Professional Documents
Culture Documents
Ihp QP Nov - 2022
Ihp QP Nov - 2022
Seat
No. Set P
T.Y (B.Tech.) (Sem-I) (New) (CBCS) Examination: Oct/Nov-2022
MECHANICAL ENGINEERING
Industrial Hydraulics & Pneumatics
Day & Date: Thursday 09-02-2023 Max. Marks: 70
Time: 10:00 AM To 01:00 PM
Instructions: 1) Q. No. 1 is compulsory and should be solved in first 30 minutes in Answer
Book. Page No.3 (starting page of the Answer Book). Each questions
carry one mark.
2) Don’t forget to mention Question Paper Set (P/Q/R/S) at the top of the
same page.
3) Figures to the right indicates full marks.
4) Assume suitable data wherever needed and mention it clearly.
Page 1 of 12
SLR-HL-94
Set P
7) In counter balancing circuit holding pressure is used to ______.
a) To prevent falling of the load while descending
b) To allow falling of the load while descending
c) To prevent raising of the load while ascending
d) All of the above
8) The regenerative circuit of a double - acting cylinder is used _____.
a) To increase the out-stroke speed of piston
b) To decrease the out-stroke speed of piston
c) To increase the inward stroke speed of piston
d) Both b & c
9) A pneumatic symbol is: ______.
a) Different from a hydraulic part used for the same function
b) The same as a hydraulic part used for the same function
c) Not to be compared to a hydraulic part used for the same function
d) All of above
10) How is reverse flow possible in pilot operated check valve?
a) Spring force lifts the ball due to which reverse flow is possible
b) Fluid pressure lifts the ball due to which reverse flow is possible
c) Both a and b
d) None of the above
11) Mostly Service unit (FRL) is _____.
a) At outlet of compressor b) At inlet of the compressor
c) Both a and b d) All of the above
12) A pressure relief valve can be ______.
a) Direct operated b) Pilot operated
c) Solenoid operated d) All the above
13) Time delay valve is _____.
a) Pneumatic Pressure Control Valve
b) Pneumatic Direction Control Valve
c) Pneumatic Flow Control Valve
d) Hydraulic Pressure Control Valve
14) Why the pilot operated check valve used in clamping operation?
a) To reduce leakage in spool valve
b) To avoid decrease in pressure during clamping
c) Both a and b
d) None of the above
Page 2 of 12
SLR-HL-94
Seat
No. Set P
T.Y (B.Tech.) (Sem-I) (New) (CBCS) Examination: Oct/Nov-2022
MECHANICAL ENGINEERING
Industrial Hydraulics & Pneumatics
Day & Date: Thursday 09-02-2023 Max. Marks: 56
Time: 10:00 AM To 01:00 PM
Instructions: 1) All questions are compulsory.
2) Figures to the right indicates full marks.
3) Assume suitable data wherever needed and mention it clearly.
4) Use of non-programmable calculator is allowed.
Section – I
Section – II
Page 3 of 12