Professional Documents
Culture Documents
Assignment # 03
Assignment # 03
Assignment # 03
Total Pages 2
Page 1 of 2
Please turn over
Continued From Overleaf
Q1. A concentrated load of 1000N is applied on a simply supported beam as shown in the figure below.
The beam is to be designed in such way that it has minimum weight without exceeding the allowable
stress. In order to minimize the weight, we need to find the optimum cross sectional dimensions of the
beam. The width and height of the beam should not be less than 10mm and the maximum stress at any
point on the beam must not exceed 200MPa. The material of the beam is steel having a modulus of
elasticity of 200GPa. Analyze the beam and optimize the design variables i.e., find optimum beam
dimensions using FEA Package (ANSYS).
[ | CLO3 | C4 | PLO5 | CP1, CP2 & CP3]
Page 2 of 2
Please turn over