Professional Documents
Culture Documents
Oscillator Site Information1
Oscillator Site Information1
Oscillator Site Information1
Picture in the left is axis installation, and picture in the right is parallel installation.
if there is enough space at the client site, we usually choose the axis installation, if not, we can choose the
parallel installation.
2. What’s the distance between the supports in two ends? (we need this parameter to calculating the length
of header)
3. What’s the width of the fabric (or wire)? (we need this parameter to calculate the quantity of the nozzles)
4. What’s the distance from the support to the fabric? (“BD” and “BC” in the picture below) (according to
these two distances, we can confirm the nozzle position)
5. Note: This minimum distance between two nozzles in header (“NS” in the pic below) is 75mm.
7. Confirm the direction of the nozzles and the position of inlet and drain valve and confirm these
connection size and specification.