Professional Documents
Culture Documents
Removing and Installing Upper A-Pillar Trim: Chapter Chapter
Removing and Installing Upper A-Pillar Trim: Chapter Chapter
WARNING
Observe the safety precautions for working on airbags → Chapter and head airbags → Chapter.
1 - Upper A-pillar
trim
Removing:
– Remove sun
visor
→ Chapter.
– Fold down
roof grab
handle -5-.
– Fold down
flap over
bolts at roof
grab handle -
4-.
– Screw out
bolts -2-.
– Unclip airbag
label -9- at
rear (at B-
pillar) and
pull off.
– Screw bolt
out of airbag
label.
– Pull out
upper A-
pillar trim -1-
beneath
upper B-
pillar trim
and unfasten
vw-wi://rl/A.en-GB.A03.5902.89.wi::25580490.xml?xsl=3 10.09.2008
Removing and installing upper A-pillar trim Page 2 of 2
the three
clips -3-.
– Pull out upper A-pillar trim -1- to rear.
Installing:
Caution
Always keep to A-pillar trim installation sequence.
– Guide in upper A-pillar trim -1- at front between rubber door seal and side panel.
– Guide trim retainer -10- into corresponding clip.
– Secure upper A-pillar trim -1- with the three clips -3-.
– Slide trim beneath upper B-pillar trim.
– Make sure clip and metal hook of head airbag adapter are firmly engaged.
Caution
Make sure trim is a firm fit.
2 - Bolts (2x)
Tightening torque 4 Nm
Self-locking
Always replace after removing
Tapped holes for bolts are always to be cleaned (e.g. with a thread cutter).
3 - Clips (3x)
6 - Mounts
7 - Groove
8 - Seal
Make sure seal is properly positioned after fitting trim.
9 - Airbag label
10 - Retainer
vw-wi://rl/A.en-GB.A03.5902.89.wi::25580490.xml?xsl=3 10.09.2008