500 6000 7500 9000
0 to 290 psig (0 to 20.0 bar) 700
0 0
0 1000 2000 3000 4000 5000 6000
36
500
27 400
EU
70.0 (1015) 300
18
40.0 (580)
200
70.0 (1015)
9.0 40.0 (580) 70.0 (1015)
100
0 0
0 1500 3000 4500 6000 7500 9000
4.5
3.6
Pressure-Reducing Regulator Flow Curves 145
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RSH15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 580 psig (0 to 40.0 bar), 0 to 1450 psig (0 to 100 bar),
0 RSH15 Series
to 2610 (0 to 180 bar), and 0 to 3625 psig (0 to 250 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
400
24
5800 (400)
300
2900 (200)
1450 (100) 16
200
8.0
100
0 0
0 1000 2000 3000 4000 5000 6000 7000
bar psig
psig bar
32
0 to 2610 psig (0 to 180 bar) 3000
Pressure,
200
Pressure,
Outlet Pressure, psig
Pressure,
Pressure,
2500
24 400 (5800)
5800 (400)
150
300
200 (2900)
Outlet
Outlet
2000
16 100 (1450)
Outlet
Outlet
200
1500 2900 (200) 100
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RS20 Series
Flow
RS20Coefficient
Series 13, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 72.0 psig (0 to 5.0 bar),
0 to 145 (0 to 10.0 bar), and 0 to 290 psig (0 to 20.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 72 psig (0 to 5.0 bar) 0 900 1800 2700 3600 4500
75
0 to 43 psig (0 to 3.0 bar) 5
Inlet Pressure, psig (bar)
Pressure Control Range
60
0 to 72 psig (0 to 5.0 bar) 4
Outlet Pressure, psig
15 218 (15.0) 1
0 0
0 600 1200 1800 2400 3000
psig
bar
70.0 (1015)
Pressure,psig
Pressure, bar
Outlet Pressure, psig
Outlet Pressure,
OutletPressure,
3
Flow Coefficient: 13 180 15.0 (218)
12
Maximum Inlet Pressure: EU
RS20—1015 psig (70.0 bar) 1015 (70.0) US
Outlet Pressure Control 2 70.0 (1015)
580 (40.0) 30
Outlet
Outlet
218 (15.0)
0 0
0 0 900 1800 2700 3600 4500 0
0 1300 2600 3900 5200 6500
Nitrogen
NitrogenFlow,
Flow,std
Nm /h ft33/min
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
0.4
240
16
rPa
7.0
ig
Pressure-Reducing Regulator Flow Curves 147
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LRS4 Series
Flow Coefficient 0.73, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 145 psig (0 to 10.0 bar),
and 0 to 290 psig (0 to 20.0 bar)
15
Outlet Pressure, psig
218 (15.0)
362 (25.0)
100 507 (35.0)
362 (25.0) 5.0
130 (9.0)
50 362 (25.0)
507 (35.0)
507 (35.0)
130 (9.0) 507 (35.0)
0 0
0 50 100 150 200 250 300
250
15
200
15,0 (218)
35,0 (507) E
150
10
15,0 (218)
25,0 (362)
35,0 (507) 100
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.73, Pressure Control Range 0 to 290 psig (0 to 20.0 bar)
25
362 (25.0)
1.5
Outlet Pressure, psig
10 362 (25.0)
43 (3.0) 0.5
43 (3.0) 130 (9.0)
5.0 362 (25.0)
130 (9.0)
0 0
0 15 30 45 60 75 90
20
25,0 (362) 10
0,5
15 43 3,0
3,043(43)
(3.0)(43)
(3.0)
9,0 (130) 362 (25.0)
US
1.0
25,0 (362)
130 (9.0) 5,0
9,0 (130)
130 (9.0)
362 (25.0)
10
0 0
0 20 43 (3.0)
40 60 80 100 120 140 0.5
5.0 362 (25.0)
362 (25.0)
43 (3.0) 130 (9.0)
130 (9.0)
0 0
0 15 30 45 60 75 90
0.20
0 15 30 45 60 75 2.590
Pressure-Reducing Regulator Flow Curves 149
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LRSH4 Series
Flow Coefficient 0.73, Pressure Control Ranges 0 to 130 psig (0 to 9.0 bar) and 0 to 290 psig (0 to 20.0 bar)
200
2900 (200)
1450 (100)
12
Outlet Pressure, psig
200
200 (2900)
100 (1450)
12
150
100 (1450) E
8,0 200 (2900)
100
1.6
20.0
10.0
1.2
150 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LPRS4 Series
Flow Coefficient 1.84, Pressure Control Ranges 1.4 to 14.5 psig (0.10 to 1.0 bar) and
4.3 to 43Series
LPRS4 psig (0.30 to 3.0 bar)
1.8 US
20
43 (3.0), 101 (7.0), 218 (15.0) 1.2
10
0.6
0 0
0 30 60 90 120 150
0 30 60 90 120 150
50
40
Outlet Pressure, psig
2.4
Outlet Pressure, bar
30
Flow Coefficient: 1.84
Maximum Inlet Pressure:
1.8
EU
LPRS4—218 psig (15.0 bar)
Outlet Pressure Control 20
Range: 1.4 to 43 psig 1.2 3.0 (43), 7.0 (101), 15.0 (218)
(0.10 to 3.0 bar)
10
0.6
0 0
0 40 80 120 160 200
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LPRS6 Series
Flow Coefficient 1.95, Pressure Control Ranges 1.4 to 14.5 psig (0.10 to 1.0 bar) and
LPRS6
4.3 to 43Series
psig (0.30 to 3.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
4.3 to 43 psig (0.30 to 3.0 bar) 0 70 140 210 280 350 420
1.4 to 14.5 psig (0.10 to 1.0 bar) 50
40
4.3 to 43 psig (0.3 to 3.0 bar)
101 (7.0) 218 (15.0)
Outlet Pressure, psig
1.8
20
1.2
218 (15.0)
101 (7.0)
10 43 (3.0)
0.6
0 0
0 50 100 150 200 250 300
Flow Coefficient 2.07, Pressure Control Ranges 1.4 to 14.5 psig (0.10 to 1.0 bar) and
LPRS8
4.3 to 43Series
psig (0.30 to 3.0 bar)
0 50 100 150 200 250 300
50
psig
2.4
Pressure, bar
Outlet Pressure,
30
Flow Coefficient: 1.95 40
1.8
Maximum Inlet
4.3 to 43 Pressure:
psig (0.3 to 3.0 bar)
Outletpsig
1.4Pressure
to 14.5 psig (0.1 to 1.0 bar) 218 (15.0) 20
Outlet Control
Outlet Pressure,
Outlet Pressure,
1.2
30
Range: 1.4 to 43 psig
(0.10 to 3.0 bar) 15.0 (218) 1.8
7.0 (101)
3.0 (43) 10
0.6
20
1.2
0 0
10 0 70 43 (3.0) 140 101
210(7.0) 280 350(15.0) 420
218 0.6
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LPRS10 Series
Flow Coefficient 3.79, Pressure Control Ranges 1.4 to 14.0 psig (0.10 to 1.0 bar) and
4.3 to 43 psig (0.30 to 3.0 bar)
3,0
40
2,5
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LPRS15 Series
Flow Coefficient 7.3, Pressure Control Ranges 1.4 to 14.0 psig (0.10 to 1.0 bar) and
4.3 to 43 psig (0.30 to 3.0 bar)
218 (15.0)
1.5
20 101 (7.0)
43 (3.0)
218 (15.0) 1.0
43 (3.0) 101 (7.0)
10 218 (15.0)
101 (7.0) 0.5
43 (3.0)
218 (15.0)
43 (3.0) 101 (7.0)
0 0.0
0 100 200 300 400 500 600 700
3,0
40
2,5
15,0 (218)
30
2,0 7,0 (101)
15,0 (218)
1,5
7,0 (101) 20
3,0 (43)
1,0 15,0 (218)
3,0 (43) 7,0 (101)
15,0 (218) 10
0,5 7,0 (101)
3,0 (43)
15,0 (218)
3,0 (43) 7,0 (101)
0 0
0 200 400 600 800 1000
0.30
154 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.05, Pressure Control Range 0 to 5800 psig (0 to 400 bar)
150 10
200 (2900)
Outlet Pressure, bar
2000 250
15 EURO
200
1500
400 (5800) USA
100
10 150
2900 (200)
1000 5800 (400)
40,0 (580) 70,0 (1015) 100
200 (2900) 50
5,0
400 (5800)
500 50
1015 (70.0)70,0 (1015) 2900 (200)
40,0 (580)
200 (2900), 400 (5800) 5800 (400)
0 580 (40.0) 2900 (200) 5800 (400) 0
1015
50 (70.0) 100
0 0 150 200 250 300 0
0 50 100 150 200 250 300
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.05, Pressure Control Range 0 to 5800 psig (0 to 400 bar)
300
Outlet Pressure, psig
5800 (400)
3000
200
2000
2900 (200) 5800 (400)
100
1000
0 0
0 50 100 150 200 250 300
Nitrogen Flow, std ft3/min
5000
300
4000
400 (5800)
3000
200
2000
200 (2900) 400 (5800)
100
1000
0 0
0 75 150 225 300 375 450
40
156 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH6 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar) and 0 to 362 (0 to 25.0 bar)
15
Outlet Pressure, psig
150 USA
10
580 (40.0) 1015 (70.0)
218 (15.0)
580 (40.0) 2175 (150)
100 1015 (70.0)
2175 (150)
218 (15.0) 5.0
580 (40.0), 1015 (70.0)
50
218 (15.0) 2175 (150)
218 (15.0), 580 (40.0)
0
1015 (70.0), 2175 (150) 0
0 180 360 540 720 900
250
15
200
EUR
150
10
40,0 (580) 70,0 (1015)
15,0 (218)
40,0 (580) 150 (2175)
70,0 (1015) 100
150 (2175)
5,0 15,0 (218)
40,0 (580), 70,0 (1015) 50
15,0 (218) 150 (2175)
15,0 (218), 40,0 (580)
70,0 (1015), 150 (2175)
0 0
0 200 400 600 800 1000 1200 1400
Pressure-Reducing Regulator Flow Curves 157
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH6 Series
Flow Coefficient 1.95, Pressure Control Ranges 0 to 362 psig (0 to 25.0 bar), 0 to 1450 (0 to 100 bar), and
0 to 2539 psig (0 to 175 bar)
960
60
Outlet Pressure, psig
2175 (150) 40
480
1015 (70.0) 2175 (150)
580 (40.0) 2175 (150)
20
240 1015 (70.0)
RDH6 Series
Nitrogen Flow, Nm3/h
Pressure Control Range 0 400 Nitrogen
800 3/h
Flow, Nm1200 1600 2000
1200
0 to 2539 psig (0 to 175 bar) 80 0 1500 3000 4500 6000 7500
3000
720
Outlet Pressure, bar
2000
3990 (275) E
40 120
150 (2175)
1500
480
70,0 (1015) 150 (2175) 90
1000
40,0 (580) 150 (2175)
20
70,0 (1015) 60
240
180
2500
158 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD8 Series
Flow
RD8 Coefficient
Series 2.07, Pressure Control Range 0 to 1015 psig (0 to 70.0 bar)
600 US
2900 (200) 39
400
26
200 13
0 0
0 500 1000 1500 2000 2500 3000
1000
65
800
52 100 (1450)
Flow Coefficient: 2.07
Maximum Inlet Pressure:
39 200 (2900)
600 EU
RD8—2900 psig (200 bar)
Outlet Pressure Control
Range: 0 to 1015 psig 26 400
(0 to 70.0 bar)
13 200
0 0
0 750 1500 2250 3000 3750 4500
7.8
6.5
Pressure-Reducing Regulator Flow Curves 159
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH8 Series
RDH8Coefficient
Flow Series 2.07, Pressure Control Ranges 0 to 362 psig (0 to 25.0 bar) and 0 to 2537 psig (0 to 175 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 362 psig (0 to 25.0 bar) 0 300 600 900 1200 1500 1800
500
580 (40.0) 15
200
1015 (70.0), 2175 (150)
10
100
5
218 (15.0) 580 (40.0) 2175 (150)
1015 (70.0)
0 0
0 200 400 600 800 1000 1200
barpsig
psigbar
Pressure,
300
Outlet Pressure, psig
Pressure,
2900 (200)
Pressure,
(0 to 25.0 bar) 10
1000
2175 (150) 100
60
5 3990 (275)
500 15.0 (218) 40.0 (580) 150 (2175)
30
70.0 (1015)
0 0
0 300 600 900 1200 1500 1800
0 0
0 1000 2000 3000 4000 5000 6000
Nitrogen Flow, Nm3/h
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
180
2.5 2500
a
160 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD6DP Series
RDN6
Flow Series 1.95, Pressure Control Range 0 to 1015 psig (0 to 70.0 bar)
Coefficient
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1015 psig (0 to 70.0 bar) 0 450 900 1350 1800 2250
All curves 29 psig (2.0 bar) bias 750
50
150
580 (40.0)
10
1015 (70.0)
580 (40.0), 1015 (70.0)
0 0
0 300 600 900 1200 1500
320
600
0 to 1015 psig (0 to 70.0 bar) 40
Outlet Pressure, psig
psigbar
20
All Curves 116 psig (8 bar) Bias
Outlet Pressure, psig
Pressure,
240
Pressure,
450
30 70.0 (1015) 15
Flow Coefficient: 1.95
US
Maximum Inlet Pressure: EU
Outlet
20 10
1015 (70.0)
Range: 0 to 1015 psig
(0 to 70.0 bar) 580 (40.0)
All Curves 29 psig (2 bar) Bias 80 40.0 (580)
10 5
150
70.0 (1015)
40.0 (580), 70.0 (1015)
0 0
0 0
0 200 400 600 800 1000 1200
0 450 900 1350 1800 2250
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft33/min
Nitrogen Flow, Nm /h
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH6DP Series
RDHN6
Flow Series 1.95, Pressure Control Range 0 to 3335 psig (0 to 230 bar)
Coefficient
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 3335 psig (0 to 230 bar) 0 1500 3000 4500 6000 7500
All curves 29 psig (2.0 bar) bias 1800
120
900 60
2175 (150)
600 40
300 20
2175 (150)
580 (40.0)
1015 (70.0)
0 0
0 1000 2000 3000 4000 5000
bar
Pressure,psig
275 (3990)
Pressure,bar
Outlet Pressure, psig
OutletPressure,
Flow Coefficient: 1.95
Maximum Inlet Pressure: 900
60 900
60
RDHN6—3990 psig (275 bar) 150 (2175)
2175 (150)
Outlet
1500
10.0
100
275 (3990)
, psig
, ,MPa
27.5
bar
8.0 1200
80
162 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD10 Series
RD10Coefficient
Flow Series 3.79, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar) and 0 to 130 psig (0 to 9.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 43 psig (0 to 3.0 bar) 0 120 240 360 480 600
50
40
0 to 43 psig (0 to 3.0 bar)
Outlet Pressure, psig
10
0.6
0 0
0 80 160 240 320 400
2.4
Outlet Pressure, bar
7.5
Outlet Pressure, psig
40.0 (580), 30
Flow Coefficient: 3.79 90 70.0 (1015)
Maximum Inlet Pressure:
1.8
15.0 (218) EU
US
RD10—1015 psig (70.0 bar) 5.0
Outlet Pressure Control 218 (15.0) 20
Range: 0 to 43 psig 60
1.2
580 (40.0),
(0 to 3.0 bar) 1015 (70.0)
102.5
0.6
30
218 (15.0),
580 (40.0),
0 1015 (70.0) 0
00 120 240 360 480 600 0
0 150 300 450 600 750 900
Nitrogen Flow, std ft33/min
Nitrogen Flow, Nm /h
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD10 Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 290 psig (0 to 20.0 bar) and 0 to 1015 psig (0 to 70.0 bar)
60 4.0
218 (15.0) 580 (40.0),
1015 (70.0)
0 0
0 300 600 900 1200 1500 1800
600 240
40
16
Outlet Pressure, psig
200
4,0 60
15,0 (218) 40,0 (580),
10
100 70,0 (1015)
0 580 (40.0), 1015 (70.0) 0
0 500 1000 1500 2000 2500
0
0 500 1000 1500 2000 2500
50
2.0
700
164 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH10 Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar), and
0 to 1450 psig (0 to 100 bar)
580 (40.0),
60 4.0
1015 (70.0)
30 2.0
580 (40.0), 1015 (70.0),
2900 (200), 3990 (275)
0 0
0 150 300 450 600 750 900
Nitrogen Flow, std ft3/min
300 20
120
Outlet Pressure, psig
8,0
Outlet Pressure, bar
25
1.0 350
Pressure-Reducing Regulator Flow Curves 165
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH10 Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 1450 psig (0 to 100 bar) and 0 to 2537 psig (0 to 175 bar)
1200
75
Outlet Pressure, psig
50
150
900
Outlet Pressure, psig
50
1500 200 (2900) 600
2900 (200) 100
275 (3900)
3990 (275)
25
1000 70,0 (1015) 275 (3900)
200 (2900) 300
50
40,0 (580) 200 (2900), 3990 (275)
500 70,0 275 (3900) 2900 (200)
(1015)
0 0
0 2500 5000 7500 10 000 12 500
0 0
0 1500 3000 4500 6000 7500 9000
250
166 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH10 Series
Flow Coefficient 3.79, Pressure Control Range 0 to 3625 (0 to 250 bar)
3000 200
Outlet Pressure, psig
1500 100
2900 3990
(200) (275)
1000
50
500
0
0 1500 3000 4500 6000 7500
250
3500
3000
200
2500
150 EUR
275 (3900) 2000
100 1500
200 275
(2900) (3900)
1000
50
500
0 0
0 2000 4000 6000 8000 10 000
25
20
Pressure-Reducing Regulator Flow Curves 167
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD10-EF Series
Flow Coefficient 3.79, Pressure Control Range 0 to 1015 psig (0 to 70.0 bar)
RD10-EF Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1015 psig (0 to 70.0 bar) 0 300 600 900 1200 1500 1800 2100
150
10
Inlet Pressure, psig (bar)
Pressure Control Range
580 (40.0)
0 to 1015 psig (0 to 70.0 bar) 120 218 (15.0)
8
Outlet Pressure, psig
580 (40.0)
60 4
218 (15.0)
580 (40.0)
30
218 (15.0)
2
0 0
0 300 600 900 1200 1500
psig
bar
psig
bar
Pressure,
Pressure,
90
Outlet Pressure, psig
6
600 Outlet Pressure, bar
Flow Coefficient: 3.79
Pressure,
1015 (70.0) 40
Pressure,
0 0
0 300 600 900 1200 1500 1800 2100
0 0
0 500 1000 1500 2000 2500 3000
Nitrogen Flow, Nm3/h
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH10-EF Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar) and
0RDH10-EF
to 1450 psig (0 to 100 bar)
Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 145 psig (0 to 10.0 bar) 0 750 1500 2250 3000 3750 4500
180
12
Inlet Pressure, psig (bar)
Pressure Control Range
150 1015 (70.0), 2900 (200), 10
0 to 145 psig (0 to 10.0 bar) 3990 (275), 5800 (400)
Outlet Pressure, psig
580 (40.0)
90 6
US
1015 (70.0), 2900 (200),
60 3990 (275), 5800 (400) 4
580 (40.0)
30 2
0 0
0 500 1000 1500 2000 2500 3000
psig
1015 (70.0) 2900 (200)
Pressure,psig
bar
600
40
OutletPressure,
2900
275 (3990), 400 (200), 3990 (275),
(5800)
Range: 0 to 145 psig 4 40.0 (580) 60
300 580 (40.0) 1015 (70.0) 5800 (400)
(0 to 10.0 bar) 20
2 30
150 10
0 0
0 0 750 1500 2250 3000 3750 4500 0
0 2000 4000 6000 8000 10 000
Nitrogen
NitrogenFlow,
Flow,std
Nm /hft33/min
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH10-EF Series
Flow Coefficient 3.79, Pressure Control Ranges 0 to 1450 psig (0 to 100 bar), 0 to 2537 psig (0 to 175 bar), and
0RDH10-EF Series
to 3625 psig (0 to 250 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 3625 psig (0 to 250 bar) 0 3000 6000 9000 12 000 15 000 18 000
0 to 2537 psig (0 to 175 bar) 4000
Inlet Pressure, psig (bar)
0 to 1450 psig (0 to 100 bar) 250
Pressure Control Range
5800 (400)
3200
0 to 3625 psig (0 to 250 bar)
Outlet Pressure, psig
1600
100
800
50
0 0
0 2000 4000 6000 8000 10 000 12 000
RD10-EFP Series
0 2000 4000 6000 8000 10 000 12 000
4000
RD10-EFP
Flow Series
Coefficient 3.79, Pressure Control Range 0 to 500 psig (0 to 34.5 bar)
250
Nitrogen Flow, Nm3/h 400 (5800)
Pressure Control Range Nitrogen Flow, Nm3/h 3200
0 to 500 psig (0 to 34.5 bar) 200 0 300 600 900 1200 1500 1800 2100
barPressure, psig
Outlet Pressure, bar
350
100
Outlet Pressure, bar
218 (15.0)
0 0
0 200 400 600 800 1000 1200 1400
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 130 psig (0 to 9.0 bar), 0 to 290 psig (0 to 20.0 bar),
and 0 to 1015 psig (0 to 70.0 bar)
600 40
Outlet Pressure, psig
500
90
EUR
30
US
1015 (70.0) 400
5.0
60
20 70,0 (1015) 300
218 (15.0) 580 (40.0)
15,0 (218) 200
2.5
218 (15.0) 580 (40.0) 1015 (70.0)
1030 40,0 (580) 15,0 (218)
40,0 (580) 70,0 (1015) 100
40,0 (580)
70,0 (1015)
00 0 0
00 1000 400
2000 3000 800
4000 5000 1200
6000 7000 1600
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 290 psig (0 to 20.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
12
140
8.0
0 0
0 500 1000 1500 2000 2500 3000 3500
12
500
30
140
400
8,0
40,0 (580) 70,0 (1015)
300 20
1015 (70.0) 70
4,0
40,0 (580), 70,0 (1015)
200 15,0 (218)
1015 (70.0) 10
0 0
100 0 1000 2000 580 (40.0)
3000 4000 5000
0
0 1000 2000 3000 4000 5000
Nitrogen Flow, std ft3/min
2.4
0 1000 2000 3000 4000 5000
800
2.0
50
172 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar) and 0 to 362 psig (0 to 25.0 bar)
90 6.0
US
60 4.0
580 (40.0),
1015 (70.0),
30 2.0
2900 (200),
580 (40.0), 1015 (70.0), 3630 (250)
2900 (200), 3630 (250)
0 0
0 300 600 900 1200 1500 1800
3
0 300 600 Nitrogen Flow,
900 Nm /h 1200 1500 1800
Pressure Control Range: 180
12 0 1000 2000 3000 4000 5000 6000
0 to 362 psig (0 to 25.0 bar)
400
Inlet Pressure, psig (bar) 150
10 25
350
300 120
8,0 20
Outlet Pressure, psig
250
EUR
6,0 90
15
200 US
4,0 60
150
40,0 (580)
580 (40.0) , (70.0), 10
1015
70,0 (1015)
2900 , (200), 30
2,0
100 200 (2900) , (250)
3630
40,0 (580), 70,0 (1015), 250 (3630) 5.0
50 200 (2900), 250 (3630)
0 580 (40.0), 1015 (70.0), 0
0 500 1000
2900 (200), 36301500
(250) 2000 2500
0 0
0 800 1600 2400 3200 4000
Nitrogen Flow, std ft3/min
1.2
0 800 1600 2400 3200 4000
400
1.0
25
350
Pressure-Reducing Regulator Flow Curves 173
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases. Dashed line represents
calculated values.
For more flow curve information, contact your authorized Swagelok representative.
RDH15 Series
Flow Coefficient 7.30, Pressure Control Ranges 0 to 1450 psig (0 to 100 bar) and 0 to 2537 psig (0 to 175 bar)
1400
90
Outlet Pressure, psig
75
1000
60
2900 (200)
800
3630 (250)
45
600
0 2800 5600 8400 11 200 14 000
1200
Outlet Pressure, bar
E
2200
75 150
1000
140
2000
60
200 (2900) 800
130
250 (3630)
2900 (200)
1800 3630 (250)
45 120
600
0 4000 8000 12 000 16 000 20 000
1600
0 3000 6000 9000 12 000 15 000
10.5
0 3000 6000 9000 12 000 15 000
2600
9.0
170
174 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH15 Series
Flow
RDH15Coefficient
Series 7.30, Pressure Control Range 0 to 3625 psig (0 to 250 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 3625
362 psig
psig(0(0toto25.0
250bar)
bar) 0 7500 15 000 22 500 30 000 37 500
4000
0 to 145 psig (0 to 100 bar)
Inlet Pressure, psig (bar) 250
Pressure Control Range
3200
0 to 3625 psig (0 to 250 bar)
Outlet Pressure, psig
5800 (400)
800
50
0 0
0 5000 10 000 15 000 20 000 25 000
250
3200
2400
Flow Coefficient: 7.30 150
Maximum Inlet Pressure: EU
RDH15—5800 psig (400 bar) 200 (2900)
Outlet Pressure Control 1600
100 400 (5800)
Range: 0 to 3625 psig
(0 to 250 bar)
800
50
0 0
0 7500 15 000 22 500 30 000 37 500
25.0
20.0 40.0
a
Pressure-Reducing Regulator Flow Curves 175
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD20 Series
Flow Coefficient 13, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar) and 0 to 130 psig (0 to 9.0 bar)
RD20 Series
Pressure Control Range: Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
0 to 43.0 psig (0 to 3.0 bar)
0 250 500 750 1000 1250
50
1.0
10
0.5
0 0
0 150 300 450 600 750 900
2.5
Outlet Pressure, bar
1015 (70.0)
90
30
2.0
Flow Coefficient: 13
Maximum Inlet Pressure: 580 (40.0) 5.0
15.0 (218),
21835.0
(15.0)(507)
RD20—507 psig (35.0 bar) 1.5
60
Outlet Pressure Control 20
Range: 0 to 43 psig
580 (40.0)
(0 to 3.0 bar) 1.0 218 (15.0) 2.5
30
10
0.5
0 0
0
0 500 1000 1500 2000 25000
0 250 500 750 1000 1250
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD20 Series
Flow Coefficient 13, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar) and 0 to 290 psig (0 to 20.0 bar)
120 8.0
Outlet Pressure, psig
60 4.0
0 0
0 400 800 1200 1600 2000 2400 2800
Nitrogen Flow, std ft3/min
15100
Outlet Pressure, psig
200
6.0
250 (3630), 200 (2900),
EU
1015 (70.0)(580) 80
70,0 (1015) , 40,0
150
580 (40.0) USA
4.0 1060
0 0
0 1000 2000 3000 4000
0 0
0 1000 2000 3000 4000 5000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD20 Series
Flow Coefficient 13, Pressure Control Ranges 0 to 130 psig (0 to 9.0 bar), 0 to 290 psig (0 to 20.0 bar), and
0 to 1015 psig (0 to 70.0 bar)
600 40
Outlet Pressure, psig
50
4.0 700
178 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases. Dashed line represents
calculated values.
For more flow curve information, contact your authorized Swagelok representative.
RDH20 Series
Flow Coefficient 13, Pressure Control Ranges 0 to 362 psig (0 to 25.0 bar) and 0 to 1450 psig (0 to 100 bar)
8.0
0 0
0 1200 2400 3600 4800 6000
16 240
900
250(200)
2900 (3630), 200 (2900),
EUR
12
70,0 (1015), 40,0
3630(580)
(250) US
50
160
600
8.0
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases. Dashed line represents
calculated values.
For more flow curve information, contact your authorized Swagelok representative.
RDH20 Series
Flow Coefficient 13, Pressure Control Ranges 0 to 2537 psig (0 to 175 bar) and 0 to 2900 psig (0 to 200 bar)
RDH20 Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 2900 psig (0 to 200 bar) Nitrogen Flow, Nm3/h
0 to 2540 psig (0 to 175 bar)
0 7500 15 000 22 500 30 000 37 500 45 000
3500 240
Inlet Pressure, psig (bar)
Pressure Control Range
3000 200
160
1500 80
3630 (250)
2900 (200)
1000 40
500 60
0 0
0 5000 10 000 15 000 20 000 25 000 30 000
3000
200
2500
2000
Flow Coefficient: 13
250 (3630)
Maximum Inlet Pressure: 120
RDH20—5800 psig (400 bar) 1500
Outlet Pressure Control 250 (3630)
200 (2900)
Range: 0 to 2900 psig 80
(0 to 200 bar) 1000
40
500
0 0
0 7500 15 000 22 500 30 000 37 500 45 000
2.4
2.0
180 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD20-EF Series
Flow Coefficient 13, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar),
0 to 145 psig (0 to 10.0 bar), 0 to 290 psig (0 to 20.0 bar), and 0 to 362 psig (0 to 25.0 bar)
RD20-EF Series
Pressure Control Range:
0 to 290 psig (0 to 20.0 bar) Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar)
0 to 43.0 psig (0 to 3.0 bar) 0 1500 3000 4500 6000 7500
350 24
12 U
150 507 (35.0)
507 (35.0) 8.0
100 218 (15.0)
507 (35.0)
50 218 (15.0) 4.0
218 (15.0), 507 (35.0)
0 0
0 1000 2000 3000 4000 5000
psig
bar
Pressure,psig
25
Pressure,bar
16
Outlet Pressure, psig
15
Outlet
Nitrogen 3
NitrogenFlow,
Flow,std
Nmft3/h/min
Nitrogen Flow, std ft3/min
Flow Coefficient: 13 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RDH20-EF—5800 psig (400 bar)
Outlet Pressure Control 2.4 0 4000 8000 12 000 16 000 20 000
500
Range: 0 to 362 psig
(0 to 25.0 bar)
2.0
Pressure-Reducing Regulator Flow Curves 181
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH20-EF Series
Flow Coefficient 13, Pressure Control Ranges 0 to 1015 psig (0 to 70.0 bar) and 0 to 1450 psig (0 to 100 bar)
RD20-EF Series
Nitrogen Flow, Nm3/h
Pressure Control Range: Nitrogen Flow, Nm3/h
0 to 1015 psig (0 to 70.0 bar)
0 3000 6000 9000 12 000 15 000
800
Inlet Pressure, psig (bar)
Pressure Control Range 50
700
30
400
0 0
0 2000 4000 6000 8000 10 000
psig
bar
1200
psig
Pressure,bar
80
Outlet Pressure, psig
OutletPressure,
Pressure,
1000
30
400
60
800
Outlet
20
70.0 (1015)
600
2900 (200) 40
1015 (70.0) 200
400
10
100
20
200
0 0
0 0 3000 6000 9000 12 000 15 000 0
0 10 000 20 000 30 000 40 000 50 000
Nitrogen
NitrogenFlow,
Flow,std 3/min
Nmft3/h
Nitrogen Flow, std ft3/min
Flow Coefficient: 13 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RDH20-EF—5800 psig (400 bar)
Outlet Pressure Control 0 10 000 20 000 30 000 40 000 50 000
1600
Range: 0 to 1450 psig 5.0
(0 to 100 bar) 100
1400
182 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH20-EF Series
Flow Coefficient 13, Pressure Control Ranges 0 to 2537 psig (0 to 175 bar) and 0 to 2900 psig (0 to 200 bar)
RDH20-EF Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 2900 psig (0 to 200 bar) Nitrogen Flow, Nm3/h
0 to 2537 psig (0 to 175 bar)
0 15 000 30 000 45 000 60 000 75 000 90 000
3500 240
2000
5800 (400)
120 U
2900 (200)
1500
80
1000
40
500
0 0
0 10 000 20 000 30 000 40 000 50 000 60 000
Pressure, psig
Pressure, bar
Outletbar
250
Outlet Pressure, psig
1500
0 to 130 psig (0 to 9.0 bar)
Outlet
16.0
Outlet Pressure,
Outlet Pressure,
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD25 Series
Flow Coefficient 21, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 290 psig (0 to 20.0 bar),
RD25
0 to Series
130 psig (0 to 9.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
Pressure Control Range:
0 to 130 psig (0 to 9.0 bar) 0 2000 4000 6000 8000 10 000
140
0 to 43.0 psig (0 to 3.0 bar)
Inlet Pressure, psig (bar) 9.0
Pressure Control Range
120
4.5
60
218 (15.0)
3.0
40 507 (35.0)
20
507 (35.0) 1.5
218 (15.0)
0 0
0 1500 3000 4500 6000 7500
bar
40
100
Outlet Pressure, psig
Pressure,
80
30
400
4.5
Outlet
60
Outlet
Outlet
0 0
0 2000
3000 4000 6000 6000 9000 8000 10 000
12 000 15 000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH25 Series
Flow Coefficient 21, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar),
RDH25
0 to Series
1450 psig (0 to 100 bar), 0 to 2537 psig (0 to 175 bar), and 0 to 2900 psig (0 to 200 bar)
Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
Pressure Control Range:
0 to 362 psig (0 to 25.0 bar) 0 6000 12 000 18 000 24 000 30 000
400
0 to 145 psig (0 to 10.0 bar)
Pressure Control Range Inlet Pressure, psig (bar) 25
320
0 to 362 psig (0 to 25.0 bar)
580 (40.0) 1015 (70.0)
Outlet Pressure, psig
bar psig
psigbar
Pressure,
2500 240
Outlet Pressure, psig
Pressure,
E
Pressure,
1500
Outlet
(0 to 25.0 bar)
70.0 (1015), 200 (2900), 80
40.0 (580) 2900 (200) 4060 (280) 80
5.0
1000 280 (4060)
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD25-EF Series
Flow Coefficient 21, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar),
0 to 290 psig (0 to 20.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
RD25-EF Series
Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
Pressure Control Range:
0 to 130 psig (0 to 9.0 bar) 0 1500 3000 4500 6000 7500 9000
140
0 to 43.0 psig (0 to 3.0 bar) Inlet Pressure, psig (bar)
9.0
Pressure Control Range
120
218 (15.0) 507 (35.0)
0 to 130 psig (0 to 9.0 bar) 7.5
Outlet Pressure, psig
4.5
60 218 (15.0) 507 (35.0)
218 (15.0)
20 1.5
0 0
0 1000 2000 3000 4000 5000 6000
barpsig
psigbar
Pressure,
Flow0Coefficient:
to 290 psig (021
to 20.0 bar) 80 Outlet Pressure, bar
Pressure,
Pressure,
500
Maximum Inlet Pressure:
4.5
RD25-EF—507 psig (35.0 bar) 15.0 (218) 35.0 (507) 30
60
Outlet
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH25-EF Series
Flow Coefficient 21, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar),
0 to 1450 psig (0 to 100 bar), 0 to 2537 psig (0 to 175 bar), and 0 to 2900 psig (0 to 200 bar)
RDH25-EF Series
Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
Pressure Control Range:
0 to 362 psig (0 to 25.0 bar) 0 9000 18 000 27 000 36 000 45 000
400
0 to 145 psig (0 to 10.0 bar)
Inlet Pressure, psig (bar)
Pressure Control Range 25
2900 (200), 4060 (280)
320 580 (40.0) 1015 (70.0)
0 to 362 psig (0 to 25.0 bar)
Outlet Pressure, psig
0 0
0 6000 12 000 18 000 24 000 30 000
bar psig
psigbar
Pressure,
2500 240
Outlet Pressure, psig
2000
2900 (200) U
Outlet
160
Outlet
120
10 200 (2900), 280 (4060)
Outlet
1500
Outlet
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD25-EFP Series
Flow Coefficient 21, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar), and
0 to 290 psig (0 to 20.0 bar)
RD25-EFP Series
Pressure Control Range:
Nitrogen Flow, Nm3/h
0 to 290 psig (0 to 20.0 bar) Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar)
0 1500 3000 4500 6000 7500 9000
0 to 43.0 psig (0 to 3.0 bar) 350 24.0
Inlet Pressure, psig (bar)
Pressure Control Range
300
20.0
0 to 290 psig (0 to 20.0 bar)
Outlet Pressure, psig
12.0
150
8.0
100 218 (15.0) 507 (35.0)
0
218 (15.0) 0
0 1000 2000 3000 4000 5000 6000
300
20.0
250
16.0
15.0 (218)
0 0
0 1500 3000 4500 6000 7500 9000
2.4
2.0
188 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD30 Series
Flow Coefficient 36, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar),
0RD30
to 290Series
psig (0 to 20.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar) 0 1500 3000 4500 6000 7500 9000
140
0 to 43.0 psig (0 to 3.0 bar)
Inlet Pressure, psig (bar) 9.0
Pressure Control Range
120
0 0
0 1000 2000 3000 4000 5000 6000
bar
40
100
Outlet Pressure, psig
psig
Pressure,
1015 (70.0)
Pressure,
500
6.0
Pressure,
Pressure,
Flow Coefficient: 36 80
30
Maximum Inlet Pressure: 400 15.0 (218) US
EU
4.5
Outlet
35.0 (507) 60
Outlet
20
Range: 0 to 130 psig 15.0 (218), 35.0 (507)
3.0
(0 to 9.0 bar) 200 40
580 (40.0), 1015 (70.0) 10
15.0 (218), 35.0 (507)
1.5
100 507 (35.0) 20
0 0
0 0
0 5000 10 000 15 000 20 000 25 000
0 1500 3000 4500 6000 7500 9000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH30 Series
Flow Coefficient 36, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar), and
0 to 1450 psig (0 to 100 bar)
RDH30 Series
Pressure Control Range Nitrogen Flow, Nm3/h
Nitrogen Flow, Nm3/h
0 to 362 psig (0 to 25.0 bar)
0 4000 8000 12 000 16 000 20 000
0 to 145 psig (0 to 10.0 bar) 400
Inlet Pressure, psig (bar)
Pressure Control Range 25
350
150 10
100
580 (40.0), 1015 (70.0),
2900 (200), 4060 (280)
5.0
50 580 (40.0), 1015 (70.0),
2900 (200), 4060 (280)
0 0
0 2000 4000 6000 8000 10 000 12 000 14 000
psig
1200
bar
Pressure,psig
70.0 (1015),
Pressure, bar
80
Outlet Pressure, psig
Outlet Pressure,
OutletPressure,
10 150
600 40
2900 (200), 4060 (280) 100
40.0 (580), 70.0 (1015),
400
5.0 200 (2900), 280 (4060)
20
50
1015
40.0 (580) , 70.0 (1015),
(70.0)
200
200 (2900), 280 (4060)
0 0
00 4000 8000 12 000 16 000 20 000 0
0 10 000 20 000 30 000 40 000 50 000 60 000
Nitrogen 3/min
NitrogenFlow,
Flow,std
Nmft3/h
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH30 Series
Flow Coefficient 36, Pressure Control Ranges 0 to 2537 psig (0 to 175 bar) and 0 to 2900 psig (0 to 200 bar)
RDH30 Series
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 2900 psig (0 to 200 bar) Nitrogen Flow, Nm3/h
0 to 2537 psig (0 to 175 bar) 0 30 000 60 000 90 000 120 000 150 000
3500 240
Pressure Control Range Inlet Pressure, psig (bar)
0 to 2900 psig (0 to 200 bar) 3000
200
0 to 2537 psig (0 to 175 bar)
Outlet Pressure, psig
120 US
1500
4060 (280)
80
1000
2900 (200)
40
500
0 0
0 20 000 40 000 60 000 80 000 100 000
160
280 (4060)
2000
120 EU
1500
280 (4060)
80
1000
200 (2900)
40
500
0 0
0 30 000 60 000 90 000 120 000 150 000
24
20
Pressure-Reducing Regulator Flow Curves 191
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD30-EF Series
Flow Coefficient 36, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar,
0RD30-EF
to 290 psig (0 to 20.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar) 0 3000 6000 9000 12 000 15 000 18 000
140
0 to 43.0 psig (0 to 3.0 bar)
Inlet Pressure, psig (bar) 9.0
Pressure Control Range
120
218 (15.0) 507 (35.0)
0 to 130 psig (0 to 9.0 bar) 7.5
Outlet Pressure, psig
507 (35.0)
4.5
60 218 (15.0)
3.0
40 507 (35.0)
218 (15.0)
20 1.5
0 0
0 2000 4000 6000 8000 10 000 12 000
psig
0 to 1015 psig (0 to 70.0 bar)
bar
600
1015 (70.0)
psig
bar
40
6.0
Pressure,
Pressure,
0 to 290 psig (0 to 20.0 bar) Outlet Pressure, bar
Flow Coefficient: 36 80
Pressure,
Pressure,
500
Maximum Inlet Pressure: 35.0 (507)
4.5 30
RD30-EF—507 psig (35.0 bar) 15.0 (218) 60
400
Outlet
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH30-EF Series
Flow Coefficient 36, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar, and
0RDH30-EF
to 1450 psig (0 to 100 bar)
Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 362 psig (0 to 25.0 bar) 0 10 000 20 000 30 000 40 000 50 000
400
0 to 145 psig (0 to 10.0 bar)
Inlet Pressure, psig (bar)
Pressure Control Range 25
350
2900 (200), 4060 (280)
1015 (70.0)
0 to 362 psig (0 to 25.0 bar)
300
580 (40.0)
Outlet Pressure, psig
15
200 US
150
1015 (70.0), 2900 (200), 10
0 0
0 5000 10 000 15 000 20 000 25 000 30 000 35 000
psig
1200
bar
Pressure,psig
Pressure, bar
80
Outlet Pressure, psig
Outlet Pressure,
OutletPressure,
1000
15
200
60 EU
US
800
4060 (280)
Outlet
Outlet
150
10 70.0 (1015), 200 (2900),
600 2900 (200) 40
40.0 (580) 280 (4060)
100
400 1015 (70.0)
5.0 40.0 (580), 70.0 (1015),
20
200 (2900), 280 (4060) 50
200
0 0
0 0 10 000 20 000 30 000 40 000 50 000 0
0 15 000 30 000 45 000 60 000 75 000 90 000
Nitrogen 33
NitrogenFlow,
Flow,std
Nmft /h
/min
Nitrogen Flow, std ft3/min
Flow Coefficient: 36 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RDH30-EF—4060 psig (280 bar)
Outlet Pressure Control 0 15 000 30 000 45 000 60 000 75 000 90 000
1600
Range: 0 to 1450 psig 2.5
(0 to 100 bar) 20.0, 28.0
100
7.0 1400
4.0 200 (2900) 280 (4060)
2.0
1200
a
Pressure-Reducing Regulator Flow Curves 193
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH30-EF Series
Flow Coefficient 36, Pressure Control Ranges 0 to 2537 psig (0 to 175 bar) and 0 to 2900 psig (0 to 200 bar)
RDH30-EF Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 2900 psig (0 to 200 bar) 0 20 000 40 000 60 000 80 000 100 000 120 000 140 000
3500 240
0 to 2537 psig (0 to 175 bar)
Pressure Control Range Inlet Pressure, psig (bar)
3000
0 to 2900 psig (0 to 200 bar) 200
4060 (280)
0 to 2537 psig (0 to 175 bar) 4060 (280)
Outlet Pressure, psig
40
500
0 0
0 15 000 30 000 45 000 60 000 75 000 90 000
160
120
1500
200 (2900)
80
1000
40 500
0 0
0 20 000 40 000 60 000 80 000 100 000 120 000 140 000
24
20
28.0
28.0
Pa
194 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD30-EFP Series
Flow Coefficient 36, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar), and
0 to 290 psig (0 to 20.0 bar)
RD30-EFP Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar) 0 3000 6000 9000 12 000 15 000 18 000
140
0 to 43.0 psig (0 to 3.0 bar)
Inlet Pressure, psig (bar)
9.0
Pressure Control Range
120 507 (35.0)
218 (15.0)
0 to 130 psig (0 to 9.0 bar) 7.5
Outlet Pressure, psig
0 0
0 2000 4000 6000 8000 10 000 12 000
psig
bar
Pressure,psig
Pressure,bar
250
Outlet Pressure, psig
Flow Coefficient: 36 80
Maximum Inlet Pressure: 200 35.0 (507) EU
RD30-EFP—507 psig (35.0 bar) 4.5
15.0 (218) 12
60
US
Outlet Pressure Control
Outlet
150
Outlet
0 0
0 0 3000 6000 9000 12 000 15 000 18 000 0
0 2000 4000 6000 8000 10 000 12 000
Nitrogen Flow,
Nitrogen std
Flow, Nmft33/min
/h
Nitrogen Flow, std ft3/min
Flow Coefficient: 36 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RD30-EFP—507 psig (35.0 bar)
Outlet Pressure Control 0 2000 4000 6000 8000 10 000 12 000
24
0.90 350
Range: 0 to 290 psig
(0 to 20.0 bar) 3.5
1.5 300
0.75
20
a
Pressure-Reducing Regulator Flow Curves 195
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD40 Series
Flow Coefficient 36, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar), 0 to 130 psig (0 to 9.0 bar),
0RD40
to 290Series
psig (0 to 20.0 bar), and 0 to 1015 psig (0 to 70.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar) 0 3000 6000 9000 12 000 15 000
140
0 to 43.0 psig (0 to 3.0 bar)
Pressure Control Range Inlet Pressure, psig (bar) 9.0
7.5
0 to 43.0 psig (0 to 3.0 bar)
Outlet Pressure, psig
4.5
60 218 (15.0), 507 (35.0)
3.0
40
bar
40
100
psig
(0 to 09.0 bar)psig (0 to 20.0 bar)
Pressure,bar
to 290
Outlet Pressure, bar
1015 (70.0)
Pressure,
500
6.0
OutletPressure,
Pressure,
80
30
400
4.5
15.0 (218), 35.0 (507)
Outlet
60
Outlet
Outlet
300 20
3.0
40
200 580 (40.0), 1015 (70.0)
50715.0
(35.0)(218), 35.0 (507) 10
1.5 20
100
15.0 (218), 35.0 (507)
0 00
0 6000 3000 12 000 6000 18 000 9000
24 000 12 000
30 000 36 000 15 00042 000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH40 Series
Flow Coefficient 36, Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar), 0 to 362 psig (0 to 25.0 bar), and
0RDH40
to 1450Series
psig (0 to 100 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 362 psig (0 to 25.0 bar) 0 5000 10 000 15 000 20 000 25 000 30 000
400
0 to 145 psig (0 to 10.0 bar)
Inlet Pressure, psig (bar)
Pressure Control Range 25
350
psig
Pressure,psig
bar
1000
15 200 (2900), 280 (4060)
800
200
60 EU
US
Outlet
10 150
600 40
40.0 (580) (200),(1015)
2900, 70.0 4060, (280)
1015
200(70.0)
(2900), 280 (4060) 100
400
5.0
40.0 (580), 70.0 (1015), 20
50
200 200 (2900), 280 (4060)
0 0
0 0 5000 10 000 15 000 20 000 25 000 30 000 0
0 16 000 32 000 48 000 64 000 80 000
Nitrogen 3/min
NitrogenFlow,
Flow,std
Nmft3/h
Nitrogen Flow, std ft3/min
Flow Coefficient: 73 Nitrogen Flow, std ft3/min
Maximum Inlet Pressure:
RDH40—4060 psig (280 bar)
Outlet Pressure Control 0 16 000 32 000 48 000 64 000 80 000
1600
Range: 0 to 1450 psig
2.5
(0 to 100 bar) 100
1400
2.0 1200
a
80
Pressure-Reducing Regulator Flow Curves 197
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH40 Series
RDH40
Flow Series 36, Pressure Control Ranges 0 to 2537 psig (0 to 175 bar) and 0 to 2900 psig (0 to 200 bar)
Coefficient
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 2900 psig (0 to 200 bar) 0 40 000 80 000 120 000 160 000 200 000
3500 240
0 to 2537 psig (0 to 175 bar)
Pressure Control Range Inlet Pressure, psig (bar)
0 to 2900 psig (0 to 200 bar) 3000
200
0 to 2537 psig (0 to 175 bar)
Outlet Pressure, psig
120
1500
4060 (280)
80
1000
40
500
0 0
0 30 000 60 000 90 000 120 000 150 000
Pressure, psig
0 to 43.0 psig (0 to 3.0 bar)
Pressure, bar
Outletbar
100 1500
Outlet
280 (4060)
Outlet Pressure,
Outlet Pressure,
80 6.0
80 1000
507 (35.0)
40 4.5
60 218 (15.0) 500
3.0
40
0 507 (35.0) 0
0 40 000 80 000 218 (15.0)120 000 160 000 200 000
20 1.5
Flow Coefficient: 73 16
9.0
Maximum Inlet Pressure: 20.0 28.0
198 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD40-EF Series
RD40-EF
Flow Series36, Pressure Control Ranges 0 to 290 psig (0 to 20.0 bar) and 0 to 1015 psig (0 to 70.0 bar)
Coefficient
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1015 psig (0 to 70.0 bar) 0 10 000 20 000 30 000 40 000 50 000 60 000
800
0 to 290 psig (0 to 20.0 bar)
Inlet Pressure, psig (bar)
Pressure Control Range 50
700
1015 (70.0)
0 to 1015 psig (0 to 70.0 bar)
600
Outlet Pressure, psig
30
400 US
300 20
0 0
0 6000 12 000 18 000 24 000 30 000 36 000 42 000
psig
Pressure, bar
Outlet Pressure,
580 (40.0) 1015 (70.0) 4060 (280)
0 to 362 psig (0 to 25.0 bar) 30
300 400 EU
Outlet psig
bar
20
Outlet Pressure, psig
Outlet Pressure,
Outlet Pressure,
250 300
20
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RDH40-EF Series
RDH40-EF Series
Flow Coefficient 36, Pressure Control Range 0 to 1450 psig (0 to 100 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1450 psig (0 to 100 bar) 0 40 000 80 000 120 000 160 000 200 000
1600
Inlet Pressure, psig (bar)
Pressure Control Range 100
1400
2900 (200) 4060 (280)
0 to 1450 psig (0 to 100 bar)
1200
Outlet Pressure, psig
60
800
4060 (280)
600 1015 (70.0) 2900 (200)
40
400
20
200
0 0
0 30 000 60 000 90 000 120 000 150 000
Pressure, psig
Pressure, bar
Outlet bar
2500
280 (4060)
Outlet Pressure, psig
Outlet Pressure,
Outlet Pressure,
40 600
2000
400
120
1500
20
200
80
1000
0 0
0 40 000 80 000 120 000 160 000 200 000
40
500
20.0 28.0
0 30 000 60 000 90 000 120 000 150 000
240 3500
Flow Coefficient: 73 8.0
e, MPa
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RD40-EFP Series
RD40-EFP
Flow Series
Coefficient 36, Pressure Control Ranges 0 to 43.0 psig (0 to 3.0 bar) and 0 to 130 psig (0 to 9.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 130 psig (0 to 9.0 bar) 0 5000 10 000 15 000 20 000 25 000 30 000
140
0 to 43.0 psig (0 to 3.0 bar) Inlet Pressure, psig (bar)
Pressure Control Range 9.0
507 (35.0) US
4.5
60 218 (15.0)
0 0
0 4000 8000 12 000 16 000 20 000
psig
(0 to 9.0 bar)
bar
300
6.0
Outlet Pressure,
20
Outlet Pressure,
0 to 290 psig (0 to 20.0 bar)
80
507 (35.0)
EU
psig
35.0 (507)
250
4.5 bar
Outlet Pressure, psig
15.0 (218) 16
60
Outlet Pressure,
Outlet Pressure,
200
3.0 35.0 (507) 40
12 US
15.0 (218)
150
1.5 20
8.0
100
0 0
0 5000 10 000 15 000 20 000 25 000 30 000 4.0
50
0
Nitrogen Flow, Nm3/h 0
0 4000 8000 12 000 16 000 20 000
300
Pressure-Reducing Regulator Flow Curves 201
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RA4 Series
Flow
RA4 Coefficient
Series 1.84
Pressure Ratio 1:15, 1:40, 1:70
Nitrogen Flow, Nm3/h
Pressure Ratio Nitrogen Flow, Nm3/h
1:15, 1:40, 1:70 0 300 600 900 1200 1500 1800
400
320
1:15, 1:40, 1:70
Outlet Pressure, psig
160
10
1015 (70.0), 2175 (150)
80
5
218 (15.0), 580 (40.0),
1015 (70.0), 2175 (150)
0 0
0 200 400 600 800 1000 1200
1200
1:15, 1:40, 1:70 80
320
barpsig
psigbar
Outlet Pressure, psig
20
Outlet Pressure, bar
Pressure,
Pressure,
2175 (150)
900
40.0 (580)
Pressure,
60
Pressure,
240
Flow Coefficient: 1.84 15
Maximum Inlet Pressure:
Outlet
Outlet
10 3990 (275)
1:15, 1:40, 1:70 1450 (100)
70.0 (1015), 150 (2175)
300 2900 (200) 20
80
5
15.0 (218), 40.0 (580),
70.0 (1015), 150 (2175)
0 0
0 0 700 1400 2100 2800 35000
0 300 600 900 1200 1500 1800
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft33/min
Nitrogen Flow, Nm /h
Nitrogen Flow, std ft3/min
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
RA4 Series
Flow
RA4 Coefficient
Series 1.84
Pressure Ratio 1:40, 1:70
Nitrogen Flow, Nm3/h
Pressure Ratio Nitrogen Flow, Nm3/h
1:40, 1:70 0 900 1800 2700 3600 4500
3000
160
1500 US
120
2900 (200)
3990 (275)
1000
80
500
40
0 0
0 800 1600 2400 3200 4000
Pressure, psig
Pressure, bar
2000
Inlet Pressure, psig (bar) 25
1:15,1:40,1:70
160
Flow Coefficient: 1.84 320
Maximum Inlet Pressure: 1500 EU
Outletpsig
20 Outlet bar
RA4—5800 psig (400 bar) 580 (40.0) 1015 (70.0), 2175 (150)
Outlet Pressure, psig
120
Outlet Pressure, bar
275 (3990)
Outlet Pressure,
25
Pressure-Reducing Regulator Flow Curves 203
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
600 40
300 20
0 0
0 500 1000 1500 2000 2500 3000
Pressure, psig
Pressure, bar
Outlet bar
150
RA6&8—5800 psig (400 bar)
Outlet Pressure, psig
3990 (275)
Outlet Pressure, bar
2000 600
Outlet Pressure Ratio 40 Outlet Pressure,
Outlet Pressure,
1:15,1:40,1:70 120
2900 (200)
1500
20 300
90
1000
60
0 0
0 750 1500 2250 3000 3750 4500
500
30
Nitrogen Flow, Nm /h 3
0 0
0 700 1400 2100 2800 3500
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.10 Pressure Control Ranges 0 to 145 psig (0 to 10.0 bar) and 0 to 362 psig (0 to 25.0 bar)
0 10 20 30 40
250
16
200
12
Inlet Pressure, psig
USA
8.0
100
4.0
50
0 0
0 5.0 10 15 20 25 30
200
400
12
24
Inlet Pressure, psig
150
300 EURO
8,0
USA
16
100
200
4,0
8.0
50
100
0
0 00
00 10 10 20 20 30 30 40 5040 60
0 10 20 30 40 50 60
Pressure-Reducing Regulator Flow Curves 205
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.10, Pressure Control Ranges 0 to 1450 psig (0 to 100 bar) and 0 to 2537 psig (0 to 175 bar)
120
1600
100
Inlet Pressure, psig
60
800
40
400
20
0 0
0 40 80 120 160 200
2400
60 160 Inlet Pressure, bar
800
40 120
1600
400
20 80
800
0 0 40
0 50 100 150 200 250 300
0 0
0 80 160 240 320 400
10
240
3200
8.0
206 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases. Dashed line represents
calculated values.
For more flow curve information, contact your authorized Swagelok representative.
Flow Coefficient 0.10, Pressure Control Range 0 to 5075 psig (0 to 350 bar)
360
4800
300
Inlet Pressure, psig
120
1200
60
0 0
0 120 240 360 480 600
BSH2 Series
0 120 240 360 480 600
6000
Flow
BSH2Coefficient
Series 0.10, Pressure Control Range 0 to 10 150 psig (0 to 700 bar)
360 Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h 4800
0 to 10 150 psig (0 to 700 bar) 300
0 300 600 900 1200 1500
12 000
780
Pressure Control Range 240 3600
10 000
EU
0 to 10150 psig (0 to 700 bar) 650
180
2400
Inlet Pressure, psig
8000
520
120
6000
390
1200 US
60
4000
0 2600
0 150 300 450 600 750 900
2000 130
0 0
0 200 400 600 800 1000
30
0 200 400 600 800 1000
Pressure-Reducing Regulator Flow Curves 207
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BS(H)4 Series
Flow Coefficient 1.84
Regulator Series Nitrogen Flow, Nm3/h
BSH4 only 0 300 600 900 1200 1500 1800
BS4 and BSH4 2500
2175 (150)
160
2175 (150)
2000
580 (40.0)
580 (40.0) 40
500
406 (28.0)
203 (14.0)
101 (7.0)
0 0
0 200 400 600 800 1000 1200
40 40,0 (580)
2000
500
28,0 (406) 120
14,0 (203)
1000 7,0 (101)
60
0 0
0 300 600 900 1200 1500 1800
0 0
0 500 1000 1500 2000 2500 3000
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BS(H)6 Series
Flow Coefficient 1.84
Regulator Series Nitrogen Flow, Nm3/h
BSH6 only 0 300 600 900 1200 1500 1800
BS6 and BSH6 2500
2175 (150)
160
2175 (150)
2000
580 (40.0)
580 (40.0) 40
500
406 (28.0)
203 (14.0)
101 (7.0)
0 0
0 200 400 600 800 1000 1200
BSH6 Series
BSH6 Series
Flow Coefficient 1.84, Pressure Control
0 Range
2000 to 5220 psig (0 to 600
400 360 bar) 800 1000 1200
Nitrogen Flow, Nm3/h 2500
Pressure Control Range 160 Nitrogen Flow, Nm3/h 150 (2175)
0 to 5220 psig (360 bar)
0 750 1500 2250 3000 150 (2175)
3750 4500
6000 2000
4000
80
80,0 (1160)
1000
240
0 0
0 500 1000 1500 2000 2500 3000
360
5000
Pressure-Reducing Regulator Flow Curves 209
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BS(H)8 Series
Flow Coefficient 1.84
Regulator Series Nitrogen Flow, Nm3/h
BSH8 only 0 300 600 900 1200 1500 1800
BS8 and BSH8 2500
2175 (150)
160
2175 (150)
2000
580 (40.0)
580 (40.0) 40
500
406 (28.0)
203 (14.0)
101 (7.0)
0 0
0 200 400 600 800 1000 1200
BSH8 Series
BSH8 Series 0 200 400 600 800 1000 1200
Flow Coefficient 1.84, Pressure Control Range 0 to 5220 psig (0 to 360 bar) 2500
160
Nitrogen Flow, Nm /h 3
150 (2175)
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 5220 psig (360 bar) 150 (2175)
0 750 1500 2250 3000 3750 4500 2000
6000
80
Inlet Pressure, psig
0 0
0 500 1000 1500 2000 2500 3000
360
210 Pressure-Reducing Regulator Flow Curves
For options, additional technical data, materials of construction, and ordering information, see the Swagelok Pressure
Regulators, RHPS Series catalog, MS-02-430.
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BS10 Series
Flow Coefficient 3.84, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 72 psig (0 to 5.0 bar),
0 to 145 psig (0 to 10.0 bar), and 0 to 290 psig (0 to 20.0 bar)
BS10 Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 290 psig (0 to 20.0 bar)
0 300 600 900 1200 1500
0 to 145 psig (0 to 10.0 bar) 400
80
5
0 0
0 200 400 600 800 1000
25
320
20
Inlet Pressure, psig
240
Flow Coefficient: 3.84 15
Maximum Inlet Pressure: EU
BS10—1015 psig (70 bar)
Inlet Pressure Control 160
10
Range: 0 to 290 psig
(0 to 20.0 bar)
80
5
0 0
0 300 600 900 1200 1500
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BSH10 Series
Flow Coefficient 3.84, Pressure Control Ranges 0 to 580 psig (0 to 40.0 bar), 0 to 1450 psig (0 to 100 bar),
0 to 2610 psig (0 to 180 bar), and 0 to 3625 psig (0 to 250 bar)
BSH10 Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1450 psig (0 to 100 bar)
0 600 1200 1800 2400 3000
0 to 580 psig (0 to 40.0 bar) 2000
1600
0 to 1450 psig (0 to 100 bar)
200
Inlet Pressure, psig
800
100
400
50
0 0
0 800 1600 2400 3200 4000
BSH10 Series
0 800 1600 2400 3200 4000
Nitrogen Flow, Nm3/h 2000
Pressure Control Range Nitrogen Flow, Nm3/h
250
0 to 3625 psig (0 to 250 bar)
0 2400 4800 7200 9600 12 000
0 to 2610 psig (0 to 180 bar) 4000 1600
200 250
Pressure Control Range
psig
bar
3200
Inlet Pressure,
1200
Inlet Pressure,
bar
Inlet Pressure, bar
0 to 2610 psig (0 to 180 bar)
BSH10—3625 psig (250 bar)
2400
Inlet Pressure,
Inlet Pressure,
800
0 50
0
0 600 1200 1800 2400 3000
0 0
Nitrogen Flow, Nm3/h
0 1600 3200 4800 6400 8000
20.0
250
sig
212 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BS15 Series
Flow Coefficient 7.3, Pressure Control Ranges 0 to 43 psig (0 to 3.0 bar), 0 to 72 psig (0 to 5.0 bar),
0BS15
to 145Series
psig (0 to 10.0 bar), and 0 to 290 psig (0 to 20.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 290 psig (0 to 20.0 bar)
0 750 1500 2250 3000 3750 4500
0 to 145 psig (0 to 10.0 bar) 450
30
0 to 72 psig (0 to 5.0 bar)
Pressure Control Range
0 to 43 psig (0 to 3.0 bar)
360
0 to 290 psig (0 to 20.0 bar) 24
Inlet Pressure, psig
90 6
0 0
0 500 1000 1500 2000 2500 3000
360
24
270
18
Flow Coefficient: 7.3
Maximum Inlet Pressure: EU
BS15—1015 psig (70 bar)
Inlet Pressure Control 12 180
0 0
0 750 1500 2250 3000 3750 4500
3.0
2.4
Pa
Pressure-Reducing Regulator Flow Curves 213
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
BSH15 Series
Flow Coefficient 7.3, Pressure Control Ranges 0 to 580 psig (0 to 40.0 bar), 0 to 1450 psig (0 to 100 bar),
0 to 2610 psig (0 to 180 bar), and 0 to 3625 psig (0 to 250 bar)
BSH15 Series
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 1450 psig (0 to 100 bar)
0 3000 6000 9000 12 000 15 000
0 to 580 psig (0 to 40.0 bar) 2000
1600
0 to 1450 psig (0 to 100 bar)
100
Inlet Pressure, psig
800
50
400
25
0 0
0 2000 4000 6000 8000 10 000
100
psig psig
3200
bar bar
0 to 3625 psig (0 to 250 bar)
200
Pressure,
1200
Pressure,
Pressure,
2400
Pressure,
50
Range: 0 to 1450 psig
1600
(0 to 100 bar) 100
400
25
800
50
0 0
0 3000 6000 9000 12 000 15 000
0 0
0 4000 8000 12 000 16 000 20 000
NitrogenFlow,
Nitrogen Flow,std
Nmft33/h
/min
Nitrogen Flow, std ft3/min
Nitrogen Flow, std ft3/min
250
10.0
psig
3200
214 Pressure-Reducing Regulator Flow Curves
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LBS4 Series
Flow Coefficient: 1.3, Pressure Control Range 0 to 43 psig (0 to 3.0 bar)
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 43 psig (0 to 3.0 bar) 0 15 30 45 60 75 90
60
4.0
50
3.0
Inlet Pressure, psig
30 USA
2.0
20
1.0
10
0 0
0 10 20 30 40 50 60
LBS4 Series
Flow Coefficient: 1.3, Pressure Control Range 0 to 290 psig (0 to 20.0 bar)
0 10 20 30 40 50 60
Pressure Control Range Nitrogen Flow, Nm3/h 60
4,0
0 to 130 psig (0 to 9.0 bar) 0 75 150 225 300 375 450
0 to 290 psig (0 to 20.0 bar) 400 50
3,0 24
40
300
20
EUR
Inlet Pressure, psig
30
2,0
16
200 20
US
12
1,0
10
8.0
100
0 04.0
0 15 30 45 60 75 90
0 0
0 50 100 150 200 250 300
Flow Data
The graphs illustrate the change or “droop” in outlet pressures as the flow rate increases.
For more flow curve information, contact your authorized Swagelok representative.
LBS4 Series
LBS4Coefficient:
Flow with Metal 1.3,
Diaphragm
Pressure Control Range 0 to 43 psig (0 to 3.0 bar)
Nitrogen Flow, Nm3/h
Pressure Control Range Nitrogen Flow, Nm3/h
0 to 43 psig (0 to 3.0 bar)
0 15 30 45 60 75
120
4.8
60
3.6
40
2.4
20
1.2
0 0
0 10 20 30 40 50
psig
80
bar
18
250
4.8
Inlet Pressure,
Inlet Pressure,
to 130 psig (0 to 9 bar)
Maximum Inlet Pressure: 15
60
psig
bar
LBS4—507 psig (35.0 bar) 200
3.6
Inlet Pressure Control Inlet Pressure,
Inlet Pressure,
Range: 0 to 43 psig 12
40
(0 to 3.0 bar) 2.4
150
9
1.2 20
100
6
0 0
50 0 15 30 45 60 75
3
WARNING
Do not mix/interchange Swagelok products or
components not governed by industrial design
standards, including Swagelok tube fitting end Swagelok—TM Swagelok Company
connections, with those of other manufacturers. © 2013–2022 Swagelok Company
MS-06-114, RevF, January 2022