Professional Documents
Culture Documents
For Cat 1... Questions
For Cat 1... Questions
SCHOOL OF ENGINEERING
DEPARTMENTOFMECHANICALANDENERGYENGINEERING
CAT-1
YEAR:1 SEMESTER:IIGROUP:INFORMATIONTECHNOLOGY
MODULE:MEE1167ENGINEERINGDRAWINGANDCAD
DATE:18/10/2021 TIME:2hours
MAXIMUMMARKS=30
QUESTIONONE[6MARKS]
a. Fig.Q1showsanisometricprojectionofasolidobject;thearrowindicatesthedirectiontoo
btaintheviewfromthefront.DrawthefollowingviewsinFirstAngleProjection.Scale1
:1,dimensions:mm
i. Frontview [2Marks]
ii. TopView [2Marks]
iii. Rightview [2Marks]
Fig.(Q1)
QUESTIONTWO[10MARKS]
i. Usingtheconcentriccirclesmethod,Drawanellipsewithamajordiameterof100mmand
minordiameterof40mm.[4Marks]
ii. Fig.Q(2)showsorthographicviewsofasupportbracket.Drawanisometricprojectionoft
hebracketwiththecornerAasthelowestpointonthedrawing.[6Marks]
Fig.(Q2)ShaftSupport
QUESTION3[12Marks]
A. TheFig.
(Q3)showstheisometricviewofashaftsupportwhichistobesectionedalongaverticalpla
neasshown.DrawtheTopandfullsectionfrontviewinThirdangleprojectionasviewedalo
ngA-A.Alldimensionsareinmm.[6Marks]
B. ConsideringthefollowingTopandFrontviewsinThirdAngleProjection,completethemw
ithRightsideviewusingMiterLineTechnique.BuildIsometricanddon’tputdimens
ions.Indicatethefrontviewwithanarrow.
[8Marks]
END!!!!
MARKINGSCHEME:
ENGINEERINGDRAWINGANDCAD–2019-2020
QUESTIONONE[10Marks]
Marksdistribution
TopView CorrectlydrawnTopview 1mark
Correctrepresentationofhiddendetails 1mark
FrontView Correctlydrawnfrontview 1mark
Correctrepresentationofhiddendetails 1mark
RightView CorrectlydrawnRightview 1mark
Correctrepresentationofhiddendetails 1mark
QUESTIONTWO[10Marks]
i. Ellipsewithmajordiameterof100mmandminordiameterof40mm.
[4Marks]
ii. Isometric[6Marks]
Locationoffeatures 1mk
Isometriccircles 1.5mks
Tangencies 1mk
Lineconstruction 1mk
Dimensions 1mk
Lineworkandneatness 0.5mks
SectionedFrontVie Correctlydrawnfrontviewin1stAngleprojection 1mark
w Correctsectioning 1mark
Correctdimensioning 1mark
TopView CorrectlydrawnTopviewin1stAngleprojection 1mark
Correctdimensioning 1mark