Professional Documents
Culture Documents
XF Connection To ZCC Over IP
XF Connection To ZCC Over IP
Center
2. In the workflow (Zund Cut Center Connectivity) of Fiery XF / Finishing, setup your G3
ZCC device. Type in the IP address and port as found in the Cut manager.
Save this change and press the “Test” button. This should result in a pop-up stating
that “The connection to the cutter is OK”.
http://www.efi.com
Connecting Fiery XF to Zund Cut
Center
3. Now, you can save this setup as a preset in Fiery XF so that it can be easily activated in
every workflow or on every job in the Fiery XF Client Job Explorer that needs ZCC
finishing.
http://www.efi.com
Connecting Fiery XF to Zund Cut
Center
http://www.efi.com