Professional Documents
Culture Documents
Product Characteristics
Product Characteristics
The lamp is designed to illuminate small open spaces: the façade of buildings, monuments,
advertisements, etc. The body is made as a pressure sielumina casting and the reflector pea
lined aluminum sheet. The connection cube is located in a plastic housing with cable
connection. The light source is protected by tempered glass glass with the frame-mounted
silicone seal. The lamp is fixed with the the possibility of setting the housing in the vertical
plane at the right angle.
ENVIRONMENTAL PROTECTION
ENVIRONMENTAL PROTECTION It is forbidden to throw power tools at Junk email filter. In
line with the European ,2012/19/on the scrapping power tools and equipment and
converting it into right, power tools must be collected separately and returned to the point
of collection of secondary raw materials. Recycling, as a return of the device: Alternately to
the obligation to return the device after the end of the use, the is obliged to participate in its
proper Disposal. The device withdrawn from the exploits can also be returned to the
collection point secondary raw materials, which will carry out a case with national rules on
the waste and the use of secondary raw materials. This does not apply to fittings belonging
to the equipment and ancillary measures not containing components
Electrical.waste is threatened by the penalties provided for in local laws. Users in European
Union countries If necessary dispose of electrical or electronic equipment, please contact
your closest to the point of sale or with the supplier who provide additional information.
Disposal of waste in countries outside the European Union Such a symbol will only be used
by countries Union If necessary to dispose of this product, please contact your local or the
seller for information about the correct course of action.
POWER CONNECTION
It is recommended that the chain be used for the operation of the larger rendition than N)
rr1A The basis may be be executed person or legally ordained. 1835 / 1829 Unscrew the
clamping screws.cable cap. Unscrew the screws and see it. Unscrew the rinsing screw and
tighten onto the cable. Through the gasket enter the interior)
Install the pressure, yes, power supply . D-tightening the rinsing screw and mount the can
cover . Control the condition of the power cord, gaskets and arrangement. If you notice any
power cord 3 immediately with the pin of it. Prohibited use of the lamp with damaged
power cable. i is an electric shock. In the case of a lamp equipped with a power cable
( 1834/2014/2015), in case of , ask to the cultivation of the bar or the manufacturer's
service. MONTAZ AND ZARNIC REPLACEMENT Halogen Turn the lamp out and let it cool
down before changing it. Unscrew the screw the lens' reaction. Open the front part of the
lamp by unscrewing the screw above the glass safe and remove the glass. Remove the old
light bulb twisting it slightly to the left, until the right part of the bulb is out of the holder.
Pull the lightly into the protruding part of the bulb. Note! Never touched a new bulb bare
hands. Fats on the skin may have resulted in a reduction in the time use of the light bulb or
its damage. With installation of a new bulb, use gloves protective or clean, rrige-line fabric.
(Fig. B) Fix the bulb in the holder and push slightly to the left until the right side of the bulb
will not be in the property. Close the lens frame and tighten the screw so as to ensure the
tightness of the lamp. The lamp cannot be used before mounting and securing the glass.
Note! It is forbidden to install filament of a different type and power than the instructions!