Professional Documents
Culture Documents
L3VPN
L3VPN
Access PE
(Juniper PE)
1. Get subinterfaces with Node ID (monitor & data)
#show interfaces descriptions | match NID
9. If the device is switch then get the mac of CE with subint data
#show arp interfaces ge-x/x/x.1190
(Cisco) R17C-C-EG
1. Get subinterfaces with NID (monitor & data)
#show interfaces descriptions | include NID
2. Get VLAN & VRF name & IP Next device from subinterface data & monitor
#show run interfaces gx/x/x.1190
6. If the device is switch then get the mac of MSAN with subint data
#show ip arp interface vrf we ge-x/x/x.1190
Access Switch
1. Connect to the switch with its name
#Fawala-S01C-C-EG
4. Check speed & SNR & attenuation of the downlink (shl 0/18/3)
#interface shl 0/18
#display line state 3
#return (exit from interface)
6. Check the last down & up time of the downlink (shl 0/18/3)
#display interface shdsl 0/18/3
7. Compare time
#display time
3. Check the port state, speed, SNR and attenuation of the downlink (shl
0/18/3)
#show shdsl port-status shdsl_0/18/3
4. Check logs of the downlink (shl 0/18/3)
#show logging alarmlog | include shdsl_0/18/3
5. Check the last down & up time of the downlink (shl 0/18/3)
#show interface shdsl_0/18/3
6. Compare time
#show clock
4. Check speed & SNR & attenuation of the downlink (shl 0/18/3)
Show shdsl segment-status 0/18/3
5. Compare Speed
#info configure shdsl span 0/18/3
(Cisco) R17C-C-EG
1. Check the router uptime
#show version | include uptime
2. Compare Time
#show clock
(Aethra - ATOS)
1. Connect to the modem ATOS from Cisco PE and see Version of ATOS (if
boot version is 1.10.0.0 is Layer1)
#telnet 5.x.x.162 /vrf vpnmonitor /source-interface gix/x/x.1191
2. Check if the port is serial
>ntp
>ntp>> fr-iwf-1
>ntp>fr-iwf-1>> show conf
(Atrie) AT-510D
(This device hasn’t ping source)
1. Check the power
#show device information