Professional Documents
Culture Documents
Full Download Fundamentals of Chemical Engineering Thermodynamics Si Edition 1st Edition Dahm Solutions Manual
Full Download Fundamentals of Chemical Engineering Thermodynamics Si Edition 1st Edition Dahm Solutions Manual
Full Download Fundamentals of Chemical Engineering Thermodynamics Si Edition 1st Edition Dahm Solutions Manual
https://testbankfan.com/download/fundamentals-of-chemical-engineering-thermodyna
mics-si-edition-1st-edition-dahm-solutions-manual/
A. When you are heating water on your stove, before the water reaches 373 K, you
see little bubbles of gas forming. What is that, and why does that happen?
B. Is it possible to make water boil at below 373 K? If so, how?
C. What is the difference between “evaporation” and “boiling?”
Solution:
A. The small bubbles that form on the bottom of the pot are dissolved air. As
temperature goes up, air becomes less soluble in water. Since the water right next to
the bottom is hottest, the bubbles usually appear to be coming from particular spots at
or near the bottom. Full boil occurs when the temperature of the entire liquid body
reaches 373.15 K (if the pressure is atmospheric).
B. It is possible to make water boil below 373 K by lowering the pressure of the
surroundings. Water boils at a specific pressure or temperature; if you change the
pressure, the boiling temperature also changes. A temperature of less than 373 K
requires a pressure less than 0.1 MPa to boil.
C. Evaporation only occurs on the surface of the liquid, but boiling occurs throughout
the bulk of the liquid. Another way of thinking of it is that evaporation can only occur
if there is already a vapor phase above the liquid (such as the air above an open pot of
water on the stove). When a liquid boils, bubbles of vapor form inside the bulk of the
liquid; a “new” vapor phase can be created.
Boiling happens when the liquid atoms become so energized that they can overcome
the intermolecular forces holding them together which allows them to leave the liquid
phase. Evaporation occurs because not all atoms in the liquid are moving at the same
speed; even if the average molecular energy isn’t sufficient for boiling, the fastest
moving particles can overcome intermolecular forces binding them to their nearest
neighbors and escape into the vapor phase. Further, atoms in the bulk of liquid
experience intermolecular forces from all around them. Atoms at a surface feel forces
only from the atoms beneath them. This allows the surface atoms to escape into the
vapor phase more readily.
21
© 2015 Cengage Learning. All Rights Reserved. May not be scanned, copied or duplicated, or posted to a publicly accessible website, in whole or in part.
liquid phase at 298.15 K and 0.1 MPa; the water cannot evaporate unless there is a vapor
phase (air) for it to evaporate into. Water at 298.15 K will not boil unless the pressure is
lowered all the way to 3.17 kPa absolute.
2-11. 10 mol/s of gas flow through a turbine. Find the change in enthalpy that the gas
experiences:
A. The gas is steam, with an inlet temperature and pressure T = 873.15 K and P = 1
MPa, and an outlet temperature and pressure T = 673.15 K and P = 0.1 MPa. Use
the steam tables.
B. The gas is steam, with the same inlet and outlet conditions as in part A. Model the
steam as an ideal gas using the value of C*P given in Appendix D.
C. The gas is nitrogen, with an inlet temperature and pressure of T = 300 K and P = 1
MPa, and an outlet temperature and pressure T = 200 K and P = 0.1 MPa. Use
Figure 2-3.
D. The gas is nitrogen with the same inlet and outlet conditions as in part C. Model
the nitrogen as an ideal gas using the value of C*P given in Appendix D.
E. Compare the answers to A and B, and the answers to C and D. Comment on
whether they are significantly different from each other, and if so, why.
Solution:
A. Using the steam tables:
̂
̂ ̂ ̂
Therefore:
( )
22
© 2015 Cengage Learning. All Rights Reserved. May not be scanned, copied or duplicated, or posted to a publicly accessible website, in whole or in part.
Chapter 2: The Physical Properties of Pure Compounds
∫ ∫ ( )
̂ ̂ ̂
[ ( ) ( ) ( ) ( )
( )]
Reading from the appendix, the coefficients are shown in the table below.
Let us calculate!
̂ { [ ]
[( ) ( ) ]
[( ) ( ) ]
[( ) ( ) ]
[( ) ( ) ]}
̂ ( )( )
̂ ̂ ̂
23
© 2015 Cengage Learning. All Rights Reserved. May not be scanned, copied or duplicated, or posted to a publicly accessible website, in whole or in part.
Another random document with
no related content on Scribd:
One Perch to Fifty Acres and upwards in extent, and intended for the
instruction of those who know little of Gardening and rural affairs.
ENVELOPES, from the best Paper, and well made, 9d. the 100.
Envelope Cases in great variety, plain and illuminated, from 6s.
each. Blotting Books, from 1s. each. An extensive assortment of
Albums, in plain and elegant bindings. A Box to hold Miscellaneous
Music, elegantly bound, for 5s. 6d. A Travelling Writing Desk, 10
inches, 15s. 6d.; 12 inches, 16s. 6d.; 14 inches, 18s. Writing Papers,
plain and gilt, 4d., 6d., 8d., 10d., and 1s., the quire. Note Papers, at
3d., 4d., and 6d. the quire, at LIMBIRD’S STATIONERY and MUSIC
WAREHOUSE, 143, Strand, opposite Catherine Street, near
Somerset House.
These Pens are made in every variety, suitable for the MEDICAL
and LEGAL PROFESSIONS, BANKING, MERCANTILE, and
GENERAL PURPOSES, and for SCHOOLS.
It is requisite to state, as a general
“CAUTION,” that the name, “JOSEPH
GILLOTT,” is marked in full on EVERY
GENUINE PEN, and Vendors are
desired to note that his Cards of Pens
are made up in Packets of One Dozen each, and have a label
outside, with a fac-simile of his Signature.
The Genuine GILLOTT’S PENS may usually be obtained at the
regular dealers’ shops at as low prices as are generally demanded
by itinerant dealers, and others, for those very inferior articles which
are frequently palmed upon the Public as the real GILLOTT’S PENS.
☞ At the request of Persons extensively engaged in Tuition, J. G.
has introduced his WARRANTED SCHOOL PENS, which are
especially adapted to their use, being of different degrees of
flexibility, and with fine, medium, and broad points.
WHOLESALE AND FOR EXPORTATION AT THE
WAREHOUSE, 95, NEW-STREET, BIRMINGHAM,
ALSO AT
37, GRACECHURCH-STREET, LONDON,
Under the Management of Mr. FOX, from the Manufactory, or from
any of the WHOLESALE STATIONERS and MERCHANTS in
London, &c.
The great superiority of these Pens has induced their entire
adoption in the Bank of England and Her Majesty’s Public Offices,
where it is known none but the best articles are admitted: such as
the Home and Foreign Offices, the Admiralty and other Public
Boards, the Offices of the India Board, the various Offices at
Somerset-House, the British Museum Library, &c., the General Post-
Office, and others; as well as by a large number of Bankers,
Merchants, and Manufacturers, throughout the Country, and many
Public and Private Schools.
CAUTION TO FAMILIES.
The high reputation of, and consequent great demand for the
undermentioned Preparations, have excited the cupidity of some
SHOPKEEPERS of apparent respectability, but destitute alike of
honour and of talent, who, for the sake of gaining a trifle more profit,
basely attempt to impose their pernicious compounds upon the
public as the real “MACASSAR OIL” for the Hair, and “KALYDOR” for
the Complexion; they copy the bills and labels of the original articles,
substituting either a fictitious name or the word “GENUINE” in the
place of “ROWLAND’S.”
To frustrate such imposition—it is necessary on purchasing either
article, to see that the word “ROWLAND’S” is on the wrapper, as
follows, without which None are Genuine.
ROWLAND’S KALYDOR,
for the Skin and Complexion.—Price 4s. 6d. and 8s. 6d. per bottle.
ROWLAND’S ODONTO,
Or PEARL DENTRIFICE,
renders the Teeth beautifully White, and preserves the Gums.
Price 2s. 9d. per box, duty included.
A. ROWLAND & SON, 20, HATTON GARDEN, LONDON,
is written in red on the wrappers of the Macassar Oil and Kalydor,
and engraven on the Government Stamp affixed on the Kalydor
and the Odonto.
Be sure to ask for “Rowland’s” Articles.
Sold by them and by respectable Chemists and Perfumers.
DAGUERREOTYPE OR
PHOTOGRAPHIC PORTRAITS.
PORTRAITS by Mr. CLAUDET’S INSTANTANEOUS PROCESS,
under the Patronage of her Majesty, are taken daily at the
ADELAIDE GALLERY, LOWTHER ARCADE, STRAND. The Sitting
generally occupies less than One Second, by which faithful and
pleasing Likenesses are obtained, with backgrounds, the patented
invention of Mr. Claudet, representing Landscapes, the Interior of a
Library, &c. &c.
Price of a Single Portrait, usual size, One Guinea. Portraits and
Groups are also taken on Plates of an enlarged size, and for Lockets
or Brooches as small as may be required.
PAINTED GLASS,
In the ancient or modern style, from the most simple to the richest
designs. Ruby and other Coloured Glass equal to the ancient.
GLASS SHADES,
Round, Oval, or Square, for the preservation of Clocks, Alabaster
Ornaments, Minerals, &c. &c.
Sold, Wholesale and Retail, by CLAUDET & HOUGHTON, at their
Plate, Crown, Sheet, Fluted, and Painted Window Glass
and Glass Shade Warehouse, 89, HIGH HOLBORN, where
Lists of Prices may be had.
TO THE CLERGY.
CITY EQUITABLE CLOTHING ESTABLISHMENT, FLEET-STREET
(Three Doors from Temple-bar).
G. EVANS respectfully yet fearlessly submits the following SCALE
of CONTRACTS to the careful perusal of gentlemen who have been
accustomed to pay exorbitant prices, and to assure them that the
articles will be of the best materials and workmanship, as he intends
to continue that honest and just principle of doing business which he
has hitherto pursued, and which he is happy to find has given such
general satisfaction. His long experience in cutting has qualified him
to give a good fit, and his matured judgment enables him to select
none but the best materials.
Naval and Military Uniforms strictly to regulation, with a careful
regard to economy. Liveries unusually low, considering the superior
articles invariably supplied. Ladies’ Riding Habits, not to be
surpassed in style, quality, or price. Young Gentlemen’s Clothing at
extremely moderate prices.
A List of Prices forwarded to gentlemen who do not wish to
contract.
TABLE OF CONTRACT.