Professional Documents
Culture Documents
Service Documentation: Market Release 7/86
Service Documentation: Market Release 7/86
5556
BINC Rev: 7/96 Service Documentation
Exploded Drawing
BAG Rev: 10/89 5556
5556 - 2
BINC Rev: 1/00 Service Documentation
Spare Parts List
BAG Rev: 2/95 5556
5556 - 3
BINC Rev: 7/96 Service Documentation
Spare Parts List
BAG Rev: 2/95 5556
5556 - 4
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 8/92 5556
Description of shaver
General Information
Power supply: Supply by means of one built-in rechargeable battery or by direct mains
supply. A built-in electronic charger controls the supply automatically, inde-
pendently of the mains voltage or frequency. Charging of the shaver is
indicated by a red or green control lamp.
After maximum charging capacity has been reached, the electronic device
switches back to a compensating trickle charge. A special charging cable
with fuse is available, for use with outlets in car or boats. The most
favorable ambient temperatures for shaver functioning is between + 15 °C
and + 35 °C. By no means the temperature should be below 0 °C or above +
40 °C when charging the shaver.
Technical data
5556 - 5
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 10/89 5556
Disassembly
• Disconnect unit from mains outlet. Take-off cutting parts and cutter block support (6).
• Remove housing screws (32,33) and pull-off housing cover (9) and housing bottom (30).
• Be careful: leg spring (12) will jump out!
• Un-solder connecting wires from motor, disengage plug plate and remove printed circuit
board (27).
• Lift-off insulating part (26), remove screws (23) and take out motor by pulling downwards.
• Remove screws (17), lift-off cover plate (16) and pull oscillator with eccenter (15) from
shaft (14).
Assembly
ATTENTION:
Because of safety reasons, no repairs should be made on PCB (27). The PCB is protected against
humidity with a special lacquer.
5556 - 6
BINC Rev: 1/00 Service Documentation
Service Information
BAG Rev: 2/95 5556
As from the 32nd week of 1992, all Braun universal shavers for men will be furnished with
ecologically friendly batteries and all relevant PCBs to be used as spare parts will have this new
battery. This requires a rebuilding of the micron plus universal shavers which come in for repair
with a defective PCB.
The new PCB contains only one battery and, consequently, along with a exchange of the PCB, the
old 2.4 V motor must be replaced with a 1.2 V motor.
This also causes a different charging characteristic: After being fully charged the green charging
diode switches off.
From the 4th week of 1995 the rebuilding set Ni-Hy (5569650) is no longer available from
Germany and in the case of a rebuild, the following parts should be ordered however, there is a
limited number of rebuilding kits left in our inventory. Please call to see if still available.
5556 - 7