Professional Documents
Culture Documents
LEGO-lighting-GC532 71456
LEGO-lighting-GC532 71456
lighting set.
each components is working properly to avoid the situation that the lighting
the wires too hard. For different people, there may be some installation steps
that you can't understand. Please look at the previous and later installation
steps.
Section A:Check the type and quantity of components.
This set contains three bags labelled "1" "2" "3" ,please make sure that the components
in each bag are the same as shown in the pictures.
Take out the Expansion Boards and the USB Power Cable from No.3 bag.
It is worth reminding that our products are all customized. They have a unique way of
connecting. The white plug on wire and the socket of the expansion board need to be
connected together to transmit power.
Note that on one side of the white plug you can see two very small golden wires that
should be connected to the two golden needles in socket of the expansion board.shown as
blow.
Connect the Expansion Board and USB Power Cable as shown.
The USB Power Cord can be powered by phone chargers, power banks, etc. This
instruction will use the power bank as power supply.
Connect the other end of the USB power cable to the power supply.
Connect all the components in No.1 bag to the Expansion Board in same way just as
shown.Turn on the power bank, all the lights are on as shown.Remove the lamp after the
test.
Unplug these one components and put them back in the corresponding bags. There are
one in bag No.2 need to be tested.
Attention that after the test is completed, each components should put back in the
corresponding bag including the socket and the usb power cable.
Please contact us immediately if any components don't work.
Section C:laying out components following the instruction.
3
4
6
7
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
Good job, you've done all the installation steps, power it up and enjoy your work.
The battery box in bag NO.3 can also power the set. If it is necessary to change the power
supply , prepare three AAA batteries, install them in the battery box, turn on the switch on
the battery box, remove the plug of the USB Power Cable from the socket of the expansion
board,plug the plug of the battery box to the same socket in the expansion board to power
the suit as well.
THANKS