Professional Documents
Culture Documents
7in Casing Circ Inflate Modules 700-CE-11B & C, 11-CE-11A
7in Casing Circ Inflate Modules 700-CE-11B & C, 11-CE-11A
7in Casing Circ Inflate Modules 700-CE-11B & C, 11-CE-11A
Technical Manual
7” Casing Circulator
Inflation Modules
700-CE-11B
700-CE-11C
11-CE-11A
CE.05.D
Revision D
Revision Issue Date: January 10, 2006
Prepared By: C.O. Stokley
Table of Contents
Section 1
Description 3
Section 2
Assembly Drawing, Parts List 4
Section 3
Assembly Procedure 7
Testing Procedure 11
Section 4
Disassembly and Inspection Procedure 13
Revision Notice
Revision C Update Assembly Drawing, Change pg. 8 & 10, Delete “Tools Required”
Revision D Update Assembly Drawings
7” Casing Circulator
700-CE-11B, 700-CE-11C, 11-CE-11A
The 7” CASING CIRCULATOR Inflation Modules provide the means to inflate a packer
and seal against the ID of the casing, allowing circulation from the casing shoe.
Section 3
Assembly Procedure
l
Assure that the latest Revision Level Assembly Drawings, 700-CE-11B, 700-CE-11C,
and 11-CE-11A are utilized.
The lower end of the TUBE has a sealing area undercut approximately 12” long.
The top end does not.
CONNECTOR
PACKER
TUBE
INFLATION
ELEMENT
7. Slide PACKER SUB (700-CE-25) over PACKER TUBE and make up into
INFLATION ELEMENT and torque to 10,000 ft-lbs.
PACKER
SUB
THREAD
PROTECTOR
9. Go to TEST SECTION.
10. Place DRILL COLLAR (700-CE-17B) in vise with TUBE A extending outward.
The lower end of the TUBE has a sealing area undercut approximately 12” long.
The top end does not.
11. Make up CONNECTOR, 11” (11-CE-125) into DRILL COLLAR with 14,000 ft-
lbs torque.
12. Make up PACKER TUBE (700-CE-40) onto the CONNECTOR with the sealing
area facing away from the CONNECTOR and torque to 7,000 ft-lbs.
14. Slide INFLATION ELEMENT (11-IE-17, 14” OD) over PACKER TUBE.
16. Slide PACKER SUB (11-CE-25) over PACKER TUBE and make up into
INFLATION ELEMENT and torque to 12,000 ft-lbs.
17. Install THREAD PROTECTOR (700-CE-83) on lower end of tool, hand tight.
1. Install the correct size test scabbard over the INFLATION ELEMENT.
SCABBARD
4. Pump through tool and purge all air from the system.
11. Purge all air and Test ID of tool assembly to 3,000 psi for 15 minutes.
Section 4
Disassembly & Inspection Procedure