Professional Documents
Culture Documents
Practical Problems - Questionnaire
Practical Problems - Questionnaire
Practical Problems - Questionnaire
2. The two most common sizes of pipe wrenches used by a 10. The rims of the bowl used for the handicap toilets and
plumber are: nonhandicap toilets ___.
21.Heat exchangers transfer heat from a hot object, vapor a. is fire rated
or fluid to ___.
b. has a wooden studs
b. convert the hest electricity d. none of these; codes do not dictate metal
boxes
c. heat an occupied space only
d. none of these
29. During the rough-in phase, all stub-out pipes are __
22.Approximately how much does 8.1 gallons of water
a. cut off flush with the finished wall
weight?
b. capped or plugged
a. 69.4 lbs
c. not installed until after the DWV test
b. 83.8 lbs
c. 8.33 lbs d. converted to a threaded connection
d. 813 lbs
a. Chain Tong
a. it is no allowed in commercial applications
b. Strap Wrench
b. does not have a hot and cold water
connection c. Adjustable Wrench
c. a hot and cold water connection d. Basin Wrench
a. Adjustable Wrench
b. Basin Wrench
c. Internal Wrench
d. One Stop Wrench
FIGURE F
FIGURE A
a. allen
b. bristol
c. double-hex
d. flat or slot
a. bristol
b. double-hex
32. Identify WR-02 as shown in Figure A
c. flat or slot
a. Straight Pipe Wrench d. hex
b. Rapidgrid Wrench
b.Raprench Wrench
c. Offset Pipe Wrench
40. Identify SC-12 as shown in Figure F
d. Hex Wrench
a. security torx
b. spanner head
34. Identify WR-09 as shown in Figure A
c. spline
a. Chain Wrench d. square
b. Compound Leverage Wrench
41. Identify SC-16 as shown in Figure F
c. Chain Tong
a. spline b. Outside Caulking Iron
b. square c. Inside Caulking Iron
c. torq set
d. Pickout Iron
d. torx
FIGURE I
FIGURE H
43. Identify CI-03 as shown in Figure H 49. Identify PL-08 as shown in Figure I
44. Identify CI-05 as shown in Figure H 50. Identify PL-10 as shown in Figure I
45. Identify CI-07 as shown in Figure H 51. Identify PL-15 as shown in Figure I
46. Identify CI-13 as shown in Figure H 52. When hot water flows from the water heater storage
tank:
a. Large Pattern Yarning Packing Iron
a. an equal amount of cold water enters d. bolted
53. A water heater listed in sizing chart for 100 degrees a. siltation
temperature rise (TR):
b. sedimentation
c. screening
a. is only used for non residential applications
d. filtration
b. is only used for residential applications
c. provides more gph than the first-hour listing
in the chart
61. It is a valve placed on water main to which the water
d. none of the above service of the building is connected.
54. To find the gph demand of a water heater system: a. corporation cock
a. calculate the gph flow of all appliances, b. curb cock
fixtures and equipment
c. water meter
b. multiply all gpm calculations by 60 (minutes)
d. stop cock
c. both a & b
d. none of the above
62. NFPA classifies fires as class ___ by flammable liquid,
55. BTUH is the abbreviation for: gases, or grease
d. hacksaw
71. How does evaporation of the trap seal of a fixture is c. check valve
being eliminated? d. disk valve
a.inside a room
b. proper ventillaton
82. It has a deeper and broader hook jaw housing which
c. frequently used provided a smooth, flat surface that maybe used
d. installed vacuum breaker ocassionally as a hammer.
b. check valve
a. class A
c. open wrench
b. class B
d. closed wrench
c. class K
84. Which of the following is not a commercial size of d. class C
galvanized steel pipe?
91. CISPI stands for:
a. 2 inches
b. 2 3/4 inches a. Cast Iron and Steel Institute
c. 1 1/2 inches b. Cast Iron and Steel Pipe Institute
d. 1 inch c. Cast Iron Soil Pipe Institute
d. none of the above
a. pipe wrench
b. strap wrench 95. A jackhammer is typically powered by electricity or ___.
c. torque wrench
a. pneumatically (with air)
d. chain wrench
b. by battery
c. with gasoline
88. What causes the bad taste and odor of water? d. hydraulically
a. lack of oxygen
b. the presence of algae 96. ECO s the abbreviation for:
c. end cleanout
d. none of the above
89. It is an adjustable cast iron box that is flash with finished 97. The headwall of a shower means;
grade and its capped with removable iron cover.
a. the drain closer to the side of shower
a. stop cock b. the faucet is on the wall
b. stop box
c. it is a tiled wall
c. corporation cock d. it is wider than other shower wall
d. none of the above 98. what should we use to remove the gloss on the ends of
a rigid plastic pipe?
90. Class ___ fire extinguishers are identified by blue color
inside a circle a. steel wool
b. sand paper
c. emery cloth
d. knife
a. 63 mm diameter
b. 51 mm diameter
c. 76 mm diameter
d. 110 mm diameter