Professional Documents
Culture Documents
Part D (POT-ZIN)
Part D (POT-ZIN)
RE.SISTANCE TABLES
Port 0, POT-ZIN
CORROSION TECHNOLOGY
.•.• I.
.: Editor
Philip A., Schweitzer,
.
P.E.
Consultant
York, Pennsylvania
CORROSION ,
RESISTANCE TABLES
Metals, Nonmetals, Coatings, Mortars,
Plastics, Elastomers and Linings, and Fabrics
Fifth Edition, Revised and Expanded
PART D, POT-ZIN
MARCEL
~
~
MARCEL DEKKER, INC. NEW YORK' BASEL
DEKKER
Although great care has been taken to provide accurate and current information, neither the aurhorts) nor the
publisher, nor anyone else associated with this publication, shall be liable for any loss, damage, or liability directly
or indirectly caused or alleged to be caused by this book. The material contained herein is not intended to provide
specific advice or recommendations for any specific situation.
Trademark notice: Product or corporate names may be trademarks or registered trademarks and are used only for
identification and explanation without intent to infringe.
It' ISBN:
Part A, 0-8247-5673-8
Part B, 0-8247-5674-6
Part C, 0-8247-5675-4
Part D, 0-8247-5676-2
Headquarters
Marcel Dekker, Inc.
270 Madison Avenue, New York, NY 10016, U.S.A.
tel: 212-696-9000; fax: 212-685-4540
The publisher offers discounts on this book when ordered in bulk quantities. For more information, write to
Special Sales/Professional Marketing at the headquarrers address above.
Neither this book nor any parr may be reproduced or transmitted in any form or by any means, electronic or
mechanical, including photocopying, microfilming, and recording, or by any information storage and retrieval
system, without permission in writing from the publisher.
10 9 8 7 6 5 4 3 2 1
The field of corrosion resistance is one of constant change. Research and development is continuously
underway, both involving new materials and expanding the uses of known materials. These advances
are parricularly important for such areas as chemical processing and pollution control. Increased
knowledge of corrosion resistance and the mechanisms of corrosion is a vital factor in this work.
This fifth edition ofthe corrosion resistance tables has been prepared in an attempt to provide the
most current information available. Data on the corrosion resistance for the materials and corrodents
covered in the previous editions have been greatly expanded, and data for 83 additional corrodents
have been incorporated in this edition.
iii
Introduction
For years rhe chemical engineer has been faced with the problem ofselecting the proper material to be
used for the construction ofprocessing vessels, storage tanks, valves, piping systems, and whatever else
comes into contact with potentially corrosive chemicals. During the early days of the chemical
engineering profession, the list of materials from which to choose was relatively small, consisting
primarily of various metals and their alloys.
AI; technology made advances, new alloys were developed as well as synthetic materials such as
plastics. Simultaneously, new chemicals came into being, many of which required the newly
developed materials of construction for safe handling.
However, the problem of material selection is not limited to the chemical engineer. Many
industries that use chemicals in their everyday operations cannot be classified as members of the
chemical processing industry, yet they have the same problems of selecting the proper materials of
construction to handle these products. This is particularly true in the area of pollution control. Many
processes for the elimination of air and/or water pollution involve chemical changes in the pollutants
that result in problems of corrosion that were not present before.
The dictionary defines corrosion as "eating or wearing away by slow degrees," a definition that is
rather broad and does not restrict the application of the word to the destruction of metals. This is as it
should be because of the availabiliry of so many nonmetallic materials of construction.
Most reference sources for the selection ofproper materials ofconstruction are devoted to either a
specific group of metals or alloys, plastics, rubbers (synthetic and natural), gasketing materials, or
packing materials. An individual with the problem ofselecting materials of construction must usually
make a selection in more rhan one of the preceding categories, which necessitates going to several
SOurces for the information. It is the purpose of this book to provide one source from which all the
components of a system may be selected, including processing vessels, tanks, pumps, piping, valves,
gaskets, packing, etc.
These corrosion tables have been prepared with the intention of assisting not only the practicing
engineer, but whoever may be charged with the responsibiliry of selecting rhe proper materials of
construction for a specific application. Any table of this rype should be used only as a guide since it
is extremely difficult, and at times impossible, to duplicate actual operating conditions. To fully
guarantee the suitability of a particular material of construction, corrosion tests should be conducted
under actual operating conditions.
In the tables, all the chemicals are assumed to be in rhe pure state or in concentrated or saturated
aqueous solutions, unless otherwise indicated. Concentration percentages used are by weight.
Two rypes of notation have been employed to indicate the suitabiliry of a specific material of
construction-one for metallic materials and one for nonmetallic materials. This is necessarybecause
their mechanisms of corrosion differ.
v
vi INTRODUCTION
CORROSION OF METALLICS
The four most common forms of corrosion of metals are
1. General corrosion
2. Galvanic corrosion
3. Stress corrosion cracking
4. Intergranular corrosion
General Corrosion
Metals resist corrosion by the formation of a passive film on the surface, which in a sense is also
corrosion but once formed prevents further degradation ofthe base metal. Most metals form this film
after a period of time of exposure to the air. Passivation is the name applied to the chemical treatment
procedure that helps to form the film more rapidly. For example, exposure ofaustenitic stainless steels
to nitric acid will produce this protective film.
As long as these films remain intact, they protect the base metal from further attack. Certain
chemicals attack various films at varying rates. When this occurs, the metal is said to corrode. Such
interaction between a chemical and a metal can be determined from the corrosion tables. This type of
corrosion is known as general corrosion.
'J
Galvanic Corrosion
Galvanic corrosion occurs when two or more dissimilar metals are in contact, or when metals having
the same analysis have different surface conditions and an electrolyte is present.
Under these conditions an electrolytic cell is formed. All metals and alloys have certain "built-
in" properties that cause them to react as an anode or a cathode when in contact with dissimilar metals
or alloys. Whether a particular material will react as a cathode or an anode can be determined from the
relative positions of the materials in the galvanic series. The farther apart two materials are from each
other in the galvanic series, with all other factors being equal, the greater the rate of corrosion. The
material closest to the anodic end will be the one to corrode. For example, if tin and zinc were in
contact, the zinc would corrode, whereas if tin and copper were in contact, the tin would corrode.
The rate of attack is also affected by the relative size of the materials and the specific electrolyte
present. A small anode area in contact with a large cathode area will result in a rapid severe attack.
Conversely, a large anode area in contact with a small cathode area will lessen the rate of galvanic
attack since the same total electromagnetic driving force of corrosion will be spread out over a larger
area. The higher the degree ofionization of the electrolyte, the greater the rate of attack.
Galvanic corrosion can be prevented by judicious use of dissimilar metals.
Galvanic series
Galvanic series
Intergranular Corrosion
Corrosive attack involving intergranular corrosion occurs only at the grain boundaries of austenitic
stainless steels. All austenitic stainless steels contain carbon in small amounts. When this material is
heated to the sensitizing range (850 to 1650°F), such as in welding, carbon is precipitated our at the
grain boundaries in the form of chromium carbide. The chromium has been taken from the grain
boundaries, changing the composition and making this area even more susceptible to corrosiveattack.
This effecr can be minimized by annealing rhe srainless steel after it has been sensitized. This is
done by heating the alloy to 1800 °F or higher, depending on the specific alloy, and then quickly
cooling it through the sensitizing range to prevent the carbon from precipitating out. Another way to
reduce this effect is to limit the carbon content to less than 0.03%. This extra-low-carbon (ELC)
stainless steel can be welded without the danger of carbide precipitation.
CORROSION OF NONMETALLICS
Plastic materials are attacked by solvation and chemical reactions. Solvation is the penetration of the
plastic by corrosive elements that cause softening, swelling, and ultimate failure. Plastics, in contrast
to metals, do not exhibit a useful corrosion rate; they usually either completely resist attack or
deteriorate rapidly. Because of this difference in corrosion mechanism, the two types of notation used
in the tables were established.
Plastic and elastomeric materials are compounded by the manufacturer. Properties of the
materials produced can vaty from manufacturer to manufacturer. By compounding, it is possible to
improve specific mechanical/physical properties, but usually at the expense of another property.
Consequently, materials that have been produced to improve a mechanical property may have had
their ability to resist corrosion reduced. Since all plastic or elastomeric materials produced may not
have the corrosion resistance indicated in the charts, the manufacturer of the material to be used
should be consulted. The same reasoning applies to the physical/mechanical properties required for
the application.
A word of caution should also be given regarding temperatures. The table shows only the
resistivity to corrosive attack at various temperatures. Although the material may be corrosion-
resistant at a specific temperature, this does not mean that the physical/mechanical properties would
be satisfactory at these temperatures. These must be investigated at the operating temperature to
ensure that the material has the proper mechanical strength for the application.
Using the Tables
The tables are arranged alphabetically according to corrodent. Unless otherwise noted, the corrodent
is considered pure in the case of liquids, or a saturated aqueous solution in the case of solids. All
percentages shown are by weight.
There are four pages for each corrodenn one for the resistance to metals; one for the resistance
to nometallic materials, coatings, and mortars; one for the resistance to plastics; and one for the
resistance to elastomers, linings, and fabrics.
TABLE NOTATION
Since corrosion is a function of temperature, the tables indicate the suitability of each material at
varying temperatures. Symbols used to designate specific corrosion rates are shown on the bottom of
the metals pages. The use of the temperature scale is explained by the following example:
Metals
Monel
Stainless Steels
Type 316
From the sample table, it is seen that in the presence of an 80% solution of acetic acid, monel has a
corrosion rate varying with temperature rated as follows:
• From 60 to 120°F, excellent (E): <2 mils penetration/year.
• From 120 to 21O oP, good (G): <20 mils penetration/year.
• There are no data for temperatures beyond 2lOoF.
Type 316 stainless steel has a corrosion rate for the same corrodent varying with temperature
rated as follows:
• From 60 to lOO°F, excellent (E): <2 mils penetration/year.
• From 100 to 180 oP, good (G): <20 mils penetration/year.
• From 180 to 240°F, satisfactory (S): <50 mils penetration/year.
• Above 240 oP, unsatisfactory (U): >50 mils penetration/year.
ix
x USING THE TABLES
Nonrnerallics are only rated as resistant (R) or unsatisfactory (D), because they do not exhibit a
useful corrosion rate, as explained previously.
Other Notation
Further information regarding the corrosion ofspecific materials by certain corrodenrs is provided by
the following symbols. In the tables, the symbols follow the applicable material or corrodent name.
Symbol Meaning
General Notes
• Incolloy category is applicable to grades 800 and 825 only, unless otherwise specified.
• Incand category is applicable to grade 600, unless otherwise specified.
• The mortars specified are for use fuHy immersed or subject to constant flow.
• The coatings specified are for use fully immersed or for wet spills or wet fumes.
• There are many epoxy formulations. Where epoxy is shown as being a satisfactory material of
construction, it indicates that there is a suitable formulation. Manufacturers should be consulted
for the suitability of their specific formulation.
.• See Appendix 3 for plating solution compositions.
Metals
OF
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/G-276
Contents
Preface tu
Introduction v
Using the Tables tx
Part A, ACE-CHR
A
Acetaldehyde 1
Acetamide 5
Acetate Solvents, Crude 9
Acetate Solvents, Pure 13
Acetic Acid 10% 17
Acetic Acid 20% 21
Acetic Acid 50% 25
Acetic Acid 80% 29
Acetic Acid, Glacial 33
Acetic Acid Vapors 37
Acetic Anhydride 41
Acetone 45
Acetone, 50% Water 49
Acetonitrile 53
Acetophenone 57
Acetyl Chloride 61
Acetylene 65
Acetylene Tetrabromide 69
Acid Mine Water 73
Acrylic Acid 77
Acrylonitrile 81
Adipic Acid 85
Air 89
Alkaform Anesthesia 93
Allyl Alcohol 97
Allyl Chloride 101
Alum (Aluminum Potassium Sulfate) 105
Alum Ammonium 109
xiii
xiv CONTENTS
B
Barium Acetate 385
Barium Carbonate (Sar.) 389
Barium Chloride (Sat.) 393
Barium Cyanide 397
Barium Hydroxide (Sar.) 401
Barium Nitrate 405
Barium Sulfate 409
Barium Sulfide 413
Beer 417
Beet Sugar Liquors 421
Benzaldehyde 425
Benzene, Benzol 429
Benzene Sulfonic Acid 10% 433
Benzene Sulfonic Acid 100% 437
Benzoic Acid 441
Benzonittile 445
Benzoyl Chloride 449
Benzyl Acetate 453
Benzyl Alcohol 457
Benzyl Chloride 461
Bismuth Carbonate 465
BlackLiquor 469
Bleach, 12.5% Active Chlorine 473
Blood 477
Borax 481
Borax Liquors 485
Bordeaux Mixtures 489
Boric Acid 493
Brine Acid 497
xvi CONTENTS
C
Cadmium Chloride 617
Cadmium Cyanide 621
Cadmium Sulfate 10% 625
Calcium Acetate 629
Calcium Bicarbonate 633
Calcium Bisulfate 637
Calcium Bisulfide 641
Calcium Bisulfite 645
Calcium Bromide 38% 649
Calcium Carbonate 653
Calcium Chlorate 657
Calcium Chloride Dilute 661
Calcium Chloride (Sar.) 665
Calcium Fluoride 669
Calcium Hydroxide 10% 673
Calcium Hydroxide 20% 677
Calcium Hydroxide 30% 681
Calcium Hydroxide (Sat.) 685
CONTENTS xvii
Part B, CHR-IOD
Chromic Acid 50% 873
Chromium Porassium Sulfate 877
xviii CONTENTS
D
DDT (Dichlorodiphenyl-Trichloroethane) 1045
Detergents 1049
Detergent Solution, Heavy Duty 1053
Dextrin 1057
Dextrose 1061
Diacetone Alcohol 1065
CONTENTS xix
E
Epichlorhydrin 1205
Esters, General 1209
Ethane 1213
Ethanolamine 1217
Ethers, General 1221
Ethyl Acetate 1225
Ethyl Acetoacetate 1229
Ethyl Acrylate 1233
Ethyl Alcohol 1237
Ethyl Benzene 1241
Ethyl Burytate 1245
Ethyl Chloride 1249
Ethyl Chloroacetate 1253
xx CONTENTS
F
Fatty Acids 1313
Ferric Acetate 1317
Ferric Chloride 1321
Ferric Chloride 50% in Watet 1325
Ferric Hydroxide 1329
Ferric Nitrate 10-50% 1333
Ferric Nitrate (Sat.) 1337
Ferric Sulfate 1341
Ferrous Ammonium Citrate 1345
Ferrous Chloride (Sar.) 1349
Ferrous Hydroxide 1353
Ferrous Nitrate 1357
Ferrous Sulfate 1361
Fish Oil 1365
:i' Fish Solubles 1369
Flue Gas 1373
Fluoboric Acid 1377
Fluorine Gas Dry 1381
:1 Fluorine Gas Moist 1385
I Fluosilicic Acid 50% 1389
I Fluosilicic Acid 1393
I Formaldehyde Dilute 1397
Formaldehyde 35% Solution 1401
Formaldehyde 37% Solution 1405
Formaldehyde 50% Solution 1409
Formic Acid 5% 1413
Formic Acid 10-85% 1417
Formic Acid Anhydrous 1421
Freon F-ll 1425
Freon F-12 1429
Freon 17 1433
Freon F-21 1437
Freon F-22 1441
CONTENTS xxi
G
Gallic Acid 1465
Gas, Manufactured 1469
Gas, Natural 1473
Gasohol 1477
Gasoline, Leaded 1481
Gasoline, Refined 1485
Gasoline, Sour 1489
Gasoline, Unleaded 1493
Gelatin 1497
Gin 1501
Glauber's Salt 1505
Glucose (Corn Syrup) 1509
Glue 1513
Glutamic Acid 1517
Glycerine (Glycerol) 1521
Glycolic Acid 1525
Glycols 1529
Green Liquor 1533
H
Helium 1537
Heptane 1541
Hexarnethylene T etramine 1545
Hexamine 1549
Hexane 1553
Hexanol, Tertiary 1557
Hydraulic Fluid (Petroleum) 1561
Hydraulic Fluid (Synthetic) 1565
Hydrazine 1569
Hydrobromic Acid Dilute 1573
Hydrobromic Acid 20% 1577
Hydrobromic Acid 50% 1581
Hydrochlotic Acid Dilute 1585
Hydrochloric Acid 20% 1589
Hydrochloric Acid 35% 1593
Hydrochloric Acid 38% 1597
Hydrochloric Acid 50% 1601
HydrocWoric Acid Fumes 1605
Hydrocyanic Acid 10% 1609
Hydrocyanic Acid (Conc.) 1613
Hydrofluoric Acid Dilute 1617
Hydrofluoric Acid 30% 1621
xxii CONTENTS
I
Ink 1721
Iodine 1725
Iodine Solution 10% 1729
Iodine Solution (Sat.) 1733
Iodine in Alcohol 1737
Iodoform 1741
Part C, ISO-POT
Isobutane 1745
Isoburyl Alcohol 1749
Isooctane 1753
Isopropyl Acetate 1757
Isopropyl Alcohol 1761
Isopropyl Ether 1765
J
Jet Fuel JP-4 1769
Jet Fuel JP-5 1773
K
Kerosene 1777
Ketchup 1781
CONTENTS xxiii
L
Lacquer Thinner 1793
Lactic Acid 5% 1797
Lactic Acid 10% 1801
Lactic Acid 25% 1805
Lactic Acid 80% 1809
Lactic Acid (Coric.) 1813
Oil 1817
.'.
Latex 1821
Lauric Acid 1825
. Lauryl Chloride 1829
Lead Acetate 1833
Lead Chloride 1837
Lead Nitrate 1841
Lead Sulfate 1845
Lime Slurry 1849
Lime Sulfur 1853
Linoleic Acid 1857
Linseed Oil 1861
Liqueurs 1865
Lithium Bromide 1869
Lithium Chloride 30% 1873
Lithium Hydroxide 10% 1877
LPG Propane 1881
Lubricating Oil 1885
M
Machine Oil 1889
Magnesium Bisulfate 1893
Magnesium Carbonate 1897
Magnesium Chloride 1901
Magnesium Citrate 1905
Magnesium Hydroxide 1909
Magnesium Nitrate 1913
Magnesium Oxide 1917
Magnesium Sulfate 1921
Maleic Acid 1925
Maleic Anhydride 1929
Malic Acid 1933
Manganese Carbonate 1937
Manganese Chloride 1941
Manganese Sulfate 1945
Mercuric Chloride 1949
Mercuric Cyanide 1953
Mercuric Nitrate 1957
xxiv CONTENTS
N
Naphtha 2109
Naphthalene 2113
Naphthalenic Acid 2117
Nickel Acetate 2121
Nickel Ammonium Sulfate 2125
Nickel Chloride 2129
Nickel Nitrate 2133
Nickel Salt 2137
Nickel Sulfate 2141
CONTENTS xxv
Nicotine 2145
Nicotinic Acid 2149
Nitric Acid 5% 2153
Nitric Acid 10% 2157
Nitric Acid 20% 2161
Nitric Acid 30% 2165
Nitric Acid 40% 2169
Nitric Acid 50% 2173
Nitric Acid 70% 2177
Acid 100% (Anhydrous) 2181
Nitric Acid Fuming (Red) 2185
Nitric Acid:Sulfuric Acid 50:50 2189
Nitriding Gases 2193
Nitrobenzene 2197
Nitrogen 2201
Nitrogen Dioxide 2205
Nitrornerhane 2209
Nitrous Acid 5% 2213
Nitrous Acid 10% 2217
Nitrous Acid (Cone.) 2221
Nitrous Oxide 2225
o
·Ocenol 2229
Octane 2233
Oil and Fars 2237
Oil, Mineral 2241
Oils, Vegetable 2245
Oleic Acid 2249
Oleum 2253
Olive Oil 2257
Oxalic Acid 5% 2261
Oxalic Acid 10% 2265
Oxalic Acid 50% 2269
Oxalic Acid (Sar.) 2273
Oxygen 2277
Oxygen Gas 2281
Ozone 2285
p
Palmitic Acid 10% 2289
Palmitic Acid 70% 2293
Palmitic Acid (Conc.) 2297
Paper Pulp (Chlorinated) 2301
Paper Pulp (Nonchlorinated) 2305
Paraffin 2309
Peanut Oil 2313
Pentane 2317
Peracetic Acid 40% 2321
xxvi CONTENTS
Part D, POT-ZIN
Potassium Nitrate 80% 2625
Potassium Nitrite 2629
Potassium Oxalate 20% 2633
Potassium Perborate 2637
Potassium Perchlorate 2641
Potassium Permanganare 10% 2645
Potassium Permanganate 20% 2649
Potassium Peroxide 2653
Potassiurn Persulfate 2657
Potassium Phosphate 2661
Potassium Sulfate 10% 2665
Potassium Sulfate, Pure 2669
Potassium Sulfide 2673
Potassium Sulfite 2677
Potassium Triphosphate 2681
Propane 2685
Propargyl Alcohol 2689
Propionic Acid 2693
Propyl Acetate 2697
Propyl Alcohol 2701
Propyl Nitrate 2705
Propylene Dichloride 2709
~--------------_.-
xxviii
CONTENTS
Propylene Glycol
2713
Propylene Oxide
Pyridine 2717
2721
Pyrogallic Acid
Pyrogallol 2725
2729
Pyroligneous Acid
2733
Q
Quinine Bisulfare
2737
Quinine Sulfate
2741
Quinone
2745
R
Rayon Coagulating Bath
Resorcinol 2749
Road Oil 2753
Rosin, Dark 2757
Rosin, Lighr 2761
2765
Rosin, Molten
Rosin Oil 2769
2773
S
Salenic Acid Aqueous
Salicic Acid 2777
2781
Salicylaldehyde
Salicylic Acid 2785
Sea Water 2789
2793
Selenius Acid, 30%
Shellac 2797
Silicone Oil 2801
Silver Bromide 10% 2805
2809
Silver Chloride
2813
Silver Cyanide
2817
Silver Nitrate
Soaps 2821
2825
Soap Solution 5%
2829
Soap Solutions
Sodium Acetate 2833
2837
Sodium Acid Sulfate
2841
Sodium Aluminate
2845
Sodium Benzoate
2849
Sodium Bicarbonate 20%
2853
Sodium Bichromate Neutral
Sodium Bisulfate 2857
2861
Sodium Bisulfite
Sodium Borate 2865
Sodium Bromide 2869
2873
CONTENTS xxix
xxx CONTENTS
i
iH
I, Stoddard's Solvent 3077
Sryrene 3081
Succinic Acid 3085
Sugar Solution 3089
Sulfamic Acid 3093
Sulfate Liquors 3097
Sulfite Liquors 3101
Sulfonated Detergents 3105
Sulfur 3109
Sulfur Chloride 3113
Sulfur Dichloride 3117
Sulfur Dioxide Dry 3121
Sulfur Dioxide Wet 3125
Sulfur Oxychloride 3129
Sulfur Trioxide 3133
Sulfuric Acid 10% 3137
Sulfuric Acid 30% 3141
Sulfuric Acid 50% 3145
Sulfuric Acid 60% 3149
Sulfuric Acid 70% 3153
Sulfuric Acid 80% 3157
Sulfuric Acid 90% 3161
Sulfuric Acid 95% 3165
Sulfuric Acid 98% 3169
Sulfuric Acid 100% 3173
Sulfuric Acid 103% 3177
Sulfuric Acid Fuming 3181
Sulfuric Acid Vapors 3185
Sulfuric Anhydride Dry 3189
Sulfurous Acid 3193
Sulfuryl Chloride 3197
T
Tall Oil 3201
Tannic Acid 3205
Tanning Liquors 3209
Tar 3213
Tartaric Acid 3217
Terrachloroacetic Acid 3221
Terrachloroethane 3225
Terrachloroethylene 3229
Terraerhyl Lead 3233
Terrahydrofuran 3237
Terralin 3241
Terramethyl Ammonium Hydroxide 50% 3245
Terraphosphoric Acid 3249
Thionyl Chloride 3253
Thread Curring Oil 3257
Tin Chloride 3261
CONTENTS xxxi
U
Udecyl Alcohol 3361
Uranyl Sulfate 5% 3365
Urea 3369
Urea Ammonium Liquor 3373
Uric Acid (Cone.) 3377
Urine 3381
V
Vanadium Pentaoxide 3385
Varnish 3389
Vegetable Oil 3393
Vinegar 3397
Vinyl Acetate 3401
Vinyl Chloride 3405
Vinyl Chloride (Resin) 3409
Vinylidine Chloride Resin 3413
W
Water, Acid Mine 3417
Water, Demineralized 3421
Water, Distilled 3425
Water, Potable 3429
Water, Salt 3433
xxxii CONTENTS
X
Xylene (Xylol) 3457
Z ..
Zinc Carbonate 3461
Zinc Chloride 3465
Zinc Cyanide 3469
Zinc Hydrosulfire 3473
Zinc Nitrate 3477
Zinc Sulfate 5% 3481
Zinc Sulfate 25% 3485
Zinc Sulfate 50% 3489
Zinc Sulfate (Sat.) 3493
sc-
e:
Metals
Admiralty Brass
Aluminum
of
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B·2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904·L
17-4 PH
20 Cb 3
E·Bright 26·1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
of
O(
Nonmetallic Materials
r, "
Borosilicate Glass R
Carbon R
Carbon-Graphite Resin
Impregnated-Furan R ;\
Ceramics R
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
of
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
of
O(
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
II
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
i
•
o
'"
~
['
I
I
I!
O( ~~,ij ~~~.1 ~ij ~
.-- - ,'. ~,-_., '.
Ij
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
. Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
i Silicones
'1
"
Urethanes
!I Vinyls
il Water Base
II
"
Zinc Rich
i
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
iI
SchweincrlCorrosion Rtslltttnu Tabla: Fifth Edition, Rrvistd and Expanded
2638 Copyrlghr © 2004 by Marcel Dekker, Inc. All rights reserved. For more informacion, go 10 www.dekker.com.
II
on Steel
~itibium (Niobium)
~lIby B/B-2
~noy C/C-276
@16yD
tell()y G/G-3
. Silicon Iron
nel600/625
Ifoy 800/825
J400
v~rBronze
ick~1200/201
Resist
inl~ss Steels
:;)"ype. 304/347
ype 316/316 L
!TYpe 400 series
x1;Ype904-L
~17-4 PH
6 Cb 3 30% E."",...."""
!'I;:~Bright 26-1
\IJ~OI'l Bronze
i icon Copper
!ite.
'talum
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Ii,;! Polyester
i;i Polyvinyl Chloride
u
Silicones
II
'I Urethanes
II
II
Vinyls
IiI
ii
Water Base
I
Zinc Rich
!
i'
Ii Mortars
ii
It
Silicate
Ii Sodium Silicate
!
Potassium Silicate
I'
Silica
I
Sulfur
Furan Resin
I
I Polyester
Epoxy
i
I
Schwciner/Conv;ion Raissance Tabus; Fifth Edition, Reoisedand &pmuud
2642 Copyrigh[ © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go (0 wwwdekker.com.
:ner/Co17V1ilJ1I &sistanu Tabh Fifth Edition, Reoised lind Exparukd
t e 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dckker.com. 2643
a
POTASSIUM PERCHLORATE
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
iMolloy 800/825
Lead
M6nel400
Naval Bronze
i'""Nf'ic,-ke"7I-=2-=-00::c/=-20=-1;--------j
~\Ni-Resist
;Stainless Steels
Type 304/347
;Type 316/316 L
Type 400 series
Type 904-L
7-4 PH
20 Cb 3
E-Bright 26-1
S!li.con Bronze
pilicon Copper
tellite
antalurn
jrconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
A~
Acetal R In1 i.,);
U ~ ~ ~
..' ..... ".., I
~ I" 0 II
Acrylics U; '.;; I , C;' .·,i'· ','., ,i'
Asbestos Reinforced Epoxy R , ' i " ' " . ' . . '
Asbestos Reinforced Phenolic R 1 ' ; 0 ' ".... ,!
Chlorinated Polyether (Penton R , , s r I ; ','\ I,
CPVC R " . •..'... . ',' A'
E.CTFE (Halar)
.\
R ''''"
.... ii F .... Ii, .'
I P ! ' ; ; ; '.' ,'"I .
.,..... J»" ' !
Epoxy R i.;l" 'i".
ETFE (Tefzel) R r.dl liiji!i
FEP R I!iiil f.';";
Furan (Furfural Alcohol) SAT R lli!_ li;f, rf.~'I;! 3, ,"" ',i
Noryl
Nylon 6
R
U
§ Wi .' .
Illii 6 , '......ii
. ; ,,•.-•.'
Nylon 11 U i , ' /t ' ,';' i.,;
~oo66 U ~ 6 s
Phenolic R
.i;
'ii, ...
PFA (Teflon) R Imil ~H!+-"""'-+'"H'iH~'1 ;'.
Polyamide-Imide
Polyesters
Bisphenol A-fumarate SAT R
Haloqenated
Hydrogenated Bisphenol A
R I~~
I~i
R
Nonmetallic Materials
Borosilicate Glass
Carbon ,
Carbon-Graphite Resin ,
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Ofl Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
i
I
1,1
IiI
I
Fabrics
Cotton
FeltlWool\
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
I
Plastics
ABS
Acetal
Acrylics
Asbestos Reinforced Epoxy
•
Asbestos Reinforced Phenolic
Chlorinated Polyether (Penton
CPVC
E-CTFE (Halar)
EpoxY
co
O( '"
'"
FOR METALS FOR NONMETALLICS
E ~ < 2 Mils Penetration/Year: G ~ < 20 Mils Penetration/Year R ~ Resistant
S ~ < 50 Mils PenetrationlYear; U ~ > 50 Mils PenetrationlYear U ~ Unsatisfactory
Schweitzer/Corrosion Resistance Tabus: Fifth Edition, Reoised and F.xpantkd 001: 10.108 l/5672·X-120028974
Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com. 2657
••• • • •
Nonmetallic Materials
Borosilicate Glass
~<:.
,''-: , :
,:
f~:
,
,
Carbon
'"
Carbon-Graphite Resin !J '
I
Impregnated I, ' ,:: [ I ,
I .,
.'"
II c II~;
"',
Ceramics
I,:,
I:
i I
Coatings
Acrylic I
Asphalt
:, I
Chlorinated Rubber
;': 1'1:,,,1,
-i
Coal Tar
U:'
I: , i:: I,
Coal Tar Epoxy
;' 1< I
Epoxy General Purpose
I:
~~
Epoxy Chemical Resistant R > I:,
Epoxy Polyamide U I
Oil Base 1,\ I:
(Alkyd, Epoxy, Urethane) :' I
Phenolic
Polyester RIM"
Polyvinyl Chloride R
Silicones '~~ '.-' II
:
Urethanes
;~3 ;'"
,~
Vinyls R ":,
Water Base r~,1
Zinc Rich '"
I
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
;,'1 Epoxy
tl~:.
...... ~ • • •
~iq
Acrylate-Butadiene (ABR) I' -. ...
I'>
Butyl GR-1 OIR)
Carboxylic-Acrylonitrile- b k. i. " i'
•••••••••
.: I
L ......
Butadiene (XNBR) I; ti ' Ii , .' 1.1
Chemraz (FPM) R I• ••• -. '.
..
Polyethylene (CSM))
Ethylene-Acrylic (EA)
.....•
I, ..
I~;
••••••
Ethylene-Propylene (EPM)
RI,~·' :s w', :: ric .., '. I)'
Ethylene-Propylene-Diene
(EPDM)
t:
,
fe
' .. ..•.•
i+i
I, X :.• 11:
I.
i 1+
'.' ,
Ethylene-Propylene R \. ..
:.
". Ii I.' ...•....
Terpolymer (EPT) : :
r',y :'; f; li,.\ ,
I
FKM (Viton A) [.::' '0 I"
Hard Rubber : .C
Soft Rubber I:', ; \, I...
I·
Ii "
;
I: I; I'if'
Isoprene OR)
Kalrez (FPM) R ... I:'f k ;' :•
I··.. I
:
~ . ':,.;
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR) R
b
!,~
I·'·,
I"
Ii;
, 'i'W
"..
......
I,C
Pi
I'i
I:
lif
,\,.
·V: :,
I>
Nitrile Buna-N (NBR)
Nordel (EPDM) U[i. 1"
Ii [:
Ii,. ,X': I;
....•. , .•
lit' t' j
,.:
Polybutadiene (BR)
Polyester (PE) fiV; j, I); ':
i .. 'e, I:. i
.' f1
.,!'
~'r
Polyether-Urethane (EU
I'; I. I" ; i'.' I)
Polvlsoprene OR) 1', ;'. Ii' ."
{•
i;;
Polvsulfides (T) ';.
Ii;, ,v'
I~: f·~
Polvurethane (AU) iV' I)
SBR Styrene (Buna-S)
I::.
I, I'. \
Silicone Rubbers I;~~ .... b I.S
.' I.e
.......
Fabrics Ii,
k'
I}
Cotton
,. <~1\
Felt (Wool)
Rayon Viscose
OFg~!~:§l~
.~
i.,
~,
0
k 0
N
••••••
0
"
0,:0'0'0;0
o N' o::t :\0.' co
1.\
H'
"
,);
If.'
O:'O!O
•
..'11"","-§:
0,1<::
L/"l:\O::co r: g ~' ""';l.O ~N.
",,& '" lD''''':;' co
°C to.,?
..... \Il: I'
:N~fYl o ~!
... ;'!':' ,....,:CO; en
..... :~l'll""
'II"" ('Ii lY'I
NN_N
'arbon Steel
<5lumbium (Niobium 10%)
gflfler
:~telloy B/B-2
,,,~telloy D
"i>telloy G/G-3
jg~ Silicon 1ron
;'Gonel 600/625
,'GOlloy 800/825
alv. Stl.
. (>ne1400
'aval Bronze
'ekel 200/201
FResist
'tainless Steels
Type 304/347
Type 316
fType 400 series
Type 317/317 L
17-4 PH
~20 Cb 3
E-Bright 26-1
,licon Bronze
Weon Copper
Jellite
~ntalum
aniurn
conium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
--'----'.-=-----------1
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt Wool)
Rayon Viscose
. astelloy G/G-3
Ibe6110y 800/825
L.ead
Monel 400
aval Bronze
iekel 200/201
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
o~o~o~o~o~o~O~fO~O~o~o
of l.O
Nonmetallic Materials ",co:' 0 ~~" ~: "~ ee ';0- N'~' ~oo,: o~' "It '\0' ~::.: e: N ',';: ~
\'{'; P}r;,' P~; """':~; N ,~' Nt:'t, M;m' M('I"J M V "It: '''II:t
1:;:i!.' ~' ,
Borosilicate Glass R, , ' ,
[, i
)',
Carbon R"
Carbon-Graphite Resin
,
~; I ',: I ,
,
l, i' ,C
,
Impregnated R '., I, ,
,
.
:
,. II
,
,
Ceramics R , '
"
,
,",
f~, c,
,
I ", "
',:
Coatings
Acrylic
:~ .. ',
..•• ' I; ','
.'
":'.
,
~" I , : •.
Asphalt "
,~
I , "
"
"
Coal Tar
I'
.. ,
.'
'.,
' '
',<,
Epoxy Polyamide R
-:~
[, ."
;,
"
.'.•
~:, !' " ,: ••
Oil Base ,
'
i
(Alkyd, Epoxy, Urethane)
I
: I' "
::
.,',
':,
"
, ",
Phenolic
,: ' I "
"'
Polyester R
-/ , " , "
1< r:
Polyvinyl Chloride R y ." "
:':,. ,
IT~'I
I'
,
"
Silicones R
;:' ',': II"
,
Urethanes R ;; ,
Vinyls R \\ ,
1
/ "
'.';
Water Base I '. ,
:.
' "
:,
Zinc Rich U
;;'
I "
~,,' '". I'
I, ';
c
.', I;:
~:
:
.: "
Mortars
Silicate R
i ,,: I:, <.: ';.:: I.:
Sodium Silicate R
I,','
': • ".', I !
I, '"
), I' , I' " :,
Potassium Silicate R :
Silica R
'ii /' I, , I:, • 1,/ "
,.'c,
I'
'"
I:"
iI:: Ie
Sulfur R ,
I
"'.,
,: " j i I'"~
Furan Resin R ,"
Polyester R
Epoxy R I",
"
o,;B: 0 ~gi 0'6; 0
'I.: ' '
I'
06~·
.,"
-:cf: '.OJ ~;~
I
. .'
I: I::
OF 070'
l.O :'co· Oh(i '¢ ; , ; ee ;0; N
~"':/i or' ~'!j:,i P ~~; or'(\I: N
;0·
:}",r'
,(:'I.
0 0
U)'CO'· 0 :'N ''It :to:j
N :N; M,m', rt'IM-
o~,o
!;j \,,! ~
O( ~'ili 00:0i; o:"~' N:&i: ~\o r-.
~N: M:V; U)~;
~,'6' or':N: M~': ~"';, ~
00_0'1: 0',,-', N :M' ''It\O' r-.,OO ~. or' N M
Ceo:
.:.. :) .. /.:' '.'.;.i;':.: P~: p.~ 'l"""iI""':! P ;~ PN; NN: N
ALL
ALL
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
-t
...
:Brass
~:Bronze
'Carbon Steel
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica I
Sulfur
Furan Resin
Polyester
Epoxy
,-:~
'j
•
S,hw,ia,dC'""i,n Resistance Tabk" Fifth Edition, Rro.,d and &pn"Md,I.,·',:,
2670 Copyright © 2004 by M,,~I Dekker, Inc. All rights reserved. Por more information, go ro wwwdekker,com. ••
',~
Plastics
ASS
Acetal
II
Polystyrene
Fabrics
Colton
Felt (Wool)
Rayon Viscose
OF ~ ~;~ ~ ~ ,:~:; ~~:] ~ '~~ ~; ~;~ ~ ,i;~,; ~ t;', ~
°C ~ ~ ~i~1 gl ~:~Ji ~;~' ~;;~j ~:;:~-: E'~:( ~t~i ~.~~: ~
stelloy B/B-2
'~t~lIoy C/C-276
AtEl"oy G/G-3
J9hSilicon Iron G
'GoneI 600/625 G
qlloy 800/825 G
Onel 400
'val Bronze
U
u I
,,*el 200/201 G I
- inless Steels
E
I
i
{Type 304/347 G i
: Type 316/316 L G I
j{;;rype 400 series G I
:i,Type 904-L
i:17-4PH
."20 Cb 3
{E-Bright 26-1
G
I
I,con Bronze
Il'e:on' Copper
Jellite
?ntalum
~nium
<:onium
Nonmetallic Materials
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
. i
I
1
1
1
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
,
'See also Nylon 11 under PLASTICS
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
•
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
~Ha~s~te_lIo_y_D -=-- ~
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Galv. Stl.
Monel 400
Naval Bronze
Nickel 200/201
'. Ni-Resist
. Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
. E-Bright 26-1
::Silicon Bronze
.Silicon Copper
:';Stellite
(Tantalum
: Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
II,
~
;=- ~','.',*~;,..J~:NN,N
....
:,
,',c." ~,g',
I';
i'l".li 1.
fJ g~~.
"'miM' ~g,c i'l~, s
M-~;o::t;..;;to::t
II
;t . '
ACrYlics
Asbestos Reinforced Epoxy
Asbestos Reinforced Phenolic lei 1'm::
c
1':;,(;'; i' I
I I
'
CPVC Rfo'T~f--li"iiH;;;'1
I I
E-CTFE (Halar)
Epoxy
I:.
I.
I."
I,
ETFE (Tefzel)
i" I·:
: I;:
• I:
Nylon 11
Nylon 66
Phenolic
PFA (Teflon) .-r- -IR
Polyamide-Imide
Polyesters
--I
. I·:
Bisphenol A-fumarate
Halogenated
Hydrogenated Bisphenol A
-Bisphenol A
lsophthalic
Terephthalate (PET)
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
Polyethylene HMW
Polyethylene UHMW
Polvrnethvloentene
Polypropylene (PP)
Polystyrene
Polysulfone
Polyvinylidene Chloride
Ii\!:!
PVC Type 1
PVC Type 2
PVDF (Kvnan
Ryton
TFE (Teflon)
Vinyl Ester
r
I
Fabrics
Cotton
Felt (Wool
Rayon Viscose
)stelloy G/G-3
High Silicon Iron
iJ:1c:;onel 600/625
l(iColloy 800/825
.Lead
Monel
,- '
400
aval Bronze
· ickel 200/201
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
:$i1icon Bronze
$i1icon Copper
Stellite
Tantalum
titanium
irconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
,
Schweiner/Corrosion Raieance TabkJ: Fifth Edition. Revised and Expandtd
2682 Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com-
Plastics
ABS
Acetal
OF
II
Ac lies
Asbestos Reinforced E ox
Asbestos Reinforced Phenolic
Chlorinated Pol ether (Penton
CPVC R~+&+"'**f---fF;
E-CTFE (Halar
EpoxY--=--c-~ ---i
ETFE (Tefzel)
FEP
Furan (Furfural Alcohol
Nory:-I_ _
N Ion 6
Nylon 11
Nylon 6=-=6'----- --1
Phenolic
PFA (Teflon
Bisphenol A-fumarate
Halogenated
Hydrogenated Bisphenol A
-Bisphenol A
Iso hthalic
Terephthalate PET
Pqlyetherimide ULTEM)
Polyetheretherketone PEEK
Pol ethersulfone (PES
Pol eth lene HMW
Pol eth lene UHMW
Pol meth I entene
Polypropylene (PP
Pol st rene
Pol sulfone
Polyvinylidene Chloride
PVC T e 1
PVC T pe 2
PVDF K nar
Ry10n
TFE Teflon
Vinyl Ester
I
I
Metals
•
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
.
I
I
Carbon-Graphite Resin
Impregnated
Ceramics
I
I, Coatings
Acrylic
f-
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o0 0 (::) 0 0 0 '0 0 0 0 0 0 0 0 0 0 0 0 0 0
of ~~o~o::t~CO:O_N~~~ONo::t~COO.N~u)
Plastics : ; ..... :~- ..... ,......... N NN, N N m M: 1'1"1 M fY'Io::::t "'" - "It
ABS
Acetal
R
I I •••••
Acrylics ..
Asbestos Reinforced Epoxy
Asbestos Reinforced Phenolic
.: I·.•· .· .
I
Chlorinated Potvether (Penton R ·
CPVC R I·"
E-CTFE (Halar) R " ••• · I
..
•• ••
Epoxy R ... I· f I
ETFE (Tefzel)
FEP
R
R ..•..
r-.'
• . '•. > -'.
I
I' .
1
••
I.· ~:" I
Furan (Furtural Alcohol) "
•• '.
Noryl R .... [Yi I'
1/ ..
....
I'
·
Nylon 6 R ,;. 1-- .. I ·
. ' i
Nylon 66 R ~.•.•.
I >/ ....-: • .. '
.:
Phenolic
., iii' '.', . Y
., Y
.:
I• ... .' .
I> I',..
"
•. ...
,
polyamide-Imide ... ..
Y
Halogenated _
..•• .. '
e
C ••
••• •
Hydrogenated Bisphenol A ....' .. ) ','.'.
,/ · I
-
-Bisphenol A R - .... •• >
•• •••• I .'.,
lsoohthalic R .
.; •• - . ',',' I ' .. '
.
Terephthalate (PET) •••••• ; •• .'. ,.' .: .,'.
Polyetherimide (ULTEM) ....
Polyetheretherketone (PEEK) R .... '-;.' '. ..
•••••.•
,'
.>
' .:
,. • . "
• ••
Polyethylene HMW
Polyethylene UHMW
U .•.•' ..•.
';'..
R •.•.',..
"
1<
, ••••••
•,. -.': '.,
.,
< .
".
"',
Polymethylpentene U '/ ••••• "
• ,
•
.
•'v-
polypropylene (PP) R -.
... ,.' ••
.<
•
...•• .
'. Polystyrene ;-••••••• ".
•.I. i
.',..'. -:
..•. ... • •••••
,
'.,
...
'
U /. ...
'
"Polvsultone .. .. . , ;
. Polvvinvlidene Chloride R ".",..,
.. . .. . '
.".'
•• '.
,.
'
, •".
PVC Type 1 R •
/'
.PVC Type 2 R ":
,Y
/
••
... •
-.
,
'
",'
.
..'..•.
PVDF (Kynar) R
,
TFE (Teflon) 14 R ••
"
.
,.
• ••
."
.;
ll"l.l.D 00 m' 0"",": NfY\ oct .\D' ""'00 0'10 ..... N ", o::::t \0 1'-: co
°c _N:lY'I~\O~co~,o,....NMo::t~""':COcnO""'NfY'I
--; ~ ..... ...- ..... "":"; ......... ,....._ ..... N N N N
~-'-C.-~~,,:-,-cc.=~~_-jU
==-=--cc='-=-==- -jU
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R~~,.
Silicones
Urethanes
Vinyls R&..,...,.
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
ABS
Ul%~ [\1 "i; '; "
.,
[; f;'
!. li'f I,',
..,.'
Acetal X; '
12 ..
1"
Acrylics I;') I i. ~t .....; I ....
If 11 F,
Asbestos Reinforced Epoxy IiF,' l/t in II / I'i 1/I'
~)' 1'.
,
~j*
Asbestos Reinforced Phenolic '/ .. ;
Ii
L: !{ [;
Chlorinated Polyether (Penton ri; 11 :
b,
CPvc R
li(~ In "
i..i. f;'· I:·;
I,;
;i
E-CTFE (Halar)
Epoxy
I~\
I;'
11 ; i.,
in ~f' ,;,8 '';'
I~
ETFE (Tefzel) , ;;
AI
R ".
FEP R
I'(~
f
Furan (Furfural Alcohol) ;, .', i.! [t,
Noryl ;~
I',;
Nylon 6
--
.'
1.1
I,;·
I; l~;~ ii
~C
Nylon 11
Nylon 66 i0; ."'. ,
Phenolic Wi ~. ~~;,I
?;:
PFA (Teflon)
b' I,,'
1m" Ii'
Polyamide-Imide
r~
.'
Polyesters
Bisphenol A~fumarate I. "
Halogenated
Hydrogenated Bisphenol A
-Bisphenol A
ir! II
I~
'i
Isophthalic
Terephthalate (PET) lit ';j' I:t' ."i. ~i,;,
it
Polvetherirnide (ULTEM)
Polyetheretherketone (PEEK)
!~.
·;i ;,',
~j
Polyethersulfone (PES)
Polyethylene HMW R
I~~I ~' iii
ii'
8;
1>/
Polyethylene UHMW R MIt ,< l;f'
Polvmethvlpentene
Polypropylene (PP)
Polystyrene
U
'f
;;
'x;
i.: <',' ii
Polysulfone
Polyvinylidene Chloride
PVC Type 1 R ;(~ ij fl
;, .; f,t
j;~
i !
9;
l'
'J,
~f~
~.'
/:f
"
l& '~ "',
pvc Type 2 R ,> .
PVDF (Kynar)
>,"
••
1. l'
Ryton
TFE (Teflon) R
~ :x,:i~ }1,\ ,;'; ~. ...
.
OF 0
'"
o~6:' ~;g;
O:Ni
..... :e;.....
o::r,~
0
co '0:
'6: N0
....,("iI: N
0,"0'
U)
°:0
iCO; 0Ni oo::t ,;\0
N'~; rt'l~t
10 bi ob: 06"
coo' N
tr'I!"'. l't'l:o::r~ 0::1';r
0
U)
".: o::r
~~co~o~!N~;.~;~~l~~""~M~U)~ico
O( ,.-·t":'",v,,\Of'·co'cn:O_'N!'Vl.oo:::tl.O:
, .. •.. . ; ...... _
...... CO;O'lQ·NNNl
.... ,.,,:-' ..... '.... ; .... :,~' ..... 'N: N, N
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Incone1600/625
Incolloy 800/825
Galv. Stl.
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Zirconium
•• ••• j
j
1I
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars -1'
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
1
i
1
Fabrics
Cotton
Fell Wool)
Ra on Viscose
I
Schweitzer/Corrosion lWistaner Tahlrs: Fifth Edition, Revuedand Exparukd
2696 Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com.
I:
··Metals
Admiralty Brass II
..
I
·
Columbium (Niobium) ·
.Copper
Hastelloy B/B-2
!
:.,
Hastelloy C/C-276 .. I
Hastelloy D
Hastelloy G/G-3 .
High Silicon Iron ·
Inconel 600/625
Incolloy 800/825
Galv. Stl.
Monel 400 ·
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
:,=:=:.::::::..-'-==c=,::c~~::L------1U
:...:,::c=:"==::"-.::=.:..:-=ccl:::'-,:L------1 U
:..:..:..:=-=-~~~"-.:.:~-- __lu
II
O~O~O'~O~O~O~iO~iO-~O~o~;o6;o'CiO~
Metals °F~~~~'~~~~_~~':~'~~J:~.~i~~~_~~_~~~~
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Galv. Stl.
Copper
Hastelloy B/B·2
Hastelloy C/C·276
Hastelloy 0
Hastelloy G/G·3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Hesist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904·L
17·4 PH
20 Cb 3
E·Bright 26·1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose R
Epoxy Chemical Resistant R
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R~-i;s;!'I
Polyvinyl Chloride R""",,"~'/-
Silicones R~~./-
Urethanes
Vinyls
Water Base
Zinc Rich R~-+l'\+-"'!1
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
.... . · <
• •
...
Chemraz (FPM)
Chloro-Isobutene-Isoprene
(CUR)
;it
i;,i;
,
'!
., ii.
I. rIS
,
'C'"
" · .; ;•••• ;
••••
.;, ..
ii, iii : ii i;ii
','
Hypalon (Chloro-Sulfonyl- R ;;
iit lei I:,. :, · i;i ....
• ii
Polyethylene (CSM)
Ethylene-Acrylic (EA) i.~ .' .i·;
'c
[i•• Ie
;;i ,;
Ethylene-Propylene (EPM)
Ethylene- Propylene-Diene
R
~i\);
~ ~,\, iH Iii
rV' I't
I,;
, ;
Ii
,; ,i::
lit ',;.
(EPDM) L.
1"
Ethylene-Propylene R !i I'I( I' m' ;
".'!i
:W I,
iV; I
i I"
I··.··..
I);
Ii
"i'i
i
'.
,
'"
'.
i.·.·.
•
Isoprene (IR) ~I" tst:1
R Il~'jl Iii;'
;. pi i.;;:" ,
I' ;
i'.·.'i
.'.
'F
Kalrez (FPM) I',
f;'1i i) i ••••
Koroseal I"
" ',' ,
•••••••
~I
Neoprene GR-M (CR)
}
I•• .C!
;
"
i
Nitrile Buna-N (NBR)
•,.
"
I':
~
I
Nordel (EPDM)
Polybutadiene (BR) I' ii),; 'i '·~i iiii I,
;< 'i ,
Iii Ii,
Polvether-Urethane (EU) ,;' i'\.
U
Polvisoprene OR) 1,; Ii,;
{ii
h!i , ;'i .i :
Polvsultides (T) )'i Iii,
Iii i\ I: ',; . 'jii
if:,
Polyurethane AU)
SBR Styrene Buna-S)
i,:
I~~ r. I, [Ii .,
Ii
iJi
!"
Silicone Rubbers R
1'. I, i.
l~iJl
{,f; !
~
-v-:
ii'
Fabrics
);) ii, ii I'i', i : i/&
Cotton R;;i. I,; ;'t, " J liS
iii: I'H
I; i i:
i, iq; I'
Felt (Wool) R ,..;
Rayon Viscose
Y','>
, "~-
~,j~i;( Ii; , Iii .....
OF o\.0 :.~; 0 ';~l 0~ .,\0·00
~ClO ON1 ;;~" 0 '~~':'
:0. N.
~H~~~;~_or-~N~:N'N.~~~~:~~~
0 ,:,~.,1.0,,00,
0 ::'0" 0 ~o;
.N, 0,-0::
~ ;I.D, 0:. 0:) ~ ~;. lD
CO . .o", 0
•
~~CO~O~N~~~~!~;~~:or-~~~lD~OO
O( .- :N' ~ i;fl::t; "'.:1'>:' com: 0 .e-: N em: ~U) ...... 00. O'l :0, '"" if'''' M
j:~ ~~ ~~,""~,""~_:~~or-h'"":N'NiNN
..,
'See also Nylon 11 under PLASTICS
,
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o
Elastomers* and Linings of '"
Acrylate-Butadiene (ABR)
Butyl GR-1 (IIR)
Carboxylic-Acrylonitrile-
Butadiene (XNBR)
Chemraz (FPM)
Chloro-Isobutene-Isoprene I;
(CIIR)
Hypalon (Chloro-Sulfonyl-
I
1 '
Polyethylene (CSM))
Ethylene-Acrylic (EA)
I '
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene t ~A.
(EPDM) I
Ethylene-Propylene
Terpolymer (EPT)
I;
I;
I;
FKM (Viton A)
Hard Rubber 1
Soft Rubber I
Isoprene (lR)
Kalrez (FPM)
Koroseal ;,
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N NBR)
Nordel (EPDM
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU
Poly isoprene (lR)
Polvsulfides (T
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
.~
'1
SchweiacrlCorrosion ReJlstana Tabk: Fifth Edition. Revised and &pandrd .~
2708 Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekkcr.com. .~
.~
Metals
Admiralty Brass
Aluminum
OF
I
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Incone1600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
OF
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride U
Silicones
Urethanes
Vinyls U
Water Base
Zinc Rich
,
,""
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
r
I,
I,
i
,-==c::=,,-==::.e.:..-::':'-:~:L..-_-jU
"-="-=-C=~~"'-'""-"-"'--_-jU
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Galv. Stl.
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
-----------1
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
=-,---:-,--------1
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
:,~
Potassium Silicate
Silica
Sulfur
Furan Resin
:" -.-'.
';'.
,",'
Polyester
.j,":"
Epoxy ,: -
II
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (IR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
<10
'"
N
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum G
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich R
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
14 R~~H"I-H~H"'I-~-+"H"++-"I-i
U
OF gi)'~> gfg; ~{f61 ~(g' ~;~'l ~·Z~j g:'g! ~:~'. ~~g' ~~2. s
;,>;:JJ ~"r'::: r-,~: r- :t"II' N .Y\j: N 'N f"l'l~, f"l'l-t'rJ fY'I :'~' qo ::~ '¢
~~~~o~N~:~~;~~~E~~f"l'l~~~~~
II
of 0 0',6; 0';(;>0 o'::6! 0':0' 0':0: 0\6; 0:6: ~:.§. 0'0' 0.0: 00' 0 0
O~~~OO~N~ltD_O~~~i N~;ltD~;O:N_~
Metals '" e- ~< or- ;',!";':':: ,.. :-:Ni Nl~_' N :~N rt'l J"i'\:
t·· i> .'
m,:t":r lilt;. ) q- .'. "LtU/) Lt'll.n
::.~r
Admiralty Brass
;;"~:; ( ~: I I
-,,-,-;
1
~.,""
,0""
r; -', I I I.
~~
<',-'
Aluminum
Aluminum Bronze
G
I';, i-~ r
~ I
I
I. :
\~ 1
1
1
Brass G
l:-~ ':'" : . [.
:.: 1
I 1
I I
.
1
Bronze G
. ~
;c;
Carbon Steel
[I '. '.
I
I.
I I
I
ftt,~
G [.
I I
I I I
Columbium (Niobium) E •• I: .
I
Copper G f\' I I~ [
[
.
.
I;, I
Hastelloy B/B-2 G I
Hastelloy C/C-276 50% E
l!il , . : I: 1
I 1
I
Hastelloy D
'.'1
;.' I', I:: I
.
1
I.:
Hastelloy G/G-3 1
II 1
..
3 '." 1
If~~1 ::
High Silicon Iron 1 -: ..... :
Inconel 600/625 1 G
I:; I:
1 I',. .''.
1 '
1 I'
[
I
Incolloy 800/825 : I I:
I~
1
1
Lead G ~ v.
I 1:\ I I
Monel 400
Naval Bronze
G Ie I
Iv [•. I' I·:I I:I: I.
Nickel 200/201 G I:: I·: I: 1 1\ I
I:I.": I'I· II
1
I,:
Ni-Resist
r~~1 I II. I'
Stainless Steels
;;; I~: I> :" I
I; I
1
Type 304/347 G I
I I 1
~
1
t Type 316/316 L G I:', I, • .'
1/I' , I>
I: I
~
Type 400 series I I
I
Type 904-L '.<
[, I; i·.·. k I:' '.
I:
.:
17-4 PH
",. 1
1
••••
I II : I I
I
I
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
G I~j
I'
~~...
I>~'
I
'.
I·
I'I
J
f'
I I II
I
I: I '
I,~' II'.. I.I
I' [
I,
Stellite
I I~· I'
I;
~Il
"
""
Tantalum r. I, : !' I'; I .
O~O'! 0 ~6~
·V;i.
~',,;)
&;,':
~;--". b [ I I: I
06; C.N
I'
0,0:: 0 :0
I
o 0;'61 0 ,-'cb:: ~ . o _;q~ ~~:_
OF W'CO' N; oq- ;u:r 00 ';0;
~;~?-: ,... ~j ~ ln~ ,... ~NJ '" co·
N~~,
0 'N
m;.Mj
r 00;0'
m.!¢;q--·- ..
0
N .•.
.-,~ ",.:
~ _~ o::t .J""
. o::t" 'Ln'LI'I-Ln-Ln
-;. .•.... ',<, -: "
LI'If(O; oo':C;;: ~~_; 'M'. ~ :<e ""':00' '" ~o; ,...;:N: m :-~ \0 'r< 00'6\' o:~ Nm
. . ~:J ir;~ co}:J~ ~ ~~
0 N
O( m [J;t-J
N "l:t:\0: ,.... ,,00: 0'1,' ,... :-N. t'I"I :<q' \0,....: oom
~M;
lD ,...~,...~,...i~,...~N~N~NNN.N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic i
j
Asphalt ,
j
Chlorinated Rubber I
Coal Tar 1
j
Coal Tar Epoxy 1
1
Epoxy General Purpose ,J
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate •••
Sulfur
Furan Resin
Polyester
Epoxy
Halogenated U : I· I. ,.... 1
Hydrogenated Bisphenol A I ' . I~ I.'; ( II"
-Bisphenol A U I "
Isophthalic U I::: I . .•• I
Terephthalate (PET)
Polvetherimide (ULTEM)
R I:' I 'I: :' ',' .
I • •'
Polvetheretherketone (PEEK)
" '\
Polvethersulfone \PES} "
U I''';'
k[.',
I'
I"
I >' I
Polyethvlene HMW R( I~,: .: I
Polyethvlene UHMW R ;': I:'
Polvmethvlpentene " I.-
Polypropylene (PP) R ,... I.;'
Polvstvrene
..~
=-'-'--'::'='-='''-''=~~----JU
==-'-::....:C'.:::::=~ ---JU
I
Type 400 series
Type 904-L
17-4 PH
I 20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials OF
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I~
I~
Acrylate-Butadiene (ABR
~' Ii 1
I
Butyl GR-1 (IIR) I: I , I 1
Carboxylic-Acrylonitrile- R..' I
',' I ,
I " ,
Butadiene (XNBR) I '"
I
' ,
:
,
'.,.','
,
I
(CIIR) ; ,
"
if ,
,
Hypalon (Chloro-Sulfonyl- R I .':'
Polyethylene (CSM)) ~.I\
I,"
I: I I ,
,
I,
Ethylene-Acrylic (EA) ,I' ',"
::: ~i.,
.
I I ,
.:,
Ethylene-Propylene (EPM)
. I ,
I "f,
.:. .~
(EPDM)
Ethylene-Propylene
I,{ ," "
I
: I
"
, " :,
I
Teroolymer (EPT)
FKM (Viton A) R: ;': ' : ' ,
"
I
II II
'>
'
,."
:
Hard Rubber
'-; I:
I,,',' .-
I I
". :',
Soft Rubber , I , '.
,
Isoprene (IR)
Kalrez (FPM) R
J' P ,".
.,,' ,
'"
,
,
;
Koroseal 'i~ , :" ' .
"
:;'
"
,
':
,
:§ •
"
Silicone Rubbers
"" ; ,:' :
~;:
,; :: ,.:
f
f',
' '
Fabrics
Cotton ~:: :: ,~.
Felt (Wool)
Rayon Viscose
". ",
I
\ "
'f
,:< i·
OF s i: ~ ~~: ~~ ~, ~J$.:~
N<N;
oO~OO*
';'N.! oq
l'I"I-c;!):m
o~~ 0\0
0co (0;
fT'j':~i o::t
O( ~ '"
~,~~; :E; ~', N'm .. ;iQ' 8 CJ'I :'<::l ... :N~
oo;t't.D; ",00, CJ'I ~o-_ "';:~' fT'I
fT'I ;~;: \D :-~-' 00
~;;':\ ~~; ~ rt;:.i ClO ... :;~: e-- t~j ""'N Nc:,- -' N
Metals
Admiralty Brass
Aluminum
of
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper E
Hastelloy B/B-2 G
Hastelloy C/C-276 G
Hastelloy D G
Hastelloy G/G-3
High Silicon Iron G
Inconel 600/625 G
Incolloy 800/825 E
[ Lead
Monel 400
r Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
f
If Type 304/347
tt Type 316/316 L
~
Type 400 series
Type 904-L
f 17-4 PH
t' G
! 20 Cb 3 G
fi,
{ E-Bright 26-1
[c
Silicon Bronze
~ Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
OF
O(
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
;':;--'=:-':::-'-:-'-~-------1 R~};+c"',~<cH!*-m..,....H...,..H-+'l'iiH~iiH-I
f!j; :;(~~ ,
0:6'" 0.:6; 0 ~61 0 :B~ 06i 0':6: 0
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
>
II
l
f
;
t
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
Plastics
ABS
Acetal
Acrylics
Asbestos Reinforced Epoxy
Asbestos Reinforced Phenolic
Chlorinated Polyether (Penton
CPVC
E-CTFE (Halar)
Epoxy
ETFE (Tefzel)
Nylon 6
Nylon 11
Nylon 66
Phenolic
PFA (Teflon)
Halocenated
Hydrogenated Bisphenol A
-Bisphenol A
lsophthalic
Terephthalate (PET)
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
Polyethylene HMW
Polyethylene UHMW
Polymethylpentene
Polypropylene (PP)
Polystyrene
Polysulfone
Polyvinylidene Chloride
PVC Type 1
PVC Type 2
PVDF (Kvnar)
Ryton
I
i; .,"\p
r,
,
.
~j.•.
"."i
>
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
of
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
\.
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o
o
~
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy R
Epoxy General Purpose
,
Epoxy Chemical Resistant 1,
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane) J
Phenolic j
"J
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R~""""+-
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
! PVDF (Kynar)
Ryton
R'..
.'. r,' ~~;
I:
I,
;i .
.. :
~ TFE (Teflon)
Vinyl Ester
Rfo'o++H;+.H++-+-i-+-+-i-+-f++-f-l
R. 'e:, .'. '
I OF s :~~~ g',gi
"""
~,_;\
~:~~ ~:g: ~ s t~f s ,~' ~ ~~. ~ :g' ~ >ii ~
......
_:~< """;~: N- N m Nt'\I; ,.., ',('1").' ,..,:.-'::"'t ',o:;:t, "'::t' _~- o::t
!I
SchweinerlCom7.l"ion R/!suranct Tabks: FifthEdilion, &viud and Expamud
Copyright cg 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com. 2751
-
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
"
,{ '
-.-
.-.
I
t Schweitzer/Corrosion RtJistanu Tabus: Fifth Edition, &viud and &pantkd
2759
I
Copyrighr © 2004 by Marcel Dekker, Inc. All rights reserved. For more informarion, go to www.dekker.com.
•• •• •
o
oe--
ee
.
o
'"
ee
'" '"
N
.
$chweinerlCorrosion Res1stancr Tabks: Fifth Edition, Reviud and Expantkd
2760 Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information. go to www.dekker.com.
ROSIN, DARK
Metals
Admiralty Brass : :
Aluminum
Aluminum Bronze
Brass
, '
Bronze :
Carbon Steel
Columbium (Niobium) '"
' .
Copper ,
Hastelloy B/B-2 \ ..
Hastelloy C/C-276
,
Hastelloy D .,'
Hastelloy G/G-3
.',
High Silicon Iron "
.' .
Inconel 600/625 :
Incolloy 800/825
:.
Lead ,
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316
Type 430
1I1'~
Type 904-L .
17-4 PH
20 Cb 3 60%E
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt Wool)
Rayon Viscose
•
;-.;/:j ... ~t':';: '.:,,0<,' ... ::~~-' N ::,N' N:r.t M:t.r'\'; rt'l'E!>.- M!~ N~"'~ON
o:t.i:.O
Metals "d' \, .: "d' ,'- ,,' It'l'lf) It'110
;',,,jJ
;,-~:: ?/
",
; , ,
,
Aluminum G
Aluminum Bronze
:: } I;;; 1 " ,
Brass U'
"
,
I t ;'
,
,
Bronze U I,' ,
i, :, I t,
Carbon Steel Ul , '"
r.: , , "
;~.:
,
"
"': Ii , '"
-'
, "
1/I
"
I" I'
,'"
I: I:
Hastelloy G/G-3 I' ,;' "
,
l~i, ',' I ,
High Silicon Iron
I~;I :, ,
Inconel 600/625 E
I
~y
, ,',
II: ,
Incolloy 800/825
l~:
",
Monel 400 G
Naval Bronze
I; ,
I, I:, 1
U
Nickel 200/201
Ij11 " I' I:
,
E
Ni-Resist
'"
;~ '"
," '"
,{ •.:'
,
"
:. '
:,
17-4 PH
S' , .:
I~:
"
20 Cb 3 60% E
I}:
I~ ;
',',;
t ,~ I,
,
"
E-Bright 26-1
Silicon Bronze
;,; I:' ,.'
f,: •• ) ,
l;~ I,l
Silicon Copper U
\ '"
~U ~i
Stellite :
',,; I":;il I': " ,
"'
,
Tantalum £¥)f 5'," ,j5~'
".f(
r:~
%:""'-'
[: :
::\U "i)'< i:j :,;T;,ii
I;, '
I":
:'~
Titanium ~:1t i~j.I -.;, ';<'
(~ ;:i""' :;:',: ~;~~
:!l J",-;; nr: ';
Zirconium
o:~6j
;~~~
rust ofg;otoi o:----lO:'(bil
o:9i o'~: 0,0;
:i,t'~: <,~
,
v:J'j",'
:\-;<-
j"<
,
I I '
t~o~
0>0,:
N' u \D:(:(); ~---~
0;0'
OF N;, ': lOr:CO' o !~- "It ;(,01 co
1.0 :~tx)! °f~j "I:t ~_' - ~
~~~; N;;t'~( N:;r:~ ty'J('I"I'MT~:
o:t:\D
!!_~i£ ,.... -\'ttJ ,....-r't~ fY'I oct. : "t,"t, U't'1.t'I;
~t~
~\~~l r... o-~;
O( ~.'~J ~{~r ~}m~
"': .... ;".,., N-;m:
;~{;;
.'(1): 0'
.... \D :'.7: oo\Oi
""',f'\I
.... ;~:
M"","; \D't'
;:!:>~ ,....-:~ N'N N:N
N.m
oo-en
NN
Nonmetallic Materials
Borosilicate Glass , I I ' I I
I . I
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic ",'
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
_k,'
ROSIN, LIGHT
Plastics
ABS
Acetal
Acrylics
II
polyc1;lrbonate
Asbestos Reinforced Phenolic
Chlorinated Polyether (Penton
CPVC
E-CTFE (Halar)
Epoxy
ETFE (Tefzel)
FEP
Furan (Furfural Alcohol)
Norvl
Nylon 6
Nylon 11
Nylon 66
Phenolic
PFA (Teflon)
Polyamide-Imide
Polyesters L
Bisphenol A-fumarate
Haloqenated :'
Hydrogenated Bisphenol A
-Bisphenol A
I'
Isophthalic
I:: ·
~ ~,
Terephthalate (PET)
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
" , ",'
Polyethylene HMW
Polyethylene UHMW
Polymethylpentene
Polypropylene (PP)
I
1•
Polystyrene
I
Polysulfone
Polyvinyltdene Chloride
PVC Type 1
PVC Type 2
PVDF (Kynar)
Ryton
I TFE (Teflon)
Vinyl Ester
i
I
Schweitzer/Corrosion Resistanu Tabb: Fifth Edition, Rrviud and Expanded
Copyright © 2004 by Maced Dekker, Inc. All rights reserved, For more information, go to www.dekker.com. 2767
'See also Nylon 11 under PLASTICS
20 Cb 3
k :
E-Bright 26-1
I I
Silicon Bronze I I,
,
Silicon Copper
Stellite Ie'
..
I
Tantalum
Titanium ;>
.:;
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
----
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
i
!I
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
•
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy 8/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316
Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3 .~-------j
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
ee
'"
N
I
,
ff
2774 Copyright © 2004 by Marcel Dekker, Inc. All righrs reserved. For more information, go to www.dekker.com.
II
"
l
1
-I
I
1
~
Fabrics
Cotton
Felt (Wool
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R~~j..
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
.c,
:;;:::=-Schweitzer/Corros£on Raistdnu Tabks: Fifth Edition, RroiJed and &pal/tied
0:, -Copyright (0 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com. 2779
SALENIC ACID AQUEOUS
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
~-
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
'I·::k~illl'..".•
;-",: Nonmetallic Materials
1.,,- .,' Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
I
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
"
Coatings
Acrylic
Asphalt
.r
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes "
x:
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
of 0
<0
0
0 O~!O~O~o~:o~o~o~o:~:o
~m;CODiN:~;\D~jO!N~ CO~N~~
Plastics
ABS
Acetal
U
'E
>,
1<
~ ... ...
~ ~N:~,N~"'M~'"
I>, ,\
',"",'
Ii
.
c
I,'
",~:~
>-. .:
~
,
Acrvlics '( I;r (
Asbestos Reinforced Epoxy Ii,> ,
f' ,
V: ; ',.,,'
Ii> ",'
i'~
R~
Asbestos Reinforced Phenolic j
,
"
I; L
"... ~;(.,
i
Chlorinated Polyether (Penton
"
•
,(' ,
, Ii'I.
Ul',', I,. • ",
CPVC I>
E-CTFE (Halar) R
Iii I
H
t· W. ,
Epoxy R f-
ETFE (Tefzel) R l." .. li{
"'.'
\
•
FEP R
l$i.'1
'" Ii·
~~
Nylon 11
ii ), ,,' i
••
I"i
'i' ii, lit
t\
l~\
Nylon 66
.•'.•.•
Phenolic
PFA (Teflon)
I.,.
.,••. j;~ U; ~i, I: i,,.
•••••••
Ii,:
•I
Polyamide-Imide
Polyesters K
I'·,; ;~ ie
..... ,
II.
Bisphenol A-fumarate
~I
.Cr.
M t,,: ,.;i.e
I'.,
Haloqenated ; I'·' "t
Hydrogenated Bisphenol A
-Bisphenol A
Ii; 'i, '; I'; ..,10 ,
••
~:
lsophthalic ,'. '',itrt ", i'.
Terephthalate (PET) 'ii I
I·' ,,
Polyetherimide (ULTEM) 1M ~i X I,;; "I·;' I', •.m ;,
,.,'
~ li, ,
Polyetheretherketone (PEEK)
" '. J' "
I., ;~;
Polyethersulfone (PES) 10';
;'.
I;i·~
Polyethylene HMW R ',.' Ii.!' :'
Polyethylene UHMW I;.'.
Polymethylpentene R
;; i ;; "
1(J' Ix;1 .... .<!' ;
Polypropylene (PP) R
;0; I;
•
'ii :,
Polystyrene
Polysulfone
Polyvinylidene Chloride
'!
U it;
U ii;,
'i~
Iii: I;;:,
ii,·
.; lei
/ii~ :x
'.
.; ;"
;;
PVC Type 1 U ;,1; H'· Ii i' i '.
~~
.'';.'•.''"
~;.
if li.'
r~9'
PVC Type 2 U I ",
PVDF (Kynar)
I'i'. r),
I'
R IP IY'
Ryton ii ii.
\,.
I': I;
TFE (Teflon) R ""; ,
Vinyl Ester .- il"
R ;.'>'<:)' ";\J "",','
O' ,{
! 'fl I)
OF s r~_i ~:~l ~:;~ ~ "~: ~ ?~: g';i g~~1 ~ ,~:. g:8: ~6- s
,~,",,",,~
;!:"" e- ... ::;, e-- _~, N N- N N rt'lP'( M:M: rt'l "¢: o:::r ~~_. o:::r
O( Ln ::~:'
..... co:~: \0
N-l't'l'..q·
,:':'\:'
9 :~~: Nth ~CO:~ 0\0;
o:::r:tD! NM
com 0:..- o:::r ... ::r'f enm-:~':
r....CQ_ 0 ....\O-~:
N
\£)'
'. ," ........ - ........ ,... ~ .... _~........ ·N. N N- N
ex)
rt'l
Nonmetallic Materials
Borosilicate Glass ••' . I '.
Carbon
Carbon-Graphite Resin
Impregnated-Furan · ,
Ceramics
, .
Coatings · .' .
Acrylic
.. "
Asphalt · .
Chlorinated Rubber ':. '
Coal Tar
Coal Tar Epoxy . .
· ':
Epoxy General Purpose " '.
Epoxy Chemical Resistant . ".
.
Epoxy Polyamide · .
· ....
Oil Base
': " .
(Alkyd, Epoxy, Urethane) · .
.
Phenolic
Polyester · ..
Polyvinyl Chloride
Silicones ••• •
.:. '.
•
Urethanes .. . :.
Vinyls '. '.
Water Base : .'
linc Rich
... '.
.,.: ••..
Mortars :.' •. '
Silicate
. •
Sodium Silicate
Potassium Silicate
:: . ::
':' i.:' ;' .: ' "
'."
"
"
. ,
: , ,
,i.'
Furan Resin ..
:::.
,", "
Polyester ,':
1<
" : ,
Epoxy :
, : .' "
of 0:8'; 0 <0: 0 ~o-: 0 ::0: 0 _:~, ~ :~_ 0 0 ' 0 -'ci ~ :.:~ oc:{ 0
\D _~! o ,'r'4I' 'lit i~' 00 _~o: ~ ~.. ': 0 iN' 'lit ~l;O; ~ .~~ \0
Plastics ~;;H 'l"" "~; 'l""~~ e- J::~,::~- m -;1"1''1,1 "'_(\1: : : "=t
Polybutylene
R~ I' •
Acetal ). !'!,. '" .••..,. Ii
<; I' . ': I'
~
Acrylics
I.~ I;::; ;.Ii .'
.~~
i'
Asbestos Reinforced Epoxy
·,,1 ;6 V' I: ••••••••• i'
Asbestos Reinforced Phenolic
Chlorinated Polyether (Penton R
1m.
·U','
• I,. ••••
I 5" ..! "
~1~1
I
CPVC U
E-CTFE (Halar)
k , ••••••
'M >
••••••••
..',
1. .'
~
Epoxy
ETFE (Tefzel) ~J.
i;"
FEP ,
R H!0/ 1'7'1
Furan (Furfural Alcohol) R in I~~ .:
Norvl
."
"" .~ 'J
.y ie
Nylon 6 R
~i
~i
Nylon 11
!.~, .y i,' I{.;
Nylon 66 I.\ l[i
Phenolic
PFA (Teflon)
"'.' i'!. ;1;
R li'.;1 i.i
~
;;
Polyamide-Imide
Polyesters
I;; i.
ti:.J
.;.
Bisphenol A-fumarate R ~Wli F';; ;J.,; .;,i ;2
Halogenated R h:' .~•.
~. 16 ;',' •
Hydrogenated Bisphenol A
~.
-Bisphenol A
.' -
./
;~ I;, in i.':
1'1}
Isophthalic R~ Ii:
.~"
I ..
t
Terephthalate (PET) Ii': 'i'
Polyetherimide (ULTEM)
:~ :i; l.:: I, jj
Polyetheretherketone (PEEK)
I.·.
I; ..;
I·,! ';t
Polyethersulfone (PES)
IX :rl , j. It; • ::
~~ n·~~
Polyethylene HMW 'ru .< i.·;,
Polyethylene UHMW
R,.; >. IJ [; ij:
;i:
Polvrnethvloentene
Polypropylene (PP)
R
R ii;
-~;' ';J!
.:,,' ':"
Iii'
,.'. i, .;
Polystyrene .'! ·x.
i". ~';
Polvsulfone (PSF) R - • ~;
~I~, ~ .,
'
Polvvinvlidene Chloride R ••• ;ii! A i.,
~.
pvc Type 1 R ii',
PVC Type 2 U
i~ I, •••
jc~ Ii:; iii
PVDF (Kynar) R
Ryton (&; ~;;I
TFE (Teflon) Ri(nt -';-"
." ~
.~1-; ',C_,
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Furan
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane) /
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
,
Epoxy i
j
OF g;~;~ '~ ~~~; ~.~.~ .~~~.~ .~~.~ ~
O( ~:~; ~ :,,:Jl ~;~' &1~~~j ~~:~J S:'~: :! '§: 5:~: m-~; ~ :~~: ~ I
Schweio:erlCon-osiofl Rrsimmu Tables: FifthEdition, Reviudand Expantkd
2794 Copyright © 2004 by Marcel Dekker, Inc. All rightS reserved. For more information, go to www.dekker.com.
:::=,-==:,,,,---~ ~R~.~~~1'1
=:=:~:.:.L."='-"='--=":'".:~_--IR
~~CLI::"-' --IR
~~~--'=-;c-- --1R
~::":"-'"-=="'-- --1R~~"""1I-~....j;o:.I
~::'-;:;::-::-----,--- --1R ~....,.~ (,I.-I'ii'l~H;,;.j
;';:---"'~="'L --1R ~-l!l!'l~H'i'\iI-*,*~f-+,"4-~-+HI-+o+-l
R ?~;; C<;, '~. .. •. ,}
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o:6'o~:o-dob:ob'oSob:odo,6:o'o'o
PIast "ICS of \.0:«)' C'N· oo;t\o: CC,:O Nil;;t: "" co' Or,., oc:tt.D: ceo N :o;;t: lD
i:~" <r"'" ::~' "'~t;-, ... }~ N 'f'\I! N'N; f'I"I :1"1'1; M 'M: f'I"I ,"¢: .q:~ "It
ABS I, . I.
Acetal I ". I .. I
Acrylics I I
Asbestos Reinforced Epoxy I . I. I I.
Asbestos Reinforced Phenolic I .. I, : I I .
Chlorinated Polyether(Penton I .,.'; II' I I
CPVC
E-CTFE (l-lalar)
11
1" I . , ••.
I
i. •. I . . ..
" ,
I
i
I
1 I '•
' ...
I•
I
l
Epoxy ~''" ,~;~ I' 'I'"
ETFE (Tefzel)
.1\ I" I'
I,
I I Ii"
I
II I ,.' . .•
I
I ; I; (
I: I ~
I I,
i
I
I.
Phenolic I' I:, I··
I'.. '': I,
I '
I· I ' I I
I: I, 1
PFA (Teflon)
Polyamide-Imide
Polyesters
I'
:
I I,,:
I' '.:
I,'
I: I, , ' I .
I: ,;' :.;'
I;;. I" ,> II';
X
Bisphenol A-fumarate
Halo!:jenated
Hydrogenated Bisphenol A .
" I, .'" I.
I.. ,: II: I
I: I:
I"
I,
~:.
I.,
II
-Bisphenol A I'·' I: I:: I I -: I "
i II'
Polyethylene HMW
Polyethylene UHMW
:: ' . .
• ",,''; kl, ' ".' .:. I
I
I
P~:~~~~~IPentene
Pol ro lene (PP)
1\I: I:'
1,1
. t:.
I. i
' ,". I." ,: lit' I':
I'
Polystyrene I~ " \ I I ' "I.: I'
Polysulfone .," :;. I I: . ' I: I [;
~~I~y~:~~~ne Chloride ~:';: ['; I:·:, .;: [ i: h
PVC Type 2
PVDF (Kynar)
;
R ;'
"';,.
.'~ :
1::
I> I';
I. I. :..' I
I, , :
I,
Ryton
TFE (Teflon)
.'
:
,.:
I L
I'I.' .".•. Ii,'
:. r
Vinyl Ester i';-: I', I. ; .', f. I, ;.
:,
OF ~ ~ ,~ @:~,' ~~~: ~ ~'~: ~:*, ~:,,$1 ~ ~
O( Ll'\:1.0 00 '(ri, 0·.... N 'rwi: 'tt,fL( r-, '«f' 0\0: .... iN, l'I"l'~, \Ok'
~'N~l'I"l~\O'~:c:om:O~:Nm:~·~,r-.OO:~O:~<N'M
ce
..C'" "',; '~":' "" 't""':_,..... """':: .... _: .... »-: ~('.I' N N N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
L
"I',','
i
,I' ,
I "
.
,
I:
.
''
. ' ,,' ,
Polyethylene UHMW R I;,' I i · · -, .
Polymethylpentene
PolYPropylene (PP) R;,,:,
,,':
, I "
I". : "".' II ..
",':
Polystyrene " • . '
Polysulfone ", I : ,
" ', ", ' I ' ", ; "'. :
Polyvinylidene Chloride '".'", / Ii i Ii' I' '.' ';.'
pvc Type 1 R' I,', I;
PVC Type 2
; . If
',;, I''I: "
I:;'
.' '
Fabrics
Cotton
Felt Wool)
Rayon Viscose
'.1
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 825
Galv. Stl.
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 317/317 L
Type 321
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vin~s R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
._----------j
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
;.
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825 E
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3 E
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
....•. Ii
<
.:
.•
j. . I.
~~~::E (Halar) RR ~.~~
Llllii!!..~
1\')'1, .i i! [',.',i.
~~~E
o
= 11ii!i'r"'.: I··-;···,'.'
h,,, i)
IF
(Tefzel)
Furan (Furfural Alcohol, R ~
I.....· 1\ I 1),,'1
i
v" .:
L'!l",.).
.. I·...
I)
..••
I> .• .•.
1 1 ; ; " ;..
.,. .'.) ii''i. I").
Norylii ',; ... .)
Nylon 6 I~!
Nylon
Nylon 66
:.
)i
~..
.vi,)'J ,),
f
I)
Phenolic); ',".
PFA (Teflon) R I
..J
..... I'; I
, V
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
HastelIoy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Galv. Stl.
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series 10-90% G
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum 50% E
Titanium 50% E
Zirconium 50% G .sa '." ;';:,
Nonmetallic Materials
Coatings
Acrylic I.
Asphalt 1\I:c.
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic ;c:
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy 8/8-3
High Silicon Iron
Inconel 600/625
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber "
Coal Tar
Coal Tar Epoxy ,
,
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
SOAPS
I
II I.
Fabrics
Colton
Felt (Wool)
Rayon Viscose
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin I
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
:'0:
of O)Oi~:
-... o00 ~_(~: ~~;: ::-0' :;~
0 0\0;0:0:0
.0:' 0N .q', IDCIQ
0 0 0qo 00,'0: N ~; \0
1O]~j
O'M'
Plastics ""';:q.4: Nf'I; N~t:'I' t'l"If"l' m l"I"It~, 'I:t -_-~: q-
,
i,
Polybutylene Terephthalate R i' v
~'?i I,1/
;-;'!
Acetal R ii ....
t Ii ..
W; (:
Acrylics R fe t))' '2 ; .'
polycarbonate RT r. t.. <
R(:': i
polyphenylene Oxide %) ;; ii "
·'v·
i'·. ;
Chlorinated Polyether (Penton R 1/ I, .:
' i'ii
l~>
•. •...
":
I~ I;i..
CPVC R Ii
E-CTFE (Halar)
Epoxy R I';
••
.'
<
,..•'
"," .
L i'
ii, f~i
It
ETFE (Tefzel)
fA
if .~ ';, I"i
FEP R
'~,
<)~
Furan (Furfural Alcohol fa, ' '
Nylon 6 R ;'..;
j~ .;, > Ii'.
Nylon 11 R A i,.
I~
iIfu
Nylon 66 R •••• i'. ,;
Phenolic '); i'E i
PFA (Teflon)
iI;' i; ,k.i t
R
'J0'
Polyamide-Imide i;
': E
It
~it1 ~:
' .i, ,,'
'I'
i\ I~';
Polyesters
Bisphenol A-fumarate R
.; ..... i: I'; I'},
,". i'. ,g
I;~:
Halogenated R < ., •...
J) i.' :
~ ~
Hydrogenated Bisphenol A <,e
,i•
iE'
; i
-Bisohenol A
lsonhthallc R
1
,< II; It:
I~, I
"
I~
;.
Terephthalate (PET i,i'
ii?:; x ii,
Polyetherimide (ULTEM .I. • I.:i
I~
.I.;
Polyetheretherketone (PEEK) H .; i··.·.• iN.•....
.~
Polyethersulfone (PES)
;';
.'
I'!'
Polyethylene HMW
Polyethylene UHMW
Rt:;:';1
R
i ·Iii I;;.
1"
Polvrnethvlpentene Hi;i'! ZI :I
;I I;.
Polypropylene (PP)
Polystyrene
R
': II i;";". n.
ii,
Polysulfone R
ii;' if
ii; IJ!
~i
Polvvinvlidene Chloride
pvc Type 1
R
R :2; ',: t~ ·i.~·.,.c I;;~ ,i
1'\\
PVC Type 2
PVDF (Kynar)
R;;'"
R
•••
'I' .,
i,
;~,
i·. I'Ii,
Ii
Ryton 'i,
ii; z; ;,~ ;'
TFE (Teflon)
Vinyl Ester
R
R,,,,
.,,;
!~
,.
<,~'
;,~>
'....,;~
•. ,; ,-
..
'-';;,:'
N
obto6Io~o~o~o~o6!oBoBo&o
OF 1.0 :-00: ONi "'d' ~\Q' 00'0': N::o:::t~ \D .eo O,N: 'd' ,'\0 CO-O' N :_~- \0
':iF' ...;:C, ... :;,r;-:-, ""'" l'"e N ~N NN,' M;"); l'I"l )!\.: m :'...,.: ""'. ,:: "'"
Ln ',<0-: co --ffi< ~ :~'1 N~M~ "'"-_t.O~ f'oin' 0'\
O( ... :~m~\O ClO~'O~'N~¢:~:f'o~O'\O,"'~M e- 'N- t'l"I_~' \0'.;;':";'.: cooJ
:':',-:'1.,: .. :'''' r ! .... e-. ""._: " ' - _ i .... ·N' N_N' N
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Metals
of 0::;0
~_~o
?',i"""
0 ;~; o':t:>,: 0:,'0: 0
~'W'CO;O:N
<r"'";~·:<r"'",N.N
0'0" 0'<::)' 0
lD ,00.- O:N. 'llt
N'f!'I;mm,m
0'0- 0'.0. 0'0: 0:0:
CO.O:N~:lDOO·O'N'llt~
m-'C;t,: 'Ct:~: 'llt,..q-;
00
an}l"l' anI./)
~ ~
,~ .,
, ~
Admiralty Brass E; , '~ . ~ I '~:
G I
Aluminum , ' ~
• I
Aluminum Bronze E ~
I
,
I ,
..
,
• ,
I
Brass G- I «,
I . ,
Bronze G
I· ,
, ,~
I I I
I I
,
G'
I.:, ',,:.
Carbon Steel I, .
"
,
;
~
I
Columbium (Niobium) "
.. . Ii.: ~ "
I I I
I I
r~ •
~.,
I
,~I •
Copper G ,
Ii
~ I
I, I
Hastelloy B/B-2 G % :,. I,
[, I I I
Hastelloy C/C-276 E >.. I I' I I
"
I'
I: II I
E~ I.: [}
Hastelloy D
I:
.' ~.
I"
I [
Hastelloy G/G-3 Ii( [:
"
.,
~ I ,
,;. ., :
I
~
I
I
I
II I
High Silicon Iron
"'. ~~,' I ,
Inconel 600/625 r, . :,
. I .
I' '~ ....
I; I I
~ I
I
I: I:
Incolloy 800/825 :, .~ I· I ~. I
I
Lead G
I I L II
Monel 400 G
, - :~ ; i•.
1
I I
I
.
I
I
Naval Bronze
Nickel 200/201
Ni-Resist
E
G
G
I: I;
:,
I
I'
I.
I :
I: I
1
I
I
1
.:
Stainless Steels ;: I i.
. ~
1'<
I
~
"
,',
I I
I
Type 304/347 G
I ~,'
: •••• I: I'"~, I~~ I: I· I
~: I',
Type 316/316 L
";,
,
1
I I
I
I' II II
I,
'.
Type 400 series
Type 904-L ;~: .•..
; ;;'
.':
., I I: k II '
I
I·
I I,''
I
~
I'
17-4 PH 1
'. ,
.. I
20 Cb 3 G - f;'. ;:
v
I; I"
I
I:
I: I:I,'..
~, :: I
E-Bright 26-1
Silicon Bronze E F', ;: •••••
I:
;'.:
I:: '.: I
I
Ij:
I '
I '
I.
Silicon Copper E yi; "
I
I
I,
':, II:, I
Stellite
I
I,
Tantalum E~ ': .. ; ,',
, i> I I
. I:
Titanium Eo..
''",:: i'
I I:I,
1 '
f I",' I, I'
.'
L-~"
: I,
Zirconium :::~
t>::;,
,
I " '
II I' ,
"
o:,6~ 0 '~
re ~ ~ ~ .~,~ ~;~ ~~: ~.~' ~
0:8: 0 ;;"0000,0
OF \D h:~:i ~ ::~.: ;! ~ ~.1 ~
U1_:~:
O( ..... :N m:~\'lD Q) N ::7' 0,
:-:~; 0 ~; QOen: ~ \0' r... :,C1J'
...... Nm Ol i~, ""'co'
o:t,\O' <r"'" <~~ ~ ~:~' ~;~. co'cn" o::~: ":m
N
m 'tf'; lD,,....~ oo,cn
," ";";:< '.0,~<r"'"'_:.""'"","::<r"'",_,,,,,",
... , NN N'N'''''''N
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride
Silicones RI!i"+++-
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Epoxy .••• I I· ;
ETFE (Tefzel) ;; I,: .:. I'· ;." ;,', •
FEP R ,.
Furan (Furfural Alcohol) :Z I';," I:. '. '. ' ~:: .:;
Norvl R~ '...' I: ~,,:,
~ II:. :.<
u' •. ..
Nylon 6
Nylon 11
R 7'
R~. ,; .• .
;' !;:: :,'. ..'.:
Nylon 66 R ~, I:,:"" ...,
Phenolic: I;," .•. :,' [,i "
PFA (Teflon) R " f.' \ ' I, »: .'
Polyamide-Imide " ':":' .'. '. '. I;: •. .
Polyesters :'. '.' , ;'. ,Y. ).' i·'
Bisphenol A-fumarate 1% R ~.:.. ;" ' .
Halogenated 1% R ". 1,\ ; : : ; : ; tz:,
Hydrogenated Bisphenol A ,"1 ,.' . ., ;;.
-Bisphenol A , , : : ,,';" ?'
R~
R~",
~'~":"'"
;.
h:';'
:.;
',' ' ;.
',., .
';. , :;:
;, . ·
I
I
r~ "; '.:', ..•.
:;
.'
00- '0-
Elastomers' and Linings OF '" ~\g:-~.~;_:
0 0/6:' 0 0 0 0'6: 0 6 0 d 0
.... ;*"; . . Cl):o:N}q-:\O,.OO·O-N''II:t<1.D ClO·O,N~:l.D
f ..
-~;
Carboxylic-Acrylonitrile- i f ••
I· 'i
.F"
I I. ••• ••
•
I•••••• i, i. ..' ;'
r. ..
Butadiene (XNBR)
Chemraz (FPM) R k' "
,. I: I' I'. . I· Ii
/
>
!'~'
Chloro-Isobutene-Isoprene I' i' "
...
/ .'." Ii '.,;"
<
' ...•. ••••••
)
I· . i.•...•.
(CIIR)
Hypalon (Chloro-Sulfonyl- R
.'.i,, ii. I·
Ii; \
Polyethylene (CSM»
;: ~I;i
,s,:''i.
..
'i , Iii 1<
I".
:'
Ethylene-Acrylic (EA)
ft'Il·t". i!! Ii: it -, 'ij
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene R ti-
iit :e"•1i,. :. li
~Y Ii ii i
I,i
I.{
"',..
:
'
Iii
i.
if
..•..
'. i..· :•
(EPDM) Iii •••• ...
Ethylene-Propylene R
Fi}
iii
Ii• "
i ,;
Terpolymer (EPT)
I,'
.. if
•
!ii
I':: " , 'ii
FKM (Viton A) R
Hard Rubber
;. if i,•• i. ....'
R
". [.1 j
Soft Rubber R @ i I, i
Isoprene (IR)
Kalrez (FPM)
R
R
Ui :: ,:
i·
;
i:
i:
-:
"
p
• i
,
:i I', ,:i .; <
Koroseal
f'li•• ..'.'. ,i·
••••••
Natural Rubber (GRS)
Neoprene GR-M (CR)
R
R
i I.::
i,
i "
ii,
Ii
If
;
p'
.
;
.ii ii
....
Nitrile Buna-N NBR) R
I:
,i " < . •...
Nordel (EPDM R liii i; i
IT :
..
'.
I
'.,
Polybutadiene (BR)
~;
R i<
< "
Polyester (PE)
Polyether-Urethane (EU R
11::;1
c:
>
..... Ii
i
, I: , ;",,
:•..
ii
..
••
Polvisonrene OR)
•
I, "'i'
I , iii
li~'
;i ••••
Polvsulfides (T) , ii: '"
I;: Ii· .. , ,:i'
••••••
Polyurethane AU) R ,,'
SBR Styrene Buna-S) R
lei
'
ii,'
I::·,
:
"'.', "
"
} •••••••
•••• ,
..' ;','
<»:
;
OF 0:0':
ID:OO'O(-N:OI:tJ,o,'OO,O;N-;lDiQOO:N:o:::t'.IO·COO'
U;--; "'"" t~_: ,.... ,:'"7; ,... \N- N '.f'\! N~ rt'Lm; rt'l (Y"" m~.:
lD
o:::t
~~;C:O:~O~N:~o:::t·~~~~~"",·~.m~~lD~~oo
O( _~;m#lD,Noo~iO~:NMo:::t:ID;~~;~;O"""Nrt'l
-'-"/: {->'._ ::c> '':.':. "'"" :.- e- ..-- ,.... ..... ,.... .,.....' 'II"'" ,'N; N ,N N
I t , ,
I I
I I
I
I"
I: I
I
I I
I
I i<
I,'
I, ,.•'.
I
I' ,
I'
" "
. .
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin ·
,
Impregnated
t
Ceramics ..; I
i
Coatings . I
I I
Acrylic I I
.. , .
Asphalt , . . I' I
Chlorinated Rubber
Coal Tar
,"
. . I,. I
·
Coal Tar Epoxy "
I.' I
Epoxy General Purpose
".'. . . II
, I,
Epoxy Chemical Resistant ·
,', , • , I
Epoxy Polyamide ,
ii, I
Oil Base
I'I
(Alkyd, Epoxy, Urethane) , I. I
Phenolic , ~ ." I
Polyester .. [ I
Polyvinyl Chloride I I
Silicones
'.' I.I
Urethanes l- I I
I I I
" I' I,
Zinc Rich I
. . [" I,
I I
I I. I
I:' I'· .'
I I.
I;:
Potassium Silicate .. ,.
....
Silica .
Sulfur
Furan Resin
Polyester
Epoxy
I~
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
I
I'
I· '
High Silicon Iron G I'" I" •. • • .. I:' I I•
Inconel 600/625 10-30% G II.'...·.',"'. . . I, .,' .:. ;.' .' I·. II" I. I
Incolloy 800/825 G ... I. . I" I II
~:::
I . ,
Nonmetallic Materials
Borosilicate Glass t
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
,
I
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Kalrez (FPM)
~---=--'-;-'---L-_-----i
R " '" I , I ' : '": " ,'.',
:::
Koroseal ' ., I '" C
:7"':---=:"
1 =R---:-:-b-(=G=R=S,---I ' I , ':' :;'
Natura ub er
Neoprene GR-M (CR)
'I
R ,,'"
R , :,,": '.;',
"
I ,
'" ::'
~~:-'-"";-:--~~---IR"',
Nitrile Buna-N (NBR) '----i ,
1--I-"'1"';j-j.Ooj- "" "
I ,' I'I'" '." '," ,
Nordel ( E P D M ) , ,'1 I ,':
Polybutadiene (BR) .: " I " '; i,.
Polyester (PE)
Polyether-Urethane (EU)
Polvisoorene (IR) ,: I' :',', I I,: I
Polvsulfides (T) I, 'I";' I ," :, I
Polyurethane (AU) ,': :' " " . [,: i,' , ,-/
;~
II ','
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Carbon R i I
. I
Carbon-Graphite Resin :, l, "
'
,c. 1
I>
i
,
Impregnated R . ·
.' I,
kI .. I.
' '; ,
,
Ceramics , , I·
, •• ,
"
:
,
" ,
f !;
Coatings i I; ' .•.. , : , "
I
'~!,' !'••
",
, ,
Acrylic , '
.
,
..:
.
~ I...
Asphalt 3, I. /, .
V\~',' i,,'
Chlorinated Rubber
Coal Tar
,J
.:
," ,
. ,
' .,
"
'; ,
• ). '::'..;,
:,:
:'
,
" •
Coal Tar Epoxy I··· ' .' , · .
' I'
,.
Epoxy General Purpose . •"
'. I·
'
••
Epoxy Chemical Resistant '. ,
1
I:
.
, .
, " i%
'.~• ,:
I~
Epoxy Polyamide , :
. '
,'.
.. " ::;.
Oil Base
(Alkyd, Epoxy, Urethane) ,""
. ,
"
. f' .•• . :
..•.
Phenolic [;:j •.' '.' f' ,
.
:')
'
. :.' :
Polyester . •'.
Polyvinyl Chloride R ;"
,
IS: : .
:'
I~,
,
Silicones ,. •••
Urethanes
}
:', , .', .
,
~ l'l
Mortars
Silicate
.,.
"
.. ;
,
• :' ::
.,'.
...
r
Sodium Silicate .•.. ',
Potassium Silicate 5, ''.'' "
Silica
;.;:
.',
>. }
I"
;: [; ~.
"
Sulfur .. ; "
>:
,{
:: ..'.
Furan Resin ;". S·
Polyester I~
Epoxy f"i; •••• '. :~ ~I.
o~~
OF (,0 -';QQ\ 6~:l
0<qo..a, N
0
0,:'0- 0
"":00: ON. "!t,w;
ogi :'j'
'.0' 0'0,"
'N;. ,: co~··
0 0
\0
~}¥, ~ ~-r~ ~J N N ,NI: ~ ,~' m "1\'1: t'l"I~lI:l:t_ ...:t ,:, ,; o::t
O( lI'I :(0:
-f.N'
co '~.
m~. ,""'rs' co~~~!R: ,'"
0 ....: '"
"j
0 :~'- N·("t"r
r-, co '" 0 ~ '.1'/' (!;. '" ..... co
'"
...:t .'-0.' """cx)' 0\ '.' . ' ~N m
~ ~)~ l)~~ ~~-~~p~~~~~.Ni~N
I ',',
I',
I'"
I ";,
,,',
• fJ II" ', .. ;
Galv, StL U " I 1 : "" "
~,t
i ';
".!
I:;,
Il" 'c}y;"
.':1:. 'V
I'
I~' ,.T ,) I.
Coal Tar Epoxy
Epoxy General Purpose
R
R
- r..•.·
I'~['. !i I;'
IF IU....
Iv
"
ift 11:; .....
I' tw
f~ 'l
Epoxy Chemical Resistant R ,•.•
.
't' Iii, I ;>
TI;
"
IF'. ;'
Epoxy Polyamide RI- Ii. ,: ••••
I: ,;
Oil Base i' IW~ it ;. ••
,'. 1<
j~
(Alkyd, Epoxy, Urethane) )
Phenolic
'i;
~!;,i; ii' I,t:
y I·>
~
Polyester R - ),
!~~ I~,i ;:
I;~ ...,
Polyvinyl Chloride R 'If r·; I" I".
Silicones R icc;:
'F. ii, i" I,
I)r~,
~~:'
Urethanes
!'/f If; liN
Vinyls R ·i·; r~i
Water Base
I~' >
Zinc Rich
,F·
i"
~.:
'i Hi, :V;
if
c,~
I";,:
iN
Lj Ii
t!;~
i;
,.
~;il i~ (/ '\~ d~
Mortars
\'.
Silicate U .~~.
R '( :'. %
Sodium Silicate
R i!!:
i
Potassium Silicate
Silica
Sulfur
~~$I
R
1;",1
,...:
, :;
f
... g~ iT
1:
7;
z:
:
:(
)~' •!
i
Furan Resin R
G :.
Polyester
Epoxy
R
R
[6:'1
:f}
~{~t ><;'
...• .;: Ki;:
·c ii .':' h
; ... :
;"2i .$
.
o ~d~
OF \.0;.<:0: 0 :6', 0,'0 0 ',~di 0 '6, 0 -0' O:b~ 0
1
~ ~g
g ,..g ;~;
EIastorners* and L"ln"In9s of g ,/j~'''.; ~ g :;: ~ ~ :il g ~ ~ g ~8 :;: ~ ~
,...~.: ,.. '"t:'>l' N ,\':"': N:r"'oj:: t'I'\"", m "Ctl m'v; oe:t -'.::t; "'"
Acrylate-Butadiene (ABR
ButyIGR-1(IIR R'
" . ',i,'
, I
ii"
I
I' I,I 1"
Ethylene-Propylene R !" I . •.
Terpolymer (EPT).~ I '. I, I. ' ,
FKM (Viton A) R I':.I;i I:;, >
Hard Rubber R I: I~ I '.' I,:
Soft Rubber R ,'. I' ", i;,.
Isoprene (IR) R~ J I: I':' ,i I', .
Kalrez (FPM) R~ I,.; I ., I I., I::, '.,:
Koroseal R " I';' I:' I;; .,';
Natural Rubber (GRS)
Neoprene GR-M (CR)
R
R
1/ I.'
I
I',
.", I, I·
I I,' !\{ :
·.i
Nitrile Buna-N NBR) R I,' , I',
I' '
1 ';
Nordel (EPDM R I; I
Polybutadiene BR)
Polyester (PE)
R if :
..: ;
1<
, ; t
I
I'
I..'
I'Ii,:,:
I'; '.;
',.
;~
i I.' l,
I;
I, I·:';
I: I> I,
I'
I;· ,.'
I:,;"
I::
I:; .'.
r;
, : ,~ ~ I' ~ ,
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
. Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
O( U1 iU5: co
..... ,:N,rt'l
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
~~----j
Mortars
Silicate
"
Sodium Silicate
Potassium Silicate 50% R'::
Silica 50%R"
Sulfur 50%R;
Furan Resin 50% R"."
Polyester
Epoxy
:; " :
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Metals
lI'll$' oo':(ri'
0
<D
0 j:;).
~:=~ ~~ ~
0:)
O( ..... :st:: M_:t~E: ID • . >i ClO:;?8.'
OF ,0: g~:; o~d'
N J~\,
g :::l ~
<q' ';i:P' 0\<3•... >N, M '.'i;::f' ID-~: CO ;en-O~: N '·m
r-,
~ ~ ~ ~
~,~
;;'; m::g~
0'0: 0:0 0:0 0
~ ~ ~ ~ ~ ~ ;;l; ~
0 0 '0 II
Admiralty Brass Gul I fl' '" I :. I .
Aluminum . L
I I . . '
Aluminum Bronze U! . I . .
I . I I
I~
.
.! .' '. :
. .. .
I: . . ';.'
i
u:'
I
Nonmetallic Materials
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Urethanes
Zinc Rich
Mortars
Silicate
Sodium Silicate
I::' ,
1_
\/
Potassium Silicate "
I';
Silica
Sulfur II '~
Furan Resin l>
;-"F I';'
Polyester '.'/,'
"." C:;"
"
Epoxy ;'"
';/1;;
Chloro-Isobutene-lsoprene I
I I I
(CIIR)
Hypalon (Chloro-Sulfonyl-
I.
....
.
.'
RI-..+-IH-++-+. r :
. I
, lr
r
I I
I'
.
.
r ------IR
I'· . I1 I I.' ,
:=.S.::.;of=t:..oR=ub=b""eCc- I··' ;, ::
Isoprene (IR)
Kalrez (FPM)
RR I, I I: 1 '- II'
I I
I
I
,
II' II'
~~~~~~a~Ubber (GRS\ )1
R r,:::
d '." I"
I: .',.' I
I
.'. t' .,.;
:,
Neoprene GR-M (CR) R ' , ' , ...•
(, )\ I.,S .' •. 1< ":
Nitrile Buna-N \NBR 1 R ',' I' I ' i. ~
Nordel (EPDM) R-.,.. :, [, I:", .. . II" I. I'.
Polybutadiene (BR) ',. r· ".
Polyester (PE) , I '" c, I ",'
(.r' '. I' "
Polyether-Urethane (EU)
Polyisoprene O R ) ;
Polysulfides (T) :: .
I.I:. :.":,: ..•
I, .
~;
'.,
I " ':' " :',
r"
".
'"
Polyurethane (AU) '. !. I;' :'. "
~~~O~;~~:b~~na-s) f I': t:.· ;. .'. " i .i.. . ;
Fabrics !~ r, I;', ~::'~ \
Cotton ~ I: : .'. .:, ~., . ~ 'if
Felt (Wool)
Rayon Viscose
~:' ~.~ : '., '0 I" .'. . ".
II
Nonmetallic Materials
11
.
Mortars
I'.
Furan Resin
Polyester
Epoxy
0.:6": o-'o! 0'0' 0:"6' 0:6' 0"6' o-d 06' 06- 0'6< 0
°Fw~~g'~~lg~~.~~.~~~~~~~;~~~
~~~~I~~~~~!S!'!~~~:m~:~~~
~.
t:
~~.- &hweiner/ColTluion Resistance Tabler: Fifth Edition, lmJistdand Expanded
~ Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to wwwdekker.com. 2867
~'
~.
i··
•• ••
Butadiene (XNBR)
Chemraz (FPM)
Chloro-Isobutene-Isoprene
(CIIR)
Hypalon (Chloro-Sulfonyl-
Polyethylene (CSM))
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolvrner (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (I R)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU
Polvisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
(EPDM) Iii; k Ii ;1 ,i
mi·"
>, i",\
i'
Ethylene-Propylene R ••••••• "
Terpolymer (EPT) f I Ii •
,: ....
••••••• ••••••
FKM (Viton A) R .;'
r·~ i.
Hard Rubber R
I"f: I.:: : i I
"
r~
l.it8
IJ~
"
Soft Rubber
Isoprene (IR)
R
R "
.'; 1\
'i
:. ";
••
.i
,
Kalrez (FPM) R .: I
,!
\~
Koroseal :!;~ " ; • I
Natural Rubber (GRS) R ii,
ii'
,f' ...•
Nordel (EPDM) .. ,
Ii! •••••••
j'
It;;~ I,•
... ;
Polvbutadiene (BR)
WJ
•
.
••••••
':
0 IJ:i Ie i· ,
"J~
Polyester (PE)
Ii
.,'.'
I·:
Polyether-Urethane (EU) I
••
II I'i'
Ii••·•••
Polvisoprene (lR) .~: I". 1/',
··'i·. E.:
Polvsulfides (T) I;,
I; ••
,.); i r;~j
I·;· ". y". :
I'
Polyurethane (AU)
Ii:; I:f, ,:!j ',i
SBR Styrene (Buna-S)
Silicone Rubbers
I:" -: I'
!,
••
.!:
R; ,
: I,!!
n
i';
.: l"
Fabrics ...•;.'
",
Cotton , :
I"
I' •.;
•••••••
I:'. I)!:I
Felt (Wool) ~0 :\ .: ".
'If
{ I'. .•..•. , ;
i
,;
Rayon Viscose '> 1\
:'6' 00'
~::'~] ~( •@:
o ~o; 0,6,' 0:0:' 0
OF I~ N
N i~ N :N,
tw"I:,:m.'
0
:'¢' "",co: O.N'
0
q-
l'I"l "~N::J:'"
m', - q- - j qo
M::O:::ti ~ liZ co
.,"'i .~-_. qo-:~:: 0'.0 ~ Q'l, .~.: "''''-
°C I~ ..... N """'r"'":'I"'",..r-:- 0::::1":\0"""
,,;cir
0 _ Nm,
'1"'".'"7''1'''"
'"
'I"'"
'I"'" 'N' ec
tTl
.'1)1- N-N; N
5% E
'Tantalum
'--Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolvmer (EPT)
FKM (Viton A
Hard Rubber
Soft Rubber
Isoprene (IR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM
Polybutadiene (BR)
Polyester (PE
Polyether-Urethane (EU
Polyisoprene IR)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Furan
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Zinc Rich
Sodium Silicate
Potassium Silicate
Silica
Polyester
Epoxy
Plastics
of o\.0 :~1
'(itt 0 0::,:: 0~ip: 0::0>
-N: ~
,o"j ... ','-;'"
co 0:0': i:~ 0_:6' 0'::~;-- :co :i~ 0''::$'
'0, N }!i::t: \0
'I"'":f"'lt N
-0' 0
,'t':'I' N
C-N': 0I:t;,'to:
m'm: cYl ,~, m
N
o;t" -
\0
oo:t
ASS 25% R -.
"
i Ii I I,ii, ti ..
Acetal R ~i' 1/,
i , I,
I, I
"'i"
Asbestos Reinforced Epoxy R~
"
[,i y ,i I
I
'. I,' I ' ..,
Asbestos Reinforced Phenolic R~ ;, 2', I", , X I"
Chlorinated Polvether (Penton R i .-
'i"
,'"
I'"
f
F1' (,
CPVC R"
R I[i
f I 1
I'
I~
E-CTFE (Halar) i I, I'
Flf'il;1
Epoxy
ETFE (Tefzel) RIi'111 w
~J
if I,'
;> iT'
II.
RI'/'N
I~'i
FEP
I,i,
Furan (Furfural Alcohol) 50%
~H :;~~ ,~' 'I
,
it·'"
Noryl __
,.'
"
.... I'"~,'I,'
~r;,
R i'111 hiY] <
Nylon 6 R , .• If•
Ii; I; [',
'
IiM '
r~~ ,.
;., I.>
i, if,I;, IX I',i",
\~i$;
Bisphenol A-fumarate R IiI;
ii,
Haloqenated 10% R 1,;1 ;,1 Ii1/;.
Hydrogenated Bisphenol A I.'
-Bisphenol A 10% R ~f-
'{
,,'.
1;((
;
;
'1.
, I';
~1 , .if
I, I'
lsophthalic 20% R y£
l~
Terephthalate (PET)
1'1
!¥! i [il
R '".',
Polyetherimide (ULTEM) ~j' ,>. ,
Polyetheretherketone (PEEK) R
F
I' ~, I·}
I;, k; •••••
I~
S;' i! [;2.• ;
Polyethylene HMW R I
I)J~
~
••}/ .'
Ii' I·~,.i
D
10101 '.;.
Polyethylene UHMW R
Polvmethvlpentene
)" E
R
1j';~1 ). ¢
Polypropylene (PP) R iit
rl-filll 'i;
Polystyrene R
k I~;
Polysulfone R
m 'i·
.i.··.
1'0
.' ,
Polyvinylidene Chloride R~
1'0;1 ii I' [}i
i0. it i, I':
PVC Type 1
PVC Type 2
R
R
1';0·1 I,
E), )(, "
,
i;
I',
I
PVDF (Kvnar) R
I·f
['% .'
Ii,,:'
, s·
\"
Ryton R I, ••••••• I; ;
.1i;II,1 D,c'l I' '\ I'
TFE (Teflon)
~r;ttl I";;J ~\{ -x
U. .i
Vinyl Ester R " .. ..,' ,.
.i ~>
o~o~oEo~obo~o~obo~101~O
OF \.0 .':,~.) 0 '.t"iI'
ClQ' 1I"'"r-.l oqo '\01 00'0' N:~' ID'(l() 0 ,N: oqo'~: 00 .C)'
:N Nt'f N '('1,1' rtlm rtl 'C'li): M<Q":
11"'" ,~, .....
N ; \D
"d'" - v
~~oo~-O~N~"d'~~~'~B ..... :~·rtl~\D~OO
O( ..... NM.~\O~OO~;O~N:M.~~~~·~O,~Nrtl
',' -·-···,<·<; ..... ·............ 1I"'"_1I"'"·'":'··1I"'"N Nt'll
I
I
I'
I
I
I,
,
,
I
" ," I' I' :
.'
I ,
I
,
, ' ,
,
.-
,
I
,
,
,
,
,
,
r, I,
I :
"
I
:: I I
I ,
I
Fabrics .. "
• , ,
Cotton ,
Felt (Wool) ,
Rayon Viscose , ,
Ga~.~. G J
i
iMonel 400 10-70% E~.~ 1-
Naval Bronze G
Nickel 200/201 10-70% E~~~
Ni-Resist S
Stainless Steels
Type 304/347 50% G
Type 316/316 L TO 70% G
Type 400 series G
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
SODIUM CHLORATE
O( ~~~_O~N~~~~~~~~~m~~~~
co '0"'1 O,~l N m' "l::t.\O' ...... ·;00' en· """"".('01:,."
...... r~ ",~.IID~t':'
~ ~ ~ ~l""",~,,",,,~ ...... ~ ...... ~ ...... ~;N~:N
Nonmetallic Materials of s ;~! g:~.: :i :;~1 ~:.~' ~ :ii ~ ~g) g :I~< ~ ir~: ~.~
-::'~;i 'I"'"-:~! .,... !::.-~\ ...... ;'N- N~~; '-N' 'YL~ _~ N ",ti')
~ ~:'i- ~
oqo; : 'Q'
Carbon
;
','
f
L ,
Carbon-Graphite Resin
f; I ~ .
','
'
',: I, .
Impregnated U
:::
,
.• '
I, -.
, I
"
Ceramics R '.
I
Coatings
.~ ..
,
... I:, 1
I'
' I
; .•...
{'i-
,.
,'.
Acrylic ~
" . ',;
Asphalt t· } ,
"
f'
Chlorinated Rubber "'l "
;:' t/ I'
[
.... I· ; I
~• .
Coal Tar
I,> [, : I': I~·
r I
Coal Tar Epoxy 50% R
r~ I~'
Epoxy General Purpose 50% R 1
~.
Oil Base I.
(Alkyd, Epoxy, Urethane)
; ;, I~: .'..,
,
IiI,."
:; , I
Phenolic
Polyester
50% R
; I'·
I"
I,
I: I;
Polyvinyl Chloride R .,.
I;' (
.', [' :','
I'
Silicones
II:' ":,,
"'. I' r
I, I' I,
Urethanes !> I.' I'
Vinyls R
f;~ : I.. ~~ [;
I;,: .:
!~'
Water Base :
,
j"
Furan Resin R
"" :
1
I'
I: I
' ,
I, I; I·
Polyester R
:,
s.
:. I'I. "'.
f, I
Epoxy R 1 " 1 1'-
OF
o;6Joto;J o
O;.Nf 'I::t ~ ~'~ <:>~. <:> 0 <:> <:>' ~ ~. <:> 0: o
<:> 0
\D ;jX)j
I'''-;'~ ~)'!":!'; ~
,~: '" N co <:>
N ''N; '" N ...
mrt'L
N.~, '"
m··m' N :;j: '"
qo.; 0I:t
~in~1(~~:~~n) ~,j;
o~o~oBio~o~o~o~o~o·~oS6
""". '~~.',., ....~,;,'.,.
0F~ i';:/
~ ·.o. .. .~.~)~~
.... ~~i 'II"'"
.. :.;~.'O
.. ~N~.~ .~.:ON.i..• ·~·.~C.'.N~.'~
>-:;; . . .
,t;"I: Nr'\I: Nt;"I; "" :M' tw"I rn: tw"I,oq', ott;~, ott
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
I: ;
I'
i:," f
:
,
,
Impregnated-Phenolic R , ,
!
Ceramics R
r
i .
I: f
I
i,
:' I I' I: :i '
, ,
r
t ,
Coatings ",
,
I; , II h , ",
Acrylic I,,: ~H ~1 i
i' ,
I
I ,
I'
"
;,
,~,' ~.:),
:'
Asphalt j
:: I I ,
Chlorinated Rubber
:;'\ [;
i' i: I I, , :
Coal Tar I; I :' '"
I
II,','
,
,
.: • "
I ' .•
Epoxy Polyamide R
1:;- : I
I, I
l I,
M
Ri~
Oil Base 1 '
:'
I: I ,
,
,',"
(Alkyd, Epoxy, Urethane) ,:,' I' I' ,
I;
'
i; :: :i:
Phenolic
fo I~
)
"
I.) k !), P' I' :'-.
Polyester
Polyvinyl Chloride
R
I I, : ',. "
"
!"I,:
: ,',
R;:,:
Silicones 10% R
' ,
I 1
I .:
Urethanes R I:~ 1< I, :<
I
I,':
,)
~,
.<'"
~,
I~ !\
Vinyls R ' '
,'.
t, (,
I~i;', i
Water Base <:
:i "
::
Zinc Rich U 1
r
,
Mortars 1:
I, ;- :-: ,:':
~j ",
, ,
Silicate
Sodium Silicate
U
R
~~ :- ~: '\
Potassium Silicate R
I:.'~ ' '. ::
K~I
Silica
Sulfur
R
R
1ms I,ctl IlJl
F,
,
1"
I"
: ::,
Furan Resin R
f
:?:
,~.
Polyester R
f~,:!;1 [:j:1[ I:; "
',)
;,
1\;;1 I::
p:~1
Epoxy R .,~>, .0'2 , , 10 r •• '/, I)'
o~o~oBo~o,!o~oBo~o~oSo
OF \.O;CO' O:'N= -:tJ"'~ 00\0= N c.' \0'<0' O'N; -:t-\O- co '0 N
tt'< ... i~; ... ::~C~ or- !"'Nc! N :'N; N.N; m ':tr\: m 'm. m :~: qo _ :~ qo
\0 ;:1'
O( lJ"I)D, co.'0'( c:~} co
- ::N' t'I'l ,'~ \0
N ~M~ -:t ~/ e-, ':ecf '" :'8' or- ,N'; m ':;gc_ \0 ::~' 00
-en; 0 -~; NoM:, -:t-U)' ,... ,:00' 0'1, ,'I"'" -N- m
0;~) ~'I"'"~"'~:"'~"'~,'I"'"N:N:NN
,
I
Acetal 10% R'i' '.,"', 1/
R"· FS, 'i !"i
'" ,, ..,' 1
I..
Acrylics \,,: ,·,1 Ir I
','
"
""'.
""
.'t" -,
i 1<
Chlorinated Polyether (Penton R
lii i,' ~,'Ii <.' .... -.
"
CPVC
E-CTFE (Halar)
Epoxy
R
R
R
~ to' !'oj' , , "
i
it 8i
iW
1")
ETFE (Tefzel)
FEP
Furan (Furfural Alcohol)
Norvl
RIlL,'
~Wi0!
R
R
IRii
1m"
~fo
"If
Ij~1 F'
I"
I ~i,;
I'~r~
i'
i,r. lij
i. .'"
iii
iX
I;;,
IS',
I,
Nylon 6 R"
I"
i 1< I,
Nylon 11
R "i, I!~,I
11\1
'ii,
ji~ I,i,f: Iii: 'ii, iT I !',
~
Nylon 66 R
ri"1 '0!
Phenolic R
.. I'."! if
PFA (Teflon) R
Polyamide-Imide 10% R
",!
Ii is·
Polyesters
RI~! IJ!' 'i~'. I'"
Ii I,i , N
li~
Bisphenol A-fumarate
~
Halogenated ALL R <
Hydrogenated Bisphenol A :ill b~ li,~
-Bisphenol A R ,:
)i ji,
Isophthalic R i,i I) 1,1 A ,J I;
Terephthalate (PET) ALL R
" x'
I; i ' <, I,'
r~iN
.,.
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK) li
R :
I., "
,t I' li,i h" i, I,i,
'/
i. ,,',."
I,
Polyethersulfone (PES) R i
Ifi+
I
I'. ;', /
,i; IiI;;
Polyethylene HMW R .:, Ii'
!'
Polyethylene UHMW R L
i;' "H
~ii
Polymethylpentene R 1« I'
mb! n,
;i~'i'; •
1.<
Polypropylene (PP) R
lix,,! :'1 I~
Polystyrene R
;,
Polysulfone R '"
Iw~ j; 1("
i
Polyvinylidene Chloride R ;";
ii,'
,
~~:~~o~N~;.~~~~~I~~:m~i~k~
O( _~M~.~~'~~·O~Nm.~:~~~.O~Nm
.. • - ""'" -row' e-- .:~' .... _. e- ._: -e- .N N N N
I .•
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Borosilicate Glass I ,
I
Carbon
Carbon-Graphite Resin
R
.. ! I I
· -:
Impregnated R
•••
I
Ceramics .... ·
I . ".
.: ..': '.'
Coatings
I '.
I'
.. ..
. ..
Acrylic
,, ....... . ..' ••
- ••••
Asphalt I~ ••••
.' · ..
.... ,,~
~'" ..
Chlorinated Rubber
Coal Tar
I
.. I·
I ••••
.
I '\
I.
.
.:
·
.'
I ..
I '.. ·
• 1/
••••••
.....
I'
I ..
••
· ".
Urethanes
-~
I
1< 1<
I
.:
... '
. ""
I·
. . <
,
.,
I· ••• I
I,. .. -, • ••••••
.. ••
I, I I
· , , ·
I> ,
.' 1 I·•
..
Mortars
I' I ,
'
.. >,
I
.
,
..
Silicate ..:
I •.
,
I>. "
.
"'.
,"~
I'
'. •• ',
"
.'.'
Sodium Silicate 50% U I .
....
..... ... •
Potassium Silicate 1< I .. ' .
Silica ..
I, ',"
, ••
<
I· ·.
I ..
H • •••
.
, .....
,
~
Hypalon (Chloro-Sulfonyl- R
I· I ..... · ...
,.
••••
.. .
•••••• ~
Polyethylene (CSM)) •••••• <: [
Ethylene-Acrylic (EA) I; / I
.
. ....•
·
~.
I I ·
I' ...
I
,
! ......
'C / ~ r1\ I
I,i ..
Ethvlene-Propvlene (EPM) I .
Ethylene-Propylene-Diene U
,I I... ...... .. I
I'
I' ..
(EPDM) I.
••
II .. I' I'
....•• i/ F
Ethylene-Propylene
Terpolymer (EPT)
FKM-(Viton A)
U
-- :
R
I
......
.
.. ••••••••• Ii' I
I
....
I'
Ii
..
I I·
....
..
Hard Rubber R ~
•••••••
r, I, ..
••••••
'
, I'
.... · '
1/ y
•••••••
Soft Rubber ••••••
• .." I ...
Isoprene (lR)
I··.. [;
Iii "
R
'i
....
I; ........ I.
Kalrez (FPM) R . I •••••• ( [
.....
•••
[i ['
Koroseal
1
'
Natural Rubber (GRS)
Neoprene GR-M (CR)
R
I
•••••••
,
••••••• I•
.. Ii
... I••••••
:.,
,. ."
.'.'.
I ..
I
I:
, ... i
,
••••••
Nitrile Buna-N (NBR) U Ii ..... ••••
...
: •.: I:·[ .. I'
I .
: I:
Polvbutadiene (BR) [ •.: "
..•.. I< : ' •••••••• '-:
Polyester (PE) • I.
I.' I
· ." '. I•••••••
.:
· "
,.'.
SBR Styrene (Buna-S) !.
......
•
I ....
I', .... I
Silicone Rubbers .. I.·•.• ,
, ..
I
I'
[.
. It.. -,
.
..
Fabrics
•
[
;' .... I
••
· I [
,. I•.• · ·
OF
0'00.0-
lOCO o~-
0:'0"
q-.tC),'
o;g- 0 ,~_
- c o , N,,_
0 0 : 00- 0\00<6- 0 0 , 0
lOCO ON. qo,\t), co.o; N ~> \0
;: -: e- ,or-; or"'",~< or"'" N N:C"oI N N M'm, M m' M :o:::t; qo " qo
~~,CO:~O~~N~qo'¢'~'~~~:~~M,~\O~CO
O( ..... 'M' M o:::t \0 'I"' co ,0) O~- NfY)' "d'.\O ~oo' 0\0 ~ N rt'l
." '. '. ' . or"'"-:,"," ~~' ~ ..... ~"""7', ~N NN N
Carbon-Graphite Resin I
. '.'
Impregnated R
I .. . '.'
.
Ceramics •
,••••• .
.. ,
'.
.' ' .
[..
C I
-,
Coatings .. . I·,' .
•••••
.....
I·
..
Acrylic . ~~ &~
i
I
..
'
..
k~ f'
Asphalt :'
Chlorinated Rubber
:' I"
1·- ....
I
,·
Coal Tar
.{ I . I • ••••
......
Epoxy Chemical Resistant I
Y ••••
.. I·.··.·
••••••
. .•
. '. I .
Epoxy Polyamide U C •
...•..
.. ..
!
.'.'
•
Polyester .'
~
.. I
.. ••
••••••
I: .:
•••••• '"
....
..
,
Polyvinyl Chloride R . I . •••••••
i
Silicones ' ..
...• , .:'•....
I·
..
.'
••
I
Urethanes .. .',
"'",..
•
'. i'
I: •
'
.....
' '
Vinyls R I. I
I. I'
' ,
I' .:
i
.:
-.·
....
..:. .: •
..
•• ,.,". :' .,.
Mortars
.:f i,. '.',',' . .
',."'. ,","
. ..
,
,
,
Silicate R ...
' ,
Sodium Silicate R
.... ..•.• ..... ..1 .. .. .' ,
. .
'
.,.'
Potassium Silicate R
: :' · ,:
·'i ", .:' ..
Silica R ,'. . , .,.'. .
Sulfur U ,',',',.
,
....
.. .. I
.
'
,
Furan Resin U ..
,.,.'.'. i
,
, -: ' ...•. I""
:1 .. ..
-:
'.".'..
i
".
'
Polyester R '.,'
Epoxy
·X,
U "','
, ....•
l·.'
.,.,
• . ••••••
".
.... ','"
odo.bo~_od·odoo-o~ooo'60~O
OF \.O~:ONo::tlD-OOO
>-'1 .- ~- - ...... - N ' N ',N- N.f"\1
N:~lD-OO-ONo::t_lDOO'O N:~lD
t'l"I M m ,M tw"l,_,o::t, 'l:t", , o:t
LI"l~oo_m'O_:Nmo:t~,.....oo Q'lO: __ N'l'Y"lg'lD~ 00
O( -~':
-, M '<::t,
,,' - \D r-.
'''''' 0
_"_-'00,0'\ N
,.... ,rr>
.... qo
'I"'"" ,... .... co
1.0,"'" _ Q'l
""'" N .' NN
N ~I
N
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
.~~~~~~~~--l
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Plastics of g _;~,: ~ :;~~ ~ i~-' ~ :~: ~ :~J ~.~ ~~~' ~~-~ ~::~; ~,~~:- ~
ASS , I ,', I,
Acetal ' ' , • ,,' 1
Acrvlics : I,.' ,I,'
Asbestos Reinforced Epoxy ,I I' I,
Asbestos Reinforced Phenolic I, " , '," I 1 1'
Chlorinated Polyether (Penton I ,', I, '
CPVC (I : '.: I" I
"' ,
I
I
;' ',,' ,"
E-CTFE Halar) ",' I "I,'
Epoxy ,.,'", , " I ' "" '
ETFE (Tefzel) " z , ". " .. I, ,
FEP R.;: " +-+1+1-++·,'1 ,:
Furan (Furfural Alcohol) ,'." ;~, ':' r: ' I, "."
SODIUM CITRATE
~~l~~IO~;N~;.~~~~O:~N'm~~~·=
O( M"¢ U) f'.. com 0 __ ; Nm • . Y)' r-. 00 0 \ 0 e- N M
.... N
: 'l""'t"* 'l"" ..- 'l""' __ '11"'"._ ~ N N !"oJ N
Acrylate-Butadiene (ABR)
Butyl GR-1 (IIR) r
I
r I
Carboxylic-Acrylonitrile- .'
Butadiene (XNBR\ .
I
Chemraz (FPM) R ; ·
.'
Chloro-Isobutene-Isoprene
(CIIR\ I
Hypalon (Chloro-Sulfonyl-
Polvsthvlene (CSM\\ .... it .. ••
'.
Ethvlene-Acrvlic (EA) I
<. .t .
Ethylene-Propylene (EPM)
I.
.. it:
I. j, I
r .
Ethylene-Propylene-Diene I.
i·' . ..
I. I
(EPDM) I
••••• . ••
I •••••••••
Ethylene-Propylene I
1
I. ·
Terpolymer (EPT) ,..... , . ..
I I, \. I. .. I
. I·.·. I
FKM (Viton A) I .......
Ii . .
Hard Rubber
....'. '.? I I ., I, .
'.' i I.
Kalrez (FPM\
Koroseal
Natural Rubber (GRS)
R
I ,
I.
.. ..
,
· I
i
'.. i'
Neoprene GR-M (CR) •• ',
• • I ... -.
I .
Nordel (EPDM) ,
".' -: i '. ·.
Polybutadiene (BR)
i
..........•
.. ..
. •••
"
. ..
I"
·
.'
','
Polvester (PE) .,
••••••
I, .... I i
I.
Polyether-Urethane (EU)
i , I, I.
I. I·••• Ii
Polvisoprene (IR)
.. I
'.,
Polysulfides (T) I • I I>
I .. I ..
Polvurethane (AU\
SBR Styrene (Buna-Sl
I.. '
··i
,', .. , I,. 'X
I.
".,
I;
.... I
Ii
,
IX ".'.,'. I·
I
, ,"
..., '
Silicone Rubbers I'
• , .. I '. I I I I.
, I,
? I....
Fabrics
Cotton
, ,/
. '.,
1/
I , •...•.'.
I
I ..
I,
I·
.:
,,
'
•
?, ,.'. I' '., -.
,
Felt (Wool) I• . I.
. ,
Rayon Viscose Ii,
o;o;o~o606o6·o:oooo;6o:do.d;o
OF ~.,ooo.~;.-WC:O~.N~:U) ~:ON.~.c:o.:~.N~u)
.'I"'"";,,:.;.'l"" ..... 'II"'",NNNN Nrt'l M M Mrt'l:o::f'.- , ' .
~~c:o·mO~:NM .·~r-.W;cnO'l""NM:~·U)~ co
O( -N m'¢; \Dr--.: c:o:m 0 _ . Nm • \.0' """00: 0"10 'l"" N m
.' . ···_·~-_·'11"'"_-_.'II"'"NNNN
Impregnated
Ceramics ,
Coatings .
·
Acrylic I
·
Asphalt I I
Chlorinated Rubber II' I ·
,
Coal Tar
Coal Tar Epoxy
I' ·
I
,
Phenolic .." ! ·
Polyester I I '. :
· I
I
Polyvinyl Chloride
I '.
Silicones
Urethanes .' ':,
! I
Vinyls
Water Base
"; I
I '. .
·
----------1 I. .
Zinc Rich
. I " ,
.: . , . "
Mortars , -; II
Silicate , ,I , ,- .
.'
Sodium Silicate · I . ,
Potassium Silicate
';
-
'.
-
,. I .-
!
Silica
" I
·
Sulfur ..
I
Furan Resin
I
Polyester ·
Epoxy :'
ii, r~'
'.
Asbestos Reinforced Phenolic I';;; li I.;
'
Ie ..
Chlorinated Polyether (Penton R ;ii •••
!;
i.....•••
~r"
.N I'»: I ••••
CPVC R", 1;;;(1 i'.; p. ..... i • "
E-CTFE (Halar) R U Ii
Epoxy R :.,i.: ~-I
iii '@
i Ii
. - .
r
ETFE (Tefzel)
FEP
R
R
:j "'i
••
... •••••••••••
i ..
" .
Furan (Furfural Alcohol) R
;. ~, 1/ ~ l'
Noryl
Nylon 6
R
R
I":; - '"
i••
I., .;.
..i•
\
"
. ,
i~{ lit. .' Ie
Nylon 11 R I'
Nylon 66 R
i' i
Phenolic
I
b ',." i.'
I·
i; i·' vj I'· .'·t
PFA (Teflon) R
"
~ i. k
Polyamide-Imide
Polyesters is'; ~;; ','
Bisphenol A-fumarate R
Halogenated 50% R .• iV:. ~ ;i,
,~
f~~1
Hydrogenated Bisphenol A j' i'
il··!
•.'"
:f
-Bisphenol A . .." ; ',','
Isophthalic R •• Ii;. Ii
Terephthalate (PET) ALL R
:i"
U!' ••••••••
•••••••• ii 'H:
I;,;
,
Polyetherimide (ULTEM) 1~~1 ;}
':
Polvetheretherketone (PEEK) ••••• .;i;: i'
~i ii
Polvethersultone (PES)
Polyethylene HMW R ·it ii;,.
~~
I·.·. .;
Ii, •
/:
ii•.
j·m
Polyethylene UHMW R ~ !.• iO' i'
..
~ I, it
Polvrnethvloentene i,. '1.
Polypropylene (PP) R ~
~.,
,S - ;~;
Polystyrene
Polysulfone
Polvvinvtidene Chloride
PVC Type 1
R -
~I;;~f-*'il I'· "
-if.~.
•
;E' ii;
.;s .:~
R
pvc Type 2 11 ~1; S! ii.
PVDF (Kvnar) ~:Ji ".'
" iii <!
.
Rvton R Imil :~i
.:
':
W ii;·
;'/
TFE (Teflon)
Vinyl Ester ~~;i;::1 ;,('
'tt '",,/,
"
-.'.
o~o~0~~0~080~0~060Bo~!0
OF ~~O~'lt:~'COPN~:u).:O'N''lt'~:COPN~u)
~d~~l~~~~'~N~N~mm_Mm:ms~~~
Lt"\~CO~O~;N~'lt~f'~~~~~m~'U)~co
O( _Nm~~KCO~;o~NM~Wf'~:~e~Nlm
;::;:?:> :'"".! '.--:: ~,,~: e- ,~.: ~',,", ~<r-: ~IN N N: N
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolvrner (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (IR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU
Polyisoprene (lR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Metals
Admiralty Brass
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Galv. Stl.
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium SAT
Zirconium
SODIUM DICHROMATE
O( Lt1:-iO' cc~: ,-~,' -:~: ~ ,olD: ~&J
_~m~.~ ;jCC~~~~~~='~~:~~'~~~
s
~-N: m:~f:' \Ok i aJ N al'o:
OF 00' 0 d: 0'0' 0;'6 o-ci 00> 0 0.000,0: 000
Nonmetallic Materials : " 0~ :t"'
lJJeo' -J 0:: ','1.0 «10 N
_ ~_. '""N' N
o::t,' tD
N ,co:
m M q-1O
NN ON, ,.., m: ClO ,0 N
l'Y'I,e;;t- ~ _-
\0
o::t .:1f
.
Borosilicate Glass R
Carbon ... ....
R
· .
Carbon-Graphite Resin ...... '.'
· .
Impregnated .. ' .
. '
--
Ceramics . '
•• .
.... I
i. ••••• II.
Coatings
· '.
.' .
-: . .
Acrylic .' ~- .... I
I'
-.
.. ,
.... .'
'" l~
Asphalt •••••• I'
L
Chlorinated Rubber ••
X I~ •• ... L
Coal Tar .. •••••
.... ..
"
••
'.'
Coal Tar Epoxy
I· · '.
I.·
R
.... •••••
.....
.' I
I'[.
•••
Epoxy General Purpose
....
•••••••
.. . ','
Epoxy Chemical Resistant ...... .. I
I . .. . !
Epoxy Polyamide R h- I-
••••••
....
... Ii .... ...•.. ,
,...
Oil Base ••••••
Xi ·
(Alkyd, Epoxy, Urethane) II •
I. I ••• "
""
I
Phenolic R f;- l- ..•...
I I
Polyester R I . ••••••• ,
h I- ..... /
•••••
. ...
,
..
,.
..
I... I
.. .'
• 1/ ".
•
Silicones ....
I
..
,
--~ ••••• "
I'
Urethanes I .,.
Vinyls R '.' •• '/X
I
••••••
..
. • •••••••
I'
· I.
Water Base
I'
", •••••• I
I
••
' . .....
Zinc Rich
Ii, ...
••••••• i
I I' ......•
..
'.
"
/
,"
'
- .. I,
Mortars
[; B I·
I \
.
...
••••••
•••
i· I'
W X ... ••••••••••
\ I••
Silicate .' I'
. I.·'; I•
'
••••••
L .... I' •• ..
••••
Sodium Silicate R
Ii
"
.. ,.
I . 1\I, I.,
Potassium Silicate
Silica IX
J,
~'~
'i
I·' ;, •• ••••••••
..........
I"
1'"
• I···.
Sulfur R
,.~
I'
••• I
I, •• i
,
" •....
Furan Resin
f,' I, I·
,.' .>' •... ,
f' I'it
Polyester
Epoxy
R' '
R ~ I-
.. .. ;
.
1\ I'I;
I: I
\
"'i
"
I.'
,
I'
,'.i·.
I'.
f;
OF 0:0 o~oc: 0: _~~
<O4~ 0 N~"
\:';: .... ":"":< 'I"""
o_~i
co
'""
N,""': 0.0' 0-0:
0 0 : I.O·-co 0 -N' "I:t 0 :6' N'.
0 ,\.0' co'o 0
NN' N -N 1'1"1 :t't'1, "'M t'I'l 'oq ""'.
"0: -~:- \0
0
: 'I:t
O( ~~ClO~O~:N~.~~~~~'I"""Nt'I'l~\o·~Q)
..... N. "'0:::1'-
>.-- 1.0"'"
.__ --_~
com 0 _~ N(yl, "::I'lJ)' ","'00 0'1 - :
",' '""_ N- M
e-- _- '1"'"'_: .... :.......... N ' N N
N
2906 Copyrighc © 2004 by Marcel Dekker, Inc. All rights reserved. For more informacion, go to wwwdekker.corn-
~:.L.::"-'.L'=~-=':-==_---1R
~~:'L-~ ---/R~~
~::=~=-=--;-- ---/R
:::-:-;:::'-.--"...:..!"-=''L- -----1 R
~;:::;-'-;::;;--::;--.,.-------jR
~---;-'::::-c-:'-'--'---------IR
R 'Cc ~c;
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (IR) .. t·
Kalrez (FPM) : t
Koroseal
Natural Rubber (GRSl
Neoprene GR-M (CR
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BRl
Polyester (PE)
Polvether-Urethane (EUl
Polyisoprene (IR)
PolvsulfideslT\
Polvurethane (AUl
SBR Styrene (Buna-Sl
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L·
17-4 PH
20 Cb 3
E-Bright 26-1
Stellite
Zirconium
,~
~~~~~O~~N~'~~~'~~:~d~:~'M'~~~~
O( -;N:M~~~~~:O~Nm_~:~~OO:~O~NM
. . .': ~_ ...... ~- ......: ""'" .................. N: ,N, N
tl••
·•. . •. .i
~j Nonmetallic Materials of o~o~oooO'ooooooooo_oObO
~ooo~:~:_W'~ON~.-~:OOON~~~ON~ ~
;""'"~""'"~-NN~NNNMmMmM~~.
Carbon R I
I
1
Carbon-Graphite Resin I
Impregnated-Furan R
I ·
.
Ceramics ... '
I
•••••
; I. I' I
'.
Acrylic tif .. I
-.
, I
.~
.';
.. I .. I -; I.
I': ~
Asphalt I ...
i ."
Chlorinated Rubber
· ..'
.
,> f>.' •• I· l-
.'
Coal Tar
i I I .'
."
. ..
I···.·
..
:
Epoxy Chemical Resistant •••••
I.
I
.:
1 I. ·
. I
I I
[ .....
.
Oil Base
(Alkyd, Epoxy, Urethane)
• ,
I . ,. "
·
i·
I
I.'.
..•••' ?' ,i -.
.. I
,
,; I ...
Phenolic .. .:
,. '/
I··
I.
' . I
/'
I
Ii I
Polyester >.
; . ••••• .' I' .
Polyvinyl Chloride R "
..... .'-.,
!' I. • I
•
I'
!. ,
Silicones
Urethanes . .F
I· ....... I ....
•••••••
I
I, ........
Vinyls R
.......
.'. •
'.
I·••·••
'f '
....
... I
, ... I
.. •••
.
Water Base ·
"
.
.
Zinc Rich
-.
,
.
I • '
.......
...
,
••••••
I
••••••• . r
,
.
"
",'. !; "
·.
• I"·/ .•... l- .... •••••••
" . •
Mortars I I'.
I r-:.
I'
! ....
Silicate
••• Ii I'..... I
...
,.
••••••••
.
• ·
Silica R
...... ••
'i
...•....
"
.. .
".'.
•
Sulfur R ...•••• •
,," I· · -: ...
Furan Resin R
Polyester
Epoxy
OF
••••••
'.
"
o:b-Ob·o:6ooooo~O'OOdo6ob·o
~.ooo~:.~~~O:N~~:OOON.~~.~-ON
I
' "
I.
.. I....
~.~
....
'
' . ..
••
,
..
1,<
..
Ie
'," ~, Iir'~'
i" / '.
.. i \ .•... ./
Polyethylene (CSM))
is :i
II>l~' ~
Ethvlene-Acrvlic (EA) \ ~ I>
Ethvlene-Propvlene (EPM) \1.
Xi ii
,,~
.
:.' I,.,
.'i i.''.
Ethylene-Propylene-Diene R
:i .:
I
•••X -: I·· !
(EPDM)
ii
'
Ethylene-Propylene R
':0'.
I,' >
,
I'. 1/I·, •••••••
;
Terpolvmer (EPT) 'n I~; lSi I. " i< I:
3 ..
• i'i
••••••••
Isoprene (IR) :
RiC ii I"! /, •• Ix , '.,
Kalrez (FPM) ;' I'
I,~. \~, .i
;.
Koroseal
::'1 i: i'> Ili i ! (:
Natural Rubber (GRS) .
Ii I;': ii! I
Neoprene GR-M (CR) U>; IS,. Iii ,
....... 'i'
> I.' f> •••••
s,
'"
Nitrile Buna-N (NBR)
Nordel (EPDM)
R'"
• ". I:
ji
I'·
Ii
I'
,.'
.:
'i
i,::ii 1/I"
i -
,." ~.
'~i Ii: I;•.
R •••
,.
Polybutadiene (BR) .•..... ,
.•... [iii
1\;
I. ,
:"".
Polvester (PE)
Polvether-Urethane (EU) : .; I·
:
F
"
>
\
•••••• :
Polvisoprene (IR) >
" / .'" I,
'i..
,." i/,.. Ii. I'> I>
Polysullides (T)
Polyurethane (AU)
Ii
, ;,
....
.:X••
,
•••••••••
· .':" I; I.!
~'/1\; 1\ , .'" I1/ y..'. '.
SBR Styrene (Buna-S)
Silicone Rubbers
:. ••••••
>; i
,
:
I..·•
Rayon Viscose I·. " !
k i ••••••••••
~~~W;~·O~N~.-~·~~.~·O'''''·~:M~~~~~
O( ..... :t.., ( f'l"l~ c.o,..... co:", 0: .....: Nm o::::I'J.o' r'--OJ ~-.O ..... N m
.- d ' , . ' ,'--: e-- :.~: ""'._ .... -s-; ,....._: ,... .N: NN' N
Tantalum
Titanium
Zirconium
SODIUM FERROCYANIDE
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Epoxy
r
::
f'> [,
!: ri~
'Ii,
[?
:
If •
r; Hr,!
I,
4{ ,I.!{
!
I f'i}:
iFi>
ii';
Polvmethvlpentene i~rlI- 'i,i
PolvpropVlene (PP) R .::; 'If,i, '
Polvstvrene •. ~
iii;! ii', ~
~~:~~~~i~:ne Chloride R ~~ ',ii,
pvc Type 1 R~~;;I.<;
PVC Type 2 R 1iS!
PVDF (Kynar) R itE Pi,; iii
Ryton ,ji, '; m'
TFE (Teflon) R i~; ~;;.
Vinyl Ester ALL R w
SODIUM FERROCYANIDE
, ~ II I
~I,
I
Ethylene-Acrylic (EA) I I
I I ,
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
I '
Rfoi-!o-+-+-
I",'~ , I I I I
,. ,I' I
(EPDM) I I
I
I I
Ethylene-Propylene R I, ,
I I
"" , I I I
Terpolymer (EPT) I, I ,
FKM (Viton A)
, I, I I
Hard Rubber ,
I I[
PolyesterTPE)
Polyether-Urethane (EU) ,
Polvisoprene OR) ,
,
Polysulfides (T)
,
Polyurethane (AU) , I
Silicone Rubbers
"
-:
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
l
Borosilicate Glass U I" I;
Carbon R '" < .
......
.
R
Ii . I•
Ceramics -". Ii ••••
.
••
I'
>, I·L . I
,.
• ••••
" / I·
Ii" II
"
Coatings .;'
R ....< ...-: r.·
Acrylic I.
i" Ii
Asphalt
... r .,ii ••
••
'. I' I I'.
~
.:.
Chlorinated Rubber
••
;., I. , I
'.
.- I I
Coal Tar
1<
,
i ••••••• I
Coal Tar Epoxy
--
R .,. 2- - I.,. •i < .'
I;
:
.... I·
I
I·
I.,If.'
,,
I
Epoxy General Purpose 1/ "
' .. ·i . Ii
Epoxy Chemical Resistant R
Epoxy Polyamide R 7'"
+-- I,i' ,• I;
I'
t .'
..
••
I I
I
; Ii.
I,'
iF
I .. ••
i.. I,·;;
.
-: •
"
,
'
.. ..
Polyester U .•.. .. '. c I'
, , i i·,~
Polyvinyl Chloride R ... ••••••• 0. :i
Silicones
· ".i. i.··•. • •
••••
.:
.:
•••
••••••••••
I'.
I
( ....
Urethanes i I'" i •' i •T
,i' I'
• IV Ii
Zinc Rich
Mortars
.-
.>
,
, 'j
.....•.
•••••••
t
•
..
....
,. • ,. , i·
;
V;
;,
H. .
.....
•••••••
I{'
I.' .
Silicate .. •.·.t,
••••••
/;
... •
'I
.......
'g , > ......
'
,
....... ,
,I
Furan Resin R '. . , i
;
~8--- ••••
;" '
••.i. .,.
Polyester R ••
i ,T .:
Epoxy R
•••••••
," ;
I,
i" "1
•
0:6' 0:6: o:~; 0·:6- o;~ 0-0' 00: 0 0 0 ' 0 ' o}6': 0
OF l.O-co. '.,r"4: -,F,
",'/ 0-~'~, lilt oo'~' N . , \0 '«Ie 0 .N' '¢,\O' (0 0'
e- 'N N'N, N N mM'- m'm· m<q"
N:J- \0
'¢ - '¢
O( 1.I),u:)' Q)a\'
..... N fY'l,:<q',
. ' lD
'1):::: f"M
""; CO ·
0'1,_
'¢ !.O: ,....00:: O'l 0 - 'N m~, lD
0 ..... "-"", _ _ - " " , " - N N N
N co
,_' N :(y\' '¢\.O r-..co, O'l. - e-
N ·N
I'Y'l
I:~
;
Acetal ~~ "> 'i','
I
Acrylics R ,..:,
I,;:
rj~
..... I' X
Asbestos Reinforced Epoxy .
Asbestos Reinforced Phenolic l i
[ii.
.N
. I [.~i \
~iJ,t
d
••
I}
I }
-:
t
Chlorinated Polyether (Penton R i iT
CPvc R i v
.1~'ii·1 'j>:t
I\i I':
~hC~
E-CTFE (Halar) 'i I';·:
Epoxy r0- ,t, E I,
ETFE (Telzel) '" I:,·
I
'i'
.O'
.. ..•. ,
FEP
r,t Ii
Furan (Furfural Alcohol)
Noryl
R~
R
I'" Ii:! .:
10
rMii li\
I~"
..
iii fi'
~
Nylon 6 U lim
Nylon 11 U I';! Ii ':
I:~
Nylon 66 U I,;~ li,;~
Phenolic I,:
PFA (Teflon) R ro-I I' ,
Ii';
Polyamide-Imide Wi I
I~· lit· I': I~, Iti
~"
Polyesters
Blsphenol A-fumarate R li,r [ .
Haloqenated R - :
Ii
ti:
'ii \: I
Hydrogenated Bisphenol A
;.; if
I; i;
-Bisphenol A '.·i'. "
.: 1\
Isophthalic
Terephthalate (PET)
Polyetherimide (ULTEM)
R
;i I'B'
I·",
I'"
v' I; ".
II!;·
i/ I',.
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
I;~:I "',
1;,
1ft
-:
I'~' I::'J
I'
IiI', I"
.. I'
,
.:
Polyethylene HMW R k£ .
I' Ii;;
'if 1;"
I;: I··;
~
Polystyrene
I'I, I.
~I
Polysulfone I."i
Polyvinylidene Chloride
;'i
;, ;.,!'!i " F
I';j
PVC Type 1 R
Ii
~I '"'
pvc Type 2 R .. ; I· Ij~ .,.
I:;':
:J I,' ,~r
PVDF (Kynar)
Ryton
Ui1
{i
if.
lit
TFE (Teflon)
R r;;~J ~;:~,\ jf '." ,
o~o~o~o~o~o~o~o~o~olo
OF I.D '00' 0 ':N' oc:ri\Q' 00 '0: N-~~ \0" . CON oc:r :lJ): co 0 N _ . \0
j/;':': ",""~'i-, "'"" ;~! "'"",-N N ~, N N M -('I'). lYl!'rt rt'I -oi:::t, oo:::t:, "d'
~~OO~O~iN~oc:r'~~~:~'d",""~lY'I~\O"~oo
O( ....' N m ,'00: en ~_ "'""N t'l"I
..... N_, n'I'-::t- \D :..... ~ COO'l; 0 ""'1.0- .....
"::,:-,,~.,,< '::<: .... ~. "'"" __- "'""_r, .... ~ . ..... N: N:N N
Acrylate-Butadiene (ABR ii ,
,ii'
Chemraz (FPM) R ,i
"
•
> "
..
i '
' "
Polyethylene (CSM)) ,
\
> > I" r-
,".
' ,
;; ..
'i, ;f. '" L. 1\
Ethylene-Acrylic (EA) i I .'
.;''ii ~. I'
.'
Ethylene-Propylene (EPM) .X '.' .. I'
i y. I. -: · I
,
,
Ethylene-Propylene-Diene R
(EPDM)
R hi"
J. '.
'",'
.
'.
·,'i,. '•. Ii
" , "
"
13
I'
I
Ii
Ethylene-Propylene
• ..
"
I •••••• I
I; >.
Terpolymer (EPT)
FKM (Viton A) R
I"· ; • • ;
'" ",'
.'
"
I
Hard Rubber R • , "
I< II
,> I' I>,
Soft Rubber U
IS1'
>
. ,>
""
.. ,
", I'
Isoprene (IR) R
I· .'" . I• •••••••••
I .
, i· I", I1/
Kalrez (FPM) R
• 'I I,',.
Koroseal I> r1'> : ] ••
Natural Rubber (GRS) R
I"
. 1.3
I> • "
, I
Neoprene GR-M (CR) RI • Ii
I;· i,
': I>
Ix• :
i
I'
• ••
>, li(
~ Ii Ii;
Nitrile Buna-N (NBR) R ""1.
•••. i', t. 'i.'. I i,
Nordel (EPDM) R I I> I
I·' IX x, • .»
·.i·I",·, I I'
Polybutadiene (BR)
Polyester (PE) I' Ii' i ,i,
,
I..
I.;
I"
Iir /, I'·",
I. I"
I'
Polyether-Urethane (EU Ii' ; .;
;; I'• ,'
Polyisoprene (lR) I ..... ,( I 'i,"·
I'. Ii'
Polysulfides (T)
Ii i,' .
J
•••• ,i 1·\i' I> I; I,;
k
I \ i.
i
Ii, I, · . I '
Polyurethane (AU)
SBR Styrene (Buna-S)
I'
I.
;'
•........ I .'...•.
",1·'.
,
.,'",
Ii' i"
I'
I/i I Ii
Silicone Rubbers I' "
f[
,'i
. .,......, "
I.'·.•·
1\ I>
i
'C I
Fabrics
II; ,
'. .. I n,
I, "
i"" I;'I;
Cotton r;· ••
.c- \
Ii'
,
I·
1",
O( l..():u>:
~'N'
~,-~; o:·~{; NM"
~·~'OO~:O~;NM·
""'-.Y:{ ,....,,·00 0\'0: '-'.N M'~' ~:~. 00
• . ~:"""~O\-O '-M-1"l"I
_,,;;; :::> ;,.:; '-""7:'. .- .,....... e- ~~ . .-.~ .-'('1,,1 NN N
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 825
Lead
Monel 400
Naval Bronze
Nickel 200/201 G
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum E
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
-N:m'~ ~ ~;~:O~NM~W'~~;~:O'~'NM
'::.,:\':; '/,,_'" 'I'"" .<r:""';'" ~, _ _ , .... ~N: Nr"", N .e-.
of ob;o&ob;o6obob.o6'o6i o b : 0 6 ; o
~~oN~.m~o'N~~~ON;.~·~;O:N3~
Elastomers' and Linings ; 'I""',~: ",Or-- '1'""').1' N N N N l'Yl (fl: t"t"fY) N'l,l::::t e-. "o::t'
'I'""
Acrylate-Butadiene (ABR) : !
".
k "
I ....
I I
.....
.•. ....
,
•
•.'.
~, I .. . '
Polyethylene (CSM))
,
Ii,
' .. ..
1/ F .•....... ••
Ethylene-Acrylic (EA) .... ,
Jf] ••••
!. .. ' i
.'
•••• I' Ii
Ethylene-Propylene-Diene "
(EPDM) •
•
•• !:t I ... Ie I ·
......
•••
• •
I',. ?
.... •, .:
••
. ....
i;i IT
Isoprene (IR) ·
I,
'.
") I ) ......
Kalrez (FPM) R
""'. I'; If' ': I >
;:
...•... '
,
Koroseal .......•
... ,X' I ; <
I:; 1\ ..
Natural Rubber (GRS) I, •
!,
.•...
"
Neoprene GR-M (CR) ,: ; I;'
Nitrile Buna-N (NBR)TO 10% R " I' .....
• .. '. ..',
I,
,.1,< I:... , ,
, " .. " ..
Nordel (EPDM) i;< ,
Polybutadiene (BR)
Polyester (PE)
!i I,
I'"
, I·
'.,'
.<,
.'.;.•... !.
"
I
I
I' , ,
••
Polyether-Urethane (EU) : I.'•• I;.. !'
...." ..
!i
Polvisoprene (lR) I ••••• i
·
'.'.,',
Polysulfides (T)
Polyurethane (AU)
I,
I
I'. I
I'I,
.., .•.•
I' H'"
••
I·"
I'
..
..',.
'
••
.. ,." 'i,
I
1'.
I' I I'
!
Silicone Rubbers '. I •••••
Ii I; I·
'.
......... I' I'
I" ,
I,; 1'\ I, ..','. .,','
'
I, i t •
."" f.
Fabrics .
I
....
Ie;
I,
I
-:
"'.'"
I"
I,
Rayon Viscose I,. "
Monel 400
Nickel 200/201
i-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 410
Type 444
17-4 PH
20 Cb 3
E-Bright 26-1
)tanium
Nonmetallic Materials
Carbon-Graphite Resin
Impregnated-Furan
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
°F~~g~~~~~2~$~'g:~:~~~;~2~~
:!,) .... ·,·b,; 'I"'".'":"J 'I""'-I'~,L NJ~: N ,'N tt'I.:(Y'). lY'I,:m: tt'I'l::t: ~ ;'lI::t q-
0:006.0:6:00000'000:00'000'00
Elastomers' and Linings of ~~.OiN:.~OOQN~\OOOON·.~OO.~N~\O
... , . - ' 'II"'" . . - 'f"'"N N N N N I'Yl M M('r'\' m '-=::t 'd"" •
,
Acrylate-Butadiene (ABR I·.
... r
I ! ••
Butyl GR-1 (lIR) R I I
Carboxylic-Acrylonitrile- .. . ..:
I
!
Butadiene (XNBR) I
Chemraz (FPM) R,
.. I I
I I
-: ..
I
Chloro-Isobutene-Isoprene R I I·
..
. I.··· I
(CIIR) ·
Hypalon (Chloro-Sulfonyl- R
I' ••
Ethylene-Propylene (EPM) R
.l I..,1tI .: '
•••••
....
Ethylene-Propylene-Diene R • '
I·
(EPDM)
Ethylene-Propylene R
.-•••• ••
i
i••••••
Terpolyrner (EPT) S -, I .'
'.
U
•
i. I;
FKM (Viton A) R .¥ •.: ....
..'
.:
,
•••
...
.
Polyether-Urethane (EU R I· ..... I'
.: .:
Pclvisoprene (I R) I; I..... "
"
U I·
i
..
Polysulfides (T) I, < il
••
.'
I
·•
Cotton U I' • I I· , '. ....
r
Felt (Wool) U ... I ....
I.
Rayon Viscose 5% R
I .'
•••
0'0: 00'· 00 0'6 00; 06 0;0 06 0'0 00" 0
OF W~ON . • ~COON~\OOOON.~:OOON#\O
: ... :~: ... "-;'II""'N'NN'NNMm MmM-~.~.
.:ze
'On Steel
'rnbium (Niobium)
er
'loy B/B-2
'Hoy C/C-276
1I0y D
alloy G/G-3
ghSilicon Iron
~8riel 600/625
"olio
, .. Y 800/825
ao
hel400
yi;S.,,·-'-·
'aVal Bronze 2
Jekel 200/201
•. tail1less Steels
'Type 304/347 2
Type 316/316 L
<Type 410
Type 317/317 L
17-4 PH
.20 Cb 3 2
..... E-Bright 26-1
Silicon Bronze
§i1icon Copper
'$tellite
"Tantalum
£Titanium
Zirconium , ",,-,
OF ~~1~t~]~~1@~~1
of o'lii o~otio~O~.Ob'Obo~o~o~o
Nonmetallic Materials <OJ o 'ry:
,...;.~, ,... :i~: 1"""('1;
'l:t ,'+"';, 00 . . ,' N
N}'iN
.. "iNN', o·'m',
lD '0)- rt'I N' ~ ''I)'
m 'M', 00:0'
1'1"I i~_ N .~!.... \0
oqo, 0Ilt
· I. ,
.
,'.
Impregnated-Furan ·. ,
R ,'e '"
Ceramics :, I: .. I '"
· ·
'; : , ·
Coatings .
Acrylic
Asphalt
r~ ;; :
,< "
,
I
r
I·
I
f'
I
II
',;
v;
,'..
,:
,
"
~t
1'"
I,
"
.:
' .
. · .
,
;
"
Chlorinated Rubber "
..•.
.';
,
Coal Tar I, ,
, .
II, .
I,
, ·
.: I I ,"
I "
Oil Base
(Alkyd, Epoxy, Urethane)
,
Ii
,',
'. ,
:: I
" '..
" I I
Phenolic R
r ,
I:'·, • I,
,
• ••
Polyester R •
,:,'\:
:, "
,: : I" ,
I'
·c'
·
"
,.
I
I.
,
,':
, "
:
.c
Water Base " '
".
.. ,'" I: :
'~.:
Zinc Rich " ,
,? ' ' ,
:
It;
,
~
'C
~Is
,
,,'
,
':
Mortars l ::
, I>
"
•
.
."
Silicate
Sodium Silicate
U
U
,,~ :"
"
:: li ., ,.'
["
/'
,:,.'.' :'; , I:
Potassium Silicate U
1~~1
Silica U I "
I'"
Sulfur
r.:
\,I : I
I'
' .;
Furan Resin
U
R
\
·cc·" I" , I: Ii' " ,
I::
I;
~rtt- ':~
L ' :
,i,' [, I:
Polyester
Epoxy R 'i~!,"V
o~o~o~o~o~oB'o~obobiO~O
,
.'"
,: I',
V I
I I
;
, I'
i
k
OF \O'QO. 0 iN~ 'l:t ,'\0: 00: . N -~- "'co' ON' .....\0 co ,0' N ,:~: U)
-~;r; ... ~t'7~ .... ~e~ e- ;'N' N :c,,' N ,'N' mM: mm- m~, qo ,:_ oq-
i
.a valBronze 2 Giie+-l!ioi+-~-+i'iOI
Jekel 2001201 2 Ef..i+~Hr~"",,*"'!-fB-
. i-Resist G
tairiless Steels
Type 304/347
. Type 316/316 L
Type 410
Type 904-L
\".17-4 PH
"20 Cb 3 2
;,i: E-Bright 26-1
.iliCbn Bronze
$iliqon Copper
$f~lIite
1'~ntalum
I!g.oium
irconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~s
Acetal
R~
Uk; I: [
U~ i I
I; ~ Ii
I
M~i~ R~ ~ b C 1< ~. ;, ~ • I,·
Asbestos Reinforced Epoxv R I I .. i I
Asbestos Reinforced Phenolic U ti" f,~ i, I, I, "',
Chlorinated Polyether (Penton R" I h ' 7 , ',.'. I, ',', .,,'
CPVC R ;'i ',.,
' ,.i.
II """
Polyethersulfone (PES)
Polvethylene HMW
R
R
It Ii ~. I
I,,' I' Ii • Ii
i/' I: :
I
Ii 1 \ , ; I'i Ii;
I
Polyethylene UHMW
Polymethylpentene
Polypropylene (PP)
R
R
R li'!:l
I"! 1\
8 Ii
·i ,iii ItI':.• i;
",
I;
I'
Polystyrene
Polysuifone
Rill
R
I;;
I:
'iii
", 1m
I., I:
Polwinylidene Chloride
PVC Type 1
R
R
1$ --lit-
Ii,;I"
Ii.; .•. ,.
I; ', "" I Ii
Ii: I:
I,
I
PVC Type 2 Rl'iilil .• I i:. I}, r
i; Ii I,
PVDF (Kynar) 2 R I . ·'ri'.,; I',
R~:; IG ",;;.:.'0,
Ryton
T:E (Teflon)
Vinyl Ester R
RM n ra: I;", " .
"I:i
(;oi; I:'
°F~~g~~~~~~I;~gg~~~~~j~~~
;fi~; 'r"'",~~:; '_N; NCN: N :f)f M,rr); J'l"I, M ~..=:t;: o::::t ..q.. 'o::t
'II"'" ;::: 'II"'" t'I"I
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
ronze
arbon Steel
Olumbium (Niobium)
ii~telloy B/B-2
astelloy C/C-276
astelloy D
/-lastelloy G/G-3
;High Silicon Iron
Hnconel 600/625
lhcolloy 800/825
400
Naval Bronze
200/201
Ni-Resist
Stainless Steels
Type 304/347 E
Type 316/316 L 2E
Type 410 G
Types 430 AND 444 U
17-4 PH U
20Cb3 2G
E-Bright 26-1 E
Silicon Bronze U
Silicon Copper U
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
...
Acrylate-Butadiene (ABR)
Butyl GR-1 (IIR) R
I ••••••
I.
II ! .
.: I .. '
Carboxylic-Acrylonitrile- i ••••
I· I. ..:
' ...•
•••••
•• I.'" I·,
I' '.'
•
.... , )
ii. j
Ethylene-Propylene (EPM) R
I·L;
,J ....•...
~\ ~
ii·
I I·
I
I)
•· k
.,.
Ethylene-Propylene-Diene R .' <.i
.
(EPDM) Ii
I)
·ii,. I; j' 12 .'
.... ( I '.
Ethylene-Propylene R . '
' .. ••
••••• I.
....
Terpolymer (EPT) I." -.
.: ",. ,X ,
I.
••••••
._.~
I
FKM (Viton A RU ;;
"". I I, I"
•••••
• '.,..•...
Hard Rubber R
,. I
I
, r I. I
Soft Rubber U I. I) •• I .. i. I' I·
., <
Isoprene (IR)
R" .H· ;" • I
Kalrez (FPM) R
,.'
"
?, I I:: ...
,
;.
Koroseal
Natural Rubber (GRS)
R i'
R X
,
I • • ,. I'
·
'"
...."
.,. ,
i'
Neoprene GR-M (CR) R "
I;
"
•••••• I
I ."
I.
Nitrile Buna-N (NBR) R
.;
'.
i,
, '...•.,
. ...
• '"
.... ' ,.'. I.
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE
R I,·,
R
f't .,• i',
,
I.,
..
,
.'
.
.:
'"
;
• ••
I'
•
y I"'" '.
Polyether-Urethane (EU
Polyisoprene IIR)
"
• ".i ,-:
.. '
I'
I • I '••
I.
..
•
, •
r..
•• I
•• I;' I,
Polysulfides (T)
Polyurethane AU)
U
R :g.' I'
, ",
• "'..
."""}'"
'
I,
.... ' '.
,
·a
.,
1<
SBR Styrene Buna-S) U
R~
• , ".
...••"
{ "'"
,
.:•.....
Silicone Rubbers .. '.'..
,
,
••••
} ',' j §
•
•
;
i '•... ; , )
Fabrics
Cotton U
'.'
,'}. .. i' i
,
Felt (Wool)
Rayon Viscose
U,
U
"
.,' .'
.. '
.'
}','.
,
<
"',.
, , •
odo:~o-6o'6:o'dod-06o~ob'o~o
OF W~O~"d'~-OO'ON~:"',~ON"d'"~OOON~'"
;:':) .... ~... , .... _: e- "f'J- N.N NN M.m: M ..m, M~; o::I':,!Q" 0::1'
Admiralty Brass G 1/ •• I I
I I
Aluminum U I·
U '.'
Aluminum Bronze . · .'. I
I I··
Brass Ul I I. I
Bronze
-
S~ .:
Iir.: '.
I I ..
Carbon Steel S
[' >
UI
.
I '
I ••••• '>. . i I. ·
.:
,
Columbium (Niobium) i I' I. I
> I ..... .:
I' >
.X > I ·.'. .: I ...
Copper S I> II •••••••
Hastelloy B/B-2 E
r •••
....
.
. ...
..
.; .... GII 1\r.
•••••••
i
I
I
••••••
....
Hastelloy C/C-276 E G Ii
\ ••
~
1
Hastelloy D
-
G .. ' • ".
.......
I>
-.
I"
..
••••••• ••••••
'.'
c••• · c·· .•
1\\ I. I- c 1\ Ic
..
E •••• I .i ...c·•
~
Incolloy 800/825 -. •
i\ .
•
Lead G I. l"
c,> . .. .·.·cc. • ·.c
• ,;
•
I ....
Monel 400
Naval Bronze
E
U
i
.....
..
I·
U
c·..••
"c··
••••••
.·cc.
I •.
III
.
.c . •
•c·\'·
c' ..
/ Ii
G~
• •••c••. .... . ...
..
·.c'.
Nickel 200/201
Ni-Resist
2E I,;
G
" i -
--..--
.' I
I· •••
.;. .
.'c· '.
.'
;
.'
.. c
Stainless Steels I •••• I
;1••
I>
c, I
----. i. .- I.
>•••••
..
+- i~
• •••••
Gil
-
i •••··c
Type 400 series
, i • .... •• 1
c I.. •••
. •••••
•• c•
..:
Type 904-L '.;.'.c. .·c
. ·c.' c·c. ··
. .'
17-4 PH G
••••••
">
0
•
..•
••••
i
;•..
·.c.;.
I
..
"c
••
.- •••••
..i. c'c'
. ..
,· ..
I .'.
•••••••• .;
20 Cb 3 2G •
;1 ·.· .· c ..
..
•••••• >
E-Bright 26-1 l -.. 'cc' c••• ••••
·• \
•••••• .: >. ·c·'.
Silicon Bronze U c.· ·c "·c·.' ..c.
Coatings
Acrylic
-:---------1
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
'"
a'I '0' ~; '" r-: '"
,.. :N' m
M,,~,
'Il""";,f'<l.' N
Acrylate-Butadiene (ABR
Butyl GR-1 (IIR\
Carboxylic-Acrylonitrile-
Butadiene (XNBR\
Chemraz (FPM\
Chloro-lsobutene-Isoprene
(CIIR)
Hypalon (Chloro-Sulfonyl-
Polyethylene (CSM))
Ethylene-Acrylic (EA)
Ethylene-Propylene· (EPM\
Ethylene-Propylene-Diene R
(EPDM)
Ethylene-Propylene R
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (I R
Kalrez (FPM
Koroseal
Natural Rubber (GRS\
Neoprene GR-M (CR)
Nitrile Buna-N NBR)
Nardel (EPDM
Polvbutadiene BR\
Polvester (PE)
Polvether-Urethane (EU\
Polvisonrene (I R\
Polvsulfides IT)
Polvurethane (AU)
SBR Styrene (Buna-S\
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose ;'
Nonmetallic Materials
Borosilicate Glass ,
Carbon
Carbon-Graphite Resin
Impregnated I
1
Ceramics
Coatings
,
Acrylic
,
":,' ii'
Coal Tar
,
Oil Base ,
(Alkyd, Epoxy, Urethane) I '
I ,
Phenolic , ,I,
, I
Polyester , "
Polyvinyl Chloride I ,
i ,
Silicones
1
Urethanes " ! I
Vinyls I! , . '
Ii
.
I
Water Base I . '
.
'I' . ,:
,
Zinc Rich ,
, , I I·
· I . I' ,
I '. I· 1
Mortars , I. I . ",
; I ,
Silicate
·
", i
II , " 'I
Sulfur ·
, , !'
I
Furan Resin I
Polyester ,
,
•" I"
'
,
,
•
I,
! I"~
I,'
••
Epoxy . I I, ,
\
:; I·!
Asbestos Reinforced Epoxy I
"/ II',
,.
.',',"
Asbestos Reinforced Phenolic U IY r'l; >
IX / I, '.
Chlorinated Polyether (Penton R ),
'.1 ',. > I ' ....'
R
·W
ii,•• I, I.
',.'
l~
CPVC 1""
;.g ;
",'
f. I; I; 1/
E-CTFE (Halar) Rk,
01 ,V. I'.
Epoxy I't, •••••
10
I:. ,.
I
ETFE (Tefzel) ~'" • I;,;; I)
, i •• .. W
I,
i',"
"
~~
"
FEP I>
',' I';~'~ InI·j'·
" .~;
Furan (FUrfural Alcohol) I.
No 111 .&
;,
.{
I'~. I)
'~~
',..
Nylon 6
f; .).' I., Ii '; 1/.
Ii11
Nylon 11 ., .. ,WI
I'. I'";;1.'
'~.'. I.
'.;
Nylon 66 '.',. ,I I
U ¥.
Phenolic
ii'. !ie I j
•••
PFA (Teflon)
t'" I'. ji' 1\;>F Ii'
polyamide-Imide
,I) iIg I
i);; ~; ',' Ii!,
i\,; :,~; :~
Polyesters
Bisphenol A-fumarate I;
!i...... .'1
i,
I~;1 ~l
Halogenated I;
Hydrogenated Bisphenol A I;.;
-Bisphenol A
,.Ij.;" lifj
"1" I.,
i/
Isophthalic
Terephthalate (PET)
Uj'
U " !I •••• I.
{.; ?~ I;.11
Polvethenrnide (ULTEM) 1'1 1\.1
Polyetheretherketone (PEEK) R
§;;,~!
- .; j' ,;
~l ~
Polyethersulfone (PES)
ric
Polyethylene HMW "','., r.' 1\ IS;
,; I:; I.'
Polyethylene UHMW Ii
Polvmethvlpentene
Polypropylene (PP)
R
RI0;~
~:
.ii - . .i ;':1 I'~
1.;\
I;;r 1;'[; fI;
lljd '~:
I
Polystyrene R
Polysulfone R fi! I': }
i~i
Polyvinylidene Chloride U
\;; [*;
PVC Type 1
11;'[ -ilt §: Ii;:
pvc Type 2
R
1-1I-:/ I'i~ I'; I,;" I'r;
I";, I~
R
PVDF (Kynar) 2 Ri', U
Ryton ~.;,
\: iiri.
TFE (Teflon) R l \r x,,,
.:<\: e: 5/" .e ~:
Vinyl Ester U 2]; 1r~1i '(hi, ,~".
~-'-i ~
:~(-~
OF o~o~o~o~o~o~o~o~o~o~:o
:,1"1)
\0.; _j 0 co \D,C1J
qo :~~'
Nf"I, 0m '-_~' co'c:>' N'_~: \D
~~' N "0;1"
-f'!'- ":t':\O;
-}-~{ e- J~} ....t:r ':'" .... --~- N ,N;
tr'I 'J't}- rr'lq o::t _ : o::t
o
A
__d_m--.ir_a_lt,-Y~B_r_as_s ---IU ~~ t ;~,' :' I I I
_A_Iu_m_i_nu_m ~GU- I I, I, ..' ,
Aluminum Bronze ~ '
---------~G-.. ' I " I
Brass , , I
Bronze S- I' , I I
-----------i',
Carbon Steel U..
- - - - - - - - - - - 1 'c'
k.: I:
II'
'
"
' 'I
, I :.
';:
I
I'
, I I
I
I
Columbium (Niobium) U:: I, c' ,, I I
-:CC-op-p-e-r --'------'----i~ f' I 1:,,/
1 ," ;' •,': i' ~ I' I I 1 I
I 1 I, I
HasteJloy B/B-2 U: II" I:" I.' ' : I", I I I
_H_as_te-,I,-Io,-y--.C_/C_-_27_6 -I ~ '; I:: I~ ,I I I
",', I'
1 i '
I; ~
1
HasteJloy D ._-1 I I I I 1
'
I,
I
'
I
Lead U. I'
I;
I,I ,",'" " I '" I'
" I I , ,'" I
I· I' I I
I I
I I I
I I I,
I I I I
I I : I
I,
I ,
I'
,
I.
I
I
I II' I
I
1 I I :
I.. I' I '
I' I I '
I ,
I I
I I
I
I I"
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester 17%
---
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
------------1
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
ASS R .
I"
Acetal ut I, •••••
."
./ 1/
1
Epoxy 5% R U ,
,.
I" Ii., .... I I "',.
•
i" .-: I'·
ETFE (Tefzel)
FEP
R
R
'",i "ii 'S, './
I,.••••
.. ,
Furan (FUrfural Alcohol) 5% U
Noryl 20%
I;
ii
/ Ii,•••
. •••••••
..' .:
"'!
••••••••
./.
I
f
I~· I .'
.
.
R " 11., ••••••
Nylon 6
-
-
I;i.
....
UI~! ••••••• . iii ••
ii.
I). "
,
I I. ..,.. ,
I'
~ ii'
Nylon 11
Nylon 66
Phenolic
PFA (Teflon)
U
R
I'·
Ii
I"i
1,1 •••••••j'
•
I'; r ••• •• I
,
,', I· ••
I'
Polyamide-Imide 10% R
Ii' ".
1< •••••• • .> I
I..
,
I)'
• .~
Polyesters •i;. I•
•• I··'•
Bisphenol A-fumarate 15% U :"., 1,/ Ii i., , . .•.' •. •• I
,
Halogenated U, • "j. ;
..• •• I
C •
.~J
•••• '. • !i •• ; ..... I.
Hydrogenated Sisphenol A
-Sisphenol A 10% R
I' i : "
i y. i i
it
...... I It
Isophthalic U 1
> i I
Terephthalate (PET) R IB; Ii; ,. I, Ii Ir. { " I:
Polyetherimide (ULTEM) R' I,i: Ii. i 1 -:
;.
.•...
I'
I
,t ,-.'. I ; Ii
Polyetheretherketone (PEEK) R
ii I;: ,:
'f
i; I',
Polyethersulfone (PES)
Polyethylene HMW
R¥' '-
R•• Ii'
I:' I;
• C.
"r. I·
.....
,; Ii
I
I:
I>
Polyethylene UHMW I
Polymethylpentene
R
R
I,:.
it r;:. m·
.: i I
...
••••••
I·.
I ..
.
, I
•..'•..
I',
I
IX
I· ::
"
.
Nonmetallic Materials
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Sulfur
Furan Resin
Polyester
Epoxy
·--'::-=~=~-==-~-1U
=---~=C='-===Cc'=~'-----i R
':::-"c:.L::::::=:..::..:.c=--'-'C~:;::::L----i R
':::-"c;'-=:='='::":~==C===~==-.:Lj R
':::-"c~::==:":'=~~C=-~---i R
~"--=~~.:..::.c:~:------i R.~
::o-"-;-L.=:..:.L2~-=:'--'-c:.:..:...:_----i RI"!;I-&
::o-"-;-'-'-'-'-''-''-'L==-:..:.:;:o~-----iR ~~
~"-=-'::.J:..Lc=.:..:'---"-C-L-_ _---i R ~-I1.11
;::o-c~~-'-'-=-~~~~~---i R
;::o-c;<-=-:=-='-':"-~=-,------,~~---i R
~~~=:":"::--="::"::':":-==--~---iR
~~::,-c-=-....c~~ ~---iR
~=~-=-='-c-~~_~---iR
;:;-'_.L:L:..c=~ ---iR~~-
~=-=~--c- ---iR 'l4i#-~~
;-;;--'c-'==-':.=::..:L ---i R
R ~H;HH¥+-fi!+-~~~-+"4~
" :~;
Metals o~o~o~o:~o~io~:o~oi;o~o~~o~o~o~
of l..O'OO' O,'N 0::1"\0. (0-:0 N'.'=t, \0:00: C,'N; o::t
'''""" . ..-: or-:t""": e- ~' N-N N ""':1- mr:o: 1TI
00'0 N ~llD-~; O'N' o::t\O
rt'l'oq "d': ',o::t - - I.n l.t'l: Ln I.I"l
I'
~ ~
Brass I ~~ II 1
, I
Bronze I
,
I, ~
I
I
Carbon Steel ~ ~ 1 ~ I ~ ~ I
I ~
I
Columbium (Niobium) : ,~ ~
1
I I I ~ ~
~
I':
~ ~
Copper G
I> I
1 ,
~
~ :~>
Hastelloy B/B-2
i;
,
E ~ -,
I
, I , :
Hastelloy C/C-276 E:--: I, I •
' ~
, ••• 1 I '~ ; : ~
Hastelloy D
.~
; I I
I'
,
~ I
Hastelloy G/G-3
'.'. :
"
~.:. ! '~ I: II
,~ ,
1 ~
Inconel 600/625 E~ 1 ~ ~ ~
~~~ I ~~ ~ ,
Incolloy 800/825
G~ I
1
, ~
Lead
.-: :~
I I
L , i
I I ~~~
~: :
/', ' ~ I
Monel 400
Naval Bronze
EG
~ "
I;; ; I'
, '
I
I,
I
,
:
:
I
I
I
.
,
, ~~
~
,
~
.:
~',
~
~
~
k
,
, '~
Nickel 200/201 E > ,
,
, I,
I:I
1 ' ~
~
Ni-Resist
Ie
:
; I ,
~~
Stainless Steels I
I:
,> I
!
k , ,
I ~
~ ~
:~
I
Type 304/347 u'" J I I
' ~
I, I.'' ,~
~
I ,
Type 316/316 L U I
Type 400 series G I'
I' , I I, ; ~ II ,
,
~
I
" I
Type 904-L
I,' I, .:
I ': , I :
,
I
17-4 PH
E~ I: : I I ~
1
,
I,
I, I ~
20 Cb 3 ~
I I: I:' ~
E-Bright 26-1
~ :~ I::
: ~ I ~~
I~; ,
I ~
1 ;
GI: ~.
~,; I
1
,
Silicon Bronze ,,'
I: I:;
"
~~ ,
Silicon Copper "
~r I
Stellite
: I;, ..
"
,
1
I
I
I I
,
I II
Tantalum
Titanium
E
I".
l, I:; ..'. I "
~:~
, ~~
"
1
1
,
•
I I,I
" -;c~:
I' ,
", ,
Zirconium k ~
" I'. ;
6~~
OF o~'\~; 0'01 @;,F' ~:,~
o::t i'_~:
.... e- ' ':1~
0'(:), 1,~: 0;6 0'6: !~~; 0.0' 06: 0 6
\O~:
N'(\I 0m o::t:~: CO'C::',
mf") m,q-, N o:t \D :N~ 'd'
'"OCt 0Ln'LO:
'd',q-, LnLO'lO
O( LO'm; co
.... ,(\I'm
~
~;:::N
'" co~
'd' :~' ~,~;, en
O~'Nm:o:tw:~~eno :':N': m~:
:,0 . .
.... ~, .... ~ .... :~ .... :~ .... 'N
~ ,~. cccn; 0 :,'~' NM
m¢:\D'KCCm
NNNN'NN
.",;
Borosilicate Glass R Y
I:I
Carbon >I ....
,
I'I .
I I
I' I
1
I:
.
I
Carbon-G raphite Resin
;'
I ,
I f
'. I. .. I
Impregnated I 1
•
1 I '.
,:" I· . r
I'I,
1
Ceramics .
'
I.
I;I:
';: . ,
. ... :
:, I:.
II' '
:
Coatings .; ,
Acrylic ;, ,
'
. '"
.
I
I':
,~\' I{
Asphalt . I.;
;
~
," '
h
.
,; ;~
:,
Epoxy Chemical Resistant ;.
::,"
:: I; ,
,
:~.
Epoxy Polyamide ,) ."
.
,J
. ; .
'
'
:',
,:,
i (:
;~:,
Urethanes
Vinyls t ,: '. '
:: :"
,
,"
Water Base
Zinc Rich
~i ": " :. .:, ;;.' ~;'
,
',"
,",
",
:': ' ,;:1 :i,: ,
Mortars
f~
.',: I:"
c, ':
:~
Silicate , .i..
~ ~,~I i~.
~,
Sodium Silicate ;i:,
., ;"
:'
Potassium Silicate '.'
; .;:
i,:'
Silica ;' :.
ri:! :.;'"
, , "
i
.:;': :,
;
Sulfur ':" "
,,'
Furan Resin
;~ " " ,
;: ~'
"
:,i .::,
Polyester ':
y ,',': ,',: ;",
" >,
Epoxy ,
Monel 400
~'Naval Bronze
Nickel 200/201
" Ni-Resist
"Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
---------j
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Acrvlate-Butadiene (ABR
t:.,>;
,;
or"" :f"0.l
I;·
or- :h:-, ...
K;:' l
II'
NN. N -N' m M MM' t'I"I
,
. i,'
' . ~;~.: ; ~
i
I
I.
II
Chemraz (FPM) I -
Chloro-lsobutene-Isoprene
R ...',.
..'
I
I
I ,
I
II
(CIIR) ',C,
, I I'
I' .
",' I, I e '. I
Hypalon (Chloro-Sulfonyl- R I: II . .
,': I
Polyethylene (CSM)) ': . I·
I·I I ., .... ~ I
'
1
~k " ;'
Ethylene-Propylene (EPM) :
Ethylene-Propylene-Diene
(EPDM)
: 1,:1
"i
'.
I; I:I •••
"
I· "
"
,,
1
I
" r. ..' I'·"
I~
Ethylene-Propylene
z: .
:, ". <
i
:. :. I ..
Terpolvmer (EPT) .,
FKM (Viton A) / '.: ; .;.
Hard Rubber
Soft Rubber
,~
,
ii;
',,,
.
[
' -:
I,,'
:"
.:
.;
/ , ('
? I'
,
I
:,
'
Isoprene (IR) ;i . ,
I:,
,:i •
I~
Kalrez (FPM) R •
Koroseal
i, " .
• I ,
'.: {;
i.,:
Natural Rubber (GRS)
. I
,i .i ' .. I .i
Neoprene GR-M (CR) R '. '
' •. ' .'
i;
". i.
"
',' i..
Polybutadiene (BR)
Polyester (PE) ••• '.'
"
','
~
.' "!
it ;'
::•.
,
,~
•••• ,
Polyether-Urethane (EU) , . ,
~. '::' ",i;
Polvisoprene OR) (. i,
'y
Polysulfides (T)
• .' •
Polyurethane (AU) ,
,
,
..
" . .
..',
"
Fabrics
/'
(
~~; · .",
.;.
I~~I
"
••• ."
Cotton
Felt (Wool) ii. :,
;'.'
I'
•} ,
ii' ) . . ,
Rayon Viscose ,i ' ,
,
.
"
OF
0
~~~'. ~ oooo~ 0C'f"I
CO:O'N¢- !~*'*'''1~iOOO co N'~~)U)
'" ....
,.. iN;,' N "'.-
.N .r tv'l 0::1' i,':,
.,
o:t
N '-M, .'·,lD' f' ,"ix) ~ :t:::)'-' ,... :f~i ~ --~-, \0 ;~; co
O( ~, ig <Xl'O>' ~:
fY'l,,~l 00 ,:0:)' 0,'.....; N:M o:::t ilD: r--.. '00: N i"l"I ~ ~N
,';:oc' ',:>", e- /"'"7) or-;~: or- ';""7' e- :~p! or-:~_ N
,O'nze
rbon Steel
lumbium (Niobium)
·pper
~telloy B/B-2
astelloy C/C-276
~stelloy 0
astelloy G/G-3
igh Silicon Iron
oconel 600/625
ncolloy 800/825
ead
onel 400
laval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool)
Rayon Viscose ..
Brass
Bronze
. •. Carbon Steel
Columbium (Niobium)
Copper G
Hastelloy B/B-2
Hastelloy CIC-276
Hastelloy D
. Hastelloy G/G-3
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
-~
Nonmetallic Materials
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Urethanes
Vinyls
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
g1~~elloy B/B-2
§lltelloy C/C-276
'astelloy D
stelloy G/G-3
'h Silicon Iron
conel 600/625
90lloy 800/825
~ad
onel 400
aval Bronze
lckel 200/201
" i-Resist
Stainless Steels
Type 304/347
Type 316/316 L
, Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
"Silicon Copper
Stellite
'Tantalum
Titanium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride Rfi'ifl--l!'!:'1!-
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Galv. Stl.
Tantalum
Titanium
Zirconium
o~'o~ob:odoSo6o~o~o~ob'o
Nonmetallic Materials OF ~~iO~_~~'tO~.N~\D.~O~:~~tOON:;:\D
~\.-.~ """', .... : ""'"~'t-.-; .... N N,' . N('\J'" 1"0' M:m Mq-· 'lIl:t.',_ 'Ilt
Borosilicate Glass
Carbon
R
R " ...•... .,
......
I.i
......
•i i I,
.
, i'
Carbon-Graphite Resin Y " ••
...
.......
.'."'. / . ',' ...
Impregnated-Furan R
' I•
I
."
,,..
',' '.
···i. "
.... /
f~0
I :>
.
.
Coatings
I·. •••••
i
I ....
Acrylic
fe, I'I. i' Ii .,'. I,; "
I
• ,
'•••••.'.Ii
,
•••••
,.
Asphalt .""
I I I·f .... ,
I~~ ~.
If ::i, >
. ,•
••
i::
Chlorinated Rubber
Coal Tar
'.
I. : r
I"
I".
-.
I,; Ii...
:'
Coal Tar Epoxy
Epoxy General Purpose
R
R
••
It· .'·'i
.'
.'.1.'.
':'i
Ii
i'"..., I'
I>
'i,
I,' . •
,'.,
.... ,
'.....
U· .,. '.<, I;" .1
"":.'.
(Alkyd, Epoxy, Urethane)
I·'I!:·~
Iii In I; >
••••••. ....•'
Phenolic
Polyester I. I'"
1< . '1,"
, In
I, Ii
I'
'"'
.
"'"
...
."',
...."
.',,'
y
R ; I:
Iii I·; ,. ;~
,
Polyvinyl Chloride
Ii • <
I'
I"·iF "
I~ c' -.«
",
~H
Silicones
... . ...
r,••••
' •. ','
Urethanes
Ii, A, I"
"
I)" Ir,, ...
.•' t
Vinyls R ii, ... •
;' . ,
u~
:.; "1,••:
Water Base
i;
Sodium Silicate
" Il~ is' ,: .,.; ,."
..
Potassium Silicate RI':;,I ;,. •• "
Silica R •
It.
"~I
'.>.
,!'if I';l
I:'. iii; I.
II, o
ABS R, "
,
, " ,','
Ii ,
Acetal
Acrylics
50%
=~i ..
" i I
Asbestos Reinforced Epoxy R~
Asbestos Reinforced Phenolic R~ I .,.
I
Ii
I
"
,'....,'
"
I
.,.....
,
I.
,
I>....
I,
'
I
R!'; I
I'
FEP . I
Furan (Furfural Alcohol) R "::
..
..,
y. -: '",'
ii .. -;
I....
.' ,
'",
,
,
II
=~
Noryl
1" .. I
Nylon 6 ,
I
I. I, ',"
I· ....
Nylon 11
Nylon 66
I...
}
"
I,
.,.',
' .....
i','
I I,
,
Rr I" .... "
I, , i,I}
Phenolic
PFA (Teflon)
Polyamide-Imide
Polyesters
Rrr
R ,.,
J.,
i I·
I,
Ii
i
I;
I'
I.,
i
.:
.
"'',' ' , I
I' I;
I
I;
.•.•,.
., ,',"
...,,'"
,
........
,
I'
",",.
I,'
I" '
.".,.. ;
Bisphenol A-fumarate R; Ii ..
·i .... "
•• Ii
I,'
Halogenated ALL
Hydrogenated Bisphenol A
R""
.. ; W
, ..
I
I.
I
',","
'. -;.. ,
-Blsphenol A R
.....
, ><
• i If . !;
/ .'," I,
••••
I', .:
Isophthalic R' ... ' I, I
R ,I,', "
....'
Terephthal'!!e (P~l__
I'·' , I'
. .. Li I'
II;'"~ IJ I.
I'
Polyetherimide (ULTEMT
Polyetheretherketone (PEEK) "
1"
....'"
' ..
Ii '.
,
.) i I
",
Polyethersulfone (PES) I.> I ""
..
..
1
"'i, ',.",•
".'i·. •• .:
I
',.
Polyethylene HMW R,• I,
Polyethylene UHMW R
",
I
" I1'1 "'i, .. !.. .r: ,}
',,",
. 1jr: ;i
II'
Polvrnethvlpentene
R '" "I ,;'"
r
II
j
;, i
Polypropylene (PP)
Polystyrene
Polvsulfone
R
R
I"
."". ,I
I
I'
1',,,,,, Ii
,' Ii
,
..
V ',I I
I, Ii I ••
i·
II ii,
Polvvinvlidene Chloride
pvc Type 1
R
R, ..
I,', If Ii I,.
',, •...
..
','i' """;
PVC Type 2 R "• "i' I,; ....', ..'
j
,
I,
PVDF (Kynar) R
I;, /' "
I "
••
I
Ryton R
I,
I,; .. "','"
. '.
.
<: ....
I
;! II" j
I>
TFE (Teflon) R
1i I' "
•• I'
"I I
Vinyl Ester R "
i' 1<
oSoblo6:ob:6do~ob:oao6;o:do
OF ~~ON_~~'=O:N~:~~ON . • W~ON~~
' : e- .:..;-, ""'" .... - - N N N N N0 t'tl m tt'lM M "q-- "d' - , •
Ui 't.o:: CIOm' 0 ...... Nm . \ 0 r-..i::o 0'1 0; ..... 'N M'-.::t, IQ r-, ' 00
°C ..... " : l'I"l :<¢: 1Q.f'; 00 ,en ~::' ~ ,~ ~, t:: -,~: ~ _~ N :~-_ ~ :!
..»; I; t.·
b.
r.
,.}~; Ii
•••
Ii:
Butyl GR-1 (IIR) RI~ ,. Ie I" t; I),)
Carboxylic-Acrylonitrile- RI ,
t·' ..,'" ;
I;' Y Ii";
Butadiene (XNBR)
I'" !l. Ii.IE, ; I'
./
.",." I··..
Chemraz (FPM)
Chloro-Isobutene-Isoprene
R
Rli'
";,, F
••,
I
I"
I
,
"." i.
-.
Ii
'"
(CIIR)
>
fi)'. . it;
Hypalon (Chloro-Sulfonyl- R~," I";
it
I·t
;; liV' k "
Polyethylene (CSM)) ',. I;' Ii ,"f ,i
. I, ;i;
.,~'
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
R
R
I, I··t, ,',{
I;.
I:{t I·;; !; ;'t' 1
I", ;~ it.,:
%:
;
§,
(EPDM) J 'r)
I'
I;
1
Ethylene-Propylene R
. .
Terpolymer (EPT)
FKM (Viton A R
I':;' I·" :
I;
t'>
;. !:~ I;,;
r:;: im
.i~
Hard Rubber R
[:
i ii
.;
U"~' ~l~. \0
O( -;N' R~~'j GO
~a", ,,"'to
,'O'lj O;'~; ,,'eil ~~: ~'Ni m'g' i:~:
~~'-'~' r:;,~~:/ ": ..... r": ~."""';-c_; "'m; ~.' ; ~:'
N,'M: o::t:\O'
~"oO-', ~'N;
l'Y\
N
/"Z~':; ;.'~~1
OF ~~~~L~,j~~~~~~}
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride RI!H+,,*,,+-
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
,,.
,
,
,
,
"
,
: .
•
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Plastics OF 0'00;00
1O.OO: ON' o:::r
"' .e-_;'If"'"
o-~: No~--
coo
'f""'N N
o::::t: 0 0:
U).OO
:N N N'
O
mm
:0:; ::_~_
0 N o:::t
rt'l
co
0 >0
M'¢
0 ~_~
N
.q
0
\0
o::t
ABS
c ,: ....
Acetal .: ". .' .,
..
I"
I
I
Acrylics
Asbestos Reinforced Epoxv
. ,.
• I.
'.'
Chlorinated Polyether (Penton R .', I'
•• >
CPVC R .: , I> -:
E-CTFE (Halar)
I>
,:
", " I""",. I I:
I, I
Epoxv IX >, >
"'. I:••••• ,";
>.
., ..
I
Nylon 6 R i'" .. I> I '". I
r.
I ,
Nvlon 11 R
R ~.
~.' .•..'. ".'',".,. i
I: ',•• '
>
Nvlon 66 X, .,"", Ii i. > I' I:
Phenolic I, ""'i
". 1".,'.
Ii
I I:
PFA (Teflon) I·, ',.'... ,
,
"
i' I> I:'
..
, ,'> IiI
',:
I I
Polvamide-Imide
-: I,. I> ,
I, I' :
I I'
H ....""' ,,·i.:. •"I"',
Polyesters
Bisphenol A-fumarate I.
I Ii ... r:
I
,
I·;
Halooenated Ii 1;1 i' >,
:, -.'
II,
i':'< I I
Isophthalic
I
'11' "'""
", ,,',' } ,',
'; ""1"".',i·
,
Terephthalate (PET)
Ii i:
( Ii
I ,
;, ,
, I
Ii; I:,
;
I,
,
'. :'
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK) li,i ii~
(
•
'.
.'
I
I
.:', ,,".' ,
,
,
I·:,
I; I'
:
·.',i'· I
Polyethersulfone (PES)
Polyethylene HMW R fi i,
:
: I'>
:
I' ( Ii
I>,
I
l Ii
I:"
; Polyethylene UHMW R ( I:
,t Polymethylpentene
m .. "
"'" I>
'11,'
,:
"",
II ""', > I; • I.
~ Polypropylene (PP)
Polystyrene
R
I,' I~ .(
:
..
(
I,
"""
, ;' I"
I
,r Polysulfone Ii > i;' I;
I'
I'., 'Ii i. I', "'" '=; I'
I •
'"."
Polyvinylidene Chloride r >; ';.",
'. .i I,
.'
,
I
PVC Type 1 R .; "ii'• ie, I:
1'< • •, ,
'I',' :
PVC Type 2
PVDF (Kvnar)
I
R I:,
I ,.i",',
'.; I; '.,:,.i " II.i I •
'; i .
,
Ryton 'i
.s:
"
,
I, i I,
TFE (Teflon)
Vinyl Ester
R
OF 1O
Ii' :
" I, ,
I
. I
~:~ 0'6: 00: 0 :0: 00' 00' 00'· 0'0- 00: 0 '6 0
o~:.:~·CIOON.·u)OOONo::t~.CIOON.\O
,
I.:
"
r"""~;"""~'''""N.NNNNMm-''''m·'''o:::t. o::t
l/"lWCOmO-~;N-M o:::tW'~~-~O~N:~~;~_~~
O( -;N~~~~~~~~~-~'~~~~~~~~
Acrylate-Butadiene (ABR
/ i I
Butyl GR-1 (lIR)
Carboxylic-Acrylonitrile-
R
R
, I I
I
I
I
.
,
II
'
'c'
.,',
Butadiene (XNBR)
Chemraz (FPM) R '" f
'"
I ,
Chloro-Isobutene-Isoprene I
-. "
(CIIR)
,
, ,
I I'
'"
Hypalon (Chloro-Sulfonyl- R ,
"co
.,'"
!' "
Ethylene-Propylene (EPM)
,'" / !~&•• ,;'!, I "',' II
I.
•
Ethylene-Propylene-Diene R I,
(EPDM) . I> " I,
I
•
Ethylene-Propylene R"., I
Terpolymer (EPT) > . I', I, I .. I,
• ", I ',"
FKM (Viton A) R " ,.'
': '., I
Hard Rubber R
Soft Rubber
'.'. ::. I,i I I I I. I·
R " I
I, I' I
Isoprene (lR) R I,
I,
" ,",'.' .'. I
,
' ...•
: ,
, ',.,' I·
Koroseal
Natural Rubber (GRS) R
Y.
,[/ ['
!
, I
.,'.•
n
., ••
'
Polyisoprene (IR)
""
I: "
Polysulfides (T)
. .. I' .' I
I, I I ".',
,
"
.•. "., I.
Polyurethane (AU) : rI, I. I I "~,co
I'
,;
. i;,,'i.. I ,
Cotton I !.
...
Felt (Wool)
Rayon Viscose i,
obo~;ocobo:oo.~o:oo~o~,o:6o
I
Ii
I
I··
..
'Y
,
" '
Ellais
CClmiralty Brass
luminum
luminum Bronze
ronze
arbon Steel
Columbium (Niobium)
. pper
astelloy B/B-2
.. astelloy C/C-276
Hastelloy D
Hastelloy G/G-3
CHigh
:i-'
Silicon Iron
Iriconel 600/625
CI~colloy 800/825
''Lead
Monel 400
JNaval Bronze
'Nickel 200/201
£ Ni-Resist
i Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium TO 100% E",
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o
'"...
ex>
",
N
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (lR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU) U
Polyisoprene (lR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
...OO~
N 0<D
...
Aluminum I
I
Aluminum Bronze
: I
Brass ,
I
Bronze I I
I
Carbon Steel
Columbium (Niobium) ,',
Copper
,
Hastelloy B/B-2 ,
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Incone1600/625
Incolloy 800/825
Lead ,
Naval Bronze
Nickel 200/201
:
..
Ni-Resist
Stainless Steels
,
Type 304/347
Type 316/316 L , '
Silicon Bronze :
Silicon Copper
Stellite "
:
Tantalum
,
Titanium ,
"
Zirconium
Nonmetallic Materials
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
R I• Y. "'.
i) ,;.
l' ~
Chloro-Isobutene-Isoprene "
(CIIR) :I~' : ..
.; ,<\\:.
<t t,
Hypalon (Chloro-Sulfonyl- R ii
~
i' ;3'1 •.
'r' It,~
Polyethvlene (CSM) ft
,/ <;
Ethylene-Acrvlic (EA !;~ 11
~~,
.>
Ethylene-Propylene EPM)
1
"
t it
Ethylene-Propylene-Diene R ,c, ><", 'W'
(EPDM) ': ii; ~ J'"
I'f" ..• "
I' :!q.."
Ethylene-Propylene R :> :. .,..1;
Terpolymer (EPT) •~ •••••••••
,
I !~ ,~f .; 'ii ",
Polvsulfides (T) :.' ....... ..
;,,'c· 'ii
Polvurethane (AU)
SBR Styrene (Buna-S) "1;~ Ii.
I'
>: iii! ,. '....
....•
;'
Silicone Rubbers U ~•..• i ',D.
,~,; 'ii,
Fabrics
Ii ['" lij, ";; 'i ,£/
Cotton
Felt (Wool) ,
I"; 1<
I'!
/
; I[;.'
\' ;~i
Rayon Viscose I'; ~; •••••••
I, f
',,; i*.'dli.t
OF 55;~j ~:~i~ •.~~
~ j~1"
O( ......
0'6; 0;;0: 0'6': 0
N'I:::t;\O,OO;O'N:o::t:t.O;~O.N;::\D
NCN;N;~im;.M:m'~:m:~~~~:~
~N m'g' '"
" 0 0:'.00 0
i':': ee
m'. .l l i ' i oo,<7\i o'..~' N'e"t)' ~l.O, r....·GO: en.,",:
:,:'i,,-~j ;::', ":' """"- -(~ ~~: ~',of-' ~'N
~-~', N
N'N I'I'l
'l-lastelloy D
'Hastelloy G/G-3
High Silicon Iron
lnconel 600/625
lncolloy 800/825
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones U
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
\
I
SchweirzeriCoTTosion Rtsistnnu Tabus: Fifth Edition, R~lJis~d and Expantkd
Copyright ~ 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to www.dekker.com. 3003
Elastomers' and Linings of g :~. ~ r§. ~ ~. §g ~.~ ~ ~ ,~' ~ .~, ~ ~ ~ ~. ~
Acrylate-Butadiene (ABR)
Butyl GR-1 OIR) R
t i. I
I
I
"I
I
I
r
I'
l··'
r.
Carboxylic-Acrylonitrile-
I:' I.:" t I : '. I.. l t,'
Butadiene (XNBR) I.,' [,;, I I .' I (:
Chemraz (FPM) R :. 1- r' , r' " . I'
Chloro-Isobutene-Isoprene R .'., I·. II., ;,. .' !
(CIIR),~ . I' ' . i
Hypalon (Chloro-Sulfonyl- R .: ' ; , •.• I '.
Polyethylene (CSM)) r ·c.·!· I I, t . '
I
s.: I i . ; ; ',.
·c " ' I:
~ C'.,J'
I'
'. [,
k:
,s
,
:>
i
Koroseal '. I'.;: t: ;; >: .,
Natural Rubber (GRS) R ., , '., :' [f',; . i,,: ,';.
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
~t!-
R
I , ", " i':
I
L
Aluminum Bronze ,
I
Brass G ,
,
Bronze G
Carbon Steel
I,
, ,
I I
I ,.'.
1
•• ,
Columbium (Niobium) I •
"
"
,
"
,
"
1
, "
Copper G :' I I
.,.
'"
'" , '
I
,
Hastelloy B/B-2 G
" "'., 1 ' ' •. '
I'
,
Hastelloy C/C-276 G 1
I I
Hastelloy D G
;, ,
1 : I
I , L ,
,
1
I ,
" 1 .,
Hastelloy G/G-3 I
S~ I .:
,
I
High Silicon Iron ;.
.
,
I I
: ',,',
1 ,
Inconel 600/625
l
,
• 1
I
1 I ,
I: , , '
I ,
Monel 400 G,. I
,
Naval Bronze
:. j I' 1
,
: ,
Nickel 200/201 G
t' " i 1
"
1
"
"
., .'
,
Ni-Resist ,
I I 1
.. ,
Stainless Steels
1< ' 1
1
I I .:
.
I
,
1
,
,
'~ <: 1
1
I I
Type 400 series E I '. I
I~
1
Type 904-L 1 I
' ,
,. "
G~
,
17-4 PH I. ' I ,
"
G:
,
20 Cb 3 I
I: I
, , i ,
E-Bright 26-1 ••
' "
I I
,
" ,
I" I.
,
,
,
Silicon Bronze
;, ' . '.' 1 :' , I
Silicon Copper I' I:
,
~: I .:
I~
, "
Stellite
Tantalum G,
, •. ,
,,'
i I I'
:
,
i
• I;
. :
.
,
I, I . I:
I;
I,
Titanium G I' ,
, "
" : .: 1
, ,
,
Zirconium G
o~:d' o.c:i oiO': 0:6:
060 0'0 o-:b-' 0'6' 0,000: 00' 00
OF 1..0'00' O'N'. o::t;~_ 00:0: N:."'=t, 1.0
,';,,' """':""~;
ON,¢!W:CO:O'N~\OroON:,¢~
m 'M moM t'I"I ,q- 0I;,f'. ',o::t -q- U\ 'Ll), Ln:Ll"I
e":............ N. NN N
!', . -
t.n'\;o: co;:m o·~! N:M '¢'.l.D',...., :00' at '0 "s- ·:N: m-.::t" lD ,'t-;.- 00-.01: 0 ...... NM
O( ..... '('1 ty'j',¢' U) .:...... : co ,en 0,""': N:m oct :'\0 f"'oo :00, (TIO: ... N m',q-' \D :l" co m
·· .... ~ ... ~: ... ~, ... :~ ... ~NN:N~NNNN
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
r
.~
I
SODIUM PHOSPHATE NEUTRAL
ABS I, .. .". I ,
Furan (Furfural Alcohol) U I.', [,;i ';! I' .'.'. ,.i I, .'
Noryl .. ~: ,'. ,I .•'. '........
Nylon 6 Rf,o I> '• • ' I·". ".',.' "'.
Nylon 11 R ~J I.. ., ".' Ii, I; . . "', . •. • • I," I'· .
Nylon 66 R 1<, I.i.
Ii, I ,.... '" '.".'. ..".',
Phenolic
PFA (Teflon)
Polyamide-Imide
R.
R"
" I'
I
@ ': < ,
I,.,""
IF,
..
••.••••
·.·,i,'
I
""
,'.....
',"
".
Polyesters i' I' ,. i' ••, I ,I I'
Bisphenol A-fumarate
HaloClenated
il. .· I
1 "
"
i'll' ' . •., ,
i'>
k ,.,
Hydrogenated Bisphenol A.,
-Bisphenol A •••,. . . I
.',"" '< e . ..'....\(
,i I, . ..".~'
I'
I'
ii I'
.....
... •
Polyvinylidene Chloride R ,•• .','" [, I "•." •••.•••• I I>
PVC Type 1 R ' . . ; ....... I I '" 1
astelloy B/B-2
; astelloy C/C-276
iiStelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
[ncolloy 800/825
Lead
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R~~l-
Silicones
Urethanes
Vinyls R~~l-
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
ABS R ....
Acetal
•••• I .' I •••• ,(
Acrylics RI
I·
I·' •••••••
••••
.. '
,
Asbestos Reinforced Epoxy I;; ...... I I
Asbestos Reinforced Phenolic R~ I " .
R' •• I
Chlorinated Polyether (Penton I' I'
CPVC R
•• '••••) ). n.'
I>
••
·
I .. I;;
I.
I
I
(
E-CTFE (Halar) R
I>
I I
Epoxy R •••• .
J I
ETFE (Tefzel) R
• I
.) I I
I'. I'" I' H I..
FEP
Furan (Furfural Alcohol)
NoryL
R
R
Pi
[:...
.{ >) )
['
C
..
' I> I:' I',
{
~i
- - RI ,· •
~~. ,',
Nylon 6 I
I
•••••••
.. I[>
• )
--
Nylon 11 ••••••
, '. ,
I> Ii
I.'
Nylon 66 Rr- ..
,
,
Phenolic R7'
•••••
I·"'," I' H'
.' • ,
I',
.. I• [
I,
PFA (Teflon)
Polyamide-Imide
R" I, '.'.
, I i>
II'
J~
•••••••• .:.
Polyesters
" ;
." J' k
I
I, I'
1'. I'
,
Bisphenol A-fumarate
Haloqenated R I £'
'.
••••••••
.C I" ,. I
•••••
I.
...•.'. .:':
,
[ .
Hydrogenated Bisphenol A
-Bisphenol A ,• I·. "i 1';
(
I,.
I,T
,""'.
•••••
,
., i' I, I
·i:·:.
I>
Isophthalic U ••.•. • • > .. I,
,.'It I'.:
'0
Terephthalate (PET) Rt, .'.'
)
•• }
I' :;'
Polyetherimide (ULTEM)
•
.:
",'"
"
Polyetheretherketone (PEEK)
PoJyethersulfone (PES) __
• ""
..... I> I;; I
.I>
I
P
•
Ie i.
I.
',,'.' I
I>
Polyethylene HMW - - R ..
"
"..". I' >, I I·
~;:,
<'
Polyethylene UHMW I I.
Polymethylpentene R'T
>
... I',
,
'..•...
•
.•...
•...
I If
I. I
Polypropylene (PP) R"
I' I'I,
.
Ii'.
Polystyrene "
I'
I. R~, • I.>
i'
•
Polysulfone R, I
I)' '. '.
•••••
"
I·'
..':
Polyvinylidene Chloride R
R"
I' f f·' ",.
.' i., I;
PVC Type 1 IX '.'."
PVC Type 2 R
I::· ",.' ., I
.. '
. "
, I I> • I>
PVDF (Kynar) R " '.
I'
". • ','
It
Ryton ALL R
I>., p' }
· ,
I'
TFE (Teflon) R ., · ;;, ;:}:'"); I,.
I", ...• '.
Vinyl Ester ALL R '.' <j-'
o'6-oSododo'ao'oob:o$obo:o'o'
OF ~~O·N:.~CO~N.I.DCOON:.~,ClO~.N~\O
""_:"":~""N:NNNNM~m_m:m~~'.~
Hard Rubber
Soft Rubber
Isoprene (IR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
er
'alloy 8/8-2
~"Jloy C/C-276
~$lelloy
'.
~ ","';
G/G-3
'inless Steels
: Type 304/347
}Type 316/316 L
:"Type 400 series
<Type 904-L
7-4 PH
20 Cb 3
K.;:'; .
'ff'OR METALS FOR NONMETALLICS
:f:E = < 2 Mils PenetrationlYear; G = < 20 Mils PenetrationlYear R = Resistant
~7S = < 50 Mils PenetrationlYear; U = > 50 Mils PenetrationlYear U ; Unsatisfactory
ilSchweltter/C01Tosion Raistance Tabus: FifthEdition, RroirrJ and Expantkd DOl: 1O.108115672-X·120028918
'~~_c:opyrigh( <0 2004 by Marcel Dekker, Inc. All rights reserved. fur more information, go to www.dekker.com. 3013
~'
-
SODIUM SULFATE
~~~~O~N'~~~·~~·mb'~~~~~~~
O( ~~'M~~,N~~;O~N~~~~Wlm~'~~:M
j.;_')':~ '§-:~;y ;:>/.: 'ro.' ~:~: .... )r'~: .-,.... ~ .... )7.: ... )~.;, N'N- N
oho~'o~o~'oB'o6'o;b'o~~o~o~o
Nonmetallic Materials of I.D ~! 0 ·'t,r
q- -\0; 00'0: N:o::tC'. ID :CO: ON: "'=t -. ; co- v , N}q·" u:I
W'-~""~""~:NNjN~·m.mm~m~,q-~: •
Borosilicate Glass R
-'~'.
.;
I
.
~t I. h'
Carbon R r·i•
I
I
1
1'.
I·~· I·.I; . . I. ' ~'.•"
'.
. •••
Carbon-G raphite Resin
Rt': !. . .-.
,
I.
Impregnated-Phenolic
r.y
, I:
'..
,;:
I,~
I' r .
Ceramics R"
,.
I ,.' I I IiU.'
, r
f~
.:
.~.
I 1<
Coatings .,
i·
'"
Ii I"i
I··I"~
•'. I'[.' I·I; 'k
. I.·,..
Acrylic
I. I
.•.··i ..•.
I;
I
I·•'.•
.. \",.I .'..
Asphalt
Chlorinated Rubber :.: i. i'" I' I.:
Coal Tar \!: I[: I..
••
n i . I,
I; •
Coal Tar Epoxy
Epoxy General Purpose \f
il•.
Ii' I.u, ••·.i·.
I····
I·.···
I"
,. i< Ii.;
[GJ
R
.,
I~
.
Epoxy Chemical Resistant R
Epoxy Polyamide
.'..•. I'
••••••• 1<
I; ; I~\[
.~~
R
Oil Base ft' ~'j
k•.
'.'
I. 1 I;•
I;
~;i I.i
I;i • 1 I;; 1
(Alkyd, Epoxy, Urethane) ••••••
·
Phenolic R
II r··:..: Iii
I. 1/,;
• ~.
I'y I·I;.I~:
Polyester R h: <; I
Polyvinyl Chloride R
••• I.!! Ii ... ~ .i Ig. I'i;
Silicones R
I.
Ii: , I· I
Urethanes
Vinyls
R
R
I~.
I· I·;
;:
I.:
i.··••••
x
••
• I'·
"
; ;;
II'
1/-;
h I:'
11 I•
I:
; I'
Water Base
:
Zinc Rich U
,. ;; 1/
I' ;
.,.: · ii··.i
;.
1,: I;.I.
I·i u.·
~
I· 1
Mortars !' ;·c I
I· .. I", I
I~lc
U .i~ •
Silicate
Sodium Silicate R
y :~, I.......
"
r..
I: .) I,'
Ii!
.....
r-
IL. 10k ii .n I'{ <.
I{/;
Potassium Silicate R
Silica R'"., fi"i .·i {i 1/ I; I·;;
Iii .. ' I, It!. k; Ii
Sulfur
Furan Resin
Polyester
R,C',
R .t,.
R
[!\ 1<
....
I' it) ..;
i
't·e. Ii;
I:'
I;
1'" 1/
Ii.
I' ;;; I'
R!C§ if I"
I'
.'
Epoxy I', I' 1<
o",b' 0"'6:' 0'''0' 00'-' 0 ,O'! 0 :6- 0 :0:': 00' 0·;6:; o~:: 0
OF '-0f;~; ~ ':~! ;!-'~ ~ ;'~~ gj ~~-._ ~~r ~~: ~:~: ~~) t;;J .:, - ~
", _ ,
,.~.- c/.; "" .', .. -. : : ',_ ..- ,-:" : - ..' ..,',,' ..
~~~~-o~N~:~~~~;~:d'~~;m~~~~
O( -ttm~:~:~~~:O~:Nm.~'~~~OI~Nm
,', .', .'- ·-·"'"":~:"'""t-'_~_","":"'""_ ....'~r'LN_NN
~~:=~------:-:----1R
ALL R,~
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU
Polvisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Polyester
Epoxy
~F~='-'-'--'-.L------iR
~~~ ----iR
3t'-"c;::.:..:;~------c~-;-o---j R
~2'-"-"'~'-""=""-'='----I R
~2'-"=-=------c-----jR
;;:;;::'+.S-"'--'='--;-- --jR
R
~,-..l.:..::L::':"-L-------:-AL:-::L-I R
E~=.:L----~_1R
ALL R "4 ''P'' 'f~, '(:"
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
tt='=-;-';-;:~o::.L~-----:-:-:---i R
ALL R i;-ii< it!~,' ~","t
ilJminum Bronze
~""~ ,
[ass
,"
t onze
':~rbon Steei
'alv. Stl.
lfUistelloy B/B-2
';J.,<",_
;astelloy C/C-276
,",'-':.'
I'lstelloy D
[istelloy G/G-3
igh Silicon Iron
conel 600/625
(:olloy 800/825
ead
oneI 400
aval Bronze
ickel 200/201
i~Resist
tainless Steels
Type 304/347
Type 316/316 L
Type 410
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
'Silicon Bronze
ilicon Copper
tellite
antalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant R
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride R
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
SODIUM TETRABORATE
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Galv. Stl.
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Sulfur
I
.
Furan Resin :
Polyester
Epoxy
Bronze
,Carbon Steel
Columbium (Niobium)
'Copper
,Hastelloy B/B-2
"'.~ Hastelloy C/C-276
, Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Furan Resin
Polyester
Epoxy
~:
",
I' ",
I,',.,
"
"
Aluminum Bronze ii, ,:
Ii ; ' .• ' ,i
,
i,
E
< I,: I Ii ,:
i"
Brass ',,' " '
Bronze
G~ : r< ;:', ,
ii'
, :\:
~.
Carbon Steel
Columbium (Niobium)
': I
ii'
::
Copper E "
?
',,'
Hastelloy B/B-2 E {
~, ;
WI t'i
Hastelloy C/C-276 'e
Hastelloy 0
Hastelloy G/G-3 I;,{
"
;,~ '.
: "
I(
High Silicon Iron i'l i;
,
!
II ~';
J; ;::'
.~.
Inconel 600/625
Incolloy 800/825 I': f':: ",'
I', ;:
Lead " 'i I'
,";
Monel 400 G ::
'
1/
"
Naval Bronze E
Nickel 200/201 >
Ni-Resist S !:~ h
It
,!
,: ,:~
~~~:I
Silicon Copper ,
Stellite G"
r~; "
~t
i~:
"
:>
li~
"';
~~ ~~£;'
:' ~
Tantalum E
Titanium E ~,\
l."i,
,p ",' ::; ,:'
:'~ ;:
t1~ ..
"'.,
~':>
,~;::",
~{t :,~ 2: '} ','
.~.
Zirconium I:' "
OF
o:C!:/ ODt oJ6:
\.0 :,PQ:
'
0 f~l ~ :~;
'.'.
0'4
co :~Qi
~ 0:0: 0;6:; o~o; oIo. 0 __:0') o:j' o~6: o,:d
(D '00; 0 ~~i ~ :.tP; 00 "0.; N :~.; (D i. , ,~ 0""'. q- ;:\0
;"
~:e',j .... ~~i ~:~:, .... ',t';'J: N 'N~ fY'l ~t'tl~ mJ!)' fY'l.~: ~ '_. i ~~> ~ &n'Ln; &n-~
O( l.I"l
,.... N:
,\0', 00
m :~:
:'0\; 0 ;'oiR' N rti:
(D J:':-'i co'-m: 0
~ ;~\b,: ,,: 00, Q'l :'6: .... :N; fY'l ::!: (D'!" co:"0)' 0
~,.-.;.; N M. ~ '.\,0' ..... ,.00: en.' 'N --N'
;-~1 N"
I'Y\ '-=:t.; l.O
N, 00 O"l
m
\,;~ '.,"; /'«.i :>-y .... _ e-. .... ,...." .... :.~.; .... :;~; .... ~f',p .f'! N,N. N-,N: N ~
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R~~+O
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
•••••
RHo+'!
~~=,-,,-,=--'-CL-- ---IRe~H.ioI-+-++H+H+++
R
~==-~'--=~~~ __ IR~~H~i;
R~...er~H"'+
==~'--'=~~'=::~_ _-IU
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester , :i
Polyvinyl Chloride r\',
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~@ !: :,'
:
\.i ~. >
,
..... "
.
FEP R 'j,
i%
.j~
~~! ",
Furan (Furfural Alcohol)
la
ii' y,; r~ ,I';
t ";; ~;
Norvl 1:\( I,;'.
Nylon 6 ;' & Wi; •
;~ }, ;i
,X lie:
I(!;
I' t;l
Nylon 11 I': m'l "
I~;p '~'
Nylon 66
',c,
Phenolic ii
PFA (Teflon) R'o' ;
./.",/
ii· j' ;, i; Ii
Polyamide-Imide
Polyesters
:\
I'r;;
f21
,/;: fu;
w it
I,;'
~
Sisphenol A-fumarate ;;
:: .iii :; ',;
Haloqenated
o'. i' :: i',. ;
';~
Hydrogenated Sisphenol A ') i',
-Sisphenol A ';' ;,i: ji .,'
:~i
Isophthalic
Terephthalate (PET)
Polyetherimide (ULTEM)
1&' I~;
p
~t
I,:t
F.
;.
d, .~ ii'" I) "
Ii ii!
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
I"';'
liE; i),1 r, "
j ,j
'i
d ;;
Polyethylene HMW ;, ,i:
Polyethylene UHMW
;{
.ii iI , ,i,
Polymethylpentene
I'" J~ ;1 i~ ii;
Polypropylene (PP)
Polystyrene
R ii;
i'; ~;j .i'
~
,,i. %: ji;
Polysulfone i",;
Polyvinylidene Chloride R ill'
PVC Type 1 ,;~: iii
PVC Type 2
Ill~ Xi ,\. ';,t
PVDF (Kynar)
Ryton
TFE (Teflon)
R
R
mit'/ ~~I
~t :ti ~f, is
j:
\'
~ I~fil .'
-~" ~' '~;t. ':':;0
J~!. c-;
Vinyl Ester ::;,~\; C,;
L::;, ~{t
0 oBo~o~o~o~o~!o~o~oSo
OF O~~~CO~N~:~~ON'l::t~.coiN:J~
'" -'.1"'<.: 'r",~} -:N: N!"I' N~N: m :f!'I, m;rn' m~,' . , ' ~
O( '" '..
~
co:'c,;':
m~,~
s
~" N'~' • ;\0' ~ ~,.~; m,~: ~ "~i ee
co'~ohNm;.~'~.,~c;N,N:m
:.<_;'-::~" >::.: __
:at
'r"."",,:, _ .....,
_iN:
.~, _ ,r\tN N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Furan
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
.:
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelioy B/B-2
Hastelioy C/C-276
Hastelioy 0
Hastelioy G/G-3
High Silicon Iron
Inconel 600/625
Incolioy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist :~'
Stainless Steels .. '
Type 304/347 1\ 1/
Type 316/316 L
In :
Type 400 series
',.
Type 904-L '.
17-4 PH
,
,',
: : 'i.
;",
20 Cb 3
E-Bright 26-1 '.,
Silicon Bronze
Silicon Copper 5%G
;
Stellite
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R~"""''''
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
O(
'
:'"
I "" ,';
Chloro-Isobutene-Isoprene ; " , I,
. ' '" , I ' ': 1,.. I ;:
(CIIR) ~r, I, : If:: '.'", ',' ',', ,'.
Hypalon (Chloro-Sulfonyl- R I. , I,; ,', I',V \ ,,'
Polyethylene (CSM)) " I I I ' :' :" I" " 5' ,',
:::_E-,;-th'LYII""e~ne~-A::::-:c~~ryL'll~ic..\.(E""A-,!q=~--I
" I " '.",, Ii" '; •
','
Ethylene-Propylene ( E P M I . I.',: i';, ':,:'
Ethylene-Propylene-Diene R ' . . :,',
(EPDM), I:, I ',,'
Ethylene-Propylene R ',' ,."
Terpolymer (EPT) 1'1 I~ ','; '" i,i,' I,
FKM (Viton A)
~~;~R~~~~~r
Isoprene (IR R
R
~ Rlff I.
. ' I' ' ,..
~. I~ Ii r ~l ~ ; "
,"
Kalrez (FPM R fiG] ,.. ,~~' ;1,: ','
Koroseal; "' " ",
Natural Rubber (GRS) R ' , ' , , " ' ,:'~i' '.:J,
Neoprene GR-M ICR) R '
I~!'I, ' , ' ,
Nitrile Buna-N NBRl RI"++-~H.-I--+-l--:
I" "',
Nordel (EPDM
Polybutadiene BR)
R I
Ii,,'
I'.,;':' ',;'<;,
Polyester (PE) 15% R I· ..
Polvether-UrethaneIEU)10%R '.; " ,:: ,,' ,i'
Polvisoorene OR)
I~;
lit-, : ' . " / ..
" , ,;'
Polvsulfides T)
Polvurethane IAU)
,i'
, i ''}
"
,
J: II ' , :' '; fl.:
SBR Styrene ( B u n a - S ) . : "
;, ;";',; ,
'
,
II
STANNOUS FLUORIDE
~~~~O~N~~,~~'~.~·&~~;m~'~~~
O( co Ol' , ""'"_;
..- ·N' M'¢·· l.O.f',,; 0 '""", N ,M' o:t ..I;D ""'00 0'1. ; ""'"N M
.:;,,' ,.... -";' ""'"~ ""'",_ .... - e- ;t~ NN: N
o~o6·o6Iobo6oo;o~odo606o
Nonmetallic Materials of 'l:t,I.D: co.O o N<;t IDOO 0 .t"'.I' oct -t,o coo N ~ 1.0
l.O,OC) o. N
'.,' . ,.. ..... """ ...... ""'"N N N N ."" rr"l M MO"l Mo:::t- e. . 'l:t
Borosilicate Glass i··.·.· I I '.
Carbon I .
Carbon-Graphite Resin
Impregnated
I .
.
'. .'.
Ceramics ••••
!
' ..
I. 1< •••••
Coatings I
i· I . '. I··.•
. '
•• ..•. ."....
Acrylic
Ii
Asphalt •i., I .'. ...
,
"
I .. • ••••••
.
..... ",
••••
Chlorinated Rubber I· ?., I,
Coal Tar
.. 1< I
1
I.
I.'••'.'. I I ,
,.'
,
.,.,
1
Epoxy General Purpose .
Oil Base ;
.....'
' ..
<i I •••••••• I ..
1
..
(Alkyd. Epoxy, Urethane)
••••••
.• , •••
.' ; .'
>
• .;
.
..
Phenolic .••••
<. , . I, ....
"
Polyvinyl Chloride
I 1/ I
-:
.:
......
, .....
'" I..'".
Ii '"
Silicones ••••
.
. I
••
... ••••••
.. '. ..
, ' .:
....
Urethanes I I'" ..
Vinyls \. .
Ii
IiI I'" ,
I; I
..
.. Ii
.':
. • •••••
.,.
I· .",.'. ..
Water Base , 1< I . ". ..
Zinc Rich
i
i'
"
I .:
<
i., ..
,
,
-, .' ,
.... .... ' .
,
I .. I.,•. .· ... ,
Mortars i"
.
'.i:
I".
, , i ' ..
.••..., ..
;
. Ii!. 1\
Silicate
Sodium Silicate i.. ••••
..
I <? •.•·.i
...•..'.
,
,.
I ii i"
.... \ i
. i
Potassium Silicate ••••••• I ,. Ii'. / \
' .
..
Silica I .""
Sulfur , Ii
I
,'.' ••••
I .
I.",
i ", I.
... 'i
I' ','.•;. ., .,.
i ,
Furan Resin ,.
"
'
.•. ' ,
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B·2
Hastelloy C/C·276
Hastelloy D
Hastelloy G/G·3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Reslst
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904·L
17·4 PH
20 Cb 3
E·Bright 26·1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
~~~~~
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
~~~~~~~~-/
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~II
,
Admiralty Brass I
Aluminum !G
I
I
,
'AluminUm Bronze IG
---b I I II
Brass I
~~
·
I
Bronze
Carbon Steel
Columbium (Niobium) ...
·
I
, I
Copper G
Hastelloy B/B-2 E ••
I
Hastelloy C/C-276 G
,"
I I
-j .. 1
Hastelloy D .------J · I
Hastelloy G/G-3 I
I I
I
----I · !
.
High Silicon Iron
--j I I
I
Inconel 600/625 --i E
Incolloy 800/825 J .. '.'. I
I
Lead
I
,
I
Monel 400 G .:
Naval Bronze E .
I
,
' ,
Nickel 200/201 G ..
Ni-Resist E
--
Stainless Steels , ' .... I .... I I
-- ·
I'
Type 304/347 G
". I ,
, I
Type 316/316 L G .
Type 400 series G
Type 904-L
I .
I
17-4 PH G ,
20 Cb 3 G ..
.
I I
E-Bright 26-1
,
I
I I, I
,,'.'. I
Silicon Bronze G
Silicon Copper
· .... I I
U
Stellite G
",.'. I I I
I
Tantalum G "
I I I
Titanium G I
I .-' Ii i
Zirconium E ,
00000000'000000000000000000
OF ~OOON.I.OCOON.I.OOOON.~COON.l.Ot:OON.1.O
-_-_-~NNN·NmMMMM¢ •••• ~~~~
I O( l.I"IlO CIOm 0
......
..;- N'M .1,0' r-, 00 0'10 'I- N m •
NM.I.O~COmO_NM.I.Or-..ooO'lO_Nm.l.Or-..com
U) r-; 00 m 0 ...... N m
1 I. . . ·-~-_-_-_-NNNNNNNNN
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
---c-~~~~~~-1
Polyvinyl Chloride U
Silicones U
Urethanes
Vinyls U
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Bronze
Carbon Steel
Columbium (Niobium)
Copper ·
Hastelloy B/B-2 ·
.
Hastelloy D
.
Hastelloy G/G-3 . "
Monel 400
;..
Naval Bronze '",
.. .
Nickel 200/201
,
Ni-Resist ",
;',
Stainless Steels .
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
,
•••• .',
".: .
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
--'"'---------1
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
Titanium
Zirconium
STEARIC ACID
t$i ...
O( Ltll\D:
..... ~~,
;;,,:;":
T'~'
:::IJ O:r~-'N}roj ~ "~i to- ;'Qj: 0)
ID ;~! co 0\;
rJS} ~~"c>i ... <,y,:
N ok:
"'}i
o~cb: 0;:'--;
c( e- r~
C'N m;~J 1D;k;: co
:m:
oq-; C ""'<lQ' 0\:0; '-:N, Nl
~; "'f~:N-,~_' N
o}o! ot';--:oo
...
of ~~
~t~l
o rib! 0:;6100
o:~_ 'I:t_~_\D co::0: N
0
Nonmetallic Materials ~~;i
oqo '.\0.'
"'!.r.! ~:@: f::j,~.: ~-:~j m ,;f!I:. ""1"0: ~-_~-
l'Y'l-,~-,o::t,:"t '"
<t
;\i> ~\:j; -c:
Borosilicate Glass R 'ie, 0;\
t~; "; .; .,. .,;
Carbon R ;'; \
Carbon-Graphite Resin
Impregnated-Furan R
'Vie;, ~1
,~\
;
; lief li<
I,
, I' X'
I' \X
:;,
:
,..••,;
:~~
: I' ......
Ceramics R :
;:
I,' r\> \
Coatings
Acrylic
it
'....,. [It; f*;
I:
~X. ie,
~
1\,
~
. I
;;.~
Asphalt I'.
.~ Ii
i:,J
1~
Ifm 1:'0
Chlorinated Rubber
n I; ";
Coal Tar U !' ,.;,:;, k
I;, 1/
l~/\I
:
!;\
Coal Tar Epoxy U
[In II; .. I:,
~. 11
I;~ •;: !.It,
Epoxy General Purpose U
I;;"
Epoxy Chemical Resistant U
'. I~ it II \i;
I~
Epoxy Polyamide U I;
Oil Base ',.
Ii
(Alkyd, Epoxy, Urethane) 1\: I,M I:': ?
Phenolic R -If. :·f r••.
III
Polyester R - ,. i".
fl.[" : IS·
Mt
1;\'
1\,'
I'~ i',
Polyvinyl Chloride ~ I~
1
1(,'& ';
Ix· I'
Silicones
IiI> I:'t if
I;~~ I:: ,\
I';~
Urethanes
Vinyls R I:i
1,\;'
I:,~ 1;1'
Is,'
~
Water Base \1' ft; I;:
Zinc Rich ii,' tlx
I'<~ II'I~
1;/ ,'1; i"
Mortars
'" lx\; I;~(
Silicate R
~;,j
Sodium Silicate
Potassium Silicate
R
R ,'",
[tf,'d ~~I
it
Silica R
:'¥
i~
"}Z.
Sulfur R
I~!
:;<~:'
;;,"
Furan Resin R t~~'-i';
1\\1~ t?~
>,:t:! @Er-
Polyester R't,-,-f ;~~ I~el l;'\;
if"':
~"
2~1
Epoxy -~
U~if'
~.•
i':: ~)~
t~ 0';6; {;':
·:0;
p,"'-
,is;
~~
l*i
0 16 <0
~~~1 0;-' ,~!~,~;
o:~i o~o:~ 0 0 O::Ot 0.'<::>1 o~oJ
OF "'"";~:J ;',_.-'..1
N
N '"
N
ON' <t,,>, co'0,
t'W"I J!l:: fY'l_~j
N :'~'
N'I~; "Q':., , '"
<t
\\.11: ~;~g:Ri~:~j oqo '(0; e-, ic:o~
~iil. ,... 'ocr m:"d<
",""<tiJ: \D-:g~ 00
O( ..... <M:
lI)
o .:.ir':':i N:ty}: Q'lo~ ""'".'N'm
~vn ::;:i:;~ -<:>~:}>:. ""'"','1':: 'r'" ':T'""" ""'"r ""'" ;.'7; '-'-N N iN1N
,',,,,,,,,,
\0
~1"":~' ~ i~" e-
".,,,', '" '
,... :,~,
<"
, ..
,... .:...... ; "":N'
':... "c;, '"~'''
N'N':
,,'
N
o:Q;~
Plastics
OF lO;,QQ"
:::',;:..'! ~'~ o~o,6~,~
=·0;N1Il:;t
~,'N: N:t)i'
s ::~; ~'"f6':: :i1 ':~i ~ :~, s
m,t'(): m·,m,m,,:l::t'; ~'i: lilt
ASS U
~0' ; I)' In < I~
t~ r',>;' I>
,
Acetal < ,
Acrylics
I,;) h,>
Asbestos Reinforced Epoxv R~f- L,
"
II, L" I,> h
l~
I'
I
Rf~t II: hi.. I
Asbestos Reinforced Phenolic < 1<, rill! I'
Chlorinated Polyether (Penton I I>
I>,
~l
CPVC f- ~'I Gr I"fA ;: I'
E-CTFE (Halar)
Epoxy
ETFE (Tefzel)
If'YI
1',1!'1
1;';;1
1,\ I",i
":
I"jk
1'2
f;;
,>,
1;' Ii'
FEP R I','t"
I
Furan (Furfural Alcohol) R IJ': 1(')
Norvl I'; ;TI
Nylon 6 .... ;. V,' i, "
R -1.1;;"r .>. I,i
=- , <I't
Nylon 11 in,
%
Nylon 66
Phenolic R
1'.'1 ';it' ,;
;; 1;1*
Jf:'
/ ~ ~'
1'(;1
PFA (Teflon)
Polyamide-Imide
R ,1, 'I'
Polvesters 1i:~1
Sisphenol A-fumarate R ;. .,:"
Haloqenated R :;i"
I!i~
;
~i
Hydrogenated Sisphenol A
i,B .t, ,i,1 ';', ;
-Sisphenol A R ,; I',' 'i,')
,., 'i'
Isophthalic
Terephthalate (PET)
R F:,
R \}! {
.""','
.,
V'
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK) ~ ~' i,
I,; IJ"
I'.. il ,
.'
,
,",,'
Polyethersulfone (PES)
,t.,' 1 ~l ? I,':
.~
';
Polyethylene HMW iW t,
I~j
R,t, It':; i,'
Polyethylene UHMW R I,;! I,'. ; ,
",'." J
Polymethylpentene R
B' ,\'
;',
i(
Polypropylene (PP) i.
R",;;. ,,;
ii ~i 'i"
Polystyrene
~; ~,)
·,f' iU,
~il
Polysulfone Ret fi; ;I'
Polyvinylidene Chloride R ;
PVC Type 1 R
:is! ,,:, ii, N!
'~
',: 'ii ii'
@; $ ,.
t~,
PVC Type 2 R yin
PVDF (Kynar) R ,,: w, ')".,' ;~ ;~\t
Ryton ALL R 51
TFE (Teflon) R
;" D\ ':
[1;;1
Vinyl Ester ALL R" 'z, ~ ~"", . '41 "i' .~
o~o~oao~o~ob:oB:oEo 0.0'0
OF lO·',CO: 0 :N; ~}..o: = 0 N;.~; ~<oo: O't'\l o::t.'t.D: co
tZ:·l "":.~'!) ,... ;,,,:;:,j ""N: N :f:'I: N ~!": ,.., J'Y1: m m ",iii ;m. :;;!~:g
O( ~
..... '\ir
'N: mCO"~::'
".','
~
'.q, \0
:~','
::fi N<~:.. '",..._',...;.....!,.....-
~ '~~': ~:'CO: ~ '0' ,... ::N' M·~.: \O'~'
= 'Q\' 0"_: N m' ~1O ~'CO: ~ co
0: ""N m
,...:~:-·N.N,N·N
Soft Rubber
Isoprene OR}
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones U
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Acrylate-Butadiene (ABR)
Butyl GR-1 (lIR)
Carboxylic-Acrylonitrile-
Butadiene (XNBR)
Chemraz (FPM)
Chloro-Isobutene-Isoprene
(CIIR)
Hypalon (Chloro-Sulfonyl-
Polyethylene (CSM»
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM) U
Ethylene-Propylene-Diene U
(EPDM)
Ethylene-Propylene U
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (IR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene (I R)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
O(
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride U
Silicones
Urethanes
Vinyls R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur U
Furan Resin RH*fo-++f'rl""""'+-HH,,++HYYI
Polyester R
Epoxy R
=::==.c,"-=,,--"-~L::".,"-_--jU
'-=~-:::'::-=~'.:':':=c.I~_--jU
===-cc==-=:=-- --jU
..
o
'"
00
'"
N
Admiralty Brass , I I
I
Aluminum 50% G U I , I
I
Aluminum Bronze
"
I I ! I
Brass G
,
,
I
I 1< I I
Bronze G· II I "
I I I ' I
Carbon Steel ~ 'i I , ' '
I
I,
,
" ,
I I
Columbium (Niobium) I I
II II
i
, , ,
I
Copper G ,
I ,.', I I I
Hastelloy B/B-2 G
i
I I i, I: I
I:
"
I" I
Hastelloy C/C-276
Hastelloy D
G
G
Ii ",
"' , I
I
I I;; '
.-
,
I
I I I
I
I
, I I I
I,:
II'
,
Hastelloy G/G-3
','
I
I I
I I IiI
,
I I I
High Silicon Iron G,· I
•• ,
I I c, I
-'
I, I
Inconel 600/625
Incolloy 825
G --, , .-
I I
Ii I
I
I
I
E, " I~ I
· II
", I
, I ,
Lead I
"
I', l I II
Monel 400 G
"
" ' ':
II,
I I ,
I
I
,
I,
I I
,
.- I,
:.',
Naval Bronze
Nickel 200/201 G
·
:
,
P
I'
' "
I
,
I
, '
,
,
I
I:
I
I
I
I;
'
I I
Ni-Resist
::. "
II, , ,
I ' ,
,
'
II
,
I, I
I
Stainless Steels _. __.-
,
I ,
"
,',
I I I I I
Type 304/347 G" I' , '
I, II ' ,
,
I
, U " I I
I' ,
I I II
Type 316/316 L G I, I·
I
,
I I I I I I
G" I
I~:
20 Cb 3 I I'" ,
': .' I'
,
E-Bright 26-1 [ ,
I
Eli I' "
,
I I
Silicon Bronze ,
"
I I I
r~, I
I
E I:., I "
,,'
I ,
Titanium I, I
I I ,
E I> L ,
I I
,
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes U
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
PIas
tl
ICS
of gl~i g:,~; ~J:g' ~,g, ~l:i;~ ~;~;: g,'~,: ~-Ji_- g.;i;gi. ~-:~_
;) -! .... l~-\ .... '0'7: .... ~N: N ,N' N .l"f m ;rr; m 1m
s
' o:::tq- "'d'
,.., .,"=t e
Acetal I." 1 I I
Acrylics I. " f I I I I
Asbestos Reinforced Epoxy I '. ,I .
Asbestos Reinforced Phenolic I: . . I
Chlorinated PolYether (Penton I. . ':.. ' i· It . . I : I
PVC Type 1
PVC Type 2
PVDF (Kynar)
R : C : '"
Rf . , ,
R
: [. •
I'. I" .', :.
I
. II" ;'.:.
II,'.:;
Ryton I .' -; ';: I.;
TFE (Teflon) RHo++-+++-+-+'"+-+++-+-++-+++'-I
Vinyl Ester
High Silicon Iron '. I:: '." ". ,;. " ,', I" I I '. II
"
'
Ni-Resist ;'. I. I: I !
Stainless Steels
'.,. I'.·...
..
. :. I: I; I
I ' 'I
_-:-:AI_6,XN G: II"
20 Cb 3
E-Bright 26-1
20% Gi,~;
Er : ,
1
; : ' '.;',;
.' ,:..
-c..
r I:I",
•.
'. I;
I
I·
I·
" .
I
I
I'
!:
Silicon Bronze 20% G ',: ' \ , ~ . I, . I: . I'.•' ;. I
Silicon C o p p e r : . . :
Stellite G ::<
'
lx :,
,
...
'I' I.
I I
I
.
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester 25% R
Polyvinyl Chloride
Silicones
Urethanes
Vinyls 25% R~-I\'I''I-
Water Base
linc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur 25%
Furan Resin 25%
Polyester 25%
Epoxy 25%
~~J.L-=---': -IRIo":'+""""'t-
10%
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
---1
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
-----~
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Titanium
Zirconium
SULFITE LIQUORS
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose~---j
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
SULFONATED DETERGENTS
O( ~.~~~~~~~~i~~~~~~~~=;~~
~ ~ ~ ~rmr~r~~~-~,N;~N
Ii
OF o1.0 ~ - - i o\cZ, 0 i6: ° ,'e)' oC:~', 0,6' o,:d'; 0"61 0 :~. 0'0; 0
0"." qo ,.W i CO '.0: N;o '.' ltD '.CO, 0 -N- 't:t\O; co N;~. ltD
Nonmetallic Materials 3;1fffi - ~~ .... ,?!, .... ;:,(~~f N it'~t N]'\I' lYl,'!rf Mm-, m 't:t",_, q-
;-," >., ,",
Borosilicate Glass R~ I, "., I, .'Y"i '., I
I, :
Carbon R ,
K,{I . [.
t
Carbon-Graphite Resin I
r":
I' I i , II
Impregnated [) : !• , "
I, I, .
Ceramics .'.
,
"
I" , ,
I,
':,~:
Asphalt ':,'
,
"
:?
~ ~, ~.•.
,,,"'
rt~1
Chlorinated Rubber ';,
",
'
"
"
., > '.
"
','
,
Silicones ,. > ,
Urethanes "
;)
;, (; :>.•
Vinyls ;'.
Water Base
: : ;
,: "',
,'t
Zinc Rich
>,
',
.; {
::, ;
~
:;' ;;;
Mortars
',: ?
;;
."
Silicate ::
:, .,',
~,
Sodium Silicate
'";'
.,
"
!:'
Potassium Silicate
Silica
r~1 ';.
,
:
£: i'.
}.
Sulfur
Furan Resin
:
:. :,:' :'~ "
;'i
;::
~~
"
Polyester ~.
,': ,':
r~.1 ~:
"
"~ !: ::
Epoxy
s..s:
",
,0'0 °
',. 1~':0 ;6: 0 ,~~ij\O
OF g)$j~~
~~'1
,$'
,..is:, 00'0 '"
e- ~~: N ~,~ 0-0:
O'M'ott
m~~m
CO.'O:N'- 0
M~~~ ~~
lI'ItD'; 00 <'m' 0 ~~.; N&)' '¢ ~, ,.... '00: O'lCf ,..r\i: m .'~', \0 :,k', co
O( ~~mm\O~oo~~ ~~,~~~:=g.~g~~
l'Sronze
N
S
tbarbon Steel U
'.olumbium (Niobium) E~4l!i.!-~..jO,;~~-l'!\~~~H~~H~+""H'e'I
opper S
astelloy B/B-2 U
astelloy C/C-276 E
astelloy 0 E ~""""i.!-~-l'!\HOiii+~H!!;i:1
asteuoy G/G-3
, igh Silicon Iron
I1conel 600/625
ncolloy 800/825
onel 400
Naval Bronze
i_'
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series 1
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
.Silicon Bronze
Bilicon Copper
'Stellite
rantalum
Titanium
,irconium
SULFUR
Nonmetallic Materials
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose~------j
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
ASS
Acetal
U
U:
., : [,
I'
I'
I
&I
KEL-F (CTFE) R • ••
Asbestos Reinforced Epoxy i' I'
Asbestos Reinforced Phenolic ,,' ,, I
Chlorinated Polyether (Penton R. , "
CPVC R I' " I
I E-CTFE (Halar)
Epoxy
H' ,,'
R'
:
I '
"
,,
".
s
I
I,
"
Nylon 66
Nylon 11 R "',
R "' III I ' '.','~".
'. I ," !. "
I
,,
Phenolic
PFA (Teflon),
Polyamide-Imide
R.,
",'
'
I I'
II' I
','
I I
,;
"
i
Polyesters : • [" I
Sisphenol A-fumarate I" ',"::.'~ ." I I,'"
Halogenated R" I
Hydrogenated Bisphenol A , • I;' 1<. II " I '
-Bisphenol A ••• I' • I I.
Isophthalic R' . I" I " ,
Terephthalate (PET): ' I' I" I, I' >
Polyetherimide (ULTEM) ,':. I • " ;'
i,: I' .', ;
1
':
,
,¥,'" -
~;tals
llmiralty Brass
luminum
uminum Bronze
ass
ionze
rbon Steel
olumbium (Niobium)
,astelloy B/B-2
astelloy C/C-276
f!astelloy D
}Jastelloy G/G-3
;Nickel 200/201
'Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
j.Jastelloy B/B-2
Hastelloy C/C-276
·Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
.Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
1,
::c;'-;~~~:-=---=.c.c--'-'--~--1 R
:::;;-;-:o:-:::--U=~=-------1 R
::c;'-;=-=~~'--;------1R
';;:-'-"'--'-----"-'''-'-'''''-L-----1 R
~~=-:::--.,--------1 R
-:-;;--=:-'==.:=:L------1 R
R )':r'" <f" ~
==r..:;~~~ _jU
:.;:::-=:"-"'-'---":"1- _j R
:=.:.-:.:=::,-~-~~c_-_j R"""'-..,.",.,---,
:.;:::~=-:.==='--i:~-:L--_jU
:..==..::::----:-::"-"--~c::c:,~-_IU
:==-=-.,=-"'==~~=.:..:.l-- _ _jU
'c-=-C====C:=,"=-=O~_ __jU
.'-==--'.C..=L-----c=-cc--_jR
.::c=c'-'-":..:L:,=c-===-=----1 U
==-=-:...:=:::==-=- _jR
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
FKM (Viton A
Hard Rubber
Soft Rubber
Isoprene (lR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polvisoorene IR)
Polvsulfides (T)
Polvurethane AU)
SBR Styrene Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
'Incolloy 800/825
,',.' Lead
Monel 400
'Naval Bronze
Nickel 200/201
, Ni-Resist
, , Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
iN
Carbon
Oarbon-G raphite Resin
R ',i',
if; l:j, ;,t " , 1'(
liX
Ii
Impregnated-Phenolic R
!"
'. i\ , I,'
,< Ii
iii'; 1((ii' I: .i' I;; !il iii,
Ceramics R
~~11~1 , ','"."
~~ i;'i
I; in 'ii, [if" I:i
:~
Coatings y.
iL
:;~ i~
",";
Acrylic
.~ :/~i
.,'··i,:
Asphalt ;
i;
Chlorinated Rubber
ii.
x iit \' Ii
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
U
U
R
R .~
I~;
.'j' I' ~;f;
Ii
~ ~( ;( I'
';
I:i'
Polyester
Polyvinyl Chloride :I-H- i~~ j~
1('
I;: I; ~.~ I;!f
~ ~
Silicones I, 0'.. !i' G:
Urethanes y;
'L; l~ 1,[; Iii I;
L, I,}!· I,i:
i'r'r~,
Vinyls
;';, Ii h
iii; i,i,
l~ I~~
Water Base I;,!
; Li 16',
Zinc Rich rit 'ii
;.~ ri' ; ~; '!et; I".
Mortars
Silicate U
~j
lBi
l~,
I;~ ii
~?f.~
Sodium Silicate R
!~11
~
Potassium Silicate ~"
if ;~c
Silica
f;'
I;;
.(~
!J~
~.~. ,;
Sulfur R~ f 0.
I;' }; i'"
Furan Resin
Polyester
Epoxy
:PR
III-
R ,-,,,'
N
ici
],N
'",,:>,
'~\
'.5i
ip '~
r{,~,
[;,]
~-,,-
';>"
-,-
,',
li\
I;';
o ':OJ 0 ::>'d~ 0
~
0:6. 0 .'0,,' 0 lci 00) 0.0> 0:0' O~l 0
OF 1.0 :9Q.: 0 Ai; q.
{f7.~ e- \t7':~ ,...
OJ ':01 N ;'¢~ tD ::(0' 0
,... 5fi'1; N;~) N '1':\1_ M _~) t\"l 'f\I: -m,
~ '~:: co :_.~- N; 'U)
rtl' ' : "It - .- "'"
O(
;1.";.•'
'> IA;
Chloro-Isobutene-Isoprene R ,.
...
:i ,i
Ii
,".
(CIIR)
:' ;': ii
I'
'i' !
Hypalon (Chloro-Sulfonyl- R I> fiX .. i
:;: :'...... !;
:~ Dj
kli!i
..
Polyethylene (CSM))
fA , ....
Ethylene-Acrylic (EA)
R!C: i> C, I; "'• :•• c,
Ethylene-Propylene (EPM)
FiI:;:1 't ;~ ,;:,t Ii}
I'
I~Q
Ethylene-Propylene-Diene I'
(EPDM)
;, ,,: .:, ,i g; 'i:i.
Ethylene-Propylene R
I:i·. : !;
p.
Terpolvrner (EPT) !;~ !, 'j'),
FKM (Vilon A) R
F;. r
....;
" './ [,i';!
,eX
Hard Rubber
Soft Rubber
R
R
:;: DC/ ',;:;iii I" ,..",' .',
,e I":
I" <,
r
I
Isoprene (IR) R
• .i;i ",liJ.
If; "i·'
Kalrez (FPM) R
Koroseal R ; ,
,i: g: 'ii I,;
::,. !~
Natural Rubber (GRS) R I.. ,;
"!,' .f i I~·:
•"
",
,
Neoprene GR-M (eR) R
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
R
R
R
Ii.!
iii; ;
y' ,
'.
:i
Ii
,i I,. i..; ... I'H,"
!>
,/
I, ~' '.'; I.,';" I"
,
'~j
fi
O~O$iO'O
j'
OF 's i~i :! ~F,; ~ :~J ~ .:~.l ~ ~ _:~ ~ ~:~~ ~ ~~\ ~ ~\_ " ~
0:'=' N~"7~' ~ '\J)i ~::co~ t '_'~; ~:w,mO-~'NM
O( ~'~ i~i;~ u);~:CO'~'O·_-Nm'~ ~'N:' m -~i U).~; co
,':-\ i,';.' ...... '-i"'" :~.i or- s--. ..........~. N'('l' N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Phenolic
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
I"
Potassium Silicate
Silica
Sulfur
FuranResln
Polyester
Epoxy
III
00: 0;6 0 :'6- 06' 0 -'0 ocf 00: 0.:0- 0 ' 6 0
Plastics OF 06:
~·~ON.~CClaN~\D~:ON.\O:CClON~\D
";:i ... ~- ""'" _--~- 'f"'"_l'\i N :l'" N ]",' m JY1: mm t'I'l .o;t: '¢ -e::t- oo:t
ABS R I I
Acetal U II
I> ", I
Acrylics
, I> '.
·
Rr- < .'
".""
..
Ii
".''.'
R I! " ./ I; F>
FEP
1"'. » <
R .:
....
I,,; " Ii, Ii'
=~i
Furan (Furfural Alcohol) .,.,. ··i'.·.' ·
!"J~
I' 'i', , It.!
I>
. "".',
1< ;
I..... ," .,
i;
Halogenated .
Hydrogenated Bisphenol A
R·
I; ',.
"".
;
i
•••• • "'. I
-Bisphenol A
Isophthalic
R/'"
R it} I'"
..
".'"
.... , ,
.••.•,•.
•
."
••••••
I
I;
'.
I
Terephthalate (PET) R .: •••
I; .....
."
Ie ....
" I;
=~.
Polyetherimide (ULTEM)
,
'.'." .••..,.•.
I, . •••
Polyetheretherketone (PEEK)' II" I.'., < C \ I;
-,
, ii I
,
k
KEL-F (CTFE) R' T
Polyethylene HMW R
i
R"','
r;
..
"".'
.'.. '
.; I', ,.....
. ..,
..'.,.
I
I
.'.
Polyethylene UHMW I,. .>,
Polystyrene
Polvsulfone
RIA
R
I'.
.'.,. " ••••••
•• .'
';i Hi
IT
•• ;;
.••••.<
•
.'•....
I"
I;
Polvvinvlidene Chloride R~' ....•'. I'
'..... ••-:
PVC Type 1 R
I.
I,· '. ... } I;'
,
I'.
;
PVC Type 2
PVDF (Kynar)
R
R
R I";'
Ii'."
Ii..
1<
I.
Ii
[.
T ....'.•,'.
.,
.: •• ,
•
••••••
•••••
.' .: ·
Ryton
TFE (Teflon) RI;s IY/. I' r ....
•••• It -.' •••••••• I
R I;" I." 1./ ."".
Vinyl Ester /
iF I Ii
o~o-~o~o~ooSob;o6'o6:o&ob:o
OF coeo. ON: .:\0' co '0 N 0::2" ~CO' ON.' '¢ W! 00'0' N':a: iD
':j. 0:-,,"::", ~r.: 0:- N NN; N .'N t'W'lm, (Yl M (Yl',o:::t '¢. . "d'
~~:c:o:~o~Nm'¢'~~~·~6'o:-N·t'W'l.·iD~~C:O
O( -~(Yl~iD~'CO~O~NM~~~~~~O'~N'(Yl
: ":__': : ~ """': ~_ 0:-_ ....... ~N: N N N
ii,"'_" ~
;~
Acrylate-Butadiene (ABR) !'& {'"
sro
',' ",
.,"
b
, W
'c;,,: ,
Butyl GR-1 (IIR) R I < . i ;
I:" '.' .;
Carboxylic-Acrylonitrile- X'
I'
If; liX
f"
': W
,'C" <'.
,
Butadiene (XNBR) ;, ;
Ii .. ,c:
.
Chemraz (FPM) R
[f;' if ; I
ii" "
:~ :.l'~
1·< I, ('
Chloro-Isobutene-Isoprene
(CIIR) ~'.~,
t; i
).. I"~
I', l·'
liJ k',
Hypalon (Chloro-Sulfonyl-
R!~'f' '" I '"N'
I';; ,"
Polyethylene (CSM)) f'" ,i
"
I; bL \i;
Ethylene-Acrylic (EA)
Rr~~ 1;,1 ,<
~r
h
~! ~'1
Ethylene-Propylene (EPM) ".,,.1 tJ':
Ethylene-Propylene-Diene R
". i,;' Iii, ",:,
I.' ;~
Il'~
(EPDM) ,':; 1",
~;
~lil
Ethylene-Propylene
Terpolyrner (EPT)
1.·:1 ;", he; IU. .;-. ';j
q.
.~;
FKM (Viton A R
~il; ?; It, :: 'i. .~~
:i~
Hard Rubber R
Soft Rubber
Isoprene (lR)
Kalrez (FPM)
U U M/1?1
R ''''
RI~;I
I;
if,'
,e ',J,:: II n r~,
,f
,
!, E'
JL
j~
Koroseal
~iJ I": ~;, :if! i"
~
Polyester (PE R
I, I"1':"
:~
I"
Polyether-Urethane (EU)
if. f'~(
~;,} ;8
Polyisoprene (lR)
Polysulfides (T) "
I~~
Polyurethane AU)
U f'\'
Iv
U ii,';", I:;
~:l~
SBR Styrene Buna-S)
ri~J
U
Silicone Rubbers U
;:,; I::
;~; !(~ f\)
~i
Fabrics I:';; tit:
~; ;~ \,
Cotton U iF ":
;:
I~~
Felt (Wool) U ",;;. 'ii"
Rayon Viscose U :';
OF g~o1
~~i~
s
.~: :~ N:~! o---6~; 0:;6'~:
Noq-, lD ::01),'
N:()I;
o'~-o'~j~'
""':\0' co Q
M ~rr.'f M :,':1
0
~ t,
O( U"l~lb;, ~(
~ ,~~; .~,~ ~.
~~'
:J ~.
"fiji'
O',",!,,!N3Y\'
~,~m,~,~
~"': ~i~! ~;:'N: ~, ~
or- ..-: .... :";"
s
'See also Nylon 11 under PLASTICS
ri.lrninum Bronze
- {ass
. nze
rbon Steel
\urnbium (Niobium)
opper
astelloy B/B-2
#stelloy C/C-276
astelloy D
l'iastelloy G/G-3
;igh Silicon Iron
Inconel 600/625
Incolloy 825
Lead
Monel 400
Naval Bronze
'Nickel 200/201
iNi-Resist
'Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
- Alloy C-22
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
-;,'\
Borosilicate Glass
I; :";, I', :
Carbon ' "
Carbon-Graphite Resin
Impregnated-Phenolic
I,' f : i'
I>,
~"'.
Ceramics I. ' ,"; f.
,
I'. E
,
',.
[,
"
Coatings
· ,
Acrylic
I,
,
.
Asphalt . '~
~
Chlorinated Rubber ;;
Coal Tar
.
,
•..,'.
Coal Tar Epoxy
'.
••••
Epoxy General Purpose I
:.v ....
Epoxy Chemical Resistant I.
: .
Mortars
i
Silicate
Sodium Silicate
~t~j
R
';'
';
Potassium Silicate
Silica I: , <~
Sulfur R<~ r:
:": 1ft! : :. .:;;
~kil
Furan Resin
k?';: .•...
~!~~
Polyester
~~ii l!W: .\
Epoxy :",";'-
:~'iT: ~:{
ABS
Acetal
Acrylics
R
Rr I
U·
ul' I
I
. I
I
I
II
Asbestos Reinforced Epoxy U ' I. . I I '
I
Asbestos Reinforced Phenolic R I I. I
Chlorinated Polyether (Penton R" , I
C~C R : • I I II II
:
Ri'I+++-+++-+~ I
,"
Fabrics
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Phenolic
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride
Silicones
-------------1
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
,
"<,,.'
/",
.! ':,..>:
'I"'" ",..,.' ...
>" ... ;, NNK
<.-,.-, N'Ni
'-.,'
Acrylate-Butadiene (ABR)
Butvl GR-1 (lIR)
i/:
R I ',
Ii ,'e [\ •• c;
,',".'
I,,;!
;
I'
i,' .:
Carboxylic-Acrylonitrile-
ri i Ji : F
Ii
/( i;
Butadiene (XNBR) lIi'
Ii
.. rii ; ['i
ii' ;; i
, I',
'"
,
Chemraz (FPM) R
Uri, : ii ." ,"
Chloro-Isobutene-Isoprene I.! ,i f
I Ii"'.'" (!;
!.•
'," I' ,i
i
(CIIR) i
;!'; fii ; ;, I
Hypalon (Chloro-Sulfonyl-
Polyethylene (CSM))
R
Ii
"
,i i I'
Ii,,",
I"
;'
,
';!; 'i;
•
i~
Ii I·. I ; r,
Ethylene-Acrylic (EA)
;;~ i; 1%
li~ r,~'f.
I',t! ,!i
Ethylene-Propylene (EPM) R
lei! ;/ii,
Ethylene-Propylene-Diene
(EPDM)
R
,iJ
;( [-;
j; I'...>
r'i
,,i ';~
i
I,
Ethylene-Propylene R ," ii, " ii; I'L
Terpolvrner (EPT) '" '~i \i [,i
FKM Niton A) R
Ii;
,tt
Hard Rubber U !I; it;! I~ 'il; ;"
tt~
Vi
Soft Rubber
Isoprene (lR)
U
U
i'
(,; rt;! i".' !:i; I,'
.
~ II
Kalrez (FPM) R
~i /;,i ~~
Koroseal R i
Natural Rubber (GRS) U I'!!
iii l
"
I~~
Neoprene GR-M (CR) R Ii:!
Nitrile Buna-N (NBR) R
i~;i
,
f 'i'
!~
Nordel (EPDM) R
:!i
!~f
~l k
Polybutadiene (BR) RI.,,"
~( ';
I
Polyester (PE) U i'
iii " i
'i
I~i~
Polyether-Urethane (EU i',
II
,.Is;
~
Polvisoprene (lR) @"
I~
",'
~
Felt (Wool) U
k'i ",
'!'
Rayon Viscose U ,iE,
OF Ig ~~f~,~';~
~"'t, :~1
o~Jo
N;.~.
N~;N
,;~
0
~.! ... .~~
0 0,;C:5" 0
N'~ilD
"It!~; "It
Ln Q)~j oj~1~: iBj1 E! ~~ ~! !E!l~' ~'~
...S! ;:,:;:'
'" 1.0:;.;;.;; co
O( ~ M·~~ID_J'"";: '-;("\,1' m
}.'):$ ~:;?j Ni~'N
16nze
'tbon Steel
,astelloy B/B-2
~stelloy C/C-276
.Jstelloy D
ftastelloy G/G-3
!i:lpolloy 825
Lead
.(Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Alloy C-22
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Phenolic
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Brass U .:. .
-B-ro-n-z-e----------1 U , I I I
I I .
; .: ," I'
Hastelloy D E :-;: .!. I' .:
Hastelloy G / G - 3 ; ." '" II' I' I
High Silicon Iron Er,' ., I· I I'.' / .
'.:
-ln~co-n-e-16-0-W-6-25---~U!; } .~ I. . !' 1 '.'I i I' .
I~
I
_N_ic_k_e_I__
2o_0_/2_0_1 --1UI: I: ." I, . , .. I '. ;' I. '
~~~~n~::; Steels ,. I' '. I' .' I 1 " '., .' " .'
Type 304/347 9 G~, .; I ',' 'I" "
I'·' I,·
I ".'
,
I'
I ~z:lr:c~o~ni~IUu:m ~
G
E~ ~U
i
,I"
I' ~' . I '1< I
Nonmetallic Materials
Borosilicate Glass
Carbon
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I ..' I
Acetal UI<
••••• I
••••••••
<
I I ..:
Acrvlics U ••• I·.· ·.
, .... ." .. I I
Asbestos Reinforced Epoxv U ..
I' .. <
Asbestos Reinforced Phenolic R .... - U I' .
...
..
,
-. ......
,
~I' ,,'
Chlorinated Polvether (Penton I·
". , ,
CPVC k ,
··.,c. •
E-CTFE (Halar) R
)
,. ' ......
Epoxy U ~). I· ji I
......
. '.....
I',. I ••
ETFE (Tefzel)
FEP
R
R <.' r. I....
........
'< •... ... "
,.
I,
.. I', Ii
••
Nvlon 6 U' .. ..
}, I
" "
I
Nylon 11 ~ I'. .. 1< I' •• <
I" ",
Nylon 66 ,< I' ,
.....
I'
I,' I I'
R~ I' I·. I'I .. "
Phenolic ;.
••••
,< :.
PFA (Teflon) R'I'
R ..••
..
'"
I> I, • I,·
•
••
I,
"
KEL-F (CTFE)
Polyesters
"j "
liE
I,
... ... "
•
I.
I,., x.
•
,
•••
,"'.
I···. ....
I •
Isophthalic
Terephthalate (PET)
Polvetherimide (ULTEM)
U I•
UI.·
U
,II
,/
•••• I
I,
• I
11<
;;
I
;j
I'"
I"
••
,
,<
I. ,, r >
.
I ••
I
.c
Polyethylene.HMW
Polyethylene UHMW
Polymethylpentene
U ..
<.
~~
'I
..•....
,.
I'
I
I,"
II'I' I'
I
•• •
,
••
j.,
, "
,
I
I·...
;.
.<'.
.'
,
.':
, IL'
I
Polypropylene (PP) R
I I I" IF
Polystyrene U
I',
II". I;'
••
,.:
'.'
.
" .•....,.
I•
III,,:' " .. ,'•.
I·
•
Polysulfone ....
UI I' I" . '
Polyvinylidene Chloride
PVC Type 1
U
R'"
I;. I" ••
I •••••
.1····
...
I
1 1< .. ,
., .•..
PVC Type 2
U
,•• I"
I. I'. '.
••••.j
I· './
r·.'. ; "
Ii
,j<
•••••• (.
.'•"
I' -.
PVDF (Kynar) >
... I,
i'. , I
R I" I·" I
Ryton R p ..
<> 1" ,; I • I.··.·
TFE (Teflon) R I
Vinyl Ester U.j I" I'·; , <' •
ObO:aIObio'6-o:&o'6o:o:o'6obo~:o
OF \OClC)." o'.'~'. '¢.tD' 00.0: N~o::t,: IDOO. O·"f '¢ '-0' coo N.; ID
'':~~:~::~:~'NN'N:NNmM-mmmv ~ .... ~
O( LI"I_'lb~ COCJ\' 0 .:~ N n, "It '1.0' "':00 0\0' ~:N" m-=:r ID .-"';"., 00
~N:m~:ID~'co:m-O~:NM"It~ "'OO.~O.~.NM
- ''-~: ,..._~ -r- ...... ~ ~. ~N' NN N
I,
SULFURIC ACID 80%
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
of o_o~o~o~~o~o~o~o~:O~OBiO
Nonmetallic Materials (,0., ,0,(',1: 0::1'0\0. CO-Cl:: N_~_; !D-.OO ON; .c'l:O; N~, \0 c:o.-o·
~~~~~~~N~N~m~m~M~.~:.
;<; ~:,): :
.~ ,;~
Borosilicate Glass R
Carbon R
I~': , I "
,
"
,
'"
II
,;~
'"
I
,
.: II
Impregnated-Phenolic R
I ; ,
.
;
, ~
Ceramics U i : , ,
I
':;
Coatings ~; I'; ":
I
.
,"
I
I,. "
",
;; ;i.
•••••
l
l'
~I~G:
Acrylic U I ,', ,',
f: II .
Asphalt II·; , '. I;'
I
Chlorinated Rubber
, ' I;:',
I, 1\, I;
Coal Tar U I "
";:,
I'.
' ,
I
,
I
I I
Coal Tar Epoxy U .,
i
I :
','
,
Epoxy General Purpose
Epoxy Chemical Resistant
U
U
I:: "
. '
I I,: I /
Epoxy Polyamide U I
[<1 "
"
.'
Oil Base
(Alkyd, Epoxy, Urethane) / 1,\ ;;. d
I,
I
I
.'
"
I; I ,
"i ,
"
~l'
''<
Polyester , '
,
:)
I; I;' >' I,:
[,I~:' I~;<
Polyvinyl Chloride "
I!,~;
"
'~ I :,
I'
"
, "
Water Base .i;
:i' ':
~~
,
" "
Zinc Rich
,';~,
,:' , : I;
I
I:: ,:
:
<', ,;
';, '
", " .'.'
Mortars , 1\ ,
Silicate U I;;: I': I
"
Sodium Silicate R - ; ,
,I'"~
"
Polyester
Epoxy
U
U I"I .,:'
'";',
I;,'
OF s i~, o:o,§
:t:~~ N
f"
o;~oo:~ 1.0 ~oo' 0
' \ : N':N'
N-~~: m
* 0
co
rt'l :~ -'" '" .
0
!!1
-
,-
~,~
~,~, ~E:'~
l/l ~-'NlCO
O( .. '", N
0,...-" "'00,
'. - \ '" 0 ......
"I:t\O
~i ... ,;oio::"'-, or- ~i ... ~~_ ... :~ >,!"'::N1tr'l
N:'l"'(N
'C;->:',
Nylon 66
Phenolic
PFA (Teflon)
Uf'·.
R I
Re-FH...,..H-I+H+H""*"Hi..... .;
.....J I; .'•.• •
KEL-F (CTFE) R .•.•. ., .••'.
Polyesters •...• ••••
Bisphenol A-fumarate U
HI I• •
a ogenatde. . _U. ; ...'
Hydrogenated Bisphenol A n .'. , .
. ; ; .<
-Bisphenol A U . ' " .....• •.•. •
Isophthalic UL.!;;
Terephthalate (PET) U+ ••; , '
Polyetherimide (ULTEM) U .~'.
Polyetheretherketone (PEEK) ut.;
"0
Polyethersulfone (PES) U i . ; !
Polyethylene HMW U. •..•. • .•. .
Polyethylene UHMW U ....
POlymethylpentene
Polypropylene (PP)
Polystyrene
R
R 'j'.
•••..• ..•••
••',t ••
Polysulfone U ; ' n '
Polyvinylidene Chloride U · "
PVC Type 1 Ri"'i+~oj- .;....
PVC Type 2
PVDF (Kynar)
U ;
R 'i
I.'
I.i
Ryton R ; :!ti
TFE (Teflon) R'
i i
Vinyl Ester U f."
\
Schweir.£erfCOTTOJion Resistance Tabks: Fifth Edition, Rroiud and Expanded
t- Copyright © 2004 by Marcel Dekker, Inc. All rights reserved. For more information, go to wwwdekker.com. 3163
I
u
u
u
U
Fabrics
Cotton U
Felt Wool) U
Ra on Viscose U
of
O(
0
<0
Ln
~
.'"
0
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic U,
Polyester U
Polyvinyl Chloride U
Silicones U
Urethanes U
Vinyls U
Water Base
Zinc Rich U
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
I
"
I
\
,
Metals
I!, I
I
I
I
, 1
"
,
, '
I
I, I I
Carbon Steel
Columbium (Niobium) ,
, 1 I I :'
Copper " " I
Hastelloy B/B-2
\,
,
, : ill
Hastelloy C/C-276 , I" 1
,
Hastelloy D
,
! I' I, I
I' ,
, I I
Hastelloy G/G-3 " I I I
High Silicon Iron
Inconel 600/625
[' , , :
,
I
1
II
I
I>
I
.,' I ,
Incolloy " .' : I I
,,' I'" U , , "
I I 1
,:
I', ,', ,
I;
~
> ,
':'
, r-. I I
I
II
Naval Bronze
1 ..
, f\
" 1
, • I' I I,
Nickel 200/201
, 1 I, I, I
Type 321 I' ,
" " :' II, ' I I
Stainless Steels I,
, 1 :
, 1
"
II "
I ',' [ : I I
,
I 'II
Type 316/316 L
II
','
E-Bright 26-1
, II,' I I •
,.
Silicon Bronze I I I I
Silicon Copper : I, 1
Coatings
Acrylic U
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic U
Polyester U
Polyvinyl Chloride U
Silicones U
Urethanes U
Vinyls U
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur U
Furan Resin U
Polyester U
Epoxy U
of
O(
0
\D
Lll
~
.
0
\D
I
Acetal UI. 1 , I .•..
[.
Acrylics U;c..
Asbestos Reinforced Epoxy uli Ii •
1
•••••••
.
I. I
[, I
CPVC
E-CTFE (Halar)
R ";
Ri'f I. f
Ii
);, I I.
I
I..' •
U ,•. I'. 1<
Epoxy
I:. . •••••
......
.. I..
I, i
••••••
ETFE (Tefzel) R ••• I ••• I
,. .. ' 1/ "
FEP I'
ii .,. .;
R. ....
I'
" I, :'
i. ......
Furan (Furfural Alcohol) u ... .
Noryl I'
-- R
Nylon 6 U z-, I"
I: • ....;: I. I ,:
..•.• -:
I;
•
~ .~. I' I:
••
Nylon 11 .'. :.':'
.. ,
Nylon 66 I;I·. . '
ii .,.•. :.'
•••••••
s I 1<
Phenolic Uj.'
...
·'·i·. I. .. • g I·
PFA (Teflon)
KEL-F (CTFE)
R ...
R
. I'
....
X. ,, I'· , i
•••
..
Polyesters ).\ I.
'
!
\ II
'\ •
•• .......
Bisphenol A-fumarate U
Haloqenated U .;.. I
••••••••
I'
.•..:
•••••• ••
'"
I··
I ....
.,
....•••
•••••
. ...
..
. I'
Hydrogenated Bisphenol A •i·..· •
•
•••••••• ••••••
I
..
t i...••··
-Bisghenol A Ui" Ii ••••••••
...... .:
Isophthalic
~lR ," •• ••
····.i. ..... ..•.
Terephthalate (PET)
Polyetherimide (ULTEM ~;!. : .... •....
......
.' .......
..... I•
I.
;1, I ..'. ...
Polyetheretherketone (PEE.ISL ." " ••••••
.....
• . .....
.... ••••••••
,>
I'
. , ,
.
~~
Polyethersulfone (PES)
i..
•
Polyeth.ylene HMW
. I'. ••••••
"'.
.......
••••
I
.;
..1 "
Polyethylene UHMW
Polymethylpentene
........
. .
•••••• . .....
••••• . ....•
......
Polypropylene (PP) R:.:.
u·.· i
•• ;.•... ; ••••• ••••• ;
".
....
..... .
Polystyrene
'" ) .. 'E .•..
.... ··i.,.:
;
Polysulfone
Polyvinylidene Chloride
PVC Type 1
U
U
U
','
•
....•.
: /
••••• •....
....
..'.
..
;
...
"; ..; ••••
' .
•• '.. ••••••••
•••••• .i;
.....
PVC Type 2 U •••••• • ... Ii
.:
PVDF (Kynar)
Ryton
R
E
•••r- "• •
.:
•••••
•••
...•..
......
l
"
.e, ••••
R ."
... , :.;
••••••
TFE (Teflon)
Vinyl Ester U ..; ';'. ".
....r .:
~' "
....
obo6;o~Od;o~;o6;o~:o~o~ooo
OF I..OOO'ON'~~'~O,N~'~~ON'~~O:N~,~
::< ~ .e-: ~~, ~N.N N N("IrI M~, M :m' M :o:::t ..,. ,,,," "'=t
Lt'lu:f eeee 0 _~: NM ~ iD ","00 0"10 ~'N' M"=t ~r-..- 00
°C ~Nm.~'~ ""oom'O~:NM''''=t~",",~'O''IO~N'M
~ . - i ~.- ~ .- ~ . _.• ~N N N N
Fabrics
Cotton
Felt (Wool
Rayon Viscose
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic U
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur -
Furan Resin
Polyester
Epoxy
=-=-=:.:..::::-'-c-~------1u
=='---'-'.~C1-------'---iU
U
Coatings
Acrylic U
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
.'"
o
~~:_'7~~~~~~_ju
~'----"-'-~:_;_~~--~_ju
~~_';_;:~~~~~~_ju
o
'"...
'Metals
OF
cc'Columbium (Niobium)
popper
l-tastelloy B/B-2
t1astelloy C/C-276
Hastelloy D
Hastelloy G/G-3
hligh Silicon Iron
intonel 600/625
lneolloy 800/825
ead
onel400
aval Bronze
.. iekel 200/201
Ni-Resist
'Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Uieon Bronze
ilieon Copper
,Stellite
tantalum
.,itanium
.ireonium
OF
.O( In
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
O( ~:'~:
~
'~>-"> .
Q)~: 0
', ..,r ft'lo:::t. U)
_}
N~m ~.
000'1' 0 ";:, "OO,~ ~ ::0: ~:~ m:~:
'._ N 'm· -.:tlD "000'
: '" ~ ,''P''"', ~ -~: ~_ ~ ' ..... ,
~O U)~'
~N ...,
Q)
~N N N' N
"
I' ".'
I
Acetal U I
••• I
' -: ".',
Acrylics U .. ',,'
I
"".
, I
Asbestos Reinforced Epoxy .',' .:
CPVC
.: "
," i; "',
..
i
••••
,
RN' .: I' .. ,
E-CTFE (Halar) R •• .O'.
-: ,i
. ~.
Epoxy ··"·ii• .',..." ,
U;
•••
ETFE (Tefzel)
FEP 14
R. ,!
R"
••••••
"
.'I' ....
I· Iii .,....
••
~.
uf' .· I'f'.:
Furan (Furfural Alcohol) __ I' iH
Noryl .._ R·'·.·.·
..... '
..,
.i I I,,. ,'"
.. ....
t.
..... ,
Nylon 11
Nylon 66
U
U
iy
Ii I,· ., >
. ... I
....
••••
..•. '
••••• .... I. I·
,
KEL-F (CTFE) R
.: .... • ,. ".',
PFA (Teflon) 14 R ..:
,., ; ..•
Pol}@mide-lmide
Polyesters
R ,,.. .•..., • ••••••
.
!'il II
•• "",.
..... ,
I'.'.. I" •....,
I
I'
'
.
".'
'.': i
•
.'Ii.'
,
Hydrogenated Bisphenol A
-Bisphenol A I'• I·" ,.
,
I•
......
-'.
,. . r•••.....
I.
..
..'
Isophthalic ur.i I, I>
Terephthalate (PET) I' •
•
I' '.' I'I' •
....
.' ..••',',
Polyetherimide (ULTEM) Ur, ••'.. I, ..
I"".
r,'
I" ... ,.
~I··
,.....•
Polyetheretherketone (PEEK)
I,, ' I.· .•...'
I I
...• -
Polyethersulfone (PES)
Polyethylene HMW
Polyethylene UHMW ur.'
U,..
...-:" .....
••••
I.'
....•.
.',I' II.>.....
..... , ".'.,
....
..
,.'
' I.··•
!I,
I>
'11
••••
••••••
!
'1
I ,
ufV.
,
Polymethylpentene .... .;':
•• iF ..
,
....'.
~I'B
Polypropylene (PP)
Polystyrene
'.'" I'
, I"I. •• r••• "', ....
uri ••••
(. I'
•••••• "
> I,:
I, I.'I'
Polysulfone
I' ..
••••i •••••••
Polyvinylidene Chloride U
, ••
PVC Type 1
pvc Type 2
U
ul'V
• •
i,
••
Ii, •••
,'".'
>
Ii.•• I,.>:
'.
....•
PVDF (Kynar) U ' '.: ••••••• I" '.,'. •
Ryton
TFE (Teflon) 14
RQ;
R'"
''..' • '.>
I I··.
.1 IS
,.'
.'. I. •.'•.•.
. .",
U ' i• ! I;
'. 1M "
Vinyl Ester ••••• I'
o&obobo~;0~:ob'ocijo.6oB·o~'0
OF l.O~ON,o::t:~:C:OO'N~U):~'O~~:lDC:O:ON$W
:<-": ~ .,....' .... ,.." .... 'N: N J'( N N ""M IY'l r"'" ..., ~ o::t '~
O( ~~CO~O~N~o::t~"~~O:~~'''''~I.O~CO
-~m<::tIO~'comO~NM~~~~~O""N""
, .. . . " '~..- e- ,.., or-_ or-._ ~ N N N N
o o'iJ:£i1o
Elastomers' and Linings of '" :="~ ::t
~i> ..;.,
Acrylate-Butadiene (ABR) "'-~
:;... .'
:
Polyethylene (CSM)) 1
2 :. I,'
Ethylene-Acrylic (EA) I.
Ethylene-Propylene (EPM) .. i .::
Ethylene-Propylene-Diene
:1 i: 1
1:
(EPDM) .:; .; .,
,; I'
;
! •.
Ethylene-Propylene ;(
I'h l~..:'
! ' ~
'.'
i
••••••
Kalrez (FPM)
Koroseal
Natural Rubber (GRS) ;.:
I
I':: ,:
:
i
;:
,;••••
.:
I. ~
Neoprene GR-M (CR) .: .,
Nitrile Buna-N (NBR)
Nordel (EPDM)
.: I" ' .• : I'
Polybutadiene (BR) : , II'
~ IiIx
Polyester (PE) ;~:; I:
Polyether-Urethane (EU
Polyisoprene (lR)
,
I'
Polysulfides (T) ,'.'
,.
': I
i :; :::
Polyurethane (AU)
SBR Styrene (Buna-S) .:
:·:s ::\
Silicone Rubbers
· •, ,
I~
Fabrics ." (:
Cotton
.. '.'
';
Felt (Wool)
Rayon Viscose ;
,: I~
o·'i:lo
~ ~~ ,;~
*~
N;i'"
"d' >.; oo::t
r.. ?aJ' "d'
N ~_M:-
0\·,61 ~ ~N-" rt'I:;~;
J..c): r-, '«:1\ O'l ~-- ~:N:
lD _,,: 00
m
~~~~ ~ ;t"') ~/ .....~ ~ 'i"'l: N ;()t M
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
·Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
;;
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
••••
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
·Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant.
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals ,
"
,',;; e-:
Admiralty Brass G ',", ,',;., ""
~L
";,:,'
Aluminum Bronze
Brass
Bronze
Carbon Steel
~r: :',
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium I,
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose .'
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Furan Resin
Polyester
Epoxy
;:::-'-;~~~_-:;:-;-;--;-;-_--1 R
R
;:o;':~~=-=:"-=--~~-=-=-----1R
R
~,,=~,-'-='--;-------1R
10% R
;-;;-=:-'::==c=L.- ..,..-::-:-:-!R
10% R ,,~0 '>\;5 '-, ~,r
Nonmetallic Materials
Borosilicate Glass
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~=~C-C--------1U
.c"--77~=C-~-';-~--'-"-'=-=----1U
."---:--:'=?""-'-=:-~;;o:;--,------c--:-1U
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L.
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls·
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
R 1oi!ij.-+iI!H!~~
~~~=-:::':~:'--~~~-1U
EU)
hel 400
val Bronze
ieke1200/201
l~inless Steels
'Type 304/347
Type 316/316 L ALLG
'fType 400 series 10-50% G...",...,."",-
'Hype 904-L
)17-4 PH
20 Cb 3
'E-Bright 26-1
- on Bronze
- jl]pon Copper
'~Iv. Stl.
i!htalum
i1f~nium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Phenol ic
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
I;
Coal.Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
I, ri
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
.. ~
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls I' I:i , II):
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Titanium
Zirconium
Nonmetallic Materials of o ''b't 0 :61 0 }dt 0 "'0: 0 n6; 0 ";0' 0 :-0' 00] ~} ~A 0'8 0
.'~! ...
\D ;,:s'i1 0 ;~; ...
or:t .r~: co :~"f N .:.~. ~co' o:~_ ~ :-~' ~'!;;!~ :g
pi ~~'t!"", ... --~. N 't:-J: '"
N'~: m'M rt'Im:
'''<''J •...... I,
Borosilicate Glass R
j'
\ Gt
>.
Carbon
Carbon-Graphite Resin
R
S'.t
~,;
,. s ire;
.:
~;'il ~.j. } f
li ~
<
Impregnated r
I'~,
R
x, i
'i/ ~.~. I~·A
\t,· '!"
Ceramics R ,",.,
....... I·':
ii.
it; I' it i'.
Coatings >,t,'
! [c ;1
Acrylic
J; Ii.
[p;•:.~
Asphalt I;; • "i:
i
Chlorinated Rubber ~ ~j ~;&
"
~:' :' ".. 1';'
Coal Tar
Coal Tar Epoxy ",li~ •i~
!f j
, fi I'{,
I" •••••••
••!'
I;i
Oil Base
Ii!: irA
".; ,~
(Alkyd, Epoxy, Urethane)
it~
j'l
"
Phenolic
Polyester
Jill.
i
R,
I!;~ .r. W, ij I'.,
.~
,im
I!~;' S'
Polyvinyl Chloride
Silicones
RI';!:I Ii!iliil '~J
f
',~ ~~[$
I"
!;~
Urethanes
Vinyls R >
'~
~:
i) "i;
;;
~.
I,.;
Water Base
Zinc Rich fll j. ii
,•
hi
Nij
i~' ~j.
I'" ',',
Il~
Mortars
Silicate
~) .~ 1\
~~;
,'' '} I,;
i
Sodium Silicate
Potassium Silicate ['pi
ji'
Silica
Sulfur
;:
Furan Resin
f~ ~ij~ i~
?~
I',
~~ .~
Polyester
f";
Epoxy 1;~1 .m
OF Ig, .~ i~! e!~ ~)1 ~~.~~ 06.~
"=t~\O
M:':~:
~;o:~
-e ,~, ...
O( Lt'l,'~00
...... 'N,'t'l'l
;::):~';
:ii'~
to;:}
I;! rk., .; ~,~ ~ .~' ~g ;::
'r",~'
,~i m.•~
'r"~;r 'r"',,"""
ID ,f": 00
'r"iNt'l'l
N,'NN
Nylon 66
Phenolic
PFA (Teflon)
Polyamide-Imide
Polyesters
Bisphenol A-fumarate
Haloaenated
Hydrogenated Bisphenol A ,'s[
-Bisphenol A i*:~
IsoPhthalici~
Terephthalate (PET)
Polyetherimide (ULTEM)
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
Polyethylene HMW
Polyethylene UHMW
Polvrnethvloentene
Polypropylene (PP)
PVC Type 1
PVC Type 2
PVDF (Kynar)
Ryton
TFE (Teflon)
Vinyl Ester
,: !i
Butyl GR-1 (IIR) R I'
,'i
Carboxylic-Acrylonitrile-
Butadiene (XNBR)
I:''r: ii I t
I: r I>
,< I~
, ': I"
'~.:: I'
'~ .'~.:'
Chemraz (FPM) '.,. , L,",
Chloro-Isobutene-Isoprene :',
", .
f~ I;,
Ethylene-Acrylic (EA) In",e, Ii ;; "i 1<
ii ';;J~ ',' U~ !tJ r~J' :;iIf,
Ethylene-Propylene (EPM) 1"
Ethylene-Propylene-Diene
(EPDM) U iij;
I': ;1' II'
;:,
,ji ,Ylit' ,'" I':!"
Ie[, 1::I'~~
Ethylene-Propylene
~:i iii
,f f;:,
Teroolvmer (EPT) ,:,
R"
I~;
FKM (Viton A) >
Hard Rubber R !; ,', ;,
Soft Rubber
I:' li)i: ! »: :ii:
I" I " i',S,: I'i':
=~ ~
Isoprene (I R) "",'
Kalrez (FPM)
!.,
~B i>
i:,
i:1
iii
Koroseal i;i
I;,;, 10"
Natural Rubber (GRS) R •
I.,' ii ,;~
I~,:'
s;c
Neoprene GR-M (CR) ~;i, I:;,
Nitrile Buna-N (NBR)
=1- I; 'i.t, c
",i
Nordel (EPDM)
Polybutadiene (SR)
I~e ,i~
~
i, "
I';, I
~
Polyester (PE) 11
Polyether-Urethane (EU) ;: !:' , I;:
Polyisoprene (lR) ,; '1.; In ~,;
Its ,,,'/
~t\
Polxsulfides (T) i,i <,r
,, ~~
Polyurethane (AU)
SBR Styrene (Buna-S)
ii'
W x'
~j
Silicone Rubbers
i'W ~JI
Fabrics
tii
Cotton
"',t< .',' ~;
Felt (Wool)
Rayon Viscose ';; H,!: '~; l'n
"i "
~:
OF
'" .~. ~;
0
O( ~.q .~.
0''0: 0;0: 0
~ ;~:~:
j;d'l; 0,;0-.,' ~
N ~oo;;
0'0
;:-~: ~': ~';~;~-~ '"
0'1 ":~,:' ~ t ''''g
:m q-;\O
m:,~;
O'l,' , ~' i ~
.
0
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride U
Silicones
Urethanes
Vinyls U
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
=~~=-=~~~:.L-_-IR
~'-=-:=:':==:::':-':c:"-'-'~c--_-IR
Metals
TO
II
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
-. Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 410
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum TO 50% E
Titanium TO 50% E
Zirconium E ,,,, 'f"
of \D ~:_ 0:81
o~{ 0 ~o: 0 O':~:i 0<0100': ob:~ 0:0'. 0.0'- 0
Nonmetallic Materials O~; 'lilt ("0:: co
if#s~ e- ~1 .... ,;~-:_i \"""
N
N \D'~ 0 ;.,~_ "'d"'\.(), co :_~- N-;: \D
N~~;I'Y'l~_m-im-M;:"JtOllt,,'o::t
;Ii"- ,
Borosilicate Glass R ,
l, .' , i:
Carbon R :I,
:; ; ,
';, [.:: ,~
I, ,
Carbon-Graphite Resin
Impregnated-Furan R
;; f'f 1:
"
, . , -;
i
,
". . I, I'
Ceramics R. ,
"
,
; " I:' I; i',
I,
; I,: ,
,
.
I· ,.
Coatings :
II
':,:.
",
Asphalt ,:'
I~'I ., : ':' II
t-
Chlorinated Rubber
I: ,
:
i ;, .
' ,
Coal Tar . .
I ;"
Epoxy General Purpose R ',' "
"
:' ,. ,:',
:~I~I,:1
Epoxy Chemical Resistant ;.
I'
:z
" "
;..
,
Epoxy Polyamide .. -: .
: I -:
;
Oil Base
j.
"
: i I ,:,
.
,
':
(Alkyd, Epoxy, Urethane) I;" 1 '
:;:; I,: i; I,
:;
:: ,
',':;
Phenolic 10% R
[<
I'
I, I ',',
....
Polyester R - .i i
I'
::
?
It. I:, '. ;.
"
Polyvinyl Chloride
Silicones
R
R I
'i
l
\ Ie: ';' ,
Urethanes I
.'
. I
,
.'.
!: ,
; "
,
Vinyls R
:' : I
I I ;: ,,'•. :.'" r
Water Base ;;.
:
Zinc Rich
:
': I I ,
;: ,
::
,J~I I:', I
';
I,,' I:: \ ' .
'(
'.
"
Mortars
Silicate
~:: I"
I } r:: :
R :, I;,' I" : "0 ' '.
Sodium Silicate R , "
11~ ~i
;::
Potassium Silicate .' I;' "
'.
Silica :,', I. ; ; f::: .'
I, : I: " ."
:
Sulfur R ';, .'
Furan Resin R I I
I:
~:
l,
"1
' ,
~lii'l
Polyester "
Epoxy R
h'l
'" ~'
••••
I': ,
:,:
""
Elastomers' and Linings of ~ .~. ~8: ~ ~. ~.~ ~ ~. ~re ~ ~ *.;g ~.~ ~.~ ~
Acrylate-Butadiene (ABR
Butyl GR-1 (IIR)
Carboxylic-Acrylonitrile-
Butadiene (XNBR)
Chemraz (FPM)
Chloro-Isobutene-
Isoprene (CIIR)
Hypalon (Chloro-Sulfonyl-
Polyethylene (CSM))
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolymer (EPT)
FKM (Viton A)
Hard Rubber
Soft Rubber
Isoprene (lR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene (IR)
Polysulfides (T)
Polyurethane (AU)
SBR Styrene (Buna-Sl
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
o
OF '"
O(
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride U
Silicones
Urethanes
Vinyls U
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics <
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Furan Resin
Polyester
Epoxy
:.=="--'--'~==-"_='c?_-___IU
~c::=~=--=~~~"------IU
:-=:.:.=~=====':-':c"-'-=~----IU
-:::-:7.:'-'-~::=_'_::=:--'cc=='--=----IU
=~~'_'==-=-c_'_=_ --IU
Fabrics
Cotton
Felt Wool)
Rayon Viscose
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
L
::H l::
i,
.~~ ',:
I
I:
I'
,t
,
•
f;" ,',
Bronze :.;
,
Carbon Steel >:
i::
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625 '~,
Incolloy 800/825 :'
Lead ,
Monel 400 ,
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester R
Polyvinyl Chloride U
Silicones U
Urethanes
Vinyls R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy III
II
Acrylics
Asbestos Reinforced Epoxy
Asbestos Reinforced Phenolic'
Chlorinated Polyether (PenJQ..n2i R,'-+-+-~'-+-+-~
CPVC _ IR'""I +-+...,
E-CTFE (Halar_) .JRH-+-I-++-H-+-+-+-~
EPOXy ~RH-++
ETFE (Tefzel) R ,-+-+-+-1-++-1-++++ !
FEP __,R,-+-+-+-+-+-+-+-,-+-+-+-i-++++
Furan (Furfural Alcohol)
f'!Qr:YI-------------
Nylon 6
Nylon 11
Nylon 66
Phenolic
=':--;::;-;;-----;-_. -_._----. --- - ---_._-
PFA (Teflonl_ R,-+-+-+-I-++-I-+++-+++-I-++
Polyamide:llllicJe__ '
Polyesters
Bisphenol A-fumarate
_ HaI09 enat e,~d'c-=c--c-----c-~
Hydrogenated Bisphenol A
-Bisphenol A ,
Isophthalic _,
__TEJ~§QhthaIEltei?!=IL_'
Polyetherimide (ULTEM) j
o::t o::ti
! 0C i trI 1.O co mo.- N M e-1.0 '" co c:n a .... N M o:::t 1.0 r-, ooi
: 1"- N M o:::t \D" 00 m ~ :: ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~i
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester U
Polyvinyl Chloride U
Silicones U
Urethanes
Vinyls U
Water Base
Zinc Rich R
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
=,-~';-'L-,:-'-'-'--'---:-::-':':'-::-:-:--_j U
:=-~---L;-'--;-'-"~-'-'-'---_j U
:=-;'----~~-'-'-'';:::_;=:_--_j U
:=-;'-"-:--'-LLC-'-~-'-'--'-'-_ __j R
~'--'--C~';-'-------;:~~---iU
~~~~~~-'-"-'-------iU
~:::--:O;'-L-'----=-------iU
U
~~~~,-;------jR
:;:-:=~=--::;--:;-- ----:-:_j R
~-=c-':::-"-~CL- ----,1~4--1 R ~*'{ ;!\;;
U~~! ~ '«;; ~
-::-:c:'-'-==:::'-'-:-":--'=-=-'=-="------j U
=~~'-""-~"--_ _ ___1u
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
•
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
. Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum G
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls U
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
°C
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Lead
'Monel 400 S
.Naval Bronze U
'Nickel 200/201 U
-------i
; Ni-Resist
'Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
"Stellite
Tantalum
Titanium
" Zirconium
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
TETRAPHOSPHORIC AGD
~~~~iOPN~ .• ¢·~;~~~,~:~m:~.~~~
°C ..-t',,; f'l'\ ':~: lD,....· co ,':Q'i,-, O:r: N -M: "'" \0 r-, .cc: 0\.0 """" N rt"I
• -, -, """":~: 'C""".~ .......-' ... _~-, 'I"'" ,N: NN- N
'.• ..
,
o:~:
,
o:.~. o:.~
;.: : .........
N'~lD:~ON'.W:CO:ON:~lD
I'
••
....
I
'l"'"
0'0', O~: 0 ' 0
NN Nt'll M'M t'I"l M m oi::::t • . . •
'C"""
:0,_
I' it
II
Acrylics
Asbestos Reinforced Epoxy
I'
I
I. i
r.:
i' I. .....
I ••••
", •••••
•
..
!,
!.
I ......
Asbestos Reinforced Phenolic I
•
..... ! ..
Chlorinated Polvether (Penton .'..
••••••
I. iF
CPVC I. I, ;
••••••••
I'
••• ..
.....
i·., ....
.
i.
I
'
I·····.
E-CTFE (Halar) Ii : ; ... .:
,i Epoxy I I
.. i/ I', ••
ETFE (Tefzel)
R
Wi I
"
J; <
, f •••• •••••••
FEP I{
II Furan (Furfural Alcohol) !.
"".. , ..~.• 'i~ 1\ ••••.. ,
I
Noryl 1< I. ,i .
.' .'. ,
;I~
••••••
Nylon 6 I •
Ii I'
c-:
<'
I. ,
Nylon 11 I ,f • ;,., I .'
Nylon 66 i I: I. '. I' ••••• .'
Phenolic I
lSi
••••••
'. •
I'
!
I ..'
•
•
Ii" li< I,') •••
..
-Bisohenol A i·
i'
.. " \'
I .i, .....•'
. : '. . ..
Isophthalic
Terephthalate (PET)_ , !
f'0lyetherimide (ULTEM)
". i
{.
i
,.:
<
I' .... <' .s i
,..
..•...
• iii
.... ..... ,; I.
·
·
I
I
.:
".
.'
Polyetheretherketone (PEEK) II j ; t
Polyethersulfone (PES)
.•... I"
.... -,
"
.
' .
...
•••••• '.'
I .
Polyethylene HMW "
Polystyrene
,i
•••••
j
'.' )
i . '••••.: ..
·
'. •
",
Polysulfone .,'
; ••• is ...
•
••••••••
ik •••• i •
". •••••
Vinyl Ester
.'
. :'.
0'6' 0'.0'; 0 ~': 0 ,0' 0,'16' 0 "0 0'0' o-'b~ 0'6' 0-,6 0
OF '-0 _:~' 0 .N'
.~~'-
"d:'F oof:): N ,o::r'. \0·00 0 '",,' -e co: 000' N ..q \0
~,NNNNNM.m'M~M~-~~~
~-~oo~'o~:N~.~~oo~6;'I""'"&M~\O~00
°C _NM.~\O~oomO~N~.W~~·~O_~~
~:_">" 'I""'" .~ -:0-;' - N N '. 'I""'" .... __ N N
Metals
Admiralty Brass
Aluminum
OF o~o~o~'odo~o~o:O:O:Ob;Oj:o~o-ooo
\D iCC):' ON: o::t -ID (0:0' N "t.' lD'a:r 0 N 'd';\O co 0' N - '. ID 'to O'N o:t.\.O
u
,
"
;;-;' .... r-\ .... '!"'"' .... ';'r"f N r",r N'N
"
,
I
I
t'l") m M '(~'f M '1;f',' o::t.' ~ oo::t ~_-; Lnu'f Ln-I./)
I
II
Aluminum Bronze ,
I ,
,
f
, ( I
I
,
Brass 1 I' I
Bronze 1 I, ,
Carbon Steel
Columbium (Niobium)
Copper
U
.''~ ,
:
i
I;
I '
,
•
,
I '
I
I
,
I ,
•
,
I
1
I
II,
I
II
II
,
1
I '
Hastelloy B/B-2
,
: -: ' ,
,.' I ,
,
, , ,
I' "
1
I I
Hastelloy C/C-276 10% G " ,
! ,
I I
<
,
" ' , : ,
.'
,
Hastelloy D I ,
,
Hastelloy G/G-3
'", ,
, " ,
I
High Silicon Iron " I
,
I
I "
.', I
I
I ,
,
,~
I
I
,", 1
, ,
I, :
Inconel 600/625
. I~
, ,
I! "
/"
,
,
,
'
I' , 1
1 ,
I1
Lead G
':' I ,
,
I! "
I
~
Monel 400 G
,:, • ",:
>
','
':
Naval Bronze ':
,
I ,
,
,
I ' , ,
" I I ' ,
.'
"
,
-- '"
,
, ,
1 "
, , I' ,
Stainless Steels I 1 '
"
" ,
Type 304/347 ,',
I," I" I
, , "
"
-,---- , ,
Type 316/316 L U , ,
,
,
':, I, I
, ~,
, " ','
Type 400 series
, , ,
,
'.
:'
1
,
"
:
,
, '
I:
" I .'.
,
, ,
, ,
20 Cb 3 , I ":
'"
, " , • , , ' '
'
E-Bright 26-1
Silicon Bronze
,"
.
" " ",
,:, " ,
"
:','" , "
,
" ,
'
:"~
,
, " ,
: : ':
Silicon Copper : ,,', "
,
, ,
'
,:" ,
,
, ,"
, '
Tantalum G
'•,'" ;
."':
":': "
,
. ,
: " ,
'
.' ,
"
:'
"
Titanium
'
,
, , , .' "
." ,
,
' ,
o~~_
OF \.0 -ee 00- o!'~_; o:b:'
0 '(".I, o::t).o: 00 to 0:.0: o::~_: ON o::t
N '.o::t ID'OO; o.~;·.\0: ~;~i 06-
':~';: e- "~: ,.... '~..-': ...... '.N: N'N; N .,~, fYlO"t M ,'m;
" o:~
o~-; Oct'\!; VW
N~:- \D'OCt
o::t:~; o::t ::q-, Ln'U'\: Ln • .Ll'l
0'6: 0:'0'
U'\~~~jo;~N,~o::t~]~~,~~i ...... ~m:~~§~,~,O;~N~
O( _~M~~~~m'O~IN'Mo::t~~W~Q~:NM~:~,N~m
'.1 :\-.'j ...... :~, . - .....' ...... r- . .- ;;--: ....... N
" 'I.. 'r.of N"N-N'N' N N
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
>,.; M-,~:
•.'.;..... l.O.~; 00,<:1\' O_~_
<.-, ..... ,0:"'"- N 1"1":'
...... v-..... y.-' ..... -',Y-
0\.0, ~--N
..... 'N N N- tT'I
N
.i;....
.....
:.;~:.: 00·'0:
..
••••••
0 6 0N.oq'
( I
: 0 ; e,o-oo-
e- ",-, NN- N N
.. .:
"
,
.. II.'
O-N'
M('t"I: l'l"IM
o::tw· co 0
".
m
N-o::t \0
-=::t' o::t o;;t o::t
II
•••••••• ·
•••••
Asbestos Reinforced Epoxy ...•.
.... •••
Asbestos Reinforced Phenolic .....
•
.'
, . ••
"
-.
Chlorinated Polyether (Penton U :
CPvc U
I
i. Ii
I' :.
....
,. .. :
: .:
I',
'
Epoxy UI ,
, .... ,
'.:, I
" ·
ETFE (Tefzel) R
r "' 1';:
-~ . , I:
FEP
Furan (Furfural Alcohol)
14 R
U
.;.
, , I,
I";t, ( ,•...
( .'
1/; n ••• ."
I'
·
Noryl I,
Nylon 6 - U I',•••••
....
I' .. I Ii
..
Nylon 11
Nylon 66
U >
U
r Ii'
I(
I;. ,••..•.. .
I;;: ".•.,: ,
. .
'.
\
....
I.
Phenolic R , .'
I; V ',.'"
I.
I
' ..
PFA (Teflon)
Polyamide-Imide
Polyesters
14 R
__
;:.
'
"
I' .... I;
.......
• :.'
I,
I';
I;;
....
..
i'"
I: ,.
I'
,
'.
-Bisphenol A , I>
:' I ;2 I
lsophthalic U "', ,'•..•. :. ••••
. I' , ., II·. ,
Terephthalate (PET) •• .....•
PolyetherimJde (ULTEM) • it I
I"
I ", '..'..•.
,
[.
•••••
I,: .'.
.:
Polyetherelherketone (PEEK)
Polyethersulfone (PES)
·'.i' I: :'. .' I
••••••
y .:
•. ". ,. I .. • '.
..
•
I \
..
•
..
Polypropylene (PP)
Polystyrene
R ',":',.
;" ~
- I. ,
....
..
i, :
I
I..
I..
I..i;. ....
.: Ii
U {: I: ...., i I::.
Polysulfone
Polyvinylidene Chloride U
.. a.· I;is·
I'{ I'
.
•••••••
I
..'..•.
• " ,:
;' I',
PVC Type 1 U ',', .
,' ...."', ,
'. ,.
.
U
~~-=-'-=-=,,-,-,':':'c-:'~~_---jU
~~~===:-':-'::"-'-='-'-'-' -1U
Metals "',""d'll"'"
:,,\r
m'~'_ "=t:, ; "=t ;i.q_ Lt'I'lll'II'I-~
';.,;
~' ~:; ,~
,~-
:\~
[t;! i'; , I,
,
I·:~;:' ,:;, i: : ,
~~'h; ,
,
Bronze
r· [: ;,' :.
5"
~i1~ '.'. ,
;
~i:1 i~t
,
Columbium (Niobium)
Copper
,
:,
";
:c, '. '
"
i!. 't :; ,
"
;'
Hastelloy C/C-276 i,
~ ;: , , ,
Hastelloy D I;, , , ,
',:: ; ,
k
Hastelloy G/G-3
".' .~.
"
, ..
High Silicon Iron '"
.-
Inconel 600/625 1< I::" ':l:
I',:
f ;; i'
';
,
Incolloy 800/825
I,:
,
~; •
,',
','
Lead i ;,' ,
".
,.
,
., ;;
';,
,;'
,
':
••••
':
i' :'.
Stainless Steels ,
- i:' .• ;
.~
~~
"
Type 304/347 , ; ,
e;
"
Type 316/316 L ,
I " ' ,
:
:.~
20 Cb 3 : c-,
,
,'"
:~
;",
E-Bright 26-1
:; ,'~ .'. :',
:~
','
Silicon Bronze >
" '.
,i'
~ ;~" ':,; .
,1'-'
Titanium "
;'i ",
Zirconium t~~j
i'i
. :,~ < ,
.
;
.... .
,
'
o'g'o,~'o o~Q,o~6':o:o:o:6~o;o_o::o
OF ~,~~ ~ ~ ~:M; ~ t~'~ ~ ~~.~ 'lI::t ,\D, co _,0' N ';1- \D ,00 0
m",t"1j m)~'-' 'lI::t.-,- : 'd' '''=:t~ ltLtn; U"I',U1
_N- 'd' ..W
~ ~.~
~;N:m:,*:\D,~:co~~~O'~;N;M
~:~
l./'l ~iQi co :; N :'(ri' o::t ~l,ji; r-..
O( ..... ;J;)li m ~,' 00,'''', o:~-: N r-, .ee: O'l :0: -r" -N, m '¢ \D ......' co en
,,> ,", ::' '_ ':1 ~ ~: -r" ~\t-~ ~,_N' N N' N N, N N, N~N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
;:
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
'Silicon Copper
'Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials of
Borosilicate Glass R
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
. Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool
Rayon Viscose
o
o
~
...o
~
co o
'" '"
llirninum
Ili'rninum Bronze
'0>'"
·ronze
arbon Steel
lumbium (Niobium)
pper
.stelloy B/B-2
i'lstelloy C/C-276
)stelloy 0
astelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 825
c'ead
onel400
.Naval Bronze
[Nickel 200/201
.;'Ni-Resist
'Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones U
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
, Aluminum Bronze
Brass
Bronze
Carbon Steel
'Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy 0
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
, Monel 400
-. Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 410
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
TOLUENE (TOLUOL)
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Furan
.'.
Ceramics
.. '.'
.. ;.
Coatings
Acrylic '. c.
Asphalt ':
Chlorinated Rubber -.. ....
": 'c
Coal Tar
Coal Tar Epoxy
.',c.'.,
Epoxy General Purpose
Epoxy Chemical Resistant·
Epoxy Polyamide
.
,:
',.
Oil Base
(Alkyd, Epoxy, Urethane) , ~
Phenolic
Polyester
."
Polyvinyl Chloride i,
Silicones , 'cc
. ..
Urethanes
Vinyls . "
Water Base
Zinc Rich
·i
~.
i
:
Mortars
Silicate
Sodium Silicate
Polyester
Epoxy
Naval Bronze
Nickel 200/201
Ni-Resist
--I-
Stainless Steels
Type 304/347
.. Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated-Furan
Ceramics
- - - - - - - - - - - - - j R 1"Jl'+-""""'fd
Coatings
Acrylic U
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~~~==C:-'-'-----'--'-'-'='-=='----1R
=:'-;~::=-=-::-- ---1U
:::--'-::::...:..---"--':L:-'-'=--- ---1 R
~:z.=;'='--'-'--'='c:-_---:=~-JR
~~=~~~-i'::.::::..L-JU
~~~~'-'f:-~ _ _--1 U
~:L:':-'==",,--,~L-_ _-IU
=-,--"-,~'-=-"--'=-"'--':'L_-IU
=='::'--'-'-'='==- -I U
=:.:='--- -JRf:i!iiI-~Hrm--I'H
'-""~-.:::::~ -1R
R ;c "., W. ',';
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Plastics
ASS
Acetal
II
Acrylics
Asbestos Reinforced Epoxy -
Asbestos Reinforced Phenolic
Chlorinated Polyether (Penton)! Rf-,+-H-++~f-+
CPVC ' Rf-++-!-++-
E-CTFE (Halar) ;Rf-++H+H~
Epoxy
QE~T,--e=-cf=cze:cll)c- --i' R f-++H++-
FEP i RH--f-H-+-Hf-++H++-l-++
Polyesters "
Sisphenol A-fumarate ~
Halogenated ;
Hydrogenated Sisphenol Ai
-Sisphenol A !
_--::I::-sQl2hthalic I --J .
TerephthaIElt~jE'I~.D J
Polyetherimide (ULTEM) !
Polyetheretherketone (PEEK)
Polyethersulfone (PES)
Polyethylene HMW
Polyethylene UHMW
Polymethylpe_n_t;::e:-;:ne:;-_ _--1
Polypropylene (PP) R -+-+-H-+-+-+-
Polystyrene
Polysulfone ,I
Polyvinylidene ChIOride--=- R
PVC Type 1 R -+++-,"
PVC Type 2 . ,
Ryton Rf-+-+-H-+-+- I
R -4-~-I--I-I--I--I-I--I--I-!-+-1-+-+++-+~
,
Vinyl Ester
! O( \0 co 0'1 0 , - N M o:t \.0 r-, 00 O"l 0 ...... N !'t"I o:::t 1.0 '"' ccr
! trI
'.--N ("I'\o;:;t 1.Or--. com 0 Nm o:::t\.O "'00 O"IO ..... N t'I"'I'
i ..- ...... ..- ..... N N N N:
.Hastel/oy 0
Hastel/oy G/G-3
High Silicon Iron
'Jnconel 600/625
"ncol/oy 800/825
Lead
Monel 400
Naval Bronze
~tNickel 200/201
'.f.i Ni-Resist
'~\;Stainless Steels
. Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
{>Stel/ite
~S.;;:T:-an-:t:-a'-Iu-m---------j
Titanium
;i Zirconium ~r~
'-','0' '''i'7 !;-~~
0:.61 0 ~d: 0 ~;Q! 0 ',b; 0
OF U)~CXJj ~{~;; ~~:: ~~\ ~
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose U
Epoxy Chemical Resistant U
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur U
Furan Resin
Polyester
Epoxy
OF
°C
Fabrics
Cotton
Felt Wool)
Rayon Viscose
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R
Silicones U
Urethanes
Vinyls R ~-IO\"'+-
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~=---=--==-:~=c--"=:=C:=.L---_---1U
=-==-=-=-:..:.==-==- ---1 U
Brass
•
'Bronze
arbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
·Hastelloy D
'iC:'.H:::as:.:t=el::.::lo,-,-y_G=I--=G~-3"---- --I
ZHigh Silicon Iron
!Inconel 600/625
4'ncolloy 800/825
Lead
Monel 400
Naval Bronze
'Nickel 200/201
c.Ni-Resist
tainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
" i1icon Copper
Stellite
Tantalum
Titanium
, irconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
§fass
:Iurnbium (Niobium)
, per
stelloy B/B-2
stelloy C/C-276
·,1- -
astelloy D
"astetloy G/G-3
igh Silicon Iron
):onel 600/625
'colloy 800/825
ad
pOel 400
aval Bronze
'ieke1200/201
j-Resist
tainless Steels
Type 304/347
Type 316/316 L
Type 400 series
'Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
ilieon Bronze
ilieon Copper
tellite
lantalum
itanium
,ireonium
°C
FOR METALS FOR NONMETALLICS
,.E = < 2 Mils PenetrationlYear; G = < 20 Mils PenetrationlYear R = Resistant
',:S = < 50 Mils Penetration/Year: U = > 50 Mils PenetrationlYear U = Unsatisfactory
;~weitzer/Co1TOsion Rtrutanu Tables: Fifth Edition, Reviud and Expantkd DOl: IO.I08115672-X-120030090
~pyriglu C 2004 by Marcel Dekker. Inc. All righes reserved. For more information, go to wwwdekker.com. 3301
TRIBUTYL PHOSPHATE
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~=:;.:..z.::::-'=--~~;------1 u
~'-=~C=-=""::':":":":'------1 U
~~"L'==-------""'--------j R
~~'cLl"-"-' --j U
~~~--=--'c-------1U
~-c=-'--"-~:::::-L-_------1 R =...",""
~~:-::-----'----------1 R 1!iI-...e~ i+-I'i'+-f"""i""""",,+
~=-?::~~ ----IR
R :,'"
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate ,;
Sodium Silicate
Potassium Silicate
Silica , ,
:
Sulfur
Furan Resin
Polyester
Epoxy
=O~':'L:..:'::==--='::=-C--=----j R
~=-==="---C. -jR
~=-=~=-=-c- -jU
~"'-'--~L:.:..::"-L -j R
50%R
;-;;-=:-'~=:2- -I R ~1,"~: !;\\
°/ R -ecz ~~:'_,;
50 /0 " '" 1,l'"
Carbon R
~'0
.""".
~1'''-
1<•
..
;
.y [ .
'W
Xi ,'f .... i';
Carbon-Graphite Resin
Impregnated R
[i,'; " i;
,•. r,'
Il1','[ ·i.!
I~~
'f( ';
Ceramics I'';
~ ~
h
,; I'i;' J.
,,.i,
it
]', ft.,
Coatings
l i ~
Acrylic 11: •
1.;'[, ..... I·,
I~.
Asphalt
~111'1 I:'
;1 ;'
~
Chlorinated Rubber
Coal Tar • ·i.
t;,
~ '~k Ij~,
Coal Tar Epoxy
I~
U Ii: ,',
ti·', Ii
Epoxy General Purpose It, ;1
t~1
[;~
l.:i'
Epoxy Chemical Resistant
Epoxy Polyamide
I') !i.! !~I
U
I, S'
Oil Base I'
ti, t
'{
I;':
li~it
I;~T I,',
Im~ I'i ,',;
"'.
iit
~k
r£j
I"
~1
Mortars
Silicate
Iii
I. ~ ~~
Sodium Silicate
1§i',1
'~;i [.;;
Potassium Silicate R
Silica R
.i'
'""
ii, -
f;~
r? lip.
Sulfur
~~
f~I)
U
~;\T ',T
Furan Resin s} ,&
if;1f h' "i':
Nonmetallic Materials
Borosilicate Glass
Carbon i. -_.
Carbon-Graphite Resin
Impregnated :
Ceramics 1< _:.
~,
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
==,-=~===--:...::.:,c:-~_ __iU
=='-=~===--':::':"":':":':":":"'_ __iU
Rli.ii:.l-n
==L:..:.:.'::"::":~===-=::'-----iU
=='-=:==---=-cc,----c~-_iU
~~"-l..:.:-==-=-~=-c~-_iR
='"=-=-=2L:=-.: _i U
='"==-='-LC-=--='-c- _i U
~=-----"-"'-=:.:.L-----_iR
~:=-:-:,=-c,---,,---,----_iR
:'-:'-=-c'=-='="-:L----------i~ ~.~;;I-J4oil~~-+Ooii!-~_+'"'I_..j,.iii.I-4(o;;j..oii!_+_l;;;.l
Metals
Admiralty Brass
Aluminum
OF gj~ g:~
E
.....
G ',"
ft~~j ~j8j ~~~'; ~:~1~:
i{.~~'o ~~;
..... ;'0'i: ....'J)I; N
i""
~~I
N
"~I
,:"
;y"
"J;'
':~,
:
,,~j
f
~ ~,'
~.~
0:6: 0'0: 0:0, 06: 0:6
00,'0:
m ?~t,:'
I
I' ,
~!¢: \O:~
L""",) o::r :',:
I,', ,,'
O,N;
It'l ,It'I:
"
o::r'\O
1t'l,.1.,1")
I
I '
,
II
' '; r ,
G
:-
"
Aluminum Bronze
"
Brass DRY G
f
;,
rI; , !," I
1
I.,
, "
',. ,
Bronze
Carbon Steel
G
G
,", "
"
•
,
I, ,
,
"
,
,
I'I: ,
:;
"
.'.
J ," ~,
, ',,',
~~;\I
r~:
Copper i , '; " ,
;
Hastelloy B/B-2 E
Hastelloy C/C-276 E ;: ,."
,
,,'
',;.
,I :
L ,
;
Hastelloy D :' I i , , "
Hastelloy G/G-3 ;.' .:
",•,
"
i; I ,
Inconel 600/625 E G I I;
,
'," ,
.'
, "
,
,
¢,. , ;,
~tilt
Monel 400 1 :
:;, ,i; •. '
~U
Naval Bronze DRY
•
~ ,. .~ ,;, , ' 'I,
Nickel 200/201 1 ,
"
. : ':
17-4 PH
20 Cb 3 ALL G - ';,,. '. ;.';,
:, ,.'
,
, ..; : .,
"
~~
Stellite ;. ,
"
,:-
:
Tantalum
; ) ; I,'
'.
,~,
,
", ,
Zirconium
la\;1 b1'1 ,
,
, '
",
: ,
G.",
10 ; of~ 0to~ 0:0; o~:d: oJ'O, 0:'6; ~i:: 0'0': 0:8
~~;
0 o:o~
OF to ~(lC)i 0 ~Nj o::r "(0; OQ iO' N :o:::t: \0' 00; 0 "N; "'~ON'''<O
O(
ht:1 ..... (i7'-j .... )7:1 ....;1'41 N ~'()l\ N ..r"'~ m :t!"j
l/l
-.N;
'to; OQ
'("8j
~~ 0 :':i+') N ;,M~ 'Ct'4)' . . . 'eo; '";6:; 5 ':~ "'
m~i \0 'K: OQiO'l' Orr N.'f'l'l, q- . l,()
;:'~';:;~j :,'<i ':':;~ .... f7 ,... :.~: ~ ":.......
en 0' ~
.....N;
. o::t,.: It'l :1.1'1: It'l '.LI"l
_~m~!lQ~CO~O~:Nm,~~!".O'\p~#m
~ ~ ~. ~J~~~,~:~~:~:~~:~N~:N
~;L ie·
Carbon R i.
Vi
r'" r,; • !; i -. Ii
Carbon-Graphite Resin [~f [·f ./ /
I..
Impregnated-Furan
R,."" '. F; i.e.,' !'.' I'
~•
I
Ceramics R i-
i" !. :.'ft. .
· ..i
.'•... Ii
Ii;:•
Coatings
Wi
•••••• it.•... 'i, ..,
Acrylic U ......
11,'
[.\ D' "
Asphalt
It' l· .:
Iii,
.!
'I· I~'
II
Chlorinated Rubber
•• ;'). I~Ji
, ~
Coal Tar U
rei >
ul'~
/
Coal Tar Epoxy if
I.'. Ii..; .,
I
Epoxy General Purpose
--
U 1'1
Epoxy Chemical Resistant U
f-·· :-. : *'c f<
Epoxy Polyamide U >.!.
Oil Base I~il 'i..1'.
"~
M
cp•
~.
(Alkyd, Epoxy, Urethane) ii' iN
I~/;
Phenolic ;IT
Polyester R
'i,;
-- ;.il
,"
Polyvinyl Chloride U it
Silicones U
~~f 'll
I~
Urethanes R 1.;1,. ;.
Vinyls
Water Base
Zinc Rich
U
R i-
1':'
<
'f ;,,'
'~:,
,i;
i:l
~ !
Mortars
~!I
Silicate R li}iN
Sodium Silicate R
riPI
Potassium Silicate R
--'-:;
~ 11«71
~~I "gYi
Silica R ';'~;
~
I'!; ;# f't
Sulfur U '2.,;;
:;'2
;%\
lf~~!
Furan Resin R ,"' ¥(-
}~~
",j
'y;r'
A\~,
Polyester R'c" ;1;;,1 ~(,
~:;).~.
~fS}i
~~: ;::'f
;';,~:
'~"
,';:,'; ;;~>
~1
o ~61 0 i:"< 0 ;'cf 0/",:: 0 ~ o~o,'o;i o O~bhO
:&. q- '<0.• oo,~ N
0
OF <0;\\0, 0 '" ~ '1
:co, m .. lDCOON
~~,£i t"'" ~~ t"'" Iii';;";:: ..... ~~\ N NJ~~ m Mi'" q- ..
O( [;
~ I~J ~~i ;ffi~ &r~' ~ ;-., N",; '¢:1D'" .~. en':", t"'".,~:
~::; ,,~'co; en'b;
t"'":r-: t"'":~.
t"'"
e- :_:
;;'N' rt'I:~: \0:8) co
t"'"
rt'I
:N: N '('''~J; N
--:;:-::=.:~c-;-;___;=;;:;__1U
~,.--'-'---=:-Jr:-='-==~='cL----jR
~:'-"-:=-=:;-=-_-=-.,---;--:-_---jU
=~,="c=c..=-=:':'::':':":=_---1R
=c:::-:::'-"-=--:'--- ---jU
="'=~,.=--==--:--------jU
;:,-,.-'---"-''''-'-'''''-'-- ---j R
R
~~~----,-----1:-:4:-1Rff!ii+o_!!'i!M...
~
U. * .~
~
i.f
. ~
~ ..~
~!='~~~ ---IU
:-:;="-=~-'--.:..:.:L-. ---IR
:7':..=-7'.::o-:--,------:-==c;:.,-------I U
7-:-=.:.::::c=-.c-=::c::=-':7~~----IU
~~.c:::-'-~':-:-~'=:'"------IU
~=c-~=:::':-':c:"-"'-'-"---IU
~:-=:-=-'-:-'-'~~"=:::_-----IU
·Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
. Type 316
Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
~Silicon Bronze
~Silicon Copper
Stellite
Tantalum
Titanium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
----------1
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
=~---------jU
R II
'.,=L"=:=-=-o-;-_--;-;:;------jR
Metals
I:, ....
: II
~ ;' l
, '
Admiralty Brass
I r; !
l~: .• ~
;
Aluminum
I". II
,
.;
.
Brass " .
••••
; t. 1
,
,;; I I' I , ,
~
Bronze
I~
, ,'. .
Columbium (Niobium) ..
c·.... :
I?' ;
Copper
. • ': I·
Hastelloy B/B-2
Hastelloy C/C-276
Ir ;
~.;
,: ,
I.e
Hastelloy 0 IJ ';
.'.
Hastelloy G/G-3
.'.
-;
••
High Silicon Iron
.' .
Inconel 600/625
Incolloy 800/825 i·
I;J
I: ..I .
I
~:
"
Galv. Stl. :; I
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
.
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
R
-c-:----------jR
R
?'-'-'-'--C;-~------_j
•
Metals
'Admiralty Brass
,Aluminum
"Aluminum Bronze
Brass
Bronze
Carbon Steel E
Columbium (Niobium)
Copper
Hastelloy B/B-2
-; Hastelloy C/C-276
. Hastelloy D
Hastelloy G/G-3
High Silicon Iron
lnconel
Incolloy
Lead
Monel
Naval Bronze
Nickel
Ni-Resist
.. Stainless Steels
Type 304/347 E
Type 316 E
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
0
OF \D
In
O(
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~:::C-::=-::,------; --iR
~-:-,:===-:.::.co'-- -iR
R
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
.~::=-=-:=-c--~ -IR
~~=='-=L- ---<R
ls
II
of 0000000000 0000000000000
~OOON~~C:OON~IDOOON~mC:OON~I.OOOON~
o~.
Metals I .... _ .......... 'l"'"NNNNNMmMmMo:::t~~~o:::t~~~
Admiralty Brass
Aluminum
Bronze
=-:~~-~-----~----~---.
Carbon Steel
Columbium (Niobium) ~
Copper I
Hastelloy B/B-2-~~~~I!
Hastelloy C/C-276 __
Hastelloy D ---1
Hastelloy G/G-3 __
High Silicon Iron
I Inconel 600/6~25 ~-- ~~
I Incolloy 800/825___ I
I Lead_ l
Monel 400 I
Naval Bronze l
Nickel 200/201 ~
Ni-Resist
-~~~-'--~'-- --
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904~L
17-4 PH
20 Cb 3
'.
E-Bright 26-1
Silicon Bronze I
I I·
Silicon Copper ! I· I ..
.
Stellite
I
Tantalum
Titanium
1 I
Zirconium
. II I
•••
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R
Silicones
Urethanes
Vinyls RIi'ol+-E+-
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
~~"-"-'~"-'=''-=='---.---I R
t;t;;'~~~--------jR
~;:;;';;~~~:-- --IR
';:;:':;=:-'--.l:-'L'-'='-------I R~_~-
14
~('
oc~~~I~~~~!~81;151;1~~~
., .., < .... , ......•....•. ' .. '., ..., ,
•
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
. Lead
Monel 400 I:
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347 10% E ~-Hrfi!:H1
10% E~-+'ii!I-+!\~1
Type 316/316 L
Type 400 series
I
....
Type 904-L
.'
17-4 PH J~I
20 Cb 3 ---1- yo Et~~l-~
0 °--l ;,
E-Bright 26-1 .:
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic U
Polyester R
Polyvinyl Chloride RIIii+~*"
Silicones
Urethanes R
Vinyls R~-I*'Hi.ltii
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant R
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Metals
Admiralty Brass
Aluminum
II
. Bronze
Carbon Steel
Columbium (Niobium)
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347 ""
Type 316/316 L I~I
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar U
Coal Tar Epoxy U
Epoxy General Purpose R
,--'-----''--:c-,---,---,--c:::-'~---~
Epoxy Chemical Resistant R
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
'::-'-~~-'-'-'-=--:-;~~_ _-1U
.::-=':"-"-"-'.L;~.=.-::c:..:.c:':":"':'---jU
,::-,-~c:..:.c"-;I-=-CC~~_ _-1U
'=o~;;-'7;;~:=:--"-'-'----jR
.==~-:7--'--'--=.L -1R
~~=-:-~_-:::-:-:--;--:-_-1R
';:;;-;~o:'-'~cc-::-c=.:..c:'==---1R
;:;;-;:::--::;;'-"-"--::------1 R
;:;;-;::.::-:::~-=--='__:_-----1 U
~~--L..:L.:.c.:=c.L------1 R
~~=_:::__::__-----1R
~=:_':==:.=L------1R
R ~,f '~ <'iF,'
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Epoxy I
~'...'
ETFE (Tefzel) R, .. :.; • I.>
FEP
Furan (Furfural Alcohol)
Noryl
R
I"
1",1
I..,';," !:'; I,.',
'"
I';' '.
',
','
;. ,.' I. .: ~. I; I"
I
Nylon 6 ; ,
Nylon 11
Nylon 66
"
~!
e"
';' ',. .
i!.:·:
I'
L I.
I
II:,
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt Wool
Rayon Viscose
Metals of o~o~o~o~o'ao~o~o~;o~~:o~o~!ob!o'6
I.D:. .: 0 ·N; "d' ;lD' co ,0., N :"'=:t: '" so 0 eN; "d' -,\0, 00 .,0- ':;# .;~r 1.0 '~; 0 -m' "d'iUJ
2:::'1 "'"" :~'i .... j~~ ~~: N -'('!iI- N ";,1)1' ,.., ;~, m l~! ,rq'!:t'
'C"'" ~,. :: "d' .....; In '. .' LI'U('l
Aluminum
"
TO 50% G 1
Aluminum Bronze ,'" ; I 1 ;:. ,
I
r<
, Ii I '
,
I
I
. ;:
Brass
,,' I
~
Bronze G I, I' " I
,'"
f,;;,
Carbon Steel G :~i i'; 0 I> .: I
(
Columbium (Niobium) i".'
I
Copper :,:i I' •e
. I ,
Hastelloy B/B-2
Hastelloy C/C-276
TO 50% G
28% G IN1 i i"
I
I .
I;
I
Hastelloy D
, :
Hastelloy G/G-3 ••
I,; I~' I
High Silicon Iron G I,', I (:
., ;~ I:
r~
Inconel 600/625 TO 50% G .':
Incolloy 800/825 ii.
Lead
': (
I:
Monel 400 TO 50% G : [: i,;
I
S: ; I>
Naval Bronze
Nickel 200/201 TO 50% G
:; I~::l
'f
I':
Ni-Resist ~i: I
Stainless Steels
G1 ;::1 I:'; ;,:
ii,',' I'
Type 304/347 TO 50%
Type 316/316 L TO 50% ~r; b~!'1
li!f:j
:/ '"
I:'
Type 400 series ;' 1£
Type 904-L
.§,
1;- !: I)
~U
17-4 PH
20 Cb 3 TO 50% G Ii
E-Bright 26-1 35% E I';
I
',\
Silicon Bronze Ii, ,~
I:
Silicon Copper 1
Stellite
Tantalum I:~
,';
'i •
I~,
Titanium
Zirconium
E
E i i i $::',
PijCl
;~}:(
;~i
i"
a
I:~ ,i
o;:Cf§, 0 ?Oi 0 :'Q' 0 ~o~ 0 ~~: 0 :!61 0
OF l..OPQI)' O~N; 'l:t,to1 oo!O N~'!:t: \D,COi 0
~ fmJ 00
'l:t
0 .~d-: 0 f6:. 0 :0' 0 ;08; 0 'b
·:01 N ;~! \D. oo~ 0 ~N, 'l:t:\O
"~;c-?, ... i;:t;'~ ... \t:i ..- Ft:;I_~ N ;.r;\l: N }''1: l"I'.I l"I'.I l"I'.I :,'~'j 'et ;" ; 'et "~' Ll'I ,~~ Ll'I _.:1:"
O( Ln
~
:','N: oo!'m: 0 r~ N ttYi; 'l:t ~\D; . . . .-'00: O'l
ib1 l"I'.I ,;¢~ \D ,,~, 00 '.0\: 0 :T":':', N ·'Pt ott
~ ~i ~~; \D ~~~ 00 :tcn~ 0 :;~~ N
l"I'.I "M'
..... 0'1 >C).~ e- '.N~ tTl :qo" \D "f" 00 ,0)
~;>.; ,~.::<,j ',:.: !(,_~ ... ,"-:'i ....'~- ... e- "':;N: N)~ N 'r;.f N N: N_N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls R
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
R~@
'-"--c~7.7;~~-jR ~-+i"!iI-
~"-'-'-"o::'.:J,:r::--~:::;------1 R
~LJ:::.:~=~"-L._----1 R~~--!'!'!iI--!'
Aluminum
Brass I!I
Aluminum Bronze
Brass
Bronze
C\Carbon Steel
. Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Fabrics
Cotton
Felt (Wool
Rayon Viscose
Metals
Admiralty Brass
Aluminum
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride R
Silicones
Urethanes
Vinyls R~-f1;;i+
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o~~o'~'o~ oO'~
II
o~cro 0co o'O:ooo.b:0:5
of ~~S!
'd"h\Q,N'" } "';' -: C'N; N--~I \O'-~; 0 N' 'd" ..'
Metals ... ~; N:Ni N ~~o m om, m o:r::j 'd" :._ ~ lotliJ.ii! Ln:J(l
I~
Carbon Steel
I I
I
I:'
Columbium (Niobium)
~:
••••••
I:.
Copper
Hastelloy B/B-2
I' I;:. I' I:
Hastelloy C/C-276 I '"
I,'
~
..
Hastelloy D
:i I
Hastelloy G/G-3
I'~ ~, I,
1 I; I>
High Silicon Iron . I'·,.' I:,
~,
,
Inconel 600/625 Ii I
:
Incolloy 800/825 1\ I.
Lead I~;
I
~:;
,: I~
I:: I'1<
',
I'
''. ':;'
Monel 400 I :'.
;~
I:
"
Naval Bronze
Nickel 200/201
:;
'.,' '".
: '.
I
~~
:'.
,I ;,'
Ni-Resist
Stainless Steels
;.; ~;;
:;,
,. h
,
k
Type 304/347
;: I:: I,:
':5
..'
I;;
Type 316 G I'.."
,>
Type 400 series
f:~1 1 ;:
::~
Type 317/317 L
17-4 PH
20 Cb 3
E-Bright 26-1
G
G
r,fil
1',\]'1
v,
m11i!:1 L: ·'1
,:;
I;0',
I:,
" I:' ,
Silicon Bronze I; :
Silicon Copper ;,; I,; ::''.":
Stellite I:
It, ) , ,.,
l~
:~
" I" I'
Tantalum
Titanium
Zirconium
OF I~ ::;:;:::
l ~,
I~~~1 ~'J I;, ;
o~o~oho~o~o~o~:o~o~
N; "~ lD:CO' 0 N~ 'd" _-_~- 00::0' N ~~i ID:tlO. 0 :,'N: .qo >,lD
N«Sf N,N. m:.M, mimi m~~' oct;: .l oct~"lOt: 1t\:1J')'.It\':U)
nI'r' I;~
I>
I.;'.
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
i
l
1,
Fabrics
Cotton
Felt (Wool
Rayon Viscose
o
...
'"
co
'"
N
Metals
•
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347 In
Type 316/316 L < ,,',
'.~~
':.
Type 400 series
Type 904-L ,
20 Cb 3 :)
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride U
Silicones U
Urethanes
Vinyls U
Water Base
. Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
o
'"...
'"
'"
N
O(
'.t<::;,- ~,.-:
I
odo6o~!o6ooooocoBoooboo'oooo
of \0 <((), 0 .t'J, "'" ~_U) eo ' 0 Nq-' lD '00 0 'N • ,lD coo: N "~ IDeo ON' "It ''-0
Metals '1"'",'._,' .... ,..- .... ,N N N' NN M M M M M.qo . ' • • I.t'I It\ l.ntn
•• -:
Aluminum G ... I
Aluminum Bronze
Brass
E
G ..
- ..
>
I••••
<
:
I' . ,
I
I,
Bronze G <
" ·
Carbon Steel G
I' .... ••• · I
...... ..•. ': !
. ..
Columbium (Niobium) ... I.; ..
•••••••
.'. .
•
.
I.
Copper G- .... < ·
... - ......
Hastelloy B/B-2 G .... /
.... • ••••••
.' . -: • ••
••• <
Hastelloy C/C-276 G ~ I ••
.... ... ...
•
I.. .....
....
.'
Hastelloy D ....
...
Hastelloy G/G-3 I I
, . 1< \ •••••• . .... I
High Silicon Iron , ...... '. .. ,
••••
•••
I' >•• . . I
~
....
Inconel 600/625 E fo- ,
[ . , ••
••• I ..
.. • I
[. · ...... I
I
Incolloy 800/825 < 1.... I
. '.': I
..
••••••
Lead G >, ... . .
I
·
'.
.
".
..
...
1'1
•••••
.. I
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
E
-"
"
..
~
.,
.... ,.
:>.... I;
I
I>
;
,
••••••••
••••••
-; ,
"
.
'..
•• ••••
I
.,
>
.
I
I'
I
>
.....
.,'•..
..
". .
':'.
...
·
'
.
..
...
Type 304/347 E ..
•••••
I}
..•'
',.,'
-. •••
.. '"
I
••••• ,
. ....•.
. .'
.' .
.
••
-:
, ....
'. ..
Type 316/316 L E .... .•> ..... ....... .. ..
Type 400 series
......
I"" •••• I
..•... .-. •••••
Type 904-L
>
.'
In; I I'
I I, .•.
.:
I" .. '.'.
_ ..17-4 PH G . '.':... I
ie, I,
<
•••••• ..... .: I· I.'. '
.. I..•• .. .r I • •
I
E-Bright 26-1
Silicon Bronze G ...... .'
...'• f'·,
I
'.
} .....,
•e .......
.
••
..
,.
•
.. ,•• '.,"
,
••
••
....
....
.
·
<
'
Silicon Copper
Stellite
, . .';,.,'.'
'
I,. .,<". ....:
1< .:
".
.....
.
' ..
I
I
. . }, \
••••
..
. ..
Tantalum E
" .. ..':
;
Titanium Ii', • , 0 ,.t: I.'
..
... •
•••••• ••••
" •••••
..
OF ,,~: ~ :.~! 0.0.: 0 0"0-0,0:000"0-0:600000:000
olOCO, 0 • ':t.O' 00 N~,ID~'O,N·.lD
N:,N N-:r't M',M M:N'r m.:,,¢ .,_
CO!ON;~ID~ON_.lD
:: o::t , ,'. LI'l:Ln LI'l,Ll"I
:' • .- .... ~! "'""
Ln.ij)! ~:~; 0 ,"~., N '01- .-u)" r-.. ·00: 01 :0'· .... N: M "q- 1.0: 1'0) co '(1'1,. 0..-· N'm
°C ~N;~ ~.~'~·mO~Nm,~~~~mC~Nm·~~~~m
C'", •.' ' ~ ...... e-- 'i-. ~ ..... ~ ,..- ~ eN N N NN. N N N N
Nonmetallic Materials
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
R "'
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
JAluminum Bronze
I3rass
•
'Bronze
'..arbon Steel
olumbium (Niobium)
opper
astelloy B/B-2
f:/astelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
ead
Monel 400
Naval Bronze
Nickel 200/201
.Ni-Resist
';;Stainless Steels
Type 304/347
Type 316/316 L
Type 400 series
Type
17-4 PH
20 Cb 3
.. E-Bright 26-1
~cSilicon Bronze
;i\Silicon Copper
;~ Stellite
\lTantalum
~;;Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose
-----j
Epoxy Chemical Resistant R
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Ethylene-Acrylic (EA)
Ethylene-Propylene (EPM)
Ethylene-Propylene-Diene
(EPDM)
Ethylene-Propylene
Terpolymer (EPT)
FKM (Viton A
Hard Rubber
Soft Rubber
Isoprene (lR)
Kalrez (FPM)
Koroseal
Natural Rubber (GRS)
Neoprene GR-M (CR)
Nitrile Buna-N (NBR)
Nordel (EPDM)
Polybutadiene (BR)
Polyester (PE)
Polyether-Urethane (EU)
Polyisoprene IR)
Polysulfides (T)
Polyurethane AU)
SBR Styrene Buna-S)
Silicone Rubbers
Fabrics
Cotton
Felt (Wool)
Rayon Viscose
Nonmetallic Materials of
Borosilicate Glass
Carbon
Carbon-Graphite Resin
Impregnated
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy U
Epoxy General Purpose
Epoxy Chemical Resistant R
Epoxy Polyamide U
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester U
Polyvinyl Chloride U
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
OF
O(
PVDF (Kvnar)
Ryton
TFE (Teflon)
Vinyl Ester
~~---::-'-=--C~~~CL-_--jR
:-;=~-:=O::~:':-'c:~~_ _---IR
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
Nickel 200/201
Ni-Resist
-::-----c------j
Stainless Steels
Type 304/347
Type 316
Type 400 series
Type 904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
. Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
co
'"
N
"
Metals
Admiralty Brass
Aluminum
II
Aluminum Bronze
Brass
Bronze
Carbon Steel
Columbium (Niobium)
Copper
Hastelloy B/B-2
Hastelloy C/C-276
Hastelloy D
Hastelloy G/G-3
High Silicon Iron
Inconel 600/625
Incolloy 800/825
Lead
Monel 400
Naval Bronze
Nickel 200/201
Ni-Resist
Stainless Steels
Type 304/347
Type 316/316 L
Type
Type904-L
17-4 PH
20 Cb 3
E-Bright 26-1
Silicon Bronze
Silicon Copper
Stellite
Tantalum
Titanium
Zirconium
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar
Coal Tar Epoxy
Epoxy General Purpose
Epoxy Chemical Resistant
Epoxy Polyamide
Oil Base
(Alkyd. Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
'-::-'-'-7"-'=--~~;-:-------1U
=--=-:~'-'-'-:'-"-;-'-''--=:~'-'-'-_ _---jU
=--=-:~--'-"-"':"'---=-'--'-~~_ _---jU
=--=-:LJ'-'--"-"-'='-'-'--''---'--''--_---ju
=--=-::'-"-;~:-7'--=o-c-:__c_----jU
~~;:_'_'_==-:=---=c-c~=-=-----jU
::O:,-:-=-=::'-"--"-::,-- ---jU
U
::O:,-:=-=~-=-='-:--------jR ,,;,'
Carbon
Carbon-Graphite Resin
Impregnated R
Ceramics
Coatings
Acrylic
Asphalt
Chlorinated Rubber
Coal Tar R
Coal Tar Epoxy R~·lc\1'£1
Epoxy General Purpose
Epoxy Chemical Resistant R
Epoxy Polyamide
Oil Base
(Alkyd, Epoxy, Urethane)
Phenolic
Polyester
Polyvinyl Chloride
Silicones
Urethanes
Vinyls
Water Base
Zinc Rich
Mortars
Silicate
Sodium Silicate
Potassium Silicate
Silica
Sulfur
Furan Resin
Polyester
Epoxy
A-1-1
•
A-1-2 APPENDIX 1
Formalin Formaldehyde
Furfuraldehyde Furfural
Furfural Furfural
Glucose Dextrose, corn syrup
Glvceroi Glycerine
Glycol Ethylene glycol
Glycol ether Diethylene glycol
Glycol methyl ether Methyl cellosolve
Hexamethylene Cyclohexane
Hexamethylene tetramine Hexamine
Hexandioic acid Adipic acid
Hexose Dextrose
Hexvl alcohol Hexanol
Hydrogen iodide Hydriodic acid
Hydroxy benzoic acid Salicylic acid
Hypo photographic solution Sodium thiosulfate
Isopropyl benzene Cumene
Ligroin Petroleum ether
Lime Calcium oxide
Lime sulfur Calcium sulfide
Lithic acid Uric acid
Marsh gas Methane
Methanal Formaldehyde
Methane sulfonic acid Methyl sulfonic acid
Methanoic add Formic acid
Methanol Methyl alcohol
Methyl benzene Toluene
Methyl chloroform Trichloroethane
Methyl cyanide Acetonitrile
Methyl ether Dimethyl ether
Methyl phenol Cresol
Methyl phenol ketone Acetophenone
Methyl phthalate Dimethyl phthalate
Methyl propane-2 Butyl alcohol, tertiary
Methyl sulfonic acid Methane sulfonic acid
Nitrochloroform Chloropicrin
Nitrogen oxide, tri- Nitrous acid
Octanoic acid Caprylic acid
Oil of mirbane Nitrobenzene
Oil of wintergreen Methyl salicylate
Oxalic nitrile Cyanogen
Phenyl amine Aniline
Phenyl bromide Bromobenzene
Phenyl carbinol Benzyl alcohol
Phenyl chloride Chlorobenzene
Phenyl cyanide Benzonittile
Phenyl ethane Ethyl benzene
Phosphine Hydrogen phosphide
Pimelic ketone Cyclohexanone
Pinene Dipentene
Polyphenylene sulfide Ryton
Propanoic acid Propionic acid
A-1-4 APPENDIX 1
A-2-1
-
A-2-2 APPENDIX 2
Registered trademarks of
a E. I. du Pont.
b Mohay Corp.
c Shell Chemical Co.
r 3-M Corp.
g Pennwalr Corp.
h Uniroyal.
j Ausimont.
o CHR Industries.
P Conap Inc.
q Polymer Corp:
r Monsanto Co.
$ Hardman Inc.
W Krebs Engineers.
ab Arisrech. Inc.
ac Borg Warner Chemical Co.
ad Himonr U.S.A.
ae Phillips Petroleum Co.
af T ribol Industries.
ag Amoco Performance Products.
Appendix 3: Plating Solution Composition
Brass [Iron]
~.
3% Copper, 1% zinc, and 5.6% sodium 15% CaClz
3% Cyanide 11% (NH 4lzS04
Sodium carbonate
Lead
Cadmium cyanide
8% Lead
3% Cadmium oxide
0.8% Fluoboric acid
10% Sodium cyanide
0.4% Boric acid
1.2% Sodium hydroxide
Water to make 1 gallon
Chrome 25%
25% Cr03 Nickel
12% Sulfuric acid 11% Nickel sulfate
Water 2% Nickel chloride
1% Boric acid
Chrome 40% 86% Water
40% Cr03
12% Sulfuric acid Silver
Water 4% Silver
7% Potassium cyanide
Copper cyanide 5% Sodium cyanide
10.5% Copper 2% Potassium carbonate
14% Sodium cyanide
6% Rochelle salts Tin
7% Tin
Gold 18% Stannous fluoborate
22.8% Potassium ferrocyanide 9% Fluoboric acid
0.2% Potassium gold cyanide 2% Boric acid
0.8% Sodium cyanide
Water to make 1 gallon
Zinc
Iron 9% Zinc cyanide
45% FeCl z 9% Sodium hydroxide
20% FeS04 4% Sodium cyanide
A-3-1