Professional Documents
Culture Documents
Service Documentation: Market Release 3/95
Service Documentation: Market Release 3/95
Service Documentation: Market Release 3/95
5296
BINC Rev: 7/96 Service Documentation
Exploded Drawing
BAG Rev: 3/95 5296
5296-2
BINC Rev: 7/96 Service Documentation
Spare Parts List
BAG Rev: 12/95 5296
5296-3
BINC Rev: 7/96 Service Documentation
Exploded Drawing
BAG Rev: 3/95 5296
5296-4
BINC Rev: 7/96 Service Documentation
Spare Parts List
BAG Rev: 1/96 5296
5296-5
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 3/95 5296
Housing (3, 14) The housing front part is snapped into the housing
back part by means of 4 notches "A".
By inserting a ring pliers on the right and left side
of the driving toothed wheel, press the housing
halves apart until the upper 2 notches “A” are
snapped out. Now, tear appart the housing halves
while snapping out all notches on the frame (4)
and the housing parts.
5296-6
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 3/95 5296
Note Power supply plug (15) The "H"-head housing screws (17) are required
for safety reasons and are an integral part of the
approval specification. It is not allowed to
replace them, for example, with ordinary
commercially available screws with slotted or
cross-slotted heads.
PCB (9) Snap the frame (4) into housing front part (l4).
Check if switch contact (13) is placed correctly.
Insert PCB (9) in the indentations of notch "A" in
the upper left side of the housing front part (14).
Snap connecting socket into frame.
Attention for function check only the 12 V power supply plug should be used.
The pincette disks of the hair plucker head have to turn in the direction of the
operating slider.
5296-7